Limited survey for the occurrence of aflatoxins in cereals and poultry feeds from Rabat, Morocco

Emerging mycotoxin occurrence in chicken feed and eggs from Algeria

Poultry farming has developed into one of Algeria's most productive industrial farming because of the growing demand for sources of protein among Algerian society. Laying hen feed consists mainly of cereals, which can be contaminated with molds and subsequently with their secondary metabolites known as mycotoxins. These later can pose a serious danger to the production and quality of eggs in the commercial layer industry. This work focuses on the detection of emerging mycotoxins, mainly enniatins (ENNs) and beauvericin (BEA), in poultry feed and eggs from different locations in Algeria. Two different QuEChERS-based extractions were established to extract ENNs and BEA from chicken feed and eggs. The determination of mycotoxin occurrence was achieved by a UHPLC-MS/MS method using 0.1% (v/v) formic acid in water and MeOH as mobile phase, an ESI interface operating in positive mode, and a triple quadrupole mass spectrometer operating in MRM for the detection. Matrix-matched calibration curves were carried out for both matrices, obtaining good linearity (R2 > 0.99). The method performance was assessed in terms of extraction recovery (from 87 to 107%), matrix effect (from - 47 to - 86%), precision (RSD < 15%), and limits of quantitation (≤ 1.1 µg/kg for feed and ≤ 0.8 µg/kg for eggs). The analysis of 10 chicken feed samples and 35 egg samples composed of a 10-egg pool each showed that ENN B1 was the most common mycotoxin (i.e., found in 9 feed samples) with contamination levels ranging from 3.6 to 41.5 µg/kg, while BEA was detected only in one feed sample (12 µg/kg). However, eggs were not found to be contaminated with any mycotoxin at the detection limit levels. Our findings indicate that the searched mycotoxins are present in traces in feed and absent in eggs. This can be explained by the application of a mycotoxin binder. However, this does not put a stop on the conduction of additional research and ultimately setting regulations to prevent the occurrence of emerging mycotoxins.

Mycotoxin contamination in the Arab world: Highlighting the main knowledge gaps and the current legislation

Since the discovery of aflatoxins in the 1960s, knowledge in the mycotoxin research field has increased dramatically. Hundreds of review articles have been published summarizing many different aspects, including mycotoxin contamination per country or region. However, mycotoxin contamination in the Arab world, which includes 22 countries in Africa and Asia, has not yet been specifically reviewed. To this end, the contamination of mycotoxins in the Arab world was reviewed not only to profile the pervasiveness of the problem in this region but also to identify the main knowledge gaps imperiling the safety of food and feed in the future. To the best of our knowledge, 306 (non-)indexed publications in English, Arabic, or French were published from 1977 to 2021, focusing on the natural occurrence of mycotoxins in matrices of 14 different categories. Characteristic factors (e.g., detected mycotoxins, concentrations, and detection methods) were extracted, processed, and visualized. The main results are summarized as follows: (i) research on mycotoxin contamination has increased over the years. However, the accumulated data on their occurrences are scarce to non-existent in some countries; (ii) the state-of-the-art technologies on mycotoxin detection are not broadly implemented neither are contemporary multi-mycotoxin detection strategies, thus showing a need for capacity-building initiatives; and (iii) mycotoxin profiles differ among food and feed categories, as well as between human biofluids. Furthermore, the present work highlights contemporary legislation in the Arab countries and provides future perspectives to mitigate mycotoxins, enhance food and feed safety, and protect the consumer public. Concluding, research initiatives to boost mycotoxin research among Arab countries are strongly recommended.

Co-Occurrence of Aflatoxin B1, Zearalenone and Ochratoxin A in Feed and Feed Materials in Central Italy from 2018 to 2022

Mycotoxin contamination of feed and feed materials represent a serious health hazard. This study details the occurrence of aflatoxin B1 (AFB1), zearalenone (ZEN) and ochratoxin A (OTA) in 826 feed and 617 feed material samples, collected in two Italian Regions (Umbria and Marche) from 2018 to 2022 analyzed using a UPLC-FLD platform. The developed method was validated and accredited (ISO/IEC 17025) with satisfactory accuracy and precision data obtained in repeatability and intralaboratory reproducibility conditions. Feed had a higher incidence of contaminated samples (26%) with respect to feed materials (6%). AFB1 was found up to 0.1045 mg/kg in cattle feeds and 0.1234 mg/kg in maize; ZEN was detected up to 6.420 mg/kg in sheep feed while OTA was rarely reported and in lower concentrations (up to 0.085 mg/kg). Co-contamination of at least two mycotoxins was reported in 0.8% of the analyzed samples. The incidence of above maximum content/guidance level samples was 2% for feed and feed materials while almost 3-fold-higher for maize (5.8%) suggesting how mycotoxin contamination can affect some matrices more than others. Obtained data can be useful to improve official monitoring plans and therefore further raise awareness of this issue between agriculture stakeholders, healthcare entities and non-professionals.

Aflatoxins in food products consumed in the Kingdom of Saudi Arabia: A preliminary dietary risk assessment

Aflatoxins (AFs) are hepatotoxic, mutagenic, genotoxic, and immunosuppressive toxins. Several food commodities consumed in the Kingdom of Saudi Arabia (KSA) are susceptible to AF contamination because of improper storage practices and the warm and humid climate of the country. Therefore, the occurrence of AFs in 2388 food samples was measured and the estimated daily intake (EDI) of AFs in Saudi adults was assessed. The risks of AFB1 exposure were characterized using the margin of exposure (MoE) approach and by estimating the number of possible hepatocellular carcinoma (HCC) cases in the KSA. The results revealed that 12.1% of the analyzed samples were contaminated with AFs and the highest concentration of total AFs was observed in the nut and seed group. The mean EDI of AFB1 was estimated to be 0.21 and 0.55 ng/kg body weight (bw)/day for the lower bound (LB) and upper bound (UB) scenarios, respectively. The MoEs were estimated to be 1902.4 and 722.1, while the estimated liver cancer risk ranged from 0.002 to 0.008 cancer cases/year/100,000 persons. Based on the study's findings, contamination with AFs in the KSA is low; however, AFs are considered potent genotoxic contaminants, and therefore, exposure through food should be kept as low as possible.

Occurrence of pre- and postharvest multi-mycotoxins in durum wheat grains collected in 2020 and 2021 in two climatic regions of Tunisia

Twenty two mycotoxins in 136 durum wheat collected from Tunisia in 2020 and 2021 were investigated. Mycotoxins were analyzed by UHPLCMS/MS. In 2020, 60.9% of the samples were contaminated with Aflatoxin B1 (AFB1) and/or enniatin. Whereas, in 2021, 34.4% were contaminated by enniatins. AFB1 was detected only in 2020, in the continental region (6/46) and all samples exceeded limits. AFB1 was detected in stored wheat (24-37.8 µg/kg) but also in pre-stored wheat (17-28.4 µg/kg) and in one sample collected in the field (21 µg/kg). Enniatin A1, enniatin B and enniatin B1 were detected in wheat collected in the field (30-7684 µg/kg), pre-storage (42-1266 µg/kg) and storage (65.8-498.2 µg/kg) from the continental region also, in sample collected in pre-storage (31.3-1410 µg/kg) and at harvest (48- 1060 µg/kg). Samples had a water activity less than 0.7 and moisture content ranged between 09-14%. AFB1 level represent a health risk to the Tunisian consumers.

Quantitative Estimation of Aflatoxin Level in Poultry Feed in Selected Poultry Farms

Statement of Novelty. Poultry feed contamination due to mycotoxins is one of the major threats to the growing poultry industry. Surveillance of different mycotoxins, including aflatoxin, is very important to control economic and health hazards associated with these toxins. Studies reporting aflatoxin levels in poultry feed are limited. Therefore, this study was conducted to examine the occurrence of total aflatoxin in poultry feed. This study is the first-ever documentation about the frequency and quantitative estimations of total aflatoxin levels in poultry feed consumed to provide solid feedback to the poultry industrialists and researchers involved in studying the mycotoxins. Objective. Contamination of poultry feed with mycotoxins such as aflatoxin is a major concern for the poultry industry that results in a significant economic loss and directly affects consumers. Monitoring the aflatoxin levels in poultry feed is crucial for controlling economic loss and decreasing the health hazards to the population. This study was conducted to examine the occurrence of total aflatoxin in poultry feed in a high consumption area. Three different poultry feeds, i.e., starter, grower, and finisher, were assessed through continuous sampling from farms. The incidence of positive samples for aflatoxin contamination was 92.5%. Grower feed had the highest frequency (100%) of aflatoxin positive samples and aflatoxin levels with a mean value of 56.34 ppb. Further, the range of moisture content was around 6.8%-10.98%. No significant correlation between humidity and aflatoxin contamination was revealed when analyzed by Pearson's correlation coefficient with r² of 0.05 and p value of 0.13. The results warrant the need for constant monitoring programs for the prevention of aflatoxin contamination in local poultry farms

Determination of Aflatoxins and Ochratoxin a in Animal Liver using HPLC-FD Method with Immunoaffinity Column Clean-Up

Analytical methods based on immunoaffinity column clean-up and quantitative determination with liquid chromatography-fluorescence detection were used to determine aflatoxins and ochratoxin A in liver samples. The validation of the procedures was performed. The linearity of the methods was checked, and a good coefficient of correlation was found for all aflatoxins and OTA as well. The LOD and LOQ were acceptable: 0.003 µg/kg and 0.009 µg/kg for AFB1; 0.001 µg/kg and 0.005 µg/kg for AFB2; 0.006 µg/kg and 0.020 µg/kg for AFG1; 0.007 µg/kg and 0.022 µg/kg for AFG2; 0.08 µg/kg and 0.27 µg/kg for OTA. The results for the repeatability estimated by the relative standard deviation (RSDr) were satisfactory and the obtained values were in the acceptable range (1.97–14.41% for all aflatoxins and 3.76-8.31% for OTA) at three proposed concentration levels. RSDR values showed acceptable correlation between two analysts for all four aflatoxins and OTA. The RSDR values were as followed: 2.37% and 5.60% for AFB1, 6.71% and 8.78% for AFB2, 4.40% and 7.00% for AFG1 and 10.30% and 13.91% for AFG2 (for the first and second analyst, respectively). The RSDR values for OTA were 4.91% and 3.15% (1 µg/kg); 3.76% and 4.12% (5 µg/kg) and 8.31% and 8.21% (10 µg/kg). The mean recovery for total aflatoxins and OTA were 78.10% and 93.34%, respectively. All validation parameters were in accordance to European legislation. They indicate that the proposed analytical procedures are suitable and they could be methods of choice for the determination of aflatoxins and OTA in liver samples.

Toxigenic mycoflora, aflatoxin and fumonisin contamination of poultry feeds in Ghana

The study was undertaken to identify the major mycotoxigenic fungi, aflatoxin and fumonisin levels in prepared poultry feeds in Ghana. Three hundred and fifty (350) prepared feed samples were randomly collected from 133 commercial poultry farms, 76 feed processors and eight (8) feed vendors in three major poultry producing regions of Ghana over two seasons. Fungi were isolated using the serial dilution method on potato dextrose agar and identified using standard methods of identification. Total aflatoxin and fumonisin levels were quantified using AgraStrip® Total Aflatoxin and Fumonisin Quantitative test Watex® from RomerLab, USA. Eight (8) different fungi were isolated from the feed samples with isolation frequency as follows: Aspergillus flavus (47%), A. niger (24%), A. fumigatus (17%), A. oryzae (3%), A. tamarii (2%), Penicillium sp. (3%), Colletotrichum sp. (4%) and Rhizopus sp. (0.1%). Feed samples collected during the rainy season recorded higher mean colony counts (3.39 ± 0.29) than that of the dry season (1.10 ± 0.18). Total aflatoxin and fumonisin levels ranged from 0 to 118 ppb with a mean of 57.25 ± 2.55 ppb, and 0.28-15 ppm with a mean of 1.54 ± 0.12 ppm, respectively. The study revealed co-occurrence of aflatoxin and fumonisin in all the feed samples. Significant correlations (r = 0.298, r = 0.694) (p < 0.05) were observed among the aflatoxin and fumonisin levels and the fungi isolated. Seventy-four percent (74%) of all the feed samples exceeded the 15 ppb Ghana Standards Authority threshold, the EU regulatory limit of 20 ppb and the FAO/WHO recommended maximum permissible limit of 30 ppb for poultry feeds. Although fumonisin levels were less than the EU guidance values of 20 ppm for poultry feeds, 20% of the samples were higher than the FAO/WHO maximum tolerable daily intake limit of 2 ppm. Proper handling of prepared feeds and ingredients could prevent or minimize toxigenic fungi contamination and lower the likelihood of mycotoxin development in poultry feeds.

Aflatoxin M1 prevalence in breast milk in Morocco: Associated factors and health risk assessment of newborns "CONTAMILK study"

The aim of this study was to assess the contamination of breast milk by aflatoxin M1 among nursing mothers from Rabat, Morocco, and to explore its association with several maternal parameters and dietary habits. In addition, the health risk assessment of the newborns by the estimation of the daily intake. A competitive Enzyme Linked Immunosorbent Assay method was used for the analysis of aflatoxin M1 in breast milk samples. Analytical results indicate that out of 82 total samples, 43 samples (52.4%) of milk were positive. Aflatoxin M1 levels ranged from undetectable to 13.33 ng/L, while the mean level was 5.75 ± 3.44 ng/L. Besides, several factors and foodstuffs seem to increase the level of AFM1 in breast milk. As regards the estimated daily intake of aflatoxin M1, it varies between immeasurable and a maximum of 1.16 ng/kg.bw. The degree of exposure to AFB1 and the levels of its metabolite AFM1 in breast milk were low, compared to some studies from other countries. Further investigations and periodic monitoring programs are recommended in large samples and in many cities of morocco to assess the level of exposure of the Moroccan population.

Polyphasic Assessment of Aflatoxin Production Potential in Selected Aspergilli

This study investigated the aflatoxin production potentials of selected fungi using a polyphasic approach. Internally transcribed spacer region of the fungi was amplified using the polymerase chain reaction. Forty-five Aspergillus strains were further assessed for aflatoxin production using the conventional methods such as growth on yeast extract sucrose, β-cyclodextrin neutral red desiccated coconut agar (β-CNRDCA); expression of the aflatoxin regulatory genes and the use of both thin-layer chromatography (TLC) and high-performance liquid chromatography (HPLC). A large proportion (82.22%) of the isolates harbored the Nor-1 gene while 55.56%, 68.89%, and 80% possessed the ver-1, omt-A, and aflR genes, respectively. All 100% the isolates harbored the aflJ gene. Twenty-three isolates were positive for aflatoxin production based on the yeast extract sucrose medium (YES) test; ammonium vapor test (51%), yellow pigment production (75.5%), and β-CNRDCA tests; and blue/green fluorescence (57.7%). Based on TLC detection 42.2% produced aflatoxins while in the HPLC, total aflatoxin (AFTOT) production concentrations ranged from 6.77-71,453 µg/g. Detectable aflatoxin B1 (AFB1) concentrations obtained from the HPLC ranged between 3.76 and 70,288 µg/g; 6.77 and 242.50 µg/g for aflatoxin B2 (AFB2); 1.87 and 745.30 µg/g for aflatoxin G1 (AFG1); and 1.67 and 768.52 µg/g for aflatoxin G2 (AFG2). AFTOT contamination levels were higher than European Union tolerable limits (4 µg/kg). The regression coefficient was one (R2 = 1) while significant differences exist in the aflatoxin concentrations of Aspergillus (p ≤ 0.05). This study reports the potentials of Aspergillus oryzae previously known as a non-aflatoxin producer to produce AFG1, AFG2, AFB1, and AFB2 toxins. Aspergillus species in feedlots of animals reared for food are capable of producing aflatoxins which could pose hazards to health.

Gene expression of Aspergillus flavus strains on a cheese model system to control aflatoxin production

The expression of genes associated with aflatoxin biosynthesis by different Aspergillus flavus strains growing on a cheese model system has not been studied. To control aflatoxin biosynthesis, it would be useful to understand the changes in gene expression during cheesemaking and relate those changes to toxin production. The objective of this study was to evaluate the effects of pH, water activity, and temperature on the expression of 2 regulatory genes (aflR and aflS) and 1 structural gene (aflP) involved in aflatoxin biosynthesis, using 3 aflatoxigenic A. flavus strains growing on a cheese-based medium and reverse-transcription real-time PCR. The gene expression patterns were influenced by A. flavus strain and environmental conditions. The structural gene aflP and the regulatory genes aflR and aflS showed similar expression patterns in each A. flavus strain, but we also observed inter-strain differences. We observed the highest expression levels at 6 and 9 d of incubation by A. flavus strains CQ8 and CQ103, and saw a decrease in the days following. Strain CQ7 showed the lowest expression of these genes. We observed the highest expression levels of these genes at pH 5.5, water activity 0.95, and 20 to 25°C; strain CQ103 showed a different pattern for the aflS gene, with maximum expression at pH 6.0 on d 6 of incubation. For the 3 strains, we found a strong correlation between the relative expression of the aflR and aflS genes and the concentration of aflatoxins under conditions that simulated cheese ripening. Control strategies to avoid aflatoxin contamination during cheesemaking could use the detection of regulatory gene expression.

Optimization and validation of a liquid chromatography/tandem mass spectrometry (LC-MS/MS) method for the determination of aflatoxins in maize

A LC-MS/MS method has been optimized and validated for the determination of aflatoxins (AFB1, AFB2, AFG1 and AFG2) in maize. Extraction was performed using a modified QuEChERS method with little sample preparation without the need for purification procedure. Determination was performed by high pressure liquid chromatography (HPLC) coupled to tandem mass spectrometry (MS/MS). The acquisition was performed using MassHunter software in Multiple Reaction Monitoring (MRM) mode in positive polarity. Different mobile phases were tested to control the degree of the ionization and good performances were obtained for methanol/water with 5 mM ammonium acetate. MRM experiments were optimized for each aflatoxin in order to generate sensitive transitions. Linearity was demonstrated for the aflatoxins in the range 0.225-1.25 μg/L. Limits of detection (LOD) (0.11 and 0.36 μg/Kg) and limits of quantification (LOQ) (0.36-1.19 μg/Kg) of the aflatoxins are below the maximum permitted levels set by the European Union (EU). Aflatoxins have acceptable recoveries using QuEChERS method in the acceptable range of 50-120% for levels below 1 μg/Kg. Satisfactory recoveries were also obtained in the acceptable range of 70-110% for levels between 1 and 10 μg/Kg except for AFB2. Relative standard deviation (RSD) of recoveries for the intra-day precision and inter-day precision were below 11 %. Selectivity of the method was tested and no spectral interferences were observed in the appropriate retention times. The main advantage of the proposed method is its ease of use and requires a smaller solvent consumption that reduces the time and cost of the analysis.

The efficiency of lactic acid bacteria against pathogenic fungi and mycotoxins

Mycotoxins are produced by some fungal species of the genera Aspergillus, Penicillium, and Fusarium and are common contaminants of a wide range of food commodities. Numerous strategies are used to minimise fungal growth and mycotoxin contamination throughout the food chain. This review addresses the use of lactic acid bacteria, which can inhibit fungal growth and participate in mycotoxin degradation and/or removal from contaminated food. Being beneficial for human and animal health, lactic acid bacteria have established themselves as an excellent solution to the problem of mycotoxin contamination, yet in practice their application in removing mycotoxins remains a challenge to be addressed by future research.

Toxigenic fungi and mycotoxin occurrence and prevention in food and feed in northern Africa – a review

North African countries (Algeria, Morocco and Tunisia) are surrounded by water bodies, such as the Mediterranean Sea and the Atlantic Ocean. Their climate is characterised by high temperatures and high relative humidity in some areas, which are environmental conditions favourable to fast fungal growth and toxinogenesis. This paper reports information on the presence of toxigenic fungi, mycotoxins (especially aflatoxins and ochratoxin A) and emerging Fusarium mycotoxins (enniatins, beauvericin and fusaproliferin) in some Northern African commodities that are largely consumed and were investigated thoroughly, especially raw cereals, bread, couscous, pasta, milk, spices, wine, beer, fruit juices, olives and olive oil, dried fruits and nuts, poultry feeds, etc. in the three North African countries. High contamination levels have been reported for some food samples from the three countries. Steps towards better prevention of mycotoxin production in feeds and decrease of intestinal absorption, by means of plant essential oils associated with clay, have been undertaken. Morocco presumably is the country where mycotoxin regulation is the most detailed in comparison with Algeria and Tunisia. Finally, the conclusion section offers some prospects and recommendations for actions by authorities and scientists during the monitoring of mycotoxins in the foods and feeds produced and/or commercialised in the three countries.

Aflatoxin B1 Induced Systemic Toxicity in Poultry and Rescue Effects of Selenium and Zinc

Among many challenges, exposure to aflatoxins, particularly aflatoxin B₁ (AFB₁), is one of the major concerns in poultry industry. AFB₁ intoxication results in decreased meat/egg production, hepatotoxicity, nephrotoxicity, disturbance in gastrointestinal tract (GIT) and reproduction, immune suppression, and increased disease susceptibility. Selenium (Se) and zinc (Zn), in dietary supplementation, offer easy, cost-effective, and efficient ways to neutralize the toxic effect of AFB₁. In the current review, we discussed the impact of AFB₁ on poultry industry, its biotransformation, and organ-specific noxious effects, along with the action mechanism of AFB₁-induced toxicity. Moreover, we explained the biological and detoxifying roles of Se and Zn in avian species as well as the protection mechanism of these two trace elements. Ultimately, we discussed the use of Se and Zn supplementation against AFB₁-induced toxicity in poultry birds.

A Limited Survey of Aflatoxins and Zearalenone in Feed and Feed Ingredients from Pakistan

This work presents current information on the presence of aflatoxins (AFs) and zearalenone (ZEN) in feed and feed ingredients from Punjab, Pakistan. The 105 samples tested were concentrated feed, i.e., cotton seed meal (18 samples) and soybean meal (14), and feed ingredients, i.e., crushed corn (17), crushed wheat (15), barley (17). and poultry feed (24). Samples were analyzed using high-performance liquid chromatography equipped with a fluorescence detector. Analysis revealed that 69 of 105 samples were contaminated with AFs, and the highest mean concentrations of AFB₁ (6.20 μg/kg) and total AFs (9.30 μg/kg) were found in poultry feed samples. The mean total AF concentrations ranged from the limit of quantification to 165.5 μg/kg. However, 75 of the 105 samples were positive for ZEN. The highest mean concentration (19.45 μg/kg) was found in poultry feed samples. The mean ZEN concentrations were 0.15 to 145.30 μg/kg. The prevalence of AFs and ZEN was high in feed and feed ingredients and needs urgent attention.

Aflatoxin B1 in eggs and chicken livers by dispersive liquid-liquid microextraction and HPLC

A rapid, low-cost and simple technique has been developed for the determination of aflatoxin B1 (AFB1) in eggs and livers using high-performance liquid chromatography (HPLC) with UV detection. In this study, the presence of AFB1 was investigated in 150 eggs and 50 chicken livers from the local market of Tabriz, Iran. AFB1 was extracted with a mixture of acetonitrile:water (80:20) and cleaned up by dispersive liquid-liquid microextraction which is a very economical, fast and sensitive method. AFB1 was quantified by HPLC-UV without need for any complex derivatisation in samples to enhance the detection. The results showed that 72% of the liver and 58% of the egg samples were contaminated with AFB1 ranging from 0.30 to 16.36 µg kg (̶1). limit of detection and limit of quantification for AFB1 were 0.08 and 0.28 µg kg (̶ 1), respectively. The proposed method is suitable for fast analysing of AFB1 in egg and liver samples.

Quality evaluation of five commercial enzyme linked immunosorbent assay kits for detecting aflatoxin b1 in feedstuffs

The objective of this study was to evaluate the quality of five commercial enzyme linked immunosorbent assay (ELISA) kits (A, B, C, D, and E) from different suppliers for detecting aflatoxin B₁ (AFB₁). AFB₁-free corn samples supplemented with different levels of AFB₁ (5, 10, and 20 μg/kg) were used as positive controls and 6 replicates of each control sample were tested to evaluate the accuracy and precision of these kits. In addition, we also evaluated the performance of these ELISA kits for AFB₁ in 30 feed samples, including corn, distillers dried grains with soluble, wheat samples, soybean meal, and poultry feed, which were verified by high performance liquid chromatography. Results showed that the coefficients of variation ranged from 1.18% to 16.22% in intra-plate and 2.85% to 18.04% in inter-plate for the determination of AFB₁. The half maximal inhibitory concentration for five kits ranged from 3.72 to 7.22 μg/kg. The quantitation limits of AFB₁ were all under the legal limit in China but somewhat inconsistent with kit instructions. Although the recovery rate of four of the five kits were either less than 90% or more than 110%, all these values were acceptable in practice. Two kits had high false positive rates (C and E). In conclusion, our results revealed that the qualities of five tested ELISA kits were significantly different.

Water availability and calcium propionate affect fungal population and aflatoxins production in broiler finisher feed during storage

The aim of this study was to investigate the effects of calcium propionate, water activity (aw) and incubation time on the total fungal count and aflatoxins B₁ (AFB₁), B₂ (AFB₂), G₁ (AFG₁) and G₂ (AFG₂) production in the broiler finisher feed. The feed was added with calcium propionate (5 g kg(-1)), adjusted to 0.85, 0.90 and 0.95 aw and stored for 28 days at 25°C, analysing for mould growth and aflatoxins production every 7 days. Analysis of variance indicated that all the factors (preservative, aw and storage time) alone and in combination significantly (p < 0.001) affected the total fungal count and aflatoxins production in the feed. Minimum total fungal counts (1.99 × 10(2) CFU g(-1)) were observed in calcium propionate feed at 0.85 aw on day 1 and the highest (4.36 × 10(9) CFUs g(-1)) in control sample at 0.95 aw on day 28 of storage. During the storage period, AFB₁ content in control samples increased from 11.35 to 73.44, from 11.58 to 81.81 and from 11.54 to 102.68 ng g(-1), whereas in preserved feed the content of B₁ increased from 11.47 to 37.83, from 11.54 to 49.07 and from 11.20 to 53.14 ng g(-1) at 0.85, 0.90 and 0.95 aw, respectively. Similar patterns were noted for AFB2, AFG₁ and AFG₂ contents. All the aflatoxins readily increased over storage time; however, the increase was much slower in preserved feed that contained a lower amount of available water. This study reveals that calcium propionate addition to poultry litter along with water activity amelioration is an effective tool for controlling mould incidence and aflatoxin production in poultry feed.

Detoxification of aflatoxin in corn flour by ozone

BACKGROUND

Corn, which is one of most important agricultural products worldwide, is prone to pollution by aflatoxins (AFs) in many areas, thus seriously jeopardizing human health and threatening economic growth. This study evaluated the effects of ozone on the detoxification of AFs in corn flour (CF) and the moisture content (MC) thereof.

RESULTS

The detoxifying effects of ozone on CF became more obvious as the ozone concentration and exposure time increased. After CF was treated with 75 mg L(-1) ozone for 60 min, the contents of AFB1 , AFG1 and AFB2 decreased from 53.60, 12.08 and 2.42 µg kg(-1) to 11.38, 3.37 and 0.71 µg kg(-1) , respectively, which are lower than the maximum limits of AFB1 , AFG1 , AFB2 and total AFs (20 µg kg(-1) ) for CF regulated by the Chinese government. Ozonation significantly affected the MC of CF, and ozone at a higher concentration decreased the MC more drastically. After CF was exposed to 15, 30, 45 and 75 mg L(-1) ozone for 60 min, the MC of CF decreased from 17.4% to below 15%, fulfilling the long-period storage requirements for CF.

CONCLUSION

Ozone is potentially applicable in effectively degrading the AFs in CF and in greatly decreasing the MC of CF.

Food safety management systems performance in African food processing companies: a review of deficiencies and possible improvement strategies

This study seeks to provide insight into current deficiencies in food safety management systems (FSMS) in African food-processing companies and to identify possible strategies for improvement so as to contribute to African countries' efforts to provide safe food to both local and international markets. This study found that most African food products had high microbiological and chemical contamination levels exceeding the set (legal) limits. Relative to industrialized countries, the study identified various deficiencies at government, sector/branch, retail and company levels which affect performance of FSMS in Africa. For instance, very few companies (except exporting and large companies) have implemented HACCP and ISO 22000:2005. Various measures were proposed to be taken at government (e.g. construction of risk-based legislative frameworks, strengthening of food safety authorities, recommend use of ISO 22000:2005, and consumers' food safety training), branch/sector (e.g. sector-specific guidelines and third-party certification), retail (develop stringent certification standards and impose product specifications) and company levels (improving hygiene, strict raw material control, production process efficacy, and enhancing monitoring systems, assurance activities and supportive administrative structures). By working on those four levels, FSMS of African food-processing companies could be better designed and tailored towards their production processes and specific needs to ensure food safety.

MDM2 285G>C and 344T>A gene variants and their association with hepatocellular carcinoma: a Moroccan case-control study

BACKGROUND

MDM2 gene polymorphisms 285G/C and 344 T/A are two single nucleotide polymorphisms (SNPs) recently identified as important variants that could influence the expression of MDM2 gene through the modulation of transcription factors binding on the SNP309T/G. The 285C variant seems to present a geographically distinct distribution in humans and to be associated with a low cancer risk. In the present report, we studied the distribution of the three SNPs in a population with low liver cancer incidence.

METHODS

A group of 119 patients with hepatocellular carcinoma (HCC, 63.45 ± 12.59 year, 26-80) and another of 103 non-HCC controls (56 ± 10.82 year, 22-79) were enrolled to investigate association between MDM2 polymorphisms and susceptibility to develop HCC. The three studied SNPs (285G/C, 309 T/G and 344 T/A) were genotyped using polymerase chain reaction and sequencing techniques.

RESULTS

Genotypes and alleles distributions of the three studied polymorphisms of MDM2 were not significantly different between cases and controls. An increased risk of HCC development was found in case of 309G allele presence albeit without reaching the significance (29.8% vs 22.3%, OR = 1.48, 95% CI, 0.96-2.27, p = 0.073). In addition, neither 285C nor 344A MDM2 variants were significantly associated with an increased risk of HCC (p = 0.688 and p = 1 respectively). Remarkably, we found that the supposedly Caucasian-specific 285C variant was present in 1% of the Moroccan population.

CONCLUSIONS

This is the first study of the MDM2 SNP285G/C and SNP344T/A polymorphisms in association with HCC development. In contrast with previous studies, showing that females carrying SNP285C variant have a significantly reduced risk of developing breast, ovarian and endometrial cancer, no significant modulation of HCC risk was found in a North-African population.

Mycobiota and mycotoxin contamination of maize flours and popcorn kernels for human consumption commercialized in Spain

Mycobiota and co-occurrence of aflatoxins, citrinin, ochratoxin A and zearalenone in 30 samples of maize flours and 30 of popcorn kernels purchased in Spain for human consumption were determined. The mycotoxin-producing ability of Aspergillus, Fusarium and Penicillium spp. was also studied. Total fungal counts of maize flours ranged from <10 to 8.4 × 10(4) CFU/g and predominant mycobiota belonged to Aspergillus spp. and Penicillium spp. In popcorn kernels samples the most frequent species were Aspergillus spp., Mucorales, Fusarium spp. and Penicillium spp. Aflatoxins were produced by Aspergillus flavus and Aspergillus parasiticus, citrinin by Penicillium citrinum and Penicillium verrucosum, ochratoxin A by Aspergillus niger and patulin by Aspergillus clavatus and Penicillium griseofulvum. Identification of all the mycotoxin-producing strains as well as some Aspergillus spp. difficult to identify using phenotypic characters only was also performed by molecular methods. Aflatoxins were detected in 14 maize flours and 2 popcorn kernels samples, while ochratoxin A was detected in 4 maize flours and 10 popcorn samples. Co-occurrence of aflatoxins and ochratoxin A was found in the 4 ochratoxin-positive maize flour samples. Citrinin and zearalenone were not detected. This is the first report of aflatoxins and ochratoxin A contamination in maize flours and popcorn kernels commercialized in Spain.

Real-time PCR assays for detection and quantification of aflatoxin-producing molds in foods

Aflatoxins are among the most toxic mycotoxins. Early detection and quantification of aflatoxin-producing species is crucial to improve food safety. In the present work, two protocols of real-time PCR (qPCR) based on SYBR Green and TaqMan were developed, and their sensitivity and specificity were evaluated. Primers and probes were designed from the o-methyltransferase gene (omt-1) involved in aflatoxin biosynthesis. Fifty-three mold strains representing aflatoxin producers and non-producers of different species, usually reported in food products, were used as references. All strains were tested for aflatoxins production by high-performance liquid chromatography-mass spectrometry (HPLC-MS). The functionality of the proposed qPCR method was demonstrated by the strong linear relationship of the standard curves constructed with the omt-1 gene copy number and Ct values for the different aflatoxin producers tested. The ability of the qPCR protocols to quantify aflatoxin-producing molds was evaluated in different artificially inoculated foods. A good linear correlation was obtained over the range 4 to 1 log cfu/g per reaction for all qPCR assays in the different food matrices (peanuts, spices and dry-fermented sausages). The detection limit in all inoculated foods ranged from 1 to 2 log cfu/g for SYBR Green and TaqMan assays. No significant effect was observed due to the different equipment, operator, and qPCR methodology used in the tests of repeatability and reproducibility for different foods. The proposed methods quantified with high efficiency the fungal load in foods. These qPCR protocols are proposed for use to quantify aflatoxin-producing molds in food products.

Effect of low levels of aflatoxin B₁ on performance, biochemical parameters, and aflatoxin B₁ in broiler liver tissues in the presence of monensin and sodium bentonite

Aflatoxins (AF) are a major problem in broiler production and are significant economic and public health burdens worldwide. A commercial sodium bentonite (Na-B) adsorbent was used to prevent the effect of AF [50 µg of aflatoxin B₁ (AFB₁)/kg of feed] in broiler productivity, biochemical parameters, macroscopic and microscopic liver changes, and AFB₁ liver residues. The influence of Na-B (0.3%) and monensin (MON, 100 mg/kg), alone or in combination, was investigated in depth. The dietary treatments were as follows: treatment (T) 1: basal diet (B); T2: B + MON; T3: B + Na-B; T4: B + Na-B + MON; T5: B + AFB₁; T6: B + AFB₁ + Na-B + MON; T7: B + AFB₁ + MON; T8: B + AFB₁ + Na-B. Birds were fed dietary treatments for 28 d (d 18 to 46). No significant differences (P < 0.05) were observed among treatments with respect to broiler performance, biochemical parameters, or relative liver weights. With the exception of T8, all livers showed histopathological alterations, with accumulation of fat vacuoles. The normal appearance of livers from T8 showed the protective effect of Na-B against aflatoxicosis. The residual AFB₁ levels in livers from T5 to T8 ranged from 0.2 to 1.0 ng/g and were higher in livers from T6 (P < 0.05). Results of this study indicate a competition between AFB₁ and MON for adsorption sites on Na-B when feed contains low levels of the toxin, indicating a nonselective adsorption capacity of this particular Na-B. In addition, significant levels of AFB₁ in livers indicate that this determination is an important technique not only for diagnosis of aflatoxicosis in broilers, but also for quality control of avian products.

Determination of aflatoxins in cereal flours by solid-phase microextraction coupled with liquid chromatography and post-column photochemical derivatization-fluorescence detection

A new method for the determination of aflatoxins B(1), B(2), G(1), and G(2) (AFB(1), AFB(2), AFG(1), AFG(2)) in cereal flours based on solid-phase microextraction (SPME) coupled with high performance liquid chromatography with post-column photochemical derivatization and fluorescence detection (SPME-HPLC-PD-FD) has been developed. Aflatoxins were extracted from cereal flour samples by a methanol:phosphate buffer (pH 5.8, I=0.1) (80:20, v/v) solution, followed by a SPME step. Different SPME and HPLC-PD-FD parameters (fiber polarity, temperature, pH, ionic strength, adsorption and desorption time, mobile phase) have been investigated and optimized. This method, which was assessed for the analysis of different cereal flours, showed interesting results in terms of LOD (from 0.035 to 0.2 ng g(-1)), LOQ (from 0.1 to 0.63 ng g(-1), respectively), within and inter-day repeatability (2.27% and 5.38%, respectively) linear ranges (up to 20 ng g(-1) for AFB(1) and AFG(1) and 6 ng g(-1) for AFB(2) and AFG(2)), and total raw extraction efficiency (in the range 55-59% at concentrations in the range 0.3-1 ng g(-1) and 49-52% at concentrations in the range 1-10 ng g(-1)). The results were also compared with the purification step carried out by conventional immunoaffinity columns.

Fungal mycoflora and contamination of maize from Vietnam with aflatoxin B1 and fumonisin B1

Twenty five samples of maize intended for human or animal consumption coming from North, Central and South Vietnam were analysed for fungal contamination and for the presence of aflatoxin B1 and fumonisin B1. The total fungal load was found to be greater in maize intended for animal feed than for human consumption with average levels of 4x106 and 7x105 CFU/g, respectively. Identification of fungal strains revealed that Aspergillus was the most frequent genus, found in all maize samples whatever their intended use or their geographic origin. Among the Aspergillus species, A. flavus was the most frequent contaminant, observed in more than 90% of the samples. Other fungal strains found in the Vietnamese maize samples belonged to Penicillium species, Fusarium verticillioides and to the Mucorales, and were found in up to 53, 33 and 23% of the samples, respectively. All samples were tested for both aflatoxin and fumonisin contamination. Aflatoxin B1 was found in 17 samples (68%). Five of these samples showed aflatoxin B1 levels below 10 µg/kg, ten samples were found to be contaminated in a range of 11.3 to 47.2 µg/kg, and 2 samples showed contamination levels of 98.4 and 126.5 µg/kg, respectively. The maize samples for human consumption were found frequently contaminated with aflatoxin B1 (77%), but the level of contamination was lower than those for animal consumption. Fumonisin B1 contamination was found in 8 out of 25 samples (32%). Detected amounts of fumonisin B1 ranged from 0.4 to 3.3 mg/kg.

Genomic stability prevails in North-African hepatocellular carcinomas

The molecular pathogenesis of hepatocellular carcinoma, a tumour characterized by a vast clinical heterogeneity, remains unexplored outside Europe and Eastern Asia. We analysed by direct sequencing or loss of heterozygosity assay, the common targets of genomic alterations in 42 hepatocellular carcinomas collected in western North-Africa. Overall, genomic instability was uncommon, allelic losses affecting mostly chromosomes 1p, 4q, 8p and 17p (24-28% of cases). CTNNB1 and TP53 were infrequently mutated (9 and 17% of cases, respectively). Surprisingly, TP53 mutation R249S, diagnostic of aflatoxin B1 exposure, usually frequent in Africa, was exceptional (one case), indicating that in western North-Africa, hepatocellular carcinoma genetics differs markedly from that of the remainder of the continent.