Masquelet technique for reconstructing bone defects in open lower limb fracture: Analysis of the relationship between bone defect and bone graft

A Novel Method to Assess Healing of Segmental Bone Defects using the Induced Membrane Technique

OBJECTIVE

Clinical concerns exist regarding the quality of bony consolidation in the context of the induced membrane technique. This study evaluates the clinical process of bone grafting in the second stage of induced membrane bone union in patients with tibial bone defects to infer the possibility of non-union and establish a reliable and effective evaluation method combined with computed tomography (CT) to assess fracture healing.

METHODS

Patients with tibial bone defects who underwent the induced membrane technique at our hospital between February 2017 and February 2020 were retrospectively analyzed. The Hounsfield unit (HU) values of the patients were evaluated at different times during the second stage of bone grafting. Bone healing at the boundary value of the 120 HU output threshold (-1024 HU-3071 HU) was directionally selected, and the changes in the growth volume of union (new bone volume [selected according to HU value]/bone defect volume) were compared with analyzing individual class bone union. Method 1 involved X-rays revealing that at least three of the four cortices were continuous and at least 2 mm thick, with the patient being pain free. For Method 2, new bone volume (selected according to HU value/bone defect volume) at the stage was compared with analyzing individual class healing. Receiver operating characteristic curve analysis was used for Methods 1 and 2.

RESULTS

A total of 42 patients with a segmental bone defect with a mean age of 40.5 years (40.5 ± 8.3 years) were included. The relationship between bone graft volume and time variation was analyzed by single factor repeated variable analysis (F = 6.477, p = 0.016). Further, curve regression analysis showed that the change in bone graft volume over time presented a logarithmic curve pattern (Y = 0.563 + 0.086 × ln(X), Ra2 = 0.608, p = 0.041). ROC curve analysis showed that Method 2 is superior to Method 1 (AUC: 86.3% vs. 68.3%, p < 0.05).

CONCLUSION

The induced membrane technique could be used to treat traumatic long bone defects, with fewer complications and a higher healing rate. The proposed imaging grading of HU (new bone volume/bone defect volume) can be used as a reference for the quality of bony consolidation with the induced membrane technique.

Reconstruction of an Extensive Segmental Radial Shaft Bone Defect by Vascularized 3D-Printed Graft Cage

We report here a 46-year-old male patient with a 14 cm segmental bone defect of the radial shaft after third degree open infected fracture caused by a shrapnel injury. The patient underwent fixed-angle plate osteosynthesis and bone reconstruction of the radial shaft by a vascularized 3D-printed graft cage, including plastic coverage with a latissimus dorsi flap and an additional central vascular pedicle. Bony reconstruction of segmental defects still represents a major challenge in musculo-skeletal surgery. Thereby, 3D-printed scaffolds or graft cages display a new treatment option for bone restoration. As missing vascularization sets the limits for the treatment of large-volume bone defects by 3D-printed scaffolds, in the present case, we firstly describe the reconstruction of an extensive radial shaft bone defect by using a graft cage with additional vascularization.

Combining non-vascularized fibula and cancellous graft in the masquelet technique: A promising approach to distal femur compound fracture management with large defects

INTRODUCTION

Compound fractures of the distal femur with large defects pose a significant challenge in management, with several options available, including external fixators, bone grafting, the Masquelet-induced membrane technique, and free vascularized fibular grafts. The Masquelet-induced membrane technique involves placing a cement spacer in the defect to create a biologically active membrane. In the second stage, the gold standard for filling the defect is an autologous cancellous bone graft of 1-2 mm in size. This study aims to examine the effects of using a non-vascularized fibula as a support combined with a cancellous graft in the Masquelet technique for treating compound fractures of the distal femur.

METHODS

The study was conducted between December 2017 and December 2020 and included 11 patients who underwent the Masquelet technique. The procedure involved a lateral locked plate and an antibiotic-impregnated bone cement spacer, followed by a 20-30 mm longer ipsilateral fibula used as a strut graft. The remaining area was filled with cancellous bone from the iliac crest. The size of the defect, Time to the bony union, the average range of motion of the knee, and any complications are analysed. The final evaluation was done at 18 months using the Lower Extremity functional scale to assess functional outcomes.

RESULTS

The study included 11 patients (8 male and 3 female) with a mean age of 45.8 years. The average time to bony union was 6.6 months, and the average range of motion of the knee was 2.2° to 93.3 ° (0-110 °). No complications such as infection, non-union, or implant failure were observed.

CONCLUSION

The Masquelet Technique combined with a fibular strut graft is a feasible solution for complex distal femur fractures with bone loss. The non-vascularized fibula graft provides both structural support and reduces the amount of cancellous bone graft needed, which results in earlier weight bearing and improved functional outcomes.

Management of segmental defects post open distal femur fracture using a titanium cage combined with the Masquelet technique A single-centre report of 23 cases

INTRODUCTION

The segmental bone defects post open distal femur fracture presents a reconstructive challenge, which often requires extreme solutions. The present study reviewed a new treatment strategy which used a cylindrical titanium mesh cage as an adjunct to the Masquelet technique.

METHODS

We retrospectively reviewed a consecutive series of 23 patients treated for segmental bone defects post open distal femur fracture using a titanium mesh cage combined with the Masquelet technique under a 2-staged protocol in our institution from 2017 to 2021. The study group consisted of 13 men and 10 women with an average age of 44.1 years. The surgical debridement was performed with antibiotic polymethylmethacrylate (PMMA) cement spacer implanted into the bone defect combined with cement-wrapped plate stabilization, or antibiotic beads with vacuum sealing drainage (VSD) to cover the wound. The second stage of the Masquelet technique for bone defect repair began at least 4-6 weeks after the first stage, once all signs of possible infection were eliminated. After the cement spacer was removed, the definitive reconstruction was completed with exchange to a cylindrical titanium mesh cage filled with cancellous autograft within the induced membrane. The bone defect with cage was stabilized with a distal femoral Less Invasive Stabilization System (LISS). The radiological and clinical records of the enrolled patients were retrospectively analyzed.

RESULTS

The mean follow-up was 38.6 months. The average number of operations before the second stage was 1.3. The mean interval between the two stages was 12.7 weeks. The average length of the defect measured 8.3 cm (ranging from 6.1 to 12.4 cm). All the defects filled with autograft within the cage achieved bony union, with a mean healing time of 8.4 months. At the latest follow-up, the mean knee extension measured 6.2° (ranging from 0° to 20°), and the mean flexion measured 101.8° (ranging from 60° to 120°). Complications included two instances of superficial stitch abscess, which eventually healed.

CONCLUSIONS

The use of a titanium cage implanted into an induced membrane in a 2-staged Masquelet protocol could achieve satisfactory clinical outcomes in cases of segmental defects following open distal femur fractures.

Delayed Reconstruction of the Perforator Pedicle Propeller Flap after the Induced Membrane Technique for Gustilo IIIB Open Distal Tibial Fracture

This study aimed to evaluate the safety and efficacy of delayed reconstruction of the perforator pedicle propeller flap after the induced membrane technique in the treatment of Gustilo IIIB open distal tibial fracture, and to evaluate the clinical outcome and complications of two different perforator pedicle propeller flaps.Thirty-four patients with Gustilo IIIB open distal tibial fractures treated by the induced membrane technique and delayed reconstruction of two different perforator pedicle propeller flaps from May 2017 to March 2022 were retrospectively analyzed. Patients were divided into two groups according to the different kinds of perforator pedicle propeller flaps covered. The operation required two stages. The Radiographic Union Score for Tibial fractures (RUST) was used to evaluate the healing of the tibial bone defect. The American Orthopaedic Foot and Ankle Society (AOFAS) score was used to evaluate ankle function. The complications associated with the technique were recorded.The number of serial debridements, excluding those performed during emergency and final operations, was a mean of 2.28 ± 0.83 in the PAPF group. The PAPF group had a mean bone defect length of 6.76 ± 0.69 cm, the median healing time of 13.11 ± 0.96 months, RUST score 12.68 ± 1.63, and AOFAS score of 84.12 ± 6.38. On the other hand the PTAPF group's mean bone defect length was 6.73 ± 0.95 cm, the median healing time 12.63 ± 1.46 months, RUST score 13.73 ± 1.53 and AOFAS score 82.79 ± 5.49. There were no observed significant differences the two groups in the number of serial debridements, bone defect length, bone union time, RUST score, or AOFAS score (p > 0.05). Flap size ranged from 9 × 6 cm2 to 14 × 7 cm2 in the PAPF group and from 9 × 6 cm2 to 13 × 7 cm2 in the PTAPF group. There were no severe complications such as flap-related complications or amputation. The differences in complications in the two groups were not statistically significant.In cases of severe open tibial fracture, the reconstructive method is important. When delayed reconstruction is inevitable, surgeons should first perform radical debridement, followed by vacuum sealing drainage as a bridging therapy; both PAPF and PTAPF can be considered for definitive soft tissue coverage.

Matched-Pair Analysis: Large-Sized Defects in Surgery of Lower Limb Nonunions

BACKGROUND

The treatment of large-sized bone defects remains a major challenge in trauma and orthopaedic surgery. Although there are many treatment options, there is still no clear guidance on surgical management, and the influence of defect size on radiological and clinical outcome remains unclear due to the small number of affected patients. The aim of the present study was to determine the influence of defect size on the outcome of atrophic and infected nonunions of the tibia or the femur based on the diamond concept in order to provide recommendations for treatment guidance.

PATIENTS AND METHODS

All medical records, surgical reports, laboratory data and radiological images of patients treated surgically for atrophic or infected nonunions of the lower limbs (femur or tibia) between 1 January 2010 and 31 December 2020 were examined. Patients with proximal, diaphyseal or distal nonunions of the femur or tibia who were surgically treated at our institution according to the "diamond concept" and attended our standardised follow-up program were included in a database. Surgical treatment was performed as a one- or two-step procedure, depending on the type of nonunion. Patients with a segmental bone defect ≥5 cm were matched with patients suffering a bone defect <5 cm based on five established criteria. According to our inclusion and exclusion criteria, 70 patients with a bone defect ≥5 cm were suitable for analysis. Two groups were formed by matching: the study group (bone defect ≥5 cm; n = 39) and control group (bone defect <5 cm; n = 39). The study was approved by the local ethics committee (S-262/2017).

RESULTS

The mean defect size was 7.13 cm in the study and 2.09 cm in the control group. The chi-square test showed equal consolidation rates between the groups (SG: 53.8%; CG: 66.7%). However, the Kaplan-Meier curve and log-rank test showed a significant difference regarding the mean duration until consolidation was achieved, with an average of 15.95 months in the study and 9.24 months in the control group (α = 0.05, p = 0.001). Linear regression showed a significant increase in consolidation duration with increasing defect size (R² = 0.121, p = 0.021). Logistic regression modelling showed a significant negative correlation between consolidation rate and revision performance, as well as an increasing number of revisions, prior surgeries and total number of surgeries performed on the limb. Clinical outcomes showed equal full weight bearing of the lower extremity after 5.54 months in the study vs. 4.86 months in the control group (p = 0.267).

CONCLUSION

Surprisingly, defect size does not seem to have a significant effect on the consolidation rate and should not be seen as a risk factor. However, for the treatment of large-sized nonunions, the follow-up period should be prolonged up to 24 months, due to the extended time until consolidation will be achieved. This period should also pass before a premature revision with new bone augmentation is performed. In addition, it should be kept in mind that as the number of previous surgeries and revisions increases, the prospects for consolidation decrease and a change in therapeutic approach may be required.

Predictive factors for docking site procedure in bone transport for large lower extremity segmental defects

BACKGROUND

Segmental bone transport is a common technique for treating large segmental bone defects. However, a docking site procedure is often necessary in segmental bone transport. To date, no prognostic factors for the need of docking site procedure have been reported. Thus, the decision is often made at random, based on the surgeon's subjective judgment and experience. The aim of this study was to identify prognostic factors for the need of docking site operation.

METHODS

Patients with segmental bone transport in lower extremity bone defects were included regardless of age, aetiology, and defect size. We excluded patients undergoing treatments that were not yet completed, and those who discontinued therapy by any reason. The need for docking site operation was modelled with logistical and linear regression as well as univariate analysis of variances (ANOVA). Receiver operating characteristics (ROC) curve analysis was also performed.

RESULTS

Twenty-seven patients from age 12 to 74 years (mean age: 39.07 ± 18.20 years) were included. The mean defect size was 76.39 ± 41.10 mm. The duration of transport (days) showed a significant influence (p = 0.049, 95%CI: 1.00-1.02) on the need for docking site operation. No other significant influences were detected.

CONCLUSION

A link between the duration of transport and the need for docking site operation was detected. Our data showed that if a threshold of about 188 days is exceeded, docking surgery should be considered.

Varying degrees of spontaneous osteogenesis of Masquelet's induced membrane: experimental and clinical observations

BACKGROUND

Masquelet's induced membrane (IM) has osteogenesis activity, but IM spontaneous osteogenesis (SO) has not been described previously.

OBJECTIVES

To report on varying degrees of IMSO and analyze its possible causes.

METHODS

Twelve eight-week-old male Sprague-Dawley rats with 10 mm right femoral bone defects who received the first stage of IM technique (IMT) were used to observe the SO. In addition, clinical data from patients with bone defects who received the first stage of IMT with an interval of > 2 months post-operatively and exhibited SO between January 2012 and June 2020 were retrospectively analyzed. The SO was divided into four grades according to the amount and characteristics of the new bone formation.

RESULTS

At twelve weeks, grade II SO was observed in all rats, and more new bone was formed in the IM near the bone end forming an uneven margin. Histology revealed bone and cartilage foci in the new bone. Four of the 98 patients treated with the first stage of IMT exhibited IMSO, including one female and three males with a median age of 40.5 years (range 29-52 years). The bone defects were caused by severe fractures and infection in two cases and by infection or tumor in one case each. Partial or segmental defects occurred in two cases. The time interval between inserting a cement spacer and diagnosis of SO ranged from six months to nine years. Two cases were grade I, and one case each of grades III and IV.

CONCLUSION

Varying degrees of SO confirm the existence of the IMSO phenomenon. Bioactive bone tissue or local inflammation and a long time interval are the primary reasons underlying enhancement of the osteogenic activity of IM and leading to SO, which tends to take place as endochondral osteogenesis.

Outcome of the Masquelet Technique for Complex Bilateral Distal Femoral Bone Defects

Bone defects are severe conditions caused by various etiologies, including trauma, tumor resection, or chronic osteomyelitis. Different surgical interventions can be utilized to manage such cases, including autologous graft or allograft implantation, distraction osteogenesis, acute shortening, amputation, or the induced membrane technique. Herein, the case of a 39-year-old woman with complex bilateral distal femoral fractures with intra-articular extension is presented. The fractures were accompanied by a significant metaphyseal bone defect, which was managed successfully using the induced membrane Masquelet technique. The patient fully healed despite residual knee joint contractures that did not inhibit her mobility. In conclusion, the Masquelet technique successfully manages complex bone defects and restores functionality even in bilateral simultaneous open bone defects.

Management of wounds with exposed bone structures using an induced-membrane followed by polymethyl methacrylate and second-stage skin grafting in the elderly with a 3-year follow-up

The treatment of traumatic wounds with exposed bone or tendons is often challenging. An induced membrane (IM) is used to reconstruct bone defects, as it provides an effective and sufficient blood supply for bone and soft-tissue reconstruction. This study explored a novel two-stage strategy for wound management, consisting of initial wound coverage with polymethyl methacrylate (PMMA) and an autologous split-thickness skin graft under the IM. Fifty inpatients were enrolled from December 2016 to December 2019. Each patient underwent reconstruction according to a two-stage process. In the first stage, the defect area was thoroughly debrided, and the freshly treated wound was then covered using PMMA cement. After 4-6 weeks, during the second stage, the PMMA cement was removed to reveal an IM covering the exposed bone and tendon. An autologous split-thickness skin graft was then performed. Haematoxylin and eosin (H&E) staining and immunohistochemical analysis of vascular endothelial growth factor (VEGF), CD31 and CD34 were used to evaluate the IM and compare it with the normal periosteal membrane (PM). The psychological status and the Lower Extremity Function Scale (LEFS) as well as any complications were recorded at follow-up. We found that all skin grafts survived and evidenced no necrosis or infection. H&E staining revealed vascularised tissue in the IM, and immunohistochemistry showed a larger number of VEGF-, CD31- and CD34-positive cells in the IM than in the normal PM. The duration of healing in the group was 5.40 ± 1.32 months with a mean number of debridement procedures of 1.92 ± 0.60. There were two patients with reulceration in the group. The self-rating anxiety scale scores ranged from 35 to 60 (mean 48.02 ± 8.12). Postoperatively, the LEFS score was 50.10 ± 9.77. Finally, our strategy for the management of a non-healing wound in the lower extremities, consisting of an IM in combination with skin grafting, was effective, especially in cases in which bony structures were exposed in the elderly. The morbidity rate was low.

Robot-assisted versus conventional percutaneous sacroiliac screw fixation for posterior pelvic ring injuries: a systematic review and meta-analysis

PURPOSE

Robot-assisted pelvic screw fixation is a new technology with promising benefits on intraoperative outcomes for patients with posterior pelvic ring injuries. We aim to compare robot-assisted pelvic screw fixation to the traditional fluoroscopy-assisted technique with regards to intraoperative and postoperative outcomes.

METHODS

The Preferred Reporting Items for Systematic Reviews and Meta-Analyses (PRISMA) guidelines were used along with a search of electronic information to identify all studies comparing the outcomes of robot-assisted versus conventional screw fixation in patients with posterior pelvic ring injuries. Primary outcomes included operative duration (minutes), intraoperative bleeding (mL), fluoroscopy exposure and intraoperative drilling frequency. Secondary outcome measures included Majeed score, healing time (minutes) and rate (%), postoperative complications, screw positioning, incision length (cm) and guide wire insertion times (minutes). The random effects model was used for analysis.

RESULTS

Four observational studies including a total of 294 patients were identified. There was a significant difference between robot-assisted and conventional groups in terms of operative duration (MD = - 24.66, p < 0.05), intraoperative bleeding (MD = - 10.37, P < 0.05), fluoroscopy exposure (MD = - 2.15, P < 0.05) and intraoperative drilling frequency (MD = - 2.42, P =  < 0.05). For secondary outcomes, no significant difference was seen in Majeed score, healing time and rate and postoperative complications. The robot-assisted group had better screw positioning, smaller incision length, and shorter anaesthesia and guide wire insertion times.

CONCLUSIONS

Robot-assisted fixation has superior intraoperative outcomes compared to conventional fixation. Further studies are needed to look at postoperative outcomes as there is no significant difference in postoperative prognosis between the techniques.

A Review on Three-Dimensional Printed Silicate-Based Bioactive Glass/Biodegradable Medical Synthetic Polymer Composite Scaffolds

In recent years, tissue engineering scaffolds have turned into the preferred option for the clinical treatment of pathological and traumatic bone defects. In this field, silicate-based bioactive glasses (SBGs) and biodegradable medical synthetic polymers (BMSPs) have attracted a great deal of attention owing to their shared exceptional advantages, like excellent biocompatibility, good biodegradability, and outstanding osteogenesis. Three-dimensional (3D) printed SBG/BMSP scaffolds can not only replicate the mechanical properties and microstructure of natural bone but also degrade in situ after service and end up being replaced by regenerated bone tissue in vivo. This review first consolidates the research efforts in 3D printed SBG/BMSP scaffolds, and then focuses on their composite mechanism. This review may help to provide a fresh perspective for SBG/BMSP composite system in bone regeneration.

Induced Membrane Technique for the Management of Segmental Femoral Defects: A Systematic Review and Meta-Analysis of Individual Participant Data

Several modifications of the induced membrane technique (IMT) have been reported, but there is no consensus regarding their results and prognosis. Moreover, most studies have focused on tibial defects; no meta-analysis of the treatment of femoral defects using the IMT has been reported. This systematic review and meta-analysis aimed to identify the potential risk factors of post-procedural complications following the treatment of segmental femoral defects using the IMT. A comprehensive search was performed on the Cochrane Library, EBSCO, EMBASE, Ovid, PubMed, Scopus, and Web of Science databases, using the keywords "femur," "Masquelet technique," and "induced membrane technique." Original articles composed in English, having accessible individual patient data, and reporting more than two cases of bony defect or nonunion of femur or more than five cases of any body part were included. Post-procedural bone graft infections, final union status, and union time after second-stage operation were analyzed. Fourteen reports, including 90 patients, were used in this study. External fixation in second-stage surgery had an odds ratio of 9.267 for post-procedural bone graft infection (p = 0.047). The odds ratio of post-procedural bone graft infection and age >65 years for final non-union status was 51.05 (p = 0.003) and 9.18 (p = 0.042). Shorter union time was related to impregnated antibiotics in the spacer (p = 0.005), transplanting all-autologous grafts (p = 0.042), and the application of intramedullary nails as the second-stage fixation method (p = 0.050). The IMT appears to be reasonable and reproducible for femoral segmental bone defects. Several preoperative and surgical factors may affect post-procedural complications and union time.

Multi-stage treatment for malunion and avascular necrosis of the femoral head following reverse oblique pertrochanteric fracture: A case report and literature review

Femoral reverse oblique intertrochanteric fractures are successfully treated using intramedullary devices. Poor fracture reduction and the use of the inaproppriate implant can lead to implant failure and subsequent malunion or non-union.

We present the case of a 21-year-old polytrauma female who, among other injuries, sustained a reverse oblique intertrochanteric fracture that was primarily operated on with the dynamic hip screw. After implant failure the patient developed malunion with bone defect and avascular necrosis of the femoral head. Successful salvage of the bone stock in the inter- and subtrochanteric region was achieved using the two-stage induced membrane technique. The uncemented total hip arthroplasty was performed to address the osteonecrosis of the femoral head.

A meta-analysis of the Masquelet technique and the Ilizarov bone transport method for the treatment of infected bone defects in the lower extremities

Purpose:To compare the clinical outcomes of the Masquelet technique and Ilizarov bone transport method for the treatment of patients with infected bone defects in the lower extremities. Methods: Eligible studies were searched from six databases until 12 April 2021. Data extraction was independently conducted by two investigators, which was followed by a quality assessment. Weighted mean difference (WMD) and 95% confidence interval (CI) were used to analyze continuous variables, while odds ratio (OR) and 95% CI were used to analyze categorical variables. All statistical analyses were conducted using RevMan 5.3 and Stata 12.0. Results: Thirteen articles were included in this meta-analysis. There was a significant difference observed in hospitalization costs (WMD [95% CI] = -1.75 [-2.50, -0.99] thousand US dollar, p < 0.00,001), final union time (WMD [95% CI] = -4.54 [-6.91, -2.17] months, p = 0.0002), time to full weight bearing (WMD [95% CI] = -1.73 [-3.36, -0.10] months, p = 0.04), quality of life (WMD [95% CI] = 7.70 [4.74, 10.67], p < 0.00,001), and the risk of complications (OR [95%CI] = 0.39 [0.19, 0.79], p = 0.009) between the Masquelet and Ilizarov groups. No significant differences in other outcomes were observed between the two groups. Conclusion: Masquelet technique exhibited the advantages in the lower hospitalization cost, shorter final union time, shorter time to full weight bearing, lower rate of complications, and better post-operative quality of life, compared with Ilizarov bone transport method. However, this finding should be confirmed in large-scale clinical samples.

Union, complication, reintervention and failure rates of surgical techniques for large diaphyseal defects: a systematic review and meta-analysis

To understand the potential and limitations of the different available surgical techniques used to treat large, long-bone diaphyseal defects by focusing on union, complication, re-intervention, and failure rates, summarizing the pros and cons of each technique. A literature search was performed on PubMed, Web of Science, and Cochrane databases up to March 16th, 2022; Inclusion criteria were clinical studies written in English, of any level of evidence, with more than five patients, describing the treatment of diaphyseal bone defects. The primary outcome was the analysis of results in terms of primary union, complication, reintervention, and failure rate of the four major groups of techniques: bone allograft and autograft, bone transport, vascularized and non-vascularized fibular graft, and endoprosthesis. The statistical analysis was carried out according to Neyeloff et al., and the Mantel–Haenszel method was used to provide pooled rates across the studies. The influence of the various techniques on union rates, complication rates, and reintervention rates was assessed by a z test on the pooled rates with their corresponding 95% CIs. Assessment of risk of bias and quality of evidence was based on Downs and Black’s “Checklist for Measuring Quality” and Rob 2.0 tool. Certainty of yielded evidence was evaluated with the GRADE system. Seventy-four articles were included on 1781 patients treated for the reconstruction of diaphyseal bone defects, 1496 cases in the inferior limb, and 285 in the upper limb, with trauma being the main cause of bone defect. The meta-analysis identified different outcomes in terms of results and risks. Primary union, complications, and reinterventions were 75%, 26% and 23% for bone allografts and autografts, 91%, 62% and 19% for the bone transport group, and 78%, 38% and 23% for fibular grafts; mean time to union was between 7.8 and 8.9 months in all these groups. Results varied according to the different aetiologies, endoprosthesis was the best solution for tumour, although with a 22% failure rate, while trauma presented a more composite outcome, with fibular grafts providing a faster time to union (6.9 months), while cancellous and cortical-cancellous grafts caused less complications, reinterventions, and failures. The literature about this topic has overall limited quality. However, important conclusions can be made: Many options are available to treat critical-size defects of the diaphysis, but no one appears to be an optimal solution in terms of a safe, satisfactory, and long-lasting outcome. Regardless of the bone defect cause, bone transport techniques showed a better primary union rate, but bone allograft and autograft had fewer complication, reintervention, and failure rates than the other techniques. The specific lesion aetiology represents a critical aspect influencing potential and limitations and therefore the choice of the most suitable technique to address the challenging large diaphyseal defects.