Wheat aleurone layer: A site enriched with nutrients and bioactive molecules with potential nutritional opportunities for breeding

NanoLC-MS/MS protein analysis on laser-microdissected wheat endosperm tissues: A comparison between aleurone, sub-aleurone and inner endosperm

Wheat kernel proteins are not homogeneously distributed throughout the endosperm. The goal of this study was to investigate the relative differences in protein composition between the aleurone, sub-aleurone and inner endosperm. Using laser microdissection followed by nanoLC-MS/MS, an innovative method combining high spatial specificity and analytical selectivity in sample-limited situations, 780 proteins were detected and classified by function. A higher proportion of gluten proteins was detected in the sub-aleurone than inner endosperm. Composition-wise, gluten from the sub-aleurone is relatively more enriched in ω-gliadins but impoverished in LMW-GS and γ-gliadins. While a basic set of albumins and globulins was detected in all three microdissected endosperm tissues, specific proteins, like puroindoline B, displayed a gradient. This study provides indications that both histological origin and relative positioning of the tissues drive the protein distribution. Knowledge of this protein distribution offers significant opportunities for the wheat manufacturing industry. Data available via ProteomeXchange, identifier PXD038743.

Effect of wheat aleurone on lard emulsions during in vitro digestion

Dietary wheat aleurone has been shown to affect lipid metabolism and reduce the incidence of obesity. However, the underlying mechanisms are not fully understood. This work aimed to investigate how whole wheat aleurone affects lipolysis during the whole digestion process in vitro. The physicochemical and microstructural changes and the lipolysis kinetics of different lard emulsion mixtures were determined. The results showed that the lipolysis rate and degree are inversely proportional to the amount of wheat aleurone. Wheat aleurone and flour promoted the aggregation and flocculation of lipid droplets by increasing the viscosity. More importantly, the dietary fibers released from aleurone digestion can reduced the binding of lipase to lipid droplets by adsorbing lipid droplets to increase the steric hindrance effect. These results provide a better understanding of how whole grains affect lipid digestibility and will further contribute to the development of functional foods and the improvement of individual health.

The Wheat Starchy Endosperm Protein Gradient as a Function of Cultivar and N-fertilization Is Reflected in Mill Stream Protein Content and Composition

Within the wheat starchy endosperm, the protein content increases biexponentially from the inner to outer endosperm. Here, we studied how this protein gradient is reflected in mill fractions using three cultivars (Claire, Apache, and Akteur) grown without and with N-fertilization (300 kg N ha-1). The increasing protein content in successive break fractions was shown to reflect the protein gradient within the starchy endosperm. The increasing protein content in successive reduction fractions was primarily due to more aleurone contamination and protein-rich material being harder to reduce in particle size. The miller's bran fractions had the highest protein content because of their high sub-aleurone and aleurone content. Additionally, the break fractions were used to deepen our understanding of the protein composition gradient. The gradient in relative gluten content, increasing from inner to outer endosperm, was more pronounced without N-fertilization than with and reached levels up to 87.3%. Regarding the gluten composition gradient, no consistent trends were observed over cultivars when N-fertilization was applied. This could, at least partly, explain why there is no consensus on the gluten composition gradient in the literature. This study aids millers in managing fluctuations in the functionality of specific flour streams, producing specialized flours, and coping with lower-quality wheat.

Effects of milling on texture and in vitro starch digestibility of oat rice

Compared with other oat products, consumers in China prefer oat rice and porridge made from naked oat. However, this oat product usually has poor sensory acceptance, which is directly related to the texture properties. This study aimed to use the milling method to improve the oat rice texture. The nutrient component, microstructure, pasting, and thermal properties of oat treated with different degrees of milling (0 s, 20 s, 40 s, 60 s, and 80 s) were researched. The results showed that milling would damage the bran layer of oat rice, increasing starch, β-glucan, total leached solids content, and the gelatinization enthalpy (ΔH). Meanwhile, oil, protein content, the pasting viscosity, and the pasting temperature were decreased. Milling made oat rice sticky and soft, and the bound water and non-flowing water migrated like flowing water. The cross-section of oat rice showed that milling damaged the surface of oat rice, which was beneficial to water entry and starch dissolution, and increased the viscosity of oat rice. When the milling time was 40 s and 60 s, the appearance, aroma, taste, texture, and overall acceptability of oat porridge were better. Moreover, rapid digestion fraction (k1) and slow digestion fraction (k2) are the lowest and have the effect of low blood glucose rise rate.

Genetic Approaches to Increase Arabinoxylan and β-Glucan Content in Wheat

Wheat is one of the three staple crops feeding the world. The demand for wheat is ever increasing as a relatively good source of protein, energy, nutrients, and dietary fiber (DF) when consumed as wholemeal. Arabinoxylan and β-glucan are the major hemicelluloses in the cell walls and dietary fiber in wheat grains. The amount and structure of DF varies between grain tissues. Reducing post-prandial glycemic response as well as intestinal transit time and contribution to increased fecal bulk are only a few benefits of DF consumption. Dietary fiber is fermented in the colon and stimulates growth of beneficial bacteria producing SCFA, considered responsible for a wide range of health benefits, including reducing the risk of heart disease and colon cancer. The recommended daily intake of 25-30 g is met by only few individuals. Cereals cover nearly 40% of fiber in the Western diet. Therefore, wheat is a good target for improving dietary fiber content, as it would increase the fiber intake and simultaneously impact the health of many people. This review reflects the current status of the research on genetics of the two major dietary fiber components, as well as breeding approaches used to improve their quantity and quality in wheat grain.

Cereal bran proteins: recent advances in extraction, properties, and applications

The projected global population is expected to reach around 9.7 billion by 2050, indicating a greater demand for proteins in the human diet. Cereal bran proteins (CBPs) have been identified as high-quality proteins, with potential applications in both the food and pharmaceutical industries. In 2020, global cereal grain production was 2.1 billion metric tonnes, including wheat, rice, corn, millet, barley, and oats. Cereal bran, obtained through milling, made up 10-20% of total cereal grain production, varying by grain type and milling degree. In this article, the molecular composition and nutritional value of CBPs are summarized, and recent advances in their extraction and purification are discussed. The functional properties of CBPs are then reviewed, including their solubility, binding, emulsifying, foaming, gelling, and thermal properties. Finally, current challenges to the application of CBPs in foods are highlighted, such as the presence of antinutritional factors, low digestibility, and allergenicity, as well as potential strategies to improve the nutritional and functional properties by overcoming these challenges. CBPs exhibit nutritional and functional attributes that are similar to those of other widely used plant-based protein sources. Thus, CBPs have considerable potential for use as ingredients in food, pharmaceutical, and other products.

Effects of cereal grain cell wall composition and structure on starch digestion

BACKGROUND

Wheat is an important food crop, and its characteristics vary depending on the region of cultivation; different environments have varying effects on the composition of the grains. We previously reported the effects of environmental factors on wheat grain cell wall composition and structure.

METHODS

The variations in the structure of aleurone cell walls between different wheat samples were examined to determine the effects of aleurone cell walls on grain starch digestion properties. Ten different varieties of wheat grains with different aleurone cell wall structure and composition constituted a simple research system used to study their effect on the starch digestion of bread.

RESULTS

The aleurone cell wall thickness ranged from 3.05 μm to 4.67 μm, and the arabinose to xylose ration of water-extractable arabinoxylan was 0.79-0.97. With the increase in arabinoxylans content or cell wall thickness, the total digestibility of starch within the bread decreased; this phenomenon may be related to the changes in the interaction between polysaccharides and starch granules in this process.

CONCLUSION

Our study showed that the wheat cell wall structure has a great impact on starch hydrolysis, indicating that the change in the digestibility of starch in flour and bread may be due to changes in the cell wall structure leading to different combinations, thus affecting digestibility. The present study showed that the cell wall combines the starch granules during the bread-making process; thus, the diffusion of enzymes through the cell wall was hindered. This article is protected by copyright. All rights reserved.

Mapping and validation of quantitative trait loci associated with dorsal aleurone thickness in rice (Oryza sativa)

KEY MESSAGE

Mapping of QTLs for dorsal aleurone thickness (DAT) was performed using chromosome segment substitution lines in rice. Three QTLs, qDAT3.1, qDAT3.2, and qDAT7.1, were detected in multiple environments. As a specified endosperm cell type, the aleurone has an abundance of various nutrients. Increasing the number of aleurone layers is a practicable way of developing highly nutritious cereals. Identifying genes that can increase aleurone thickness is useful for the breeding of aleurone traits to improve the nutritional and health values of rice. Here, we found that iodine staining could efficiently distinguish the aleurone layers, which revealed great variation of the aleurone thickness in rice, especially at the dorsal side of the seed. Therefore, we used a population of chromosome segmental substitution lines (CSSLs) derived from Koshihikari and Nona Bokra for quantitative trait locus (QTL) analysis of the dorsal aleurone thickness (DAT). Three QTLs, qDAT3.1, qDAT3.2, and qDAT7.1, were detected in multiple seasons. Among these, qDAT3.2 colocalizes with Hd6 and Hd16, two QTLs previously identified to regulate the heading date of Koshihikari, explaining the negative correlation between the DAT and days to heading (DTH) in rice. We also provide evidence that early-heading ensures the filling of rice seed under a relatively high temperature to promote aleurone thickening. qDAT7.1, the most stable QTL expressed in different environments, functions independently from heading date. Although Nona Bokra has a lower DAT, its qDAT7.1 allele significantly increased DAT in rice, which was further validated using two near-isogenic lines (NILs). These findings pave the way for further gene cloning of aleurone-related QTLs and may aid the development of highly nutritious rice.

The conformation of glutenin polymers in wheat grain: some genetic and environmental factors associated with this important characteristic

In a previous study we used asymmetric-flow field-flow fractionation to determine the polymer mass (Mw), gyration radius (Rw) and the polydispersity index of glutenin polymers (GPs) in wheat (Triticum aestivum). Here, using the same multi-location trials (4 years, 11 locations, and 192 cultivars), we report the factors that are associated with the conformation (Conf) of the polymers, which is the slope of Log(Rw) versus a function of Log(Mw). We found that Conf varied between 0.285 and 0.740, it had low broad-sense heritability (H2=16.8), and it was significantly influenced by the temperature occurring over the last month of grain filling. Higher temperatures were found to increase Rw and the compactness and sphericity of GPs. Alleles for both high- and low-molecular-weight glutenin subunits had a significant influence on the Conf value. Assuming a Gaussian distribution for Mw, the number of polymers present in wheat grains was computed for different kernel weights and protein concentrations, and it was found to exceed 1012 GPs per grain. Using atomic force microscopy and cryo-TEM, images of GPs were obtained for the first time. Under higher average temperature, GPs became larger and more spherical and consequently less prone to rapid hydrolysis. We propose some orientations that could be aimed at potentially reducing the impact of numerous GPs on people suffering from non-celiac gluten sensitivity.

Effect of Layered Debranning Processing on the Proximate Composition, Polyphenol Content, and Antioxidant Activity of Whole Grain Wheat

Layered debranning processing (LDP) of whole grain wheat (WGW) could not only retain more bioactive compounds but also contributes to grain saving policy as compared with the refined wheat flour (WF). In this study, effect of different debranning rates from 0 to 13.37% on the proximate composition, polyphenol content, and the antioxidant activity were analyzed. As debranning rates increased from 0 to 13.37%, the insoluble dietary fiber content decreased from 9.94% to 6.47%, whereas the soluble dietary fiber contents increased from 3.06% to 3.98%. The free phenolic content decreased by 62.72%, while the free flavonoid content increased by 4.68% with debranning rates increasing. For the phenolic acids, protocatechuic acid and ferulic acid dominated the free and bound phenolic acid in WGW, which showed the highest contents at 6.95% and 4.45% debranning rates, respectively. As for flavonoids, naringenin (the free-state phenolic) and rutin (the bound state phenolic) in WGW had the greatest level at 4.45% debranning rate. As compared to WGW and WF, LDP significantly improved the DPPH, ABTS·+ radical scavenging activities and total antioxidant activities. In conclusion, 4.45% and 6.95% were the best debranning rates to retain polyphenol contents and antioxidant activities.

Wheat bran layers: composition, structure, fractionation, and potential uses in foods

Wheat bran, the main by-product of dry milling of wheat, is currently mainly used in the animal feed industry, but has attracted attention as a food ingredient owing to its high dietary fiber and phytochemical contents, providing excellent physiological effects. The bran layers (aleurone layer, outer pericarp and intermediate layer) contain different compositions, structures, and nutrients, and have different properties. Each layer, when separated and isolated, potentially could find more extensive applications in foods. This triggered interest in isolating the bran layers using milling and wet- or dry-fractionation techniques based on their chemical or physical properties. The recent progress has allowed the production of commercial products from wheat bran layers, particularly aleurone-rich products, enhancing the value of wheat bran layers and their applications in food. The present review highlights the recent advances in studying the chemical composition including distribution of chemical components, physical structure, biopolymer matrix, and physicochemical properties of each wheat bran layer. Technologies to fractionate wheat bran layers and utilization of different bran layers in foods are discussed and reviewed, providing new strategies for improving the value of wheat bran and utilization of wheat bran in foods.

Transcriptome and Proteome Analysis Revealed the Influence of High-Molecular-Weight Glutenin Subunits (HMW-GSs) Deficiency on Expression of Storage Substances and the Potential Regulatory Mechanism of HMW-GSs

The processing quality of wheat is affected by seed storage substances, such as protein and starch. High-molecular-weight glutenin subunits (HMW-GSs) are the major components of wheat seed storage proteins (SSPs); they are also key determinators of wheat end-use quality. However, the effects of HMW-GSs absence on the expression of other storage substances and the regulation mechanism of HMW-GSs are still limited. Previously, a wheat transgenic line LH-11 with complete deletions of HMW-GSs was obtained through introducing an exogenous gene Glu-1E^bx to the wild-type cultivar Bobwhite by transgenic approach. In this study, comparative seed transcriptomics and proteomics of transgenic and non-transgenic lines at different seed developmental stages were carried out to explore the changes in genes and proteins and the underlying regulatory mechanism. Results revealed that a number of genes, including genes related to SSPs, carbohydrates metabolism, amino acids metabolism, transcription, translation, and protein process were differentially enriched. Seed storage proteins displayed differential expression patterns between the transgenic and non-transgenic line, a major rise in the expression levels of gliadins were observed at 21 and 28 days post anthesis (DPA) in the transgenic line. Changes in expressions of low-molecular-weight glutenins (LMW-GSs), avenin-like proteins (ALPs), lipid transfer proteins (LTPs), and protease inhibitors (PIs) were also observed. In addition, genes related to carbohydrate metabolism were differentially expressed, which probably leads to a difference in starch component and deposition. A list of gene categories participating in the accumulation of SSPs was proposed according to the transcriptome and proteome data. Six genes from the MYB and eight genes from the NAC transcription families are likely important regulators of HMW-GSs accumulation. This study will provide data support for understanding the regulatory network of wheat storage substances. The screened candidate genes can lay a foundation for further research on the regulation mechanism of HMW-GSs.

The Wheat Aleurone Layer: Optimisation of Its Benefits and Application to Bakery Products

The wheat aleurone layer is, according to millers, the main bran fraction. It is a source of nutritionally valuable compounds, such as dietary fibres, proteins, minerals and vitamins, that may exhibit health benefits. Despite these advantages, the aleurone layer is scarce on the market, probably due to issues related to its extraction. Many processes exist with some patents, but a choice must be made between the quality and quantity of the resulting product. Nonetheless, its potential has been studied mainly in bread and pasta. While the nutritional benefits of aleurone-rich flour addition to bread agree, opposite results have been obtained concerning its effects on end-product characteristics (namely loaf volume and sensory characteristics), thus ensuing different acceptability responses from consumers. However, the observed negative effects of aleurone-rich flour on bread dough could be reduced by subjecting it to pre- or post-extracting treatments meant to either reduce the particle size of the aleurone's fibres or to change the conformation of its components.

Simultaneous Determination of B1, B2, B3, B6, B9, and B12 Vitamins in Premix and Fortified Flour Using HPLC/DAD: Effect of Detection Wavelength

Simultaneous determination of water-soluble B vitamins is a troublesome analytical procedure since they have greatly variable structures and acid-base properties which imposed difficulties on eluting them in short time and selecting wavelength of detection. The aim of the present study was to develop a simple method that overcomes these difficulties. The method was successful in simultaneous determination of B1, B2, B3, B6, B9, and B12 in premix and fortified flour by extracting vitamins with 0.1% (w/v) of ascorbate and ethylene diamine tetra-acetic acid (EDTA) solution followed by eluting using gradient mobile phase consisting of 0.03% trifluoroacetic acid aqueous solution (pH 2.6) and acetonitrile on high performance liquid chromatography (HPLC) instrument coupled with diode array detector (DAD). Elution of vitamins was completed within 9.3 min, and the lowest values obtained for limit of quantification (LOQ) for B1, B2, B3, B6, B9, and B12 were 0.6, 0.2, 0.8, 0.3, 0.5, and 0.7 μg/mL, respectively, at four wavelengths of 361, 280, 265, and 210 nm. In general, variation of wavelength of detection in the range from 210 to 361 nm affects sensitivity but had a marginal effect on the linearity and LOQ of the developed method and its application for determining B vitamins in premix and fortified flour. The 210 nm wavelength exhibited the highest sensitivity though resulted in higher values of B vitamins in fortified flour with respect to 265, 280, and 361 nm. Noteworthy, determination of B2 and B12 in the premix at 361 nm had relatively high RSD values compared to the lower wavelengths. Thus, wavelengths in the range from 265 to 280 may be more favorable over 210 and 361 nm. The method reported in the present work does not require any sample cleanup/preconcentration steps, and chromatographic elution was achieved in 9.3 min without the need for ion-pairing reagents.

Characterisation of Grains and Flour Fractions from Field Grown Transgenic Oil-Accumulating Wheat Expressing Oat WRI1

Wheat (Triticum aestivum L.) is one of the major staple crops in the world and is used to prepare a range of foods. The development of new varieties with wider variation in grain composition could broaden their use. We characterized grains and flours from oil-accumulating transgenic wheat expressing the oat (Avena sativa L.) endosperm WRINKLED1 (AsWRI1) grown under field conditions. Lipid and starch accumulation was determined in developing caryopses of AsWRI1-wheat and X-ray microtomography was used to study grain morphology. The developing caryopses of AsWRI1-wheat grains had increased triacylglycerol content and decreased starch content compared to the control. Mature AsWRI1-wheat grains also had reduced weight, were wrinkled and had a shrunken endosperm and X-ray tomography revealed that the proportion of endosperm was decreased while that of the aleurone was increased. Grains were milled to produce two white flours and one bran fraction. Mineral and lipid analyses showed that the flour fractions from the AsWRI1-wheat were contaminated with bran, due to the effects of the changed morphology on milling. This study gives a detailed analysis of grains from field grown transgenic wheat that expresses a gene that plays a central regulatory role in carbon allocation and significantly affects grain composition.

Reducing Tillage Affects Long-Term Yields but Not Grain Quality of Maize, Soybeans, Oats, and Wheat Produced in Three Contrasting Farming Systems

Reducing tillage has been widely promoted to reduce soil erosion, maintain soil health, and sustain long-term food production. The effects of reducing tillage on crop nutritional quality in organic and conventional systems, however, has not been widely explored. One possible driver of crop nutritional quality might be the changing soil nitrogen (N) availability associated with reduced tillage in various management systems. To test how reducing tillage affects crop nutritional quality under contrasting conventional and organic farming systems with varied N inputs, we measured nutritional quality (protein, fat, starch, ash, net energy, total digestible nutrients, and concentrations of Ca, K, Mg, P, and S) of maize, wheat, oats, and soybeans harvested from a long-term trial comprised of three farming systems under two tillage regimes: a conventional grain system (CNV); a low-input organic grain system (LEG); and an organic, manure-based grain + forage system (MNR) under conventional full-tillage (FT) and reduced-till (RT) management. Although maize and wheat yields were 10–13% lower under RT management, grain quality metrics including protein, fat, starch, energy, and mineral concentrations were not significantly affected by reducing tillage. Differences in nutrient quality were more marked between farming systems: protein levels in maize were highest in the MNR system (8.1%); protein levels in soybeans were highest in the LEG system (40.4%); levels of protein (12.9%), ash (2.0%), and sulfur (1430 ppm) in wheat were highest in the CNV system, and oat quality was largely consistent between the LEG and MNR systems. As grain quality did not significantly respond to reducing tillage, other management decisions that affect nutrient availability appear to have a greater effect on nutrient quality.

Monitoring the Effects of Hemicellulase on the Different Proofing Stages of Wheat Aleurone-Rich Bread Dough and Bread Quality

This study investigated the effects of a hemicellulase dosage (20, 40, and 60 mg kg-1 of flour) on the bread quality and rheological properties of wheat aleurone-rich flour. The results showed that hemicellulase could soften dough and improve extensibility. At the optimum hemicellulase dosage (40 mg kg-1 of flour), the bread specific volume increased by 40.91% and firmness of breadcrumb decreased by 104.57% compared to those of the control. Intermolecular forces indicated that the gluten network during the proofing was mainly strengthened via disulfide bonds, hydrophobic interactions, and hydrogen bonds but not through ionic bonds after hemicellulase addition. Fourier infrared spectroscopy indicated that the hydrolytic activity of hemicellulase catalyzed the transition from α-helix to β-sheet, which verified that viscoelasticity of gluten was enhanced at a dosage of 40 mg kg-1 of flour. These results suggested that hydrolyzation of hemicellulase contributed to the structural of gluten changes, thereby improving the quality of wheat aleurone-rich bread.