1
|
Gutiérrez CF, Rodríguez-Romero N, Egan S, Holmes E, Sanabria J. Exploiting the Potential of Bioreactors for Creating Spatial Organization in the Soil Microbiome: A Strategy for Increasing Sustainable Agricultural Practices. Microorganisms 2022; 10:microorganisms10071464. [PMID: 35889183 PMCID: PMC9319577 DOI: 10.3390/microorganisms10071464] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 06/14/2022] [Revised: 07/06/2022] [Accepted: 07/08/2022] [Indexed: 02/04/2023] Open
Abstract
Industrial production of synthetic nitrogen fertilizers and their crop application have caused considerable environmental impacts. Some eco-friendly alternatives try to solve them but raise some restrictions. We tested a novel method to produce a nitrogen bioinoculant by enriching a soil microbial community in bioreactors supplying N2 by air pumping. The biomass enriched with diazotrophic bacteria was diluted and applied to N-depleted and sterilized soil of tomato plants. We estimated microbial composition and diversity by 16S rRNA metabarcoding from soil and bioreactors at different run times and during plant uprooting. Bioreactors promoted the N-fixing microbial community and revealed a hided diversity. One hundred twenty-four (124) operational taxonomic units (OTUs) were assigned to bacteria with a greater Shannon diversity during the reactor’s steady state. A total of 753 OTUs were found in the rhizospheres with higher biodiversity when the lowest concentration of bacteria was applied. The apparent bacterial abundance in the batch and continuous bioreactors suggested a more specific functional ecological organization. We demonstrate the usefulness of bioreactors to evidence hidden diversity in the soil when it passes through bioreactors. By obtaining the same growth of inoculated plants and the control with chemical synthesis fertilizers, we evidence the potential of the methodology that we have called directed bioprospecting to grow a complex nitrogen-fixing microbial community. The simplicity of the reactor’s operation makes its application promising for developing countries with low technological progress.
Collapse
Affiliation(s)
- Carlos Fernando Gutiérrez
- Environmental Microbiology and Biotechnology Laboratory, Engineering School of Environmental & Natural Resources, Engineering Faculty, Universidad del Valle, Meléndez Campus, Cali 76001, Colombia; (C.F.G.); (N.R.-R.)
| | - Nicolás Rodríguez-Romero
- Environmental Microbiology and Biotechnology Laboratory, Engineering School of Environmental & Natural Resources, Engineering Faculty, Universidad del Valle, Meléndez Campus, Cali 76001, Colombia; (C.F.G.); (N.R.-R.)
| | - Siobhon Egan
- Australian National Phenome Center, Murdoch University, Perth 6150, Australia; (S.E.); (E.H.)
| | - Elaine Holmes
- Australian National Phenome Center, Murdoch University, Perth 6150, Australia; (S.E.); (E.H.)
| | - Janeth Sanabria
- Environmental Microbiology and Biotechnology Laboratory, Engineering School of Environmental & Natural Resources, Engineering Faculty, Universidad del Valle, Meléndez Campus, Cali 76001, Colombia; (C.F.G.); (N.R.-R.)
- Australian National Phenome Center, Murdoch University, Perth 6150, Australia; (S.E.); (E.H.)
- Correspondence:
| |
Collapse
|
2
|
Mader AE, Holtman GA, Welz PJ. Treatment wetlands and phyto-technologies for remediation of winery effluent: Challenges and opportunities. THE SCIENCE OF THE TOTAL ENVIRONMENT 2022; 807:150544. [PMID: 34619225 DOI: 10.1016/j.scitotenv.2021.150544] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 03/26/2021] [Revised: 09/17/2021] [Accepted: 09/19/2021] [Indexed: 06/13/2023]
Abstract
The composition and concentration of contaminants present in winery wastewater fluctuate through space and time, presenting a challenge for traditional remediation methods. Bio-hydrogeochemical engineered systems, such as treatment wetlands, have been demonstrated to effectively reduce contaminant loads prior to disposal or reuse of the effluent. This review identifies and details the status quo and challenges associated with (i) the characteristics of winery wastewater, and the (ii) functional components, (iii) operational parameters, and (iv) performance of treatment wetlands for remediation of winery effluent. Potential solutions to challenges associated with these aspects are presented, based on the latest literature. A particular emphasis has been placed on the phytoremediation of winery wastewater, and the rationale for selection of plant species for niche bioremediatory roles. This is attributed to previously reported low-to-negative removal percentages of persistent contaminants, such as salts and heavy metals that may be present in winery wastewater. A case for the inclusion of selected terrestrial halophytes in treatment wetlands and in areas irrigated using winery effluent is discussed. These are plant species that have an elevated ability to accumulate, cross-tolerate and potentially remove a range of persistent contaminants from winery effluent via various phytotechnologies (e.g., phytodesalination).
Collapse
Affiliation(s)
- Anthony E Mader
- School of Animal, Plant, and Environmental Sciences, Faculty of Science, University of the Witwatersrand, Johannesburg 2050, South Africa
| | - Gareth A Holtman
- Department of Civil Engineering, Cape Peninsula University of Technology, Symphony way, Bellville, Cape Town 7535, South Africa; Applied Microbial and Health Biotechnology Institute, Cape Peninsula University of Technology, Symphony way, Bellville, Cape Town 7535, South Africa
| | - Pamela J Welz
- Applied Microbial and Health Biotechnology Institute, Cape Peninsula University of Technology, Symphony way, Bellville, Cape Town 7535, South Africa.
| |
Collapse
|
3
|
Welz P, Swanepoel G, Weels S, Le Roes-Hill M. Wastewater from the Edible Oil Industry as a Potential Source of Lipase- and Surfactant-Producing Actinobacteria. Microorganisms 2021; 9:microorganisms9091987. [PMID: 34576882 PMCID: PMC8465459 DOI: 10.3390/microorganisms9091987] [Citation(s) in RCA: 7] [Impact Index Per Article: 2.3] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 08/30/2021] [Revised: 09/06/2021] [Accepted: 09/10/2021] [Indexed: 11/16/2022] Open
Abstract
Wastewaters generated from various stages of edible oil production in a canola processing facility were collected with the aim of determining the presence of lipase-producing actinobacteria of potential industrial significance. The high chemical oxygen demand (COD) readings (up to 86,700 mg L−1 in some samples) indicated that the wastewater exhibited the nutritional potential to support bacterial growth. A novel approach was developed for the isolation of metagenomic DNA from the oil-rich wastewater samples. Microbiota analysis of the buffer tank and refinery condensate tank wastewater samples showed a dominance of Cutibacterium acnes subsp. defendens, followed by a limited number of other actinobacterial genera, indicating the presence of a highly specialized actinobacterial population. Cultured isolates with typical actinobacterial morphology were analyzed for their ability to produce lipases and biosurfactants. Two strains, designated as BT3 and BT4, exhibited the highest lipase production levels when grown in the presence of tributyrin and olive oil (1.39 U mg−1 crude protein and 0.8 U mg−1 crude protein, respectively) and were subsequently definitively identified by genome sequencing to be related to Streptomyces albidoflavus. Cultivation of the strains in media containing different types of oils did not markedly increase the level of enzyme production, with the exception of strain BT4 (1.0 U mg−1 crude protein in the presence of peanut oil). Genome sequencing of the two strains, BT3 and BT4, revealed the presence of a range of lipase and esterase genes that may be involved in the production of the enzymes detected in this study. The presence of gene clusters involved in the production of biosurfactants were also detected, notably moreso in strain BT3 than BT4.
Collapse
|
4
|
Ospina-Betancourth C, Acharya K, Allen B, Head IM, Sanabria J, Curtis TP. Valorization of pulp and paper industry wastewater using sludge enriched with nitrogen-fixing bacteria. WATER ENVIRONMENT RESEARCH : A RESEARCH PUBLICATION OF THE WATER ENVIRONMENT FEDERATION 2021; 93:1734-1747. [PMID: 33765365 DOI: 10.1002/wer.1561] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.3] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 12/10/2020] [Revised: 02/22/2021] [Accepted: 03/18/2021] [Indexed: 06/12/2023]
Abstract
Nitrogen-fixing bacteria (NFB) can reduce nitrogen at ambient pressure and temperature. In this study, we treated effluent from a paper mill in sequencing batch reactors (SBRs) and monitored the abundance and activity of NFB with a view to producing a sludge that could work as a biofertilizer. Four reactors were inoculated with activated sludge enriched with NFB and fed with a high C/N waste (100:0.5) from a paper mill. Though the reactors were able to reduce the organic load of the wastewater by up to 89%, they did not have any nitrogen-fixing activity and showed a decrease in the putative number of NFB (quantified with qPCR). The most abundant species in the reactors treating high C/N paper mill wastewater was identified by Illumina MiSeq 16S rRNA gene amplicon sequencing as Methyloversatilis sp. (relative abundance of 4.4%). Nitrogen fixation was observed when the C/N ratio was increased by adding sucrose. We suspect that real-world biological nitrogen fixation (BNF) will only occur where there is a C/N ratio ≤100:0.07. Consequently, operators should actively avoid adding or allowing nitrogen in the waste streams if they wish to valorize their sludge and reduce running costs. PRACTITIONER POINTS: Efficient biological wastewater treatment of low nitrogen paper mill effluent was achieved without nutrient supplementation. The sludge was still capable of fixing nitrogen although this process was not observed in the wastewater treatment system. This high C/N wastewater treatment technology could be used with effluents from cassava flour, olive oil, wine and dairy industries.
Collapse
Affiliation(s)
| | - Kishor Acharya
- School of Engineering, Newcastle University, Newcastle upon Tyne, UK
| | - Ben Allen
- School of Engineering, Newcastle University, Newcastle upon Tyne, UK
| | - Ian M Head
- School of Natural and Environmental Sciences, Newcastle University, Newcastle upon Tyne, UK
| | - Janeth Sanabria
- Environmental Microbiology and Biotechnology Laboratory, Engineering School of Environmental & Natural Resources, Engineering Faculty, Universidad del Valle, Cali, Colombia
| | - Thomas P Curtis
- School of Engineering, Newcastle University, Newcastle upon Tyne, UK
| |
Collapse
|
5
|
Rodriguez-Gonzalez C, Ospina-Betancourth C, Sanabria J. High Resistance of a Sludge Enriched with Nitrogen-Fixing Bacteria to Ammonium Salts and Its Potential as a Biofertilizer. Bioengineering (Basel) 2021; 8:bioengineering8050055. [PMID: 34062837 PMCID: PMC8147367 DOI: 10.3390/bioengineering8050055] [Citation(s) in RCA: 2] [Impact Index Per Article: 0.7] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 03/16/2021] [Revised: 04/23/2021] [Accepted: 04/27/2021] [Indexed: 01/21/2023] Open
Abstract
The increasing use of chemical fertilizers causes the loss of natural biological nitrogen fixation in soils, water eutrophication and emits more than 300 Mton CO2 per year. It also limits the success of external bacterial inoculation in the soil. Nitrogen fixing bacteria can be inhibited by the presence of ammonia as its presence can inhibit biological nitrogen fixation. Two aerobic sludges from wastewater treatment plants (WWTP) were exposed to high ammonium salts concentrations (>450 mg L−1 and >2 dS m−1). Microbial analysis after treatment through 16S pyrosequencing showed the presence of Fluviicola sp. (17.70%), a genus of the Clostridiaceae family (11.17%), and Azospirillum sp. (10.42%), which were present at the beginning with lower abundance. Denaturing gradient gel electrophoresis (DGGE) analysis based on nifH genes did not show changes in the nitrogen-fixing population. Nitrogen-Fixing Bacteria (NFB) were identified and associated with other microorganisms involved in the nitrogen cycle, presumably for survival at extreme conditions. The potential use of aerobic sludges enriched with NFB is proposed as an alternative to chemical fertilizer as this bacteria could supplement nitrogen to the plant showing competitive results with chemical fertilization.
Collapse
Affiliation(s)
- Claudia Rodriguez-Gonzalez
- School of Environmental & Natural Resources Engineering, Engineering Faculty, Universidad del Valle, Cali 760032, Colombia;
| | | | - Janeth Sanabria
- School of Environmental & Natural Resources Engineering, Engineering Faculty, Universidad del Valle, Cali 760032, Colombia;
- Correspondence: ; Tel.: +57-2-3302-0002
| |
Collapse
|
6
|
Landazuri CFG, Gomez JS, Raaijmakers JM, Oyserman BO. Restoring degraded microbiome function with self-assembled communities. FEMS Microbiol Ecol 2020; 96:5956484. [PMID: 33150935 DOI: 10.1093/femsec/fiaa225] [Citation(s) in RCA: 7] [Impact Index Per Article: 1.8] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 08/16/2020] [Accepted: 11/03/2020] [Indexed: 01/04/2023] Open
Abstract
The natural microbial functions of many soils are severely degraded. Current state-of-the-art technology to restore these functions is through the isolation, screening, formulation and application of microbial inoculants and synthetic consortia. These approaches have inconsistent success, in part due to the incompatibility between the biofertilizer, crop, climate, existing soil microbiome and physicochemical characteristics of the soils. Here, we review the current state of the art in biofertilization and identify two key deficiencies in current strategies: the difficulty in designing complex multispecies biofertilizers and the bottleneck in scaling the production of complex multispecies biofertilizers. To address the challenge of producing scalable, multispecies biofertilizers, we propose to merge ecological theory with bioprocess engineering to produce 'self-assembled communities' enriched for particular functional guilds and adapted to a target soil and host plant. Using the nitrogen problem as an anchor, we review relevant ecology (microbial, plant and environmental), as well as reactor design strategies and operational parameters for the production of functionally enriched self-assembled communities. The use of self-assembled communities for biofertilization addresses two major hurdles in microbiome engineering: the importance of enriching microbes indigenous to (and targeted for) a specific environment and the recognized potential benefits of microbial consortia over isolates (e.g. functional redundancy). The proposed community enrichment model could also be instrumental for other microbial functions such as phosphorus solubilization, plant growth promotion or disease suppression.
Collapse
Affiliation(s)
- Carlos Fernando Gutierrez Landazuri
- Environmental Microbiology and Biotechnology Laboratory, Engineering School of Environmental and Natural Resources, Engineering Faculty, Universidad del Valle, 760032, Cali, Colombia
| | - Janeth Sanabria Gomez
- Environmental Microbiology and Biotechnology Laboratory, Engineering School of Environmental and Natural Resources, Engineering Faculty, Universidad del Valle, 760032, Cali, Colombia
| | - Jos M Raaijmakers
- Department of Microbial Ecology, Netherlands Institute of Ecology (NIOO-KNAW), Droevendaalsesteeg 10, 6708 PB, Wageningen, The Netherlands.,Institute of Biology, Leiden University, Sylviusweg 72, 2333 BE, Leiden, The Netherlands
| | - Ben O Oyserman
- Department of Microbial Ecology, Netherlands Institute of Ecology (NIOO-KNAW), Droevendaalsesteeg 10, 6708 PB, Wageningen, The Netherlands.,Bioinformatics Group, Wageningen University, Droevendaalsesteeg 1,6708 PB, Wageningen, The Netherlands
| |
Collapse
|
7
|
Ospina-Betancourth C, Acharya K, Allen B, Entwistle J, Head IM, Sanabria J, Curtis TP. Enrichment of Nitrogen-Fixing Bacteria in a Nitrogen-Deficient Wastewater Treatment System. ENVIRONMENTAL SCIENCE & TECHNOLOGY 2020; 54:3539-3548. [PMID: 32083474 DOI: 10.1021/acs.est.9b05322] [Citation(s) in RCA: 12] [Impact Index Per Article: 3.0] [Reference Citation Analysis] [Abstract] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 06/10/2023]
Abstract
Anthropogenic nitrogen fixation is essential to sustain a global population of 7.7 billion. However, there has been a long-standing desire to find cheaper and more environmentally friendly alternatives to the Haber-Bosch process. In this study, we developed a new strategy of nitrogen fixation by enriching free-living N2-fixing bacteria (NFB) in reactors fed with low nitrogen wastewater, analogous to those usually found in certain industrial effluents such as paper mills. Our reactors fixed appreciable quantities of nitrogen with a rate of 11.8 mg N L-1 day-1. This rate is comparable to recent "breakthrough" nitrogen-fixing technologies and far higher than observed in low C/N reactors (fed with organic matter and nitrogen). NFB were quantified using quantitative polymerase chain reaction (qPCR) of the nifH (marker gene used to identify biological nitrogen fixation) and 16S rRNA genes. The nifH gene was enriched by a factor of 10 in the nitrogen-fixing reactors (compared to controls) attaining 13% of the bacterial population (1:4.2 copies of nifH to 16S rRNA). The Illumina MiSeq 16S rRNA gene amplicon sequencing of reactors showed that the microbial community was dominated (19%) by Clostridium pasteurianum. We envisage that nitrogen-enriched biomass could potentially be used as a biofertilizer and that the treated wastewater could be released to the environment with very little post-treatment.
Collapse
Affiliation(s)
| | - Kishor Acharya
- School of Engineering, Newcastle University, Newcastle upon Tyne NE1 7RU, U.K
| | - Ben Allen
- School of Engineering, Newcastle University, Newcastle upon Tyne NE1 7RU, U.K
| | - Jim Entwistle
- School of Engineering, Newcastle University, Newcastle upon Tyne NE1 7RU, U.K
| | - Ian M Head
- School of Natural and Environmental Sciences, Newcastle University, Newcastle upon Tyne NE1 7RU, U.K
| | - Janeth Sanabria
- Environmental Microbiology and Biotechnology Laboratory, Engineering School of Environmental & Natural Resources, Engineering Faculty, Universidad del Valle, Cali 76001, Colombia
| | - Thomas P Curtis
- School of Engineering, Newcastle University, Newcastle upon Tyne NE1 7RU, U.K
| |
Collapse
|
8
|
Guimarães V, Teixeira AR, Lucas MS, Silva AM, Peres JA. Pillared interlayered natural clays as heterogeneous photocatalysts for H2O2-assisted treatment of a winery wastewater. Sep Purif Technol 2019. [DOI: 10.1016/j.seppur.2019.115768] [Citation(s) in RCA: 15] [Impact Index Per Article: 3.0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 01/19/2023]
|
9
|
Tikariha H, Purohit HJ. Assembling a genome for novel nitrogen-fixing bacteria with capabilities for utilization of aromatic hydrocarbons. Genomics 2018; 111:1824-1830. [PMID: 30552976 DOI: 10.1016/j.ygeno.2018.12.005] [Citation(s) in RCA: 17] [Impact Index Per Article: 2.8] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 07/17/2018] [Revised: 10/08/2018] [Accepted: 12/07/2018] [Indexed: 11/28/2022]
Abstract
Metagenome from refinery wastewater treatment plant running under nitrogen stress was analyzed for mining of novel aromatic hydrocarbon-degrading bacteria. The sequence data were assembled using metaspade followed by binning using the Metabat tool to assemble genome; where coverage and depth were calculated using bowtie and samtools. The analysis picked a novel genome belonging to family Bradyrhizobiaceae, identified based on 16S rDNA gene which was supported by CheckM and Kraken analysis. Using RAST, the assembled genome showed the capabilities for nitrogen fixation with the utilization of multiple hydrocarbon substrates with 14 different types of oxygenases as mapped by Minpath. An additional genetic feature like genes for stress and resistance towards heavy metals and antibiotic suggested that the genome has gone through the rigorous process of adaptation. If such bacteria could be cultivated then it will open the broad window of bioremediation strategies under nitrogen stress environment.
Collapse
Affiliation(s)
- Hitesh Tikariha
- Environmental Biotechnology and Genomics Division, CSIR-National Environmental Engineering Research Institute, Nehru Marg, Nagpur 440020, India
| | - Hemant J Purohit
- Environmental Biotechnology and Genomics Division, CSIR-National Environmental Engineering Research Institute, Nehru Marg, Nagpur 440020, India.
| |
Collapse
|
10
|
Zhang R, Wang L, Chen P, Pu Y. Shifts in microbial community structure and diversity in a novel waterfall biofilm reactor combined with MBBR under light and dark conditions. RSC Adv 2018; 8:37462-37471. [PMID: 35557833 PMCID: PMC9089321 DOI: 10.1039/c8ra07039c] [Citation(s) in RCA: 4] [Impact Index Per Article: 0.7] [Reference Citation Analysis] [Abstract] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 08/22/2018] [Accepted: 10/29/2018] [Indexed: 11/21/2022] Open
Abstract
In this study, a novel, low-cost, easy-maintenance and effective waterfall aeration biofilm reactor (WFBR) was designed to treat wastewater with MBBR. The chemical oxygen demand (COD), nitrogen removal efficiency, and the microbial community structure in this novel system were evaluated for 70 days under light and dark conditions. The COD and ammonium nitrogen (NH3-N) removal efficiency remained at approximately 90% and 100% respectively after 25 days, even if the influent substrate concentration and illumination condition changes. High-throughput sequencing was used to investigate the composition and function of the microbial community in different fillers in the treatment system. Dark padding, illuminate carrier and fabric play the good performance in nitrogen nitrification, denitrification and fixation respectively. The major classes present were Betaproteobacteria (30.2% on average), Cytophagia (19.8%), Gammaproteobacteria (11.7%), Alphaproteobacteria (11.2%), Sphingobacteriia (5.1%), Flavobacteriia (2.6%), Deltaproteobacteria (2.4%), Verrucomicrobiae (0.7%), Chloroplast (0.6%) and Clostridia (0.5%). These results could provide important guidance for the improvement of MBBR or other tradition wastewater treatment process, and could also enrich our theoretical understanding of microbial ecology.
Collapse
Affiliation(s)
- Rui Zhang
- School of Biology and Biological Engineering, South China University of Technology No. 338, Outer Ring Road, Panyu District Guangzhou City 510006 China
| | - Lutian Wang
- School of Biology and Biological Engineering, South China University of Technology No. 338, Outer Ring Road, Panyu District Guangzhou City 510006 China
| | - Ping Chen
- School of Biology and Biological Engineering, South China University of Technology No. 338, Outer Ring Road, Panyu District Guangzhou City 510006 China
| | - Yuewu Pu
- School of Biology and Biological Engineering, South China University of Technology No. 338, Outer Ring Road, Panyu District Guangzhou City 510006 China
| |
Collapse
|