Design and evaluation of a miniature milk quality detection system based on UV/Vis spectroscopy

LED-Based Desktop Analyzer for Fat Content Determination in Milk

In dairy, there is a growing request for laboratory analysis of the main nutrients in milk. High throughput of analysis, low cost, and portability are becoming critical factors to provide the necessary level of control in milk collection, processing, and sale. A portable desktop analyzer, including three light-emitting diodes (LEDs) in the visible light region, has been constructed and tested for the determination of fat content in homogenized and raw cow's milk. The method is based on the concentration dependencies of light scattering by milk fat globules at three different wavelengths. Univariate and multivariate models were built and compared. The red channel has shown the best performance in prediction. However, the joint use of all three LED signals led to an improvement in the calibration model. The obtained preliminary results have shown that the developed LED-based technique can be sufficiently accurate for the analysis of milk fat content. The ways of its further development and improvement have been discussed.

Qualitative identification of mature milk adulteration in bovine colostrum using noise-reduced dielectric spectra and linear model

BACKGROUND

The rapid and accurate identification of colostrum, a strong non-homogeneous food, remains a challenge. In the present study, the dielectric spectra including the dielectric constant (ε') and loss factor (ε″) of 154 colostrum samples adulterated with 0-50% mature milk were measured from 20 to 4500 MHz.

RESULTS

The results showed that the noise-reducing spectral preprocessing, including Savitzky-Golay (S-G), second derivative (SD), and S-G + SD, was significantly better than scattering-eliminating, including standard normal variate (SNV), multiplicative scatter correction (MSC), and SNV + MSC. The combination of S-G and SD was the best. Principal component analysis results demonstrated that dielectric spectroscopy is less susceptible to the inhomogeneity of colostrum and can be used to identify doped colostrum. The identification performance of linear models was better than that of non-linear models. The established linear discriminant analysis model based on full spectra had the best accuracy rates of 99.14% and 97.37% in the calibration and validation sets, respectively. Confirmatory tests on samples from different sources confirmed the satisfactory robustness of the proposed model.

CONCLUSION

We found that the main unfavorable effect on the identification based on dielectric spectroscopy was noise interference, rather than scattering effect caused by inhomogeneity of colostrum. The satisfactory results undoubtedly cast light on rapid detection of strongly non-homogeneous foods based on dielectric spectroscopy. © 2022 Society of Chemical Industry.