Experimental determination of thermophysical properties of unripe banana slices ( Musa cavendishii ) during convective drying

Optimization of Convective Tray-Drying Process Parameters for Green Banana Slices Using Response Surface Methodology and Its Characterization

Green banana (Musa spp.) is a significant source of starch (resistant starch ∼50%), phenolics and flavonoid compounds, and minerals (K, Mg, Zn, and Fe). The utilization of green bananas in their fresh form is limited, whereas the drying of bananas provides the opportunity to use them for various purposes. Drying temperature and slice thickness are important to be optimized for drying of bananas as they affect the quality parameters. The present study was conducted using response surface methodology to optimize tray-drying temperatures (50–80°C) and slice thicknesses (2–8 mm) on the basis of phytochemical and physical parameters of dried green banana slices. The cubic model was found to be the best fit for most of the responses (R2 = 0.95–1), and the quadratic model was fit for water activity ( ${\mathrm{a}}_{\mathrm{w}}$ ) (R2 = 0.92). The optimized drying conditions were found as drying temperature of 50°C and slice thickness of 4.5 mm. Experimental responses exhibited maximum L ${}^{\ast }$ (84.06), C ${}^{\ast }$ (13.73), and ho(83.53) and minimum losses of total phenolic content (89.22 mg GAE/100 g) and total flavonoid content (3.10 mg QE/100 g) along with lower ${\mathrm{a}}_{\mathrm{w}}$ (0.25). The optimized green banana flour was rich in carbohydrates (77.25 ± 0.06%) and low in fat (1.79 ± 0.11%). The flour obtained had good flowability with a mean particle size of 60.75 ± 1.99 µm. Flour’s gelatinization and decomposition temperatures were 102.7 and 292°C, respectively. In addition, flour’s water absorption, oil absorption, and solubility were 5.19 ± 0.01, 1.58 ± 0.01, and 0.14 ± 0.02 g/g, respectively. Green bananas dried at optimized conditions resulted in a better product with less phytochemical loss than dried with other methods.

Ultrasound pre-treatment prior to unripe banana air-drying: effect of the ultrasonic volumetric power on the kinetic parameters

Aiming to decrease the water content during the air-drying process of unripe banana slices, ultrasound (US) pre-treatments (25 °C) for 20 and 25 min at 9.38 and 25.63 W/L ultrasonic volumetric power were evaluated. Air-drying was performed at 50 and 60 °C for 360 min. Unripe banana slices pretreated at 25.63 W/L did not improve water migration, under either air-drying temperature, while slices pretreated at 9.38 W/L resulted in an increase in water effective diffusivity of 4.8 and 13.7% at 20 min US + air-drying at 50 °C and 25 min US + air-drying at 60 °C, respectively. The drying time saving of 7% and 9%, respectively, was achieved, showing that these treatments were alternative for processing unripe banana slices. Thus, ultrasound and air-drying operational parameters required accurately defined to achieve desirable results. Experimental data were adjusted to four models and the Midilli model resulted in the best experimental data fit, with r ² > 0.9988, RMSE < 0.0873 and χ² < 0.00996.

Unripe Banana Flour Produced by Air-Drying Assisted with Ultrasound – Description of the Mechanisms Involved to Enhance the Mass Transfer in Two Approaches

In this research the application of ultrasound, prior to air-drying, describing the phenomena in two approaches: unripe banana slices immersed in water (hydrated) and vacuum packaged (non-hydrated) were investigated. The results showed two falling rate periods during the air-drying. For the second rate period, an increase of water effective diffusivity due to the “sponge effect” (direct effect of ultrasound) and the microscopic channels formation (indirect effect) was observed. Scanning electron microscopy images showed that untreated dried slices were less porous, characterized by small cavities and high density, while ultrasound pretreated slices resulted in a porous structure with more free volume between cells. An increase in porosity decreased the resistance for diffusion, influencing positively the water effective diffusivity. Moreover, ultrasound produced partial disorder of the crystalline structure within the starch granules, reducing the amount of energy required for gelatinization. Moreover, reduction of resistant starch content was not observed.