1
|
Li Z, Zhao L, Ao Q, Zhang G, Kang D, Li Y, Liu J, Ding G, Ma Z, Teow YH, Sajab MS, Li Z, Wang Z. Exploring the cationic surfactant adsorption efficiency at concentrations relative to the critical micelle concentration by SA/SiO 2 microspheres. JOURNAL OF ENVIRONMENTAL MANAGEMENT 2024; 367:122069. [PMID: 39098071 DOI: 10.1016/j.jenvman.2024.122069] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 04/23/2024] [Revised: 07/24/2024] [Accepted: 07/30/2024] [Indexed: 08/06/2024]
Abstract
Studying the adsorption behavior of cationic surfactants can help to develop more effective strategies to limit their dispersion in the environment. However, there have few studies on the adsorption of cationic surfactants from the perspective of critical micelle concentration (CMC). In this study, with cetyltrimethylammonium bromide (CTAB) and octadecyl trimethylammonium bromide (OTAB) serving as the model cationic surfactants, the effect of CMC on the adsorption behavior of cationic surfactant onto the surface of sodium alginate/silica (SA/SiO2) microspheres was systematically revealed. The adsorption mechanism relative to CMC was investigated under different conditions, including surfactant concentration, pH, temperature, and adsorption time. The results suggest that at identical concentrations, the smaller the CMC value of the cationic surfactants, the greater the adsorption amount (qt). qt for CTAB and OTAB were 583.2 and 678.0 mg/g respectively, with the concentration higher than their CMC value. When the concentration was lower than the CMC value of the cationic surfactants, qt for CTAB and OTAB were 123.2 and 138.7 mg/g, respectively. The CMC value of CTAB was lower than that of OTAB under identical conditions, suggesting that the adsorption of cationic surfactants is related to their CMC. These results are beneficial for the removal of cationic surfactants by adsorption methods.
Collapse
Affiliation(s)
- Zhiying Li
- Key Laboratory of Biotechnology and Bioengineering of State Ethnic Affairs Commission, Biomedical Research Center, Engineering Research Center of Key Technology and Industrialization of Cell-based Vaccine, Ministry of Education, Gan-su Tech Innovation Center of Animal, China-Malaysia National Joint Laboratory, Northwest Minzu University, Lanzhou, Gansu, 730030, China; School of Chemical Engineering, Northwest Minzu University, Lanzhou, Gansu, 730124, China
| | - Lei Zhao
- Key Laboratory of Biotechnology and Bioengineering of State Ethnic Affairs Commission, Biomedical Research Center, Engineering Research Center of Key Technology and Industrialization of Cell-based Vaccine, Ministry of Education, Gan-su Tech Innovation Center of Animal, China-Malaysia National Joint Laboratory, Northwest Minzu University, Lanzhou, Gansu, 730030, China
| | - Qing Ao
- Key Laboratory of Biotechnology and Bioengineering of State Ethnic Affairs Commission, Biomedical Research Center, Engineering Research Center of Key Technology and Industrialization of Cell-based Vaccine, Ministry of Education, Gan-su Tech Innovation Center of Animal, China-Malaysia National Joint Laboratory, Northwest Minzu University, Lanzhou, Gansu, 730030, China
| | - Ge Zhang
- Key Laboratory of Biotechnology and Bioengineering of State Ethnic Affairs Commission, Biomedical Research Center, Engineering Research Center of Key Technology and Industrialization of Cell-based Vaccine, Ministry of Education, Gan-su Tech Innovation Center of Animal, China-Malaysia National Joint Laboratory, Northwest Minzu University, Lanzhou, Gansu, 730030, China
| | - Dongqing Kang
- School of Chemical Engineering, Northwest Minzu University, Lanzhou, Gansu, 730124, China
| | - Yingli Li
- School of Chemical Engineering, Northwest Minzu University, Lanzhou, Gansu, 730124, China
| | - Jian Liu
- Institute of Advanced Materials, College of Chemistry and Chemical Engineering, Jiangxi Normal University, Nanchang, 330022, China
| | - Gongtao Ding
- Key Laboratory of Biotechnology and Bioengineering of State Ethnic Affairs Commission, Biomedical Research Center, Engineering Research Center of Key Technology and Industrialization of Cell-based Vaccine, Ministry of Education, Gan-su Tech Innovation Center of Animal, China-Malaysia National Joint Laboratory, Northwest Minzu University, Lanzhou, Gansu, 730030, China
| | - Zhongren Ma
- Key Laboratory of Biotechnology and Bioengineering of State Ethnic Affairs Commission, Biomedical Research Center, Engineering Research Center of Key Technology and Industrialization of Cell-based Vaccine, Ministry of Education, Gan-su Tech Innovation Center of Animal, China-Malaysia National Joint Laboratory, Northwest Minzu University, Lanzhou, Gansu, 730030, China
| | - Yeit Haan Teow
- Faculty of Engineering and Built Environment, The National University of Malaysia, Bangi, 43600, Selangor Darul Ehsan, Malaysia
| | - Mohd Shaiful Sajab
- Faculty of Engineering and Built Environment, The National University of Malaysia, Bangi, 43600, Selangor Darul Ehsan, Malaysia
| | - Zhiqiang Li
- Department of Medical, Northwest Minzu University, Lanzhou, Gansu, 730030, China.
| | - Zifan Wang
- Key Laboratory of Biotechnology and Bioengineering of State Ethnic Affairs Commission, Biomedical Research Center, Engineering Research Center of Key Technology and Industrialization of Cell-based Vaccine, Ministry of Education, Gan-su Tech Innovation Center of Animal, China-Malaysia National Joint Laboratory, Northwest Minzu University, Lanzhou, Gansu, 730030, China.
| |
Collapse
|
2
|
Golzar-Ahmadi M, Bahaloo-Horeh N, Pourhossein F, Norouzi F, Schoenberger N, Hintersatz C, Chakankar M, Holuszko M, Kaksonen AH. Pathway to industrial application of heterotrophic organisms in critical metals recycling from e-waste. Biotechnol Adv 2024:108438. [PMID: 39218325 DOI: 10.1016/j.biotechadv.2024.108438] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 03/26/2024] [Revised: 07/30/2024] [Accepted: 08/27/2024] [Indexed: 09/04/2024]
Abstract
The transition to renewable energies and electric vehicles has triggered an unprecedented demand for metals. Sustainable development of these technologies relies on effectively managing the lifecycle of critical raw materials, including their responsible sourcing, efficient use, and recycling. Metal recycling from electronic waste (e-waste) is of paramount importance owing to ore exceeding amounts of critical elements and high toxicity of heavy metals and organic pollutants in e-waste to the natural ecosystem and human body. Heterotrophic microbes secrete numerous metal-binding biomolecules such as organic acids, amino acids, cyanide, siderophores, peptides, and biosurfactants which can be utilized for eco-friendly and profitable metal recycling. In this review paper, we presented a critical review of heterotrophic organisms in biomining, and current barriers hampering the industrial application of organic acid bioleaching and biocyanide leaching. We also discussed how these challenges can be surmounted with simple methods (e.g., culture media optimization, separation of microbial growth and metal extraction process) and state-of-the-art biological approaches (e.g., artificial microbial community, synthetic biology, metabolic engineering, advanced fermentation strategies, and biofilm engineering). Lastly, we showcased emerging technologies (e.g., artificially synthesized peptides, siderophores, and biosurfactants) derived from heterotrophs with the potential for inexpensive, low-impact, selective and advanced metal recovery from bioleaching solutions.
Collapse
Affiliation(s)
- Mehdi Golzar-Ahmadi
- Norman B. Keevil Institute of Mining Engineering, University of British Columbia, Vancouver, Canada
| | | | - Fatemeh Pourhossein
- Research Centre for Health & Life Sciences, Coventry University, Coventry, UK
| | - Forough Norouzi
- Norman B. Keevil Institute of Mining Engineering, University of British Columbia, Vancouver, Canada
| | - Nora Schoenberger
- Helmholtz Institute Freiberg for Resource Technology, Bautzner Landstrasse 400, Dresden, Germany
| | - Christian Hintersatz
- Helmholtz Institute Freiberg for Resource Technology, Bautzner Landstrasse 400, Dresden, Germany
| | - Mital Chakankar
- Helmholtz Institute Freiberg for Resource Technology, Bautzner Landstrasse 400, Dresden, Germany
| | - Maria Holuszko
- Norman B. Keevil Institute of Mining Engineering, University of British Columbia, Vancouver, Canada.
| | - Anna H Kaksonen
- Commonwealth Scientific and Industrial Research Organization (CSIRO) Environment, Western Australia, Australia.
| |
Collapse
|
3
|
Du Y, Huang Y, Wang W, Su S, Yang S, Sun H, Liu B, Han G. Application and development of foam extraction technology in wastewater treatment: A review. THE SCIENCE OF THE TOTAL ENVIRONMENT 2024; 930:172755. [PMID: 38670372 DOI: 10.1016/j.scitotenv.2024.172755] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Subscribe] [Scholar Register] [Received: 02/21/2024] [Revised: 04/17/2024] [Accepted: 04/23/2024] [Indexed: 04/28/2024]
Abstract
With the advancement of technology, wastewater treatment has become a significant challenge limiting the clean and sustainable development of chemical and metallurgical industries. Foam extraction, based on interfacial separation and mineral flotation, has garnered considerable attention as a wastewater treatment technology due to its unique physicochemical properties. Although considerable excellent accomplishments were reported, there still lacks a comprehensive summary of process features and contaminant removal mechanisms via foam extraction. According to the latest research progresses, the principles and characteristics of foam extraction technology, the classification and application of flotation reagents are systematically summarized in this work. Then comprehensively commented on the application fields and prospects of iterative flotation technology such as ion flotation, adsorption flotation and floating-extraction. The shortcomings and limitations of the current foam extraction technologies were discussed, and the feasible process intensification techniques were highlighted. This review aims to enchance the understanding of the foam extraction mechanism, and provides guidance for the selection appropriate reagents and foam extraction technologies in wastewater treatment.
Collapse
Affiliation(s)
- Yifan Du
- School of Chemical Engineering, Zhengzhou University, Zhengzhou 450001, Henan, PR China
| | - Yanfang Huang
- School of Chemical Engineering, Zhengzhou University, Zhengzhou 450001, Henan, PR China; Henan Critical Metals Institue, Zhengzhou University, Zhengzhou 450001, Henan, PR China; Zhongyuan Critical Metals Laboratory, Zhengzhou 450001, Henan, PR China
| | - Wenjuan Wang
- School of Chemical Engineering, Zhengzhou University, Zhengzhou 450001, Henan, PR China
| | - Shengpeng Su
- School of Chemical Engineering, Zhengzhou University, Zhengzhou 450001, Henan, PR China
| | - Shuzhen Yang
- School of Chemical Engineering, Zhengzhou University, Zhengzhou 450001, Henan, PR China; Henan Critical Metals Institue, Zhengzhou University, Zhengzhou 450001, Henan, PR China; Zhongyuan Critical Metals Laboratory, Zhengzhou 450001, Henan, PR China
| | - Hu Sun
- School of Chemical Engineering, Zhengzhou University, Zhengzhou 450001, Henan, PR China; Henan Critical Metals Institue, Zhengzhou University, Zhengzhou 450001, Henan, PR China; Zhongyuan Critical Metals Laboratory, Zhengzhou 450001, Henan, PR China
| | - Bingbing Liu
- School of Chemical Engineering, Zhengzhou University, Zhengzhou 450001, Henan, PR China; Henan Critical Metals Institue, Zhengzhou University, Zhengzhou 450001, Henan, PR China; Zhongyuan Critical Metals Laboratory, Zhengzhou 450001, Henan, PR China.
| | - Guihong Han
- School of Chemical Engineering, Zhengzhou University, Zhengzhou 450001, Henan, PR China; Henan Critical Metals Institue, Zhengzhou University, Zhengzhou 450001, Henan, PR China; Zhongyuan Critical Metals Laboratory, Zhengzhou 450001, Henan, PR China.
| |
Collapse
|
4
|
Alkhanjaf AAM, Sharma S, Sharma M, Kumar R, Arora NK, Kumar B, Umar A, Baskoutas S, Mukherjee TK. Microbial strategies for copper pollution remediation: Mechanistic insights and recent advances. ENVIRONMENTAL POLLUTION (BARKING, ESSEX : 1987) 2024; 346:123588. [PMID: 38401635 DOI: 10.1016/j.envpol.2024.123588] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 09/11/2023] [Revised: 02/06/2024] [Accepted: 02/14/2024] [Indexed: 02/26/2024]
Abstract
Environmental contamination is aninsistent concern affecting human health and the ecosystem. Wastewater, containing heavy metals from industrial activities, significantly contributes to escalating water pollution. These metals can bioaccumulate in food chains, posing health risks even at low concentrations. Copper (Cu), an essential micronutrient, becomes toxic at high levels. Activities like mining and fungicide use have led to Copper contamination in soil, water, and sediment beyond safe levels. Copper widely used in industries, demands restraint of heavy metal ion release into wastewater for ecosystem ultrafiltration, membrane filtration, nanofiltration, and reverse osmosis, combat heavy metal pollution, with emphasis on copper.Physical and chemical approaches are efficient, large-scale feasibility may have drawbackssuch as they are costly, result in the production of sludge. In contrast, bioremediation, microbial intervention offers eco-friendly solutions for copper-contaminated soil. Bacteria and fungi facilitate these bioremediation avenues as cost-effective alternatives. This review article emphasizes on physical, chemical, and biological methods for removal of copper from the wastewater as well asdetailing microorganism's mechanisms to mobilize or immobilize copper in wastewater and soil.
Collapse
Affiliation(s)
- Abdulrab Ahmed M Alkhanjaf
- Department of Clinical Laboratory Sciences, College of Applied Medical Sciences, Najran University, Najran, 11001, Saudi Arabia
| | - Sonu Sharma
- Department of Bio-sciences and Technology, Maharishi Markandeshwar (Deemed to Be University), Mullana, Ambala, 133207, Haryana, India
| | - Monu Sharma
- Department of Bio-sciences and Technology, Maharishi Markandeshwar (Deemed to Be University), Mullana, Ambala, 133207, Haryana, India
| | - Raman Kumar
- Department of Bio-sciences and Technology, Maharishi Markandeshwar (Deemed to Be University), Mullana, Ambala, 133207, Haryana, India.
| | - Naresh Kumar Arora
- Division of Soil and Crop Management, Central Soil Salinity Research Institute, Karnal, 133001, Haryana, India
| | - Brajesh Kumar
- Division of Soil and Crop Management, Central Soil Salinity Research Institute, Karnal, 133001, Haryana, India
| | - Ahmad Umar
- Department of Chemistry, Faculty of Science and Arts, Najran University, Najran, 11001, Saudi Arabia; Department of Materials Science and Engineering, The Ohio State University, Columbus, 43210, OH, USA
| | - Sotirios Baskoutas
- Department of Materials Science, University of Patras, 26500, Patras, Greece
| | | |
Collapse
|
5
|
Zhang R, Liu Z, Yu J. Removal of Silicon from Magnesite by Flotation: Influence of Particle Size and Mechanical Mechanism. MATERIALS (BASEL, SWITZERLAND) 2023; 16:6095. [PMID: 37763373 PMCID: PMC10532998 DOI: 10.3390/ma16186095] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Grants] [Track Full Text] [Subscribe] [Scholar Register] [Received: 07/15/2023] [Revised: 08/18/2023] [Accepted: 08/18/2023] [Indexed: 09/29/2023]
Abstract
The feasibility of producing high-density sintered magnesia with a one-step sintering method was investigated by utilizing finely ground magnesite as raw materials for direct flotation. The mechanism of flotation desilication of microfine grain magnesite was investigated by combining microstructure and chemical properties. The results showed that dodecylamine (DDA) has a sorting effect on magnesite reverse flotation desilication. Under the premise of 150 mg/L sodium polyacrylate (PAANa) as an inhibitor and 300 mg/L DDA as a collector, the content and recovery rate of MgO can reach 83.91% and 78.78%, respectively. When sodium oleate (NaOL) was used as a collector, the recovery rate of MgO was only 49.22%; therefore, it is unsuitable for magnesite purification. The flotation effect was affected because MgO particles and SiO2 particles agglomerated in the flotation process. The flotation agent cannot work for a single element but works for the mineral agglomerate. While collecting Si elements, the agglomerated MgO was also brought into the froth layer, making flotation impossible.
Collapse
Affiliation(s)
- Ruinan Zhang
- School of Metallurgy, Northeastern University, Shenyang 110819, China (J.Y.)
| | - Zhaoyang Liu
- School of Metallurgy, Northeastern University, Shenyang 110819, China (J.Y.)
- Key Laboratory for Ecological Metallurgy of Multimetallic Mineral, Ministry of Education, Shenyang 110819, China
| | - Jingkun Yu
- School of Metallurgy, Northeastern University, Shenyang 110819, China (J.Y.)
| |
Collapse
|
6
|
Fabris F, Illner M, Repke JU, Scarso A, Schwarze M. Is Micellar Catalysis Green Chemistry? Molecules 2023; 28:4809. [PMID: 37375364 DOI: 10.3390/molecules28124809] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Grants] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 05/11/2023] [Revised: 06/01/2023] [Accepted: 06/13/2023] [Indexed: 06/29/2023] Open
Abstract
Many years ago, twelve principles were defined for carrying out chemical reactions and processes from a green chemistry perspective. It is everyone's endeavor to take these points into account as far as possible when developing new processes or improving existing ones. Especially in the field of organic synthesis, a new area of research has thus been established: micellar catalysis. This review article addresses the question of whether micellar catalysis is green chemistry by applying the twelve principles to micellar reaction media. The review shows that many reactions can be transferred from an organic solvent to a micellar medium, but that the surfactant also has a crucial role as a solubilizer. Thus, the reactions can be carried out in a much more environmentally friendly manner and with less risk. Moreover, surfactants are being reformulated in their design, synthesis, and degradation to add extra advantages to micellar catalysis to match all the twelve principles of green chemistry.
Collapse
Affiliation(s)
- Fabrizio Fabris
- Dipartimento di Scienze Molecolari e Nanosistemi, Università Ca' Foscari Venezia, Via Torino 155, Mestre, 30172 Venezia, Italy
| | - Markus Illner
- Process Dynamics and Operations Group, Technische Universität Berlin, Straße des 17. Juni 135, Sekr. KWT9, 10623 Berlin, Germany
| | - Jens-Uwe Repke
- Process Dynamics and Operations Group, Technische Universität Berlin, Straße des 17. Juni 135, Sekr. KWT9, 10623 Berlin, Germany
| | - Alessandro Scarso
- Dipartimento di Scienze Molecolari e Nanosistemi, Università Ca' Foscari Venezia, Via Torino 155, Mestre, 30172 Venezia, Italy
| | - Michael Schwarze
- Department of Chemistry, Technische Universität Berlin, Straße des 17. Juni 124, Sekr. TC-08, 10623 Berlin, Germany
| |
Collapse
|
7
|
Hua Q, Guo H, Wang D, Huang Y, Cao Y, Peng W, Fan G. A new strategy for selective recovery of low concentration cobalt ions from wastewater: Based on selective chelating precipitation-flotation process. J Taiwan Inst Chem Eng 2022. [DOI: 10.1016/j.jtice.2022.104605] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/19/2022]
|
8
|
Gas Hydrate-Based Heavy Metal Ion Removal from Industrial Wastewater: A Review. WATER 2022. [DOI: 10.3390/w14071171] [Citation(s) in RCA: 6] [Impact Index Per Article: 3.0] [Reference Citation Analysis] [Abstract] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 02/04/2023]
Abstract
Innovating methods for treating industrial wastewater containing heavy metals frequently incorporate toxicity-reduction technologies to keep up with regulatory requirements. This article reviews the latest advances, benefits, opportunities and drawbacks of several heavy metal removal treatment systems for industrial wastewater in detail. The conventional physicochemical techniques used in heavy metal removal processes with their advantages and limitations are evaluated. A particular focus is given to innovative gas hydrate-based separation of heavy metals from industrial effluent with their comparison, advantages and limitations in the direction of commercialization as well as prospective remedies. Clathrate hydrate-based removal is a potential technology for the treatment of metal-contaminated wastewater. In this work, a complete assessment of the literature is addressed based on removal efficiency, enrichment factor and water recovery, utilizing the gas hydrate approach. It is shown that gas hydrate-based treatment technology may be the way of the future for water management purposes, as the industrial treated water may be utilized for process industries, watering, irrigation and be safe to drink.
Collapse
|
9
|
Abidli A, Huang Y, Ben Rejeb Z, Zaoui A, Park CB. Sustainable and efficient technologies for removal and recovery of toxic and valuable metals from wastewater: Recent progress, challenges, and future perspectives. CHEMOSPHERE 2022; 292:133102. [PMID: 34914948 DOI: 10.1016/j.chemosphere.2021.133102] [Citation(s) in RCA: 20] [Impact Index Per Article: 10.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 07/17/2021] [Revised: 11/08/2021] [Accepted: 11/25/2021] [Indexed: 06/14/2023]
Abstract
Due to their numerous effects on human health and the natural environment, water contamination with heavy metals and metalloids, caused by their extensive use in various technologies and industrial applications, continues to be a huge ecological issue that needs to be urgently tackled. Additionally, within the circular economy management framework, the recovery and recycling of metals-based waste as high value-added products (VAPs) is of great interest, owing to their high cost and the continuous depletion of their reserves and natural sources. This paper reviews the state-of-the-art technologies developed for the removal and recovery of metal pollutants from wastewater by providing an in-depth understanding of their remediation mechanisms, while analyzing and critically discussing the recent key advances regarding these treatment methods, their practical implementation and integration, as well as evaluating their advantages and remaining limitations. Herein, various treatment techniques are covered, including adsorption, reduction/oxidation, ion exchange, membrane separation technologies, solvents extraction, chemical precipitation/co-precipitation, coagulation-flocculation, flotation, and bioremediation. A particular emphasis is placed on full recovery of the captured metal pollutants in various reusable forms as metal-based VAPs, mainly as solid precipitates, which is a powerful tool that offers substantial enhancement of the remediation processes' sustainability and cost-effectiveness. At the end, we have identified some prospective research directions for future work on this topic, while presenting some recommendations that can promote sustainability and economic feasibility of the existing treatment technologies.
Collapse
Affiliation(s)
- Abdelnasser Abidli
- Microcellular Plastics Manufacturing Laboratory (MPML), Department of Mechanical and Industrial Engineering, Faculty of Applied Science and Engineering, University of Toronto, 5 King's College Road, Toronto, Ontario, M5S 3G8, Canada; Institute for Water Innovation (IWI), Faculty of Applied Science and Engineering, University of Toronto, 55 St. George Street, Toronto, Ontario, M5S 1A4, Canada.
| | - Yifeng Huang
- Microcellular Plastics Manufacturing Laboratory (MPML), Department of Mechanical and Industrial Engineering, Faculty of Applied Science and Engineering, University of Toronto, 5 King's College Road, Toronto, Ontario, M5S 3G8, Canada; Institute for Water Innovation (IWI), Faculty of Applied Science and Engineering, University of Toronto, 55 St. George Street, Toronto, Ontario, M5S 1A4, Canada; State Key Laboratory of Urban Water Resource and Environment, Harbin Institute of Technology, Harbin, Heilongjiang, China
| | - Zeineb Ben Rejeb
- Microcellular Plastics Manufacturing Laboratory (MPML), Department of Mechanical and Industrial Engineering, Faculty of Applied Science and Engineering, University of Toronto, 5 King's College Road, Toronto, Ontario, M5S 3G8, Canada
| | - Aniss Zaoui
- Microcellular Plastics Manufacturing Laboratory (MPML), Department of Mechanical and Industrial Engineering, Faculty of Applied Science and Engineering, University of Toronto, 5 King's College Road, Toronto, Ontario, M5S 3G8, Canada
| | - Chul B Park
- Microcellular Plastics Manufacturing Laboratory (MPML), Department of Mechanical and Industrial Engineering, Faculty of Applied Science and Engineering, University of Toronto, 5 King's College Road, Toronto, Ontario, M5S 3G8, Canada; Institute for Water Innovation (IWI), Faculty of Applied Science and Engineering, University of Toronto, 55 St. George Street, Toronto, Ontario, M5S 1A4, Canada.
| |
Collapse
|
10
|
Xanthopoulos P, Bevandić S, Spooren J, Binnemans K, Kukurugya F. Recovery of copper, zinc and lead from photovoltaic panel residue. RSC Adv 2022; 12:2351-2360. [PMID: 35425251 PMCID: PMC8979222 DOI: 10.1039/d1ra09268e] [Citation(s) in RCA: 2] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [Abstract] [Grants] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 12/22/2021] [Accepted: 01/11/2022] [Indexed: 11/21/2022] Open
Abstract
The increase in photovoltaic panel installations in Europe will generate vast amounts of waste in the near future. Therefore, it is important to develop new technologies that allow the recycling of end-of-life photovoltaic panels. This material can serve as a secondary resource, not only for precious metals (e.g. silver), but also for base metals. In this work, the extraction and recovery of the base metals copper, zinc and lead from a copper-rich photovoltaic panel residue was investigated. The material was first leached at 80 °C under microwave irradiation with a mixture of hydrochloric acid, sodium chloride and hydrogen peroxide solutions. Based on the Box-Behnken factorial design optimization, it was possible to extract 81.2% of Cu, 96.4% of Zn and 77.6% of Pb, under the following leaching conditions: [HCl] = 0.5 mol L-1, [NaCl] = 200 g L-1, [H2O2] = 7.5 wt% and t = 60 min. Cementation with iron powder at a 1.2 iron-to-copper stoichiometric ratio allowed the recovery of copper nearly quantitatively (99.8%) as a copper-iron sediment. The gas-liquid separation technique of ion flotation was employed to separate lead and zinc from the dilute copper-free leachate. Cetyltrimethylammonium bromide (CTAB), a cationic surfactant, selectively recovered lead (99.4%) over zinc as lead(ii) tetrachloro cetyltrimethylammonium colloid, after eight ion flotation stages and [CTAB]total = 7.2 mmol L-1. The zinc that remained in the solution after the ion flotation step was recovered by precipitation and by adding sodium sulfide at 110% of the stoichiometric amount after removing iron as ferric hydroxide by slowly raising the pH to 3.7.
Collapse
Affiliation(s)
| | - Srećko Bevandić
- KU Leuven, Department of Earth and Environmental Sciences Celestijnenlaan 200E B-3001 Heverlee Belgium
| | - Jeroen Spooren
- Waste Recycling Technologies, Flemish Institute for Technological Research, VITO N.V. Boerentang 200 2400 Mol Belgium
| | - Koen Binnemans
- KU Leuven, Department of Chemistry Celestijnenlaan 200F-Box 2404 B-3001 Heverlee Belgium
| | - Frantisek Kukurugya
- Waste Recycling Technologies, Flemish Institute for Technological Research, VITO N.V. Boerentang 200 2400 Mol Belgium
| |
Collapse
|
11
|
Process Development in Biosurfactant Production. ADVANCES IN BIOCHEMICAL ENGINEERING/BIOTECHNOLOGY 2022; 181:195-233. [DOI: 10.1007/10_2021_195] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 10/18/2022]
|
12
|
Wang Y, He G, Abudukade D, Li K, Guo T, Li S, Xiao Z, Wang J, Nie S. Selective inhibition of sodium tripolyphosphate on calcite in the process of magnesite flotation. J Mol Liq 2022. [DOI: 10.1016/j.molliq.2021.117412] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 10/20/2022]
|
13
|
Hogan DE, Stolley RM, Boxley C, Amistadi MK, Maier RM. Removal of uranium from contaminated groundwater using monorhamnolipids and ion flotation. JOURNAL OF ENVIRONMENTAL MANAGEMENT 2022; 301:113835. [PMID: 34600421 PMCID: PMC8579952 DOI: 10.1016/j.jenvman.2021.113835] [Citation(s) in RCA: 2] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Grants] [Track Full Text] [Subscribe] [Scholar Register] [Received: 06/14/2021] [Revised: 09/17/2021] [Accepted: 09/22/2021] [Indexed: 06/13/2023]
Abstract
Mining of uranium for defense-related purposes has left a substantial legacy of pollution that threatens human and environmental health. Contaminated waters in the arid southwest are of particular concern, as water resource demand and water scarcity issues become more pronounced. The development of remediation strategies to treat uranium impacted waters will become increasingly vital to meet future water needs. Ion flotation is one technology with the potential to address legacy uranium contamination. The green biosurfactant rhamnolipid has been shown to bind uranium and act as an effective collector in ion flotation. In this study, uranium contaminated groundwater (∼440 μg L-1 U) from the Monument Valley processing site in northeast Arizona was used as a model solution to test the uranium removal efficacy of ion flotation with biosynthetic (bio-mRL) and three synthetic monorhamnolipids with varying hydrophobic chain lengths: Rha-C10-C10, Rha-C12-C12, and Rha-C14-C14. At the groundwater's native pH 8, and at an adjusted pH 7, no uranium was removed from solution by any collector. However, at pH 6.5 bio-mRL and Rha-C10-C10 removed 239.2 μg L-1 and 242.4 μg L-1 of uranium, respectively. By further decreasing the pH to 5.5, bio-mRL was able to reduce the uranium concentration to near or below the Environmental Protection Agency maximum contaminant level of 30 μg L-1. For the Rha-C12-C12 and Rha-C14-C14 collector ligands, decreasing the pH to 7 or below reduced the foam stability and quantity, such that these collectors were not suitable for treating this groundwater. To contextualize the results, a geochemical analysis of the groundwater was conducted, and a consideration of uranium speciation is described. Based on this study, the efficacy of monorhamnolipid-based ion flotation in real world groundwater has been demonstrated with suitable solution conditions and collectors identified.
Collapse
Affiliation(s)
- David E Hogan
- Department of Environmental Science, The University of Arizona, Tucson, AZ, 85721, USA.
| | - Ryan M Stolley
- GlycoSurf, LLC, 825 N 300 W, Suite WA011, Salt Lake City, UT, 84103, USA.
| | - Chett Boxley
- GlycoSurf, LLC, 825 N 300 W, Suite WA011, Salt Lake City, UT, 84103, USA.
| | - Mary Kay Amistadi
- Department of Environmental Science, The University of Arizona, Tucson, AZ, 85721, USA.
| | - Raina M Maier
- Department of Environmental Science, The University of Arizona, Tucson, AZ, 85721, USA.
| |
Collapse
|
14
|
Hussin F, Aroua MK, Szlachta M. Biochar derived from fruit by-products using pyrolysis process for the elimination of Pb(II) ion: An updated review. CHEMOSPHERE 2022; 287:132250. [PMID: 34547565 DOI: 10.1016/j.chemosphere.2021.132250] [Citation(s) in RCA: 2] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 07/02/2021] [Revised: 09/02/2021] [Accepted: 09/12/2021] [Indexed: 06/13/2023]
Abstract
Water pollution is one of the most concerning global environmental problems in this century with the severity and complexity of the issue increases every day. One of the major contributors to water pollution is the discharge of harmful heavy metal wastes into the rivers and water bodies. Without proper treatment, the release of these harmful inorganic waste would endanger the environment by contaminating the food chains of living organisms, hence, leading to potential health risks to humans. The adsorption method has become one of the cost-effective alternative treatments to eliminate heavy metal ions. Since the type of adsorbent material is the most vital factor that determines the effectiveness of the adsorption, continuous efforts have been made in search of cheap adsorbents derived from a variety of waste materials. Fruit waste can be transformed into valuable products, such as biochar, as they are composed of many functional groups, including carboxylic groups and lignin, which is effective in metal binding. The main objective of this study was to review the potential of various types of fruit wastes as an alternative adsorbent for Pb(II) removal. Following a brief overview of the properties and effects of Pb(II), this study discussed the equilibrium isotherms and adsorption kinetic by various adsorption models. The possible adsorption mechanisms and regeneration study for Pb(II) removal were also elaborated in detail to provide a clear understanding of biochar produced using the pyrolysis technique. The future prospects of fruit waste as an adsorbent for the removal of Pb(II) was also highlighted.
Collapse
Affiliation(s)
- Farihahusnah Hussin
- Research Centre for Carbon Dioxide Capture and Utilisation (CCDCU), School of Engineering and Technology, Sunway University, No. 5 Jalan Universiti, Bandar Sunway, 47500, Petaling Jaya, Selangor, Malaysia.
| | - Mohamed Kheireddine Aroua
- Research Centre for Carbon Dioxide Capture and Utilisation (CCDCU), School of Engineering and Technology, Sunway University, No. 5 Jalan Universiti, Bandar Sunway, 47500, Petaling Jaya, Selangor, Malaysia; Department of Engineering, Lancaster University, Lancaster, LA1 4YW, UK
| | - Małgorzata Szlachta
- Faculty of Environmental Engineering, Wrocław University of Science and Technology, Wybrzeże Wyspiańskiego 27, 50-370, Wrocław, Poland; Geological Survey of Finland, P.O. Box 96, FI-02151, Espoo, Finland
| |
Collapse
|
15
|
Chang L, Cao Y, Peng W, Miao Y, Su S, Fan G, Huang Y, Li C, Song X. Highly efficient and selective recovery of Cu(II) from wastewater via ion flotation with amidoxime functionalized graphene oxide as nano collector. Sep Purif Technol 2021. [DOI: 10.1016/j.seppur.2021.119674] [Citation(s) in RCA: 2] [Impact Index Per Article: 0.7] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 10/20/2022]
|
16
|
Efficient removal of hazardous benzohydroxamic acid (BHA) contaminants from the industrial beneficiation wastewaters by facile precipitation flotation process. Sep Purif Technol 2021. [DOI: 10.1016/j.seppur.2021.119718] [Citation(s) in RCA: 5] [Impact Index Per Article: 1.7] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 01/01/2023]
|
17
|
Miao Y, Peng W, Cao Y, Chang L, Fan G, Yu F. Facile preparation of sulfhydryl modified montmorillonite nanosheets hydrogel and its enhancement for Pb(II) adsorption. CHEMOSPHERE 2021; 280:130727. [PMID: 33964761 DOI: 10.1016/j.chemosphere.2021.130727] [Citation(s) in RCA: 11] [Impact Index Per Article: 3.7] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 11/14/2020] [Revised: 02/25/2021] [Accepted: 04/26/2021] [Indexed: 06/12/2023]
Abstract
In the work, sulfhydryl functionalized montmorillonite nanosheets based hydrogel balls were firstly synthesized for Pb(II) adsorption, and then characterized by scanning electron microscope (SEM), fourier transform infrared spectroscopy (FTIR), surface area analyzer (BET), thermogravimetry (TG), and zeta potential. Effects of initial solution pH, adsorbent dosage, contact time, temperature on Pb(II) adsorption of the resulting hydrogel balls were investigated systematically. The experimental results showed that the increase amount of sulfhydryl functionalized montmorillonite nanosheets (MMTNs-SH) maintained the hydrogel balls a better porous structure and bigger specific surface area, endowing it a bigger adsorption capacity. The adsorption process was fitted well with pseudo-second-order kinetics model and Freundlich model, and more than 97% of Pb(II) could be removed under the optimum conditions. Moreover, hydrogel spheres have a certain cycle performance. In addition, the interactions between Pb(Ⅱ) ions and the oxygen atoms in the hydroxyl groups and the sulfur atoms in the sulfhydryl groups, and the ion exchange in MMTNs-SH dominated the adsorption.
Collapse
Affiliation(s)
- Yiheng Miao
- Henan Province Industrial Technology Research Institute of Resources and Materials, Zhengzhou University, Zhengzhou, Henan, 450001, PR China
| | - Weijun Peng
- Henan Province Industrial Technology Research Institute of Resources and Materials, Zhengzhou University, Zhengzhou, Henan, 450001, PR China; School of Chemical Engineering, Zhengzhou University, Zhengzhou, Henan, 450001, PR China; National and Local Joint Engineering Research Center for Green Mineral Metallurgy and Processing, Zhengzhou, Henan, 450001, PR China; Provincial and Ministerial Joint Innovation Center for Resource Materials, Zhengzhou, Henan, 450001, PR China.
| | - Yijun Cao
- Henan Province Industrial Technology Research Institute of Resources and Materials, Zhengzhou University, Zhengzhou, Henan, 450001, PR China; School of Chemical Engineering, Zhengzhou University, Zhengzhou, Henan, 450001, PR China; National and Local Joint Engineering Research Center for Green Mineral Metallurgy and Processing, Zhengzhou, Henan, 450001, PR China; Provincial and Ministerial Joint Innovation Center for Resource Materials, Zhengzhou, Henan, 450001, PR China.
| | - Luping Chang
- Henan Province Industrial Technology Research Institute of Resources and Materials, Zhengzhou University, Zhengzhou, Henan, 450001, PR China
| | - Guixia Fan
- Henan Province Industrial Technology Research Institute of Resources and Materials, Zhengzhou University, Zhengzhou, Henan, 450001, PR China
| | - Futao Yu
- Evaluation and Utilization of Strategic Rare Metals and Rare Earth Resource Key Laboratory of Sichuan Province, Chengdu Analytical & Testing Center, Sichuan Bureau of Geology & Mineral Resources, Chengdu, 610081, PR China
| |
Collapse
|
18
|
Demissie H, Lu S, Jiao R, Liu L, Xiang Y, Ritigala T, Ajibade FO, Mihiranga HKM, An G, Wang D. Advances in micro interfacial phenomena of adsorptive micellar flocculation: Principles and application for water treatment. WATER RESEARCH 2021; 202:117414. [PMID: 34303165 DOI: 10.1016/j.watres.2021.117414] [Citation(s) in RCA: 12] [Impact Index Per Article: 4.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 04/30/2021] [Revised: 07/01/2021] [Accepted: 07/02/2021] [Indexed: 06/13/2023]
Abstract
Among various aqua remediation technologies, separation aims at cleaning pollutants by isolating them despite their destruction; solutes can also be recovered after the process. Adsorptive micellar flocculation (AMF) has been known as an important surfactant-based technique to separate poorly water-soluble hazardous pollutants from aqua media as an efficient and energy-intensive replacement for other surfactant-based techniques, as such AMF should be known. AMF is based on the partitioning of solutes gradient from bulk solution into the nanosized smart anionic surfactant micelle followed by flocculation. However, unlike coagulation/flocculation or adsorption, AMF is not viable for the production of drinking water in water utilities due to the loss of surfactant monomers. Unfortunately, it can be used as a reservoir or for the recycling/recovery of organic pollutants (intermediates) (ions, organics/bioactive, dyes, etc.), even at high concentrations. The performance of AMF depends on various parameters, and this review briefly summarizes the existing researches on different pollutants removal by AMF and material recovery/recycling. This includes operating condition factors (surfactants, flocculants, surfactant-flocculant or surfactant-pollutant concentration ratio, and water conditions chemistry). Because varieties of micro interfacial phenomena other than physical interactions occur in a versatile micellar environment in the AMF process, emphases are given to adsorptive oxidation, micellar catalysis, selectivity. Furthermore, for the first time, this review gives an overview of understanding the state-of-the-art multifunctional nano amphiphile-based AMF that behaves mimetic to aquatic organisms in the process of pollutant removal. The efficiency of AMF, including recycling concentrated solution without noticeable deterioration, as an auxiliary resource/income for the next cycle, signifies economic viability, versatility, and manifold applications in aqua remediation. Significance, ways to achieve enhanced process efficiency, as well as challenges and future opportunities in wastewater treatment, are also highlighted.
Collapse
Affiliation(s)
- Hailu Demissie
- State Key Laboratory of Environmental Aquatic Chemistry, Research Center for Eco- Environmental Science, Chinese Academy of Sciences, Beijing 100085, China; University of Chinese Academy of Science, Beijing 100049, China; Department of Chemistry, Arba Minch University 1000, Ethiopia
| | - Sen Lu
- School of Civil and Environmental Engineering, Harbin Institute of Technology, Shenzhen 518055, China
| | - Ruyuan Jiao
- State Key Laboratory of Environmental Aquatic Chemistry, Research Center for Eco- Environmental Science, Chinese Academy of Sciences, Beijing 100085, China
| | - Libing Liu
- College of Chemistry and Environmental Engineering, Shenzhen University, Shenzhen 518060, PR China
| | - Yu Xiang
- University of Chinese Academy of Science, Beijing 100049, China
| | | | | | - H K M Mihiranga
- University of Chinese Academy of Science, Beijing 100049, China
| | - Guangyu An
- State Key Laboratory of Environmental Aquatic Chemistry, Research Center for Eco- Environmental Science, Chinese Academy of Sciences, Beijing 100085, China.
| | - Dongsheng Wang
- State Key Laboratory of Environmental Aquatic Chemistry, Research Center for Eco- Environmental Science, Chinese Academy of Sciences, Beijing 100085, China; University of Chinese Academy of Science, Beijing 100049, China.
| |
Collapse
|
19
|
Ziaee F, Ziaee M, Taseidifar M. Synthesis and application of a green surfactant for the treatment of water containing PFAS/ hazardous metal ions. JOURNAL OF HAZARDOUS MATERIALS 2021; 407:124800. [PMID: 33359975 DOI: 10.1016/j.jhazmat.2020.124800] [Citation(s) in RCA: 14] [Impact Index Per Article: 4.7] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Subscribe] [Scholar Register] [Received: 09/17/2020] [Revised: 12/04/2020] [Accepted: 12/05/2020] [Indexed: 06/12/2023]
Abstract
In this work, the effectiveness of a biodegradable and natural surfactant synthesized through a novel method has been studied through the ion flotation process to treat waters containing Per/Poly Fluoroalkyl Substances (PFAS) and heavy-metal ions. This cysteine-based surfactant, which is environmentally acceptable, showed considerable solubility and foaming ability over a wide range of pH. It also could remove 97-99(%) of 5 mg/L of cadmium, chromium, copper, nickel, zinc, and manganese ions in a single batch physicochemical process. Moreover, for the first time, a foam fractionation method in association with using this cysteine-based surfactant was applied for perfluorooctanoic acid (PFOA) removal from water. This surfactant was used as a co-surfactant and could readily remove 72% of PFOA (40 mg/L) from water. The characterization of the surfactant was undertaken using 1H NMR, FT-IR, elemental analysis, melting point, and determination of its critical micelle concentration (CMC). This environmentally friendly surfactant has high potential applications in green chemistry especially in the treatment of waters contaminated with PFAS/heavy-metal ions.
Collapse
Affiliation(s)
- Farzaneh Ziaee
- Graduate School of Biomedical Engineering, University of New South Wales, Sydney, NSW 2052, Australia
| | - Mohammad Ziaee
- School of Science, UNSW Canberra, Northcott Drive, Canberra, ACT 2610, Australia.
| | - Mojtaba Taseidifar
- School of Science, UNSW Canberra, Northcott Drive, Canberra, ACT 2610, Australia
| |
Collapse
|
20
|
Simultaneous Removal of Al, Cu and Zn Ions from Aqueous Solutions Using Ion and Precipitate Flotation Methods. Processes (Basel) 2021. [DOI: 10.3390/pr9020301] [Citation(s) in RCA: 5] [Impact Index Per Article: 1.7] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/16/2022] Open
Abstract
This paper presents the results of investigations concerning the simultaneous removal of Al(III), Cu(II), and Zn(II) from dilute aqueous solutions using ion and precipitate flotation methods. The effects of initial solution pH, surface active substance concentration, and the gas velocity on the flotations’ efficiency and course are studied. Experimental results are discussed in terms of physicochemical aspects related to aqueous solutions of metal salts. The results indicate that satisfying simultaneous flotations of aluminum, copper and zinc species are observed if the pH value ranges between 7.0 and 9.0. It was found that an increase in collector concentration results in a decrease in the flotation rate constants. An increase in the gas velocity results in an increase in the ion and precipitate flotation rates.
Collapse
|
21
|
Yaqub A, Shafiq Q, Khan AR, Husnain SM, Shahzad F. Recent advances in the adsorptive remediation of wastewater using two-dimensional transition metal carbides (MXenes): a review. NEW J CHEM 2021. [DOI: 10.1039/d1nj00772f] [Citation(s) in RCA: 12] [Impact Index Per Article: 4.0] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 12/16/2022]
Abstract
MXenes, since their discovery in 2011, have garnered significant research attention for a variety of applications due to their exciting physico-chemical properties.
Collapse
Affiliation(s)
- Azra Yaqub
- Chemistry Division
- Directorate of Science
- Pakistan Institute of Nuclear Science and Technology (PINSTECH)
- Islamabad
- Pakistan
| | - Qamar Shafiq
- National Center for Nanotechnology
- Department of Metallurgy and Materials Engineering
- Pakistan Institute of Engineering and Applied Sciences (PIEAS)
- Islamabad 45650
- Pakistan
| | - Abdul Rehman Khan
- Materials Division
- Directorate of Technology
- Pakistan Institute of Nuclear Science and Technology (PINSTECH)
- Islamabad
- Pakistan
| | - Syed M. Husnain
- Chemistry Division
- Directorate of Science
- Pakistan Institute of Nuclear Science and Technology (PINSTECH)
- Islamabad
- Pakistan
| | - Faisal Shahzad
- National Center for Nanotechnology
- Department of Metallurgy and Materials Engineering
- Pakistan Institute of Engineering and Applied Sciences (PIEAS)
- Islamabad 45650
- Pakistan
| |
Collapse
|
22
|
Chang L, Cao Y, Peng W, Li C, Fan G, Song X, Jia C. Insight into the effect of oxidation degree of graphene oxides on their removal from wastewater via froth flotation. CHEMOSPHERE 2021; 262:127837. [PMID: 32768755 DOI: 10.1016/j.chemosphere.2020.127837] [Citation(s) in RCA: 4] [Impact Index Per Article: 1.3] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 02/12/2020] [Revised: 07/08/2020] [Accepted: 07/24/2020] [Indexed: 06/11/2023]
Abstract
The effect of oxidation degree of graphene oxides (GO) on their removal from wastewater via froth flotation was studied in this work. Four types of GO samples with different oxidation degrees were synthesized and characterized by X-ray diffraction (XRD), X-ray photoelectron spectroscopy (XPS), transmission electron microscopy (TEM), atomic force spectroscopy (AFM) et al. The effects of cetyl trimethyl ammonium bromide (CTAB) concentration, pH, stirring time on the removal of GO by froth flotation had been discussed. It was found that the addition of CTAB could improve surface hydrophobicity of GO, endowing GO to be easily separated by froth flotation. The removal was dependent on CTAB dosage, pH and stirring time. Moreover, the removal first increased and then decreased with the increasing oxidation degree of GO, and less kinetic energy input was needed to overcome the energy barrier between GO flocs with the increase of oxidation degree. The removal mechanism was proven to be electrostatic attraction, and the different contents of oxgenous-containing functional groups in GOs with various oxidation degrees played a vital role in their removal via froth flotation.
Collapse
Affiliation(s)
- Luping Chang
- School of Chemical Engineering, Zhengzhou University, Zhengzhou, Henan, 450001, PR China
| | - Yijun Cao
- School of Chemical Engineering, Zhengzhou University, Zhengzhou, Henan, 450001, PR China; Henan Province Industrial Technology Research Institute of Resources and Materials, Zhengzhou University, Zhengzhou, Henan, 450001, PR China.
| | - Weijun Peng
- School of Chemical Engineering, Zhengzhou University, Zhengzhou, Henan, 450001, PR China.
| | - Chao Li
- Henan Province Industrial Technology Research Institute of Resources and Materials, Zhengzhou University, Zhengzhou, Henan, 450001, PR China
| | - Guixia Fan
- School of Chemical Engineering, Zhengzhou University, Zhengzhou, Henan, 450001, PR China
| | - Xiangyu Song
- School of Chemical Engineering, Zhengzhou University, Zhengzhou, Henan, 450001, PR China
| | - Chenxi Jia
- School of Chemical Engineering, Zhengzhou University, Zhengzhou, Henan, 450001, PR China
| |
Collapse
|
23
|
Depression effect of Al(Ⅲ) and Fe(Ⅲ) on rutile flotation using dodecylamine polyxyethylene ether as collector. Colloids Surf A Physicochem Eng Asp 2020. [DOI: 10.1016/j.colsurfa.2020.125269] [Citation(s) in RCA: 12] [Impact Index Per Article: 3.0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/23/2022]
|
24
|
Zakeri Khatir M, Abdollahy M, Khalesi MR, Rezai B. Selective separation of neodymium from synthetic wastewater by ion flotation. SEP SCI TECHNOL 2020. [DOI: 10.1080/01496395.2020.1793779] [Citation(s) in RCA: 3] [Impact Index Per Article: 0.8] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Submit a Manuscript] [Subscribe] [Scholar Register] [Indexed: 10/23/2022]
Affiliation(s)
| | - Mahmoud Abdollahy
- Mining Engineering Faculty, Tarbiat Modares University, Tehran, Iran
| | | | - Bahram Rezai
- Department of Mining and Metallurgical Engineering, Amirkabir University of Technology, Tehran, Iran
| |
Collapse
|
25
|
Chang L, Cao Y, Peng W, Li C, Fan G, Song X, Shi X. Efficiently removing cetyl trimethyl ammonium bromide from wastewater by graphene oxide. SURF INTERFACE ANAL 2020. [DOI: 10.1002/sia.6800] [Citation(s) in RCA: 3] [Impact Index Per Article: 0.8] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/06/2022]
Affiliation(s)
- Luping Chang
- School of Chemical Engineering Zhengzhou University Zhengzhou China
| | - Yijun Cao
- School of Chemical Engineering Zhengzhou University Zhengzhou China
- Henan Province Industrial Technology Research Institute of Resources and Materials Zhengzhou University Zhengzhou China
| | - Weijun Peng
- School of Chemical Engineering Zhengzhou University Zhengzhou China
| | - Chao Li
- Henan Province Industrial Technology Research Institute of Resources and Materials Zhengzhou University Zhengzhou China
| | - Guixia Fan
- School of Chemical Engineering Zhengzhou University Zhengzhou China
| | - Xiangyu Song
- School of Chemical Engineering Zhengzhou University Zhengzhou China
| | - Xiaoxin Shi
- School of Chemical Engineering Zhengzhou University Zhengzhou China
| |
Collapse
|
26
|
Wen T, Zhao Y, Zhang T, Xiong B, Hu H, Zhang Q, Song S. Selective recovery of heavy metals from wastewater by mechanically activated calcium carbonate: Inspiration from nature. CHEMOSPHERE 2020; 246:125842. [PMID: 31927387 DOI: 10.1016/j.chemosphere.2020.125842] [Citation(s) in RCA: 13] [Impact Index Per Article: 3.3] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 11/22/2019] [Revised: 01/01/2020] [Accepted: 01/03/2020] [Indexed: 06/10/2023]
Abstract
In nature, the calcium carbonate shows different interactions with different metal ions. Inspiration from this natural phenomenon, in this work, the selective recovery of heavy metals from wastewater by mechanically activated calcium carbonate was investigated. The changes in Ca2+ concentration, pH value and metals uptake ratio of solution showed that M2+ (M = Cu, Mn, Zn and Ni) were endowed with different migration rules, resulting in the various interaction with the calcium carbonate in metal-bearing solution. The combination of XRD, SEM, and stereomicroscope affirmed that the adsorbed M2+ rarely change the lattice structure of calcium carbonate, while the adsorbed Cu2+ and Zn2+ could convert the mineral phase from calcium carbonate to posnjakite and hydrozincite, respectively. As a result of phase transition, 15% Cu2+ and 6% Zn2+ were uptaken with initial concentration of 1 mM for 100 min, however, the unsatisfactory recovery prevented the efficient recycling of metal. The mechanically activated calcium carbonate had a superior solubility at the solid/liquid interface, promoting mineral phase transformation on the premise of weak displacement adsorption. Hence, the uptake ratio of Cu2+ and Zn2+ were significantly increased to 99% and 53% at the same condition. Finally, Cu2+ was recovered from polymetallic systems from complex environment with high precision. The concept of selective recycling in this research guides the development of innovative processes from natural information.
Collapse
Affiliation(s)
- Tong Wen
- Hubei Key Laboratory of Mineral Resources Processing and Environment, Wuhan University of Technology, Luoshi Road 122, Wuhan, Hubei, 430070, China; School of Resources and Environmental Engineering, Wuhan University of Technology, Luoshi Road 122, Wuhan, Hubei, 430070, China
| | - Yunliang Zhao
- Hubei Key Laboratory of Mineral Resources Processing and Environment, Wuhan University of Technology, Luoshi Road 122, Wuhan, Hubei, 430070, China; School of Resources and Environmental Engineering, Wuhan University of Technology, Luoshi Road 122, Wuhan, Hubei, 430070, China; Materials Research Institute, The Pennsylvania State University, University Park, PA, 16802, USA.
| | - Tingting Zhang
- Hubei Key Laboratory of Mineral Resources Processing and Environment, Wuhan University of Technology, Luoshi Road 122, Wuhan, Hubei, 430070, China; School of Resources and Environmental Engineering, Wuhan University of Technology, Luoshi Road 122, Wuhan, Hubei, 430070, China.
| | - Bowen Xiong
- Hubei Key Laboratory of Mineral Resources Processing and Environment, Wuhan University of Technology, Luoshi Road 122, Wuhan, Hubei, 430070, China; School of Resources and Environmental Engineering, Wuhan University of Technology, Luoshi Road 122, Wuhan, Hubei, 430070, China
| | - Huimin Hu
- Hubei Key Laboratory of Mineral Resources Processing and Environment, Wuhan University of Technology, Luoshi Road 122, Wuhan, Hubei, 430070, China; School of Resources and Environmental Engineering, Wuhan University of Technology, Luoshi Road 122, Wuhan, Hubei, 430070, China
| | - Qiwu Zhang
- Hubei Key Laboratory of Mineral Resources Processing and Environment, Wuhan University of Technology, Luoshi Road 122, Wuhan, Hubei, 430070, China; School of Resources and Environmental Engineering, Wuhan University of Technology, Luoshi Road 122, Wuhan, Hubei, 430070, China
| | - Shaoxian Song
- Hubei Key Laboratory of Mineral Resources Processing and Environment, Wuhan University of Technology, Luoshi Road 122, Wuhan, Hubei, 430070, China; School of Resources and Environmental Engineering, Wuhan University of Technology, Luoshi Road 122, Wuhan, Hubei, 430070, China
| |
Collapse
|
27
|
Effect of Triton X-100 surfactant on thiol-amine cosolvents assisted facile synthesized CdS thin films on glass substrate by spin coating method. SN APPLIED SCIENCES 2020. [DOI: 10.1007/s42452-020-2423-y] [Citation(s) in RCA: 6] [Impact Index Per Article: 1.5] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 12/11/2022] Open
|
28
|
Wang S, Liu Y, Lü QF, Zhuang H. Facile preparation of biosurfactant-functionalized Ti2CTX MXene nanosheets with an enhanced adsorption performance for Pb(II) ions. J Mol Liq 2020. [DOI: 10.1016/j.molliq.2019.111810] [Citation(s) in RCA: 31] [Impact Index Per Article: 7.8] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 10/25/2022]
|
29
|
Senchukova AS, Mikhailova ME, Gubarev AS, Lezov AA, Lebedeva EV, Makarov IA, Zorin IM, Tsvetkov NV. Molecular characteristics of polymerized surfactants: influence of introduced crosslinking agent and monomer concentration. POLYM INT 2019. [DOI: 10.1002/pi.5923] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.2] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 01/18/2023]
Affiliation(s)
- Anna S Senchukova
- Department of Molecular Biophysics and Physics of PolymersSt Petersburg State University St Petersburg Russia
| | - Mariya E Mikhailova
- Department of Molecular Biophysics and Physics of PolymersSt Petersburg State University St Petersburg Russia
| | - Alexander S Gubarev
- Department of Molecular Biophysics and Physics of PolymersSt Petersburg State University St Petersburg Russia
| | - Alexey A Lezov
- Department of Molecular Biophysics and Physics of PolymersSt Petersburg State University St Petersburg Russia
| | - Elena V Lebedeva
- Department of Molecular Biophysics and Physics of PolymersSt Petersburg State University St Petersburg Russia
| | - Ivan A Makarov
- Department of Macromolecular Chemistry, Institute of ChemistrySt Petersburg State University St Petersburg Russia
| | - Ivan M Zorin
- Department of Macromolecular Chemistry, Institute of ChemistrySt Petersburg State University St Petersburg Russia
| | - Nikolay V Tsvetkov
- Department of Molecular Biophysics and Physics of PolymersSt Petersburg State University St Petersburg Russia
| |
Collapse
|