1
|
Yang C, Li T, Pei X, Li J, Yuan Z, Li Y, Bian X. Magnetorheological and Viscoelastic Behaviors in an Fe-Based Amorphous Magnetic Fluid. MATERIALS (BASEL, SWITZERLAND) 2023; 16:1967. [PMID: 36903082 PMCID: PMC10004444 DOI: 10.3390/ma16051967] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Figures] [Subscribe] [Scholar Register] [Received: 01/25/2023] [Revised: 02/24/2023] [Accepted: 02/24/2023] [Indexed: 06/18/2023]
Abstract
A novel magnetic fluid was obtained using a colloidal dispersion of amorphous magnetic Fe-Ni-B nanoparticles into water. Its magnetorheological and viscoelastic behaviors were all investigated. Results showed that the generated particles were spherical amorphous particles 12-15 nm in diameter. The saturation magnetization of Fe-based amorphous magnetic particles could reach 49.3 emu/g. The amorphous magnetic fluid exhibited shear shinning behavior under magnetic fields and showed strong magnetic responsiveness. The yield stress increased with the rising magnetic field strength. A crossover phenomenon was observed from the modulus strain curves due to the phase transition under applied magnetic fields. The storage modulus G' was higher than the loss modulus G″ at low strains, while G' was lower than G″ at high strains. The crossover points shifted to higher strains with increasing magnetic field. Furthermore, G' decreased and fell off in a power law relationship when the strain exceeded a critical value. However, G″ showed a distinct maximum at a critical strain, and then decreased in a power law fashion. The magnetorheological and viscoelastic behaviors were found to be related to the structural formation and destruction in the magnetic fluids, which is a joint effect of magnetic fields and shear flows.
Collapse
Affiliation(s)
- Chuncheng Yang
- Hebei Key Laboratory of Green Development of Rock and Mineral Materials, Hebei GEO University, Shijiazhuang 050031, China
- Institute of Basalt Fiber Materials, School of Gemmology and Materials Science, Hebei GEO University, Shijiazhuang 050031, China
- Engineering Research Center for Silicate Solid Waste Resource Utilization of Hebei Province, Shijiazhuang 050031, China
| | - Teng Li
- Hebei Key Laboratory of Green Development of Rock and Mineral Materials, Hebei GEO University, Shijiazhuang 050031, China
- Institute of Basalt Fiber Materials, School of Gemmology and Materials Science, Hebei GEO University, Shijiazhuang 050031, China
| | - Xiangyu Pei
- Hebei Key Laboratory of Green Development of Rock and Mineral Materials, Hebei GEO University, Shijiazhuang 050031, China
- Institute of Basalt Fiber Materials, School of Gemmology and Materials Science, Hebei GEO University, Shijiazhuang 050031, China
| | - Jiaxin Li
- Hebei Key Laboratory of Green Development of Rock and Mineral Materials, Hebei GEO University, Shijiazhuang 050031, China
- Institute of Basalt Fiber Materials, School of Gemmology and Materials Science, Hebei GEO University, Shijiazhuang 050031, China
| | - Zhao Yuan
- Hebei Key Laboratory of Green Development of Rock and Mineral Materials, Hebei GEO University, Shijiazhuang 050031, China
- Institute of Basalt Fiber Materials, School of Gemmology and Materials Science, Hebei GEO University, Shijiazhuang 050031, China
| | - Yan Li
- Hebei Key Laboratory of Green Development of Rock and Mineral Materials, Hebei GEO University, Shijiazhuang 050031, China
- Institute of Basalt Fiber Materials, School of Gemmology and Materials Science, Hebei GEO University, Shijiazhuang 050031, China
- Engineering Research Center for Silicate Solid Waste Resource Utilization of Hebei Province, Shijiazhuang 050031, China
| | - Xiufang Bian
- Key Laboratory for Liquid-Solid Structural Evolution and Processing of Materials, Ministry of Education, Shandong University, Jinan 250061, China
| |
Collapse
|
2
|
Ivanov AS, Solovyova AY, Zverev VS, Elfimova EA. Distribution functions of magnetic moments and relaxation times for magnetic fluids exhibiting controllable microstructure evolution. J Mol Liq 2022. [DOI: 10.1016/j.molliq.2022.120550] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/05/2022]
|
4
|
Vinod S, Philip J. Thermal and rheological properties of magnetic nanofluids: Recent advances and future directions. Adv Colloid Interface Sci 2022; 307:102729. [PMID: 35834910 DOI: 10.1016/j.cis.2022.102729] [Citation(s) in RCA: 5] [Impact Index Per Article: 2.5] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 05/31/2022] [Revised: 06/27/2022] [Accepted: 07/03/2022] [Indexed: 01/14/2023]
Abstract
Technological advancement and miniaturization of electronic gadgets fueled intense research on nanofluids as potential candidates for cooling applications as a substitute to conventional heat transfer fluids. Among nanofluids, magnetic nanofluids, traditionally known as ferrofluids have attracted a lot of attention owing to their magnetic field tunable thermal conductivity and rheological properties due to the aggregation of the magnetic nanoparticles into chains or columns in the presence of the magnetic field. The field-induced aggregates act as low resistance pathways thereby improving thermal transport substantially. Recent studies show that ferrofluids with smaller size and narrow size distribution display significant enhancement in thermal conductivity in the presence of a magnetic field with negligible viscosity enhancement, which is ideal for effective thermal management of electronic devices, especially in miniature electronic devices. On the contrary, highly polydisperse ferrofluids containing large aggregates, show modest enhancement in thermal conductivity in the presence of a magnetic field and a huge enhancement in viscosity. The most recent studies show that magnetic field ramp rate has a profound effect on aggregation kinetics and thermal and rheological properties. The viscosity enhancement under an external stimulus impedes their practical use in electronics cooling, which warrants the need to attain a high thermal conductivity to viscosity ratio, under a modest magnetic field. Though there are several reviews on heat transfer in nanofluids and hybrid nanofluids, a comprehensive review on fundamental understanding of field-induced thermal and rheological properties in magnetic fluids is missing in the literature. This review provides a pedagogical description of the fundamental understanding of field-induced thermal and rheological properties in magnetic fluids, with the necessary background, key concepts, definitions, mechanisms, theoretical models, experimental protocols, and design of experiments. Many important case studies are presented along with the experimental design aspects. The review also provides a summary of important experimental studies with key findings, along with the key challenges and future research directions. The review is an ideal material for experimentalists and theoreticians practicing in the field of magnetic fluids, and also serves as an excellent reference for freshers who indent to begin research on this topic.
Collapse
Affiliation(s)
- Sithara Vinod
- Smart Materials Section, Corrosion Science and Technology Division, Metallurgy and Materials Group, Indira Gandhi Centre for Atomic Research, Kalpakkam, India; Homi Bhabha National Institute, Mumbai, India
| | - John Philip
- Smart Materials Section, Corrosion Science and Technology Division, Metallurgy and Materials Group, Indira Gandhi Centre for Atomic Research, Kalpakkam, India; Homi Bhabha National Institute, Mumbai, India.
| |
Collapse
|