Lignin enrichment and enzyme deactivation as the root cause of enzymatic hydrolysis slowdown of steam pretreated sugarcane bagasse

Exploring the internal driving mechanism underlying bacterial community-induced organic component conversion and humus formation during rice straw composting with tricarboxylic acid cycle regulator addition

The aim of this study was to investigate the effect of tricarboxylic acid (TCA) cycle regulators on CO₂ emissions, the conversion of organic components and humus formation during composting. The addition of adenosine triphosphate (ATP) and nicotinamide adenine dinucleotide (NADH) reduced CO₂ emissions during rice straw composting. According to co-occurrence networks results, ATP enhanced the connectivity and complexity of the network; NADH enhanced microbial interactions. The different kind of TCA cycle regulators had different effect on humus formation pathway. The structural equation model showed that ATP might promote lignin transformation into humus via the sugar-amine condensation pathway and lignin-protein pathway while NADH may promote cellulose degradation into soluble sugar and organic matter, which are transformed into humus. This work will provide valuable guidance for exploring the mechanism of TCA cycle regulators in promoting organic carbon fixation and reducing inorganic carbon mineralization.

Simultaneous disintegration of municipal sludge and generation of ethanol with magnetic layered double hydroxides

In order to investigate the effect of magnetic ZnCaFe-layered double hydroxides (MLDH) on the disintegration of municipal sludge and generation of ethanol, the MLDH was synthesized for use in the treatment of municipal sludge. The results indicated that the disintegration performance of municipal sludge was obviously enhanced by the MLDH under visible light irradiation, and the MLDH could also improve saccharification and fermentation in the dark. The yields of 468.9 mg/g for reducing sugar and 136.3 mg/g for ethanol were achieved respectively when the MLDH was 0.3 mg/mL, pretreatment time was 80 min, simultaneous saccharification and fermentation (SSF) time was 120 h, and enzyme loading was 60 FPU/g. The conversion yields were still higher than that of control group after 6 cycles of the MLDH. Therefore, the recyclable MLDH is promising for the treatment and energy conversion of municipal sludge.

Substrate-Related Factors Affecting Cellulosome-Induced Hydrolysis for Lignocellulose Valorization

Cellulosomes are an extracellular supramolecular multienzyme complex that can efficiently degrade cellulose and hemicelluloses in plant cell walls. The structural and unique subunit arrangement of cellulosomes can promote its adhesion to the insoluble substrates, thus providing individual microbial cells with a direct competence in the utilization of cellulosic biomass. Significant progress has been achieved in revealing the structures and functions of cellulosomes, but a knowledge gap still exists in understanding the interaction between cellulosome and lignocellulosic substrate for those derived from biorefinery pretreatment of agricultural crops. The cellulosomic saccharification of lignocellulose is affected by various substrate-related physical and chemical factors, including native (untreated) wood lignin content, the extent of lignin and xylan removal by pretreatment, lignin structure, substrate size, and of course substrate pore surface area or substrate accessibility to cellulose. Herein, we summarize the cellulosome structure, substrate-related factors, and regulatory mechanisms in the host cells. We discuss the latest advances in specific strategies of cellulosome-induced hydrolysis, which can function in the reaction kinetics and the overall progress of biorefineries based on lignocellulosic feedstocks.

Development of modified HCH-1 kinetic model for long-term enzymatic cellulose hydrolysis and comparison with literature models

BACKGROUND

Enzymatic hydrolysis is a major step for cellulosic ethanol production. A thorough understanding of enzymatic hydrolysis is necessary to help design optimal conditions and economical systems. The original HCH-1 (Holtzapple-Caram-Humphrey-1) model is a generalized mechanistic model for enzymatic cellulose hydrolysis, but was previously applied only to the initial rates. In this study, the original HCH-1 model was modified to describe integrated enzymatic cellulose hydrolysis. The relationships between parameters in the HCH-1 model and substrate conversion were investigated. Literature models for long-term (> 48 h) enzymatic hydrolysis were summarized and compared to the modified HCH-1 model.

RESULTS

A modified HCH-1 model was developed for long-term (> 48 h) enzymatic cellulose hydrolysis. This modified HCH-1 model includes the following additional considerations: (1) relationships between coefficients and substrate conversion, and (2) enzyme stability. Parameter estimation was performed with 10-day experimental data using α-cellulose as substrate. The developed model satisfactorily describes integrated cellulose hydrolysis data taken with various reaction conditions (initial substrate concentration, initial product concentration, enzyme loading, time). Mechanistic (and semi-mechanistic) literature models for long-term enzymatic hydrolysis were compared with the modified HCH-1 model and evaluated by the corrected version of the Akaike information criterion. Comparison results show that the modified HCH-1 model provides the best fit for enzymatic cellulose hydrolysis.

CONCLUSIONS

The HCH-1 model was modified to extend its application to integrated enzymatic hydrolysis; it performed well when predicting 10-day cellulose hydrolysis at various experimental conditions. Comparison with the literature models showed that the modified HCH-1 model provided the best fit.

Lignin from hydrothermally pretreated grass biomass retards enzymatic cellulose degradation by acting as a physical barrier rather than by inducing nonproductive adsorption of enzymes

BACKGROUND

Lignin is known to hinder efficient enzymatic conversion of lignocellulose in biorefining processes. In particular, nonproductive adsorption of cellulases onto lignin is considered a key mechanism to explain how lignin retards enzymatic cellulose conversion in extended reactions.

RESULTS

Lignin-rich residues (LRRs) were prepared via extensive enzymatic cellulose degradation of corn stover (Zea mays subsp. mays L.), Miscanthus × giganteus stalks (MS) and wheat straw (Triticum aestivum L.) (WS) samples that each had been hydrothermally pretreated at three severity factors (log R₀) of 3.65, 3.83 and 3.97. The LRRs had different residual carbohydrate levels-the highest in MS; the lowest in WS. The residual carbohydrate was not traceable at the surface of the LRRs particles by ATR-FTIR analysis. The chemical properties of the lignin in the LRRs varied across the three types of biomass, but monolignols composition was not affected by the severity factor. When pure cellulose was added to a mixture of LRRs and a commercial cellulolytic enzyme preparation, the rate and extent of glucose release were unaffected by the presence of LRRs regardless of biomass type and severity factor, despite adsorption of the enzymes to the LRRs. Since the surface of the LRRs particles were covered by lignin, the data suggest that the retardation of enzymatic cellulose degradation during extended reaction on lignocellulosic substrates is due to physical blockage of the access of enzymes to the cellulose caused by the gradual accumulation of lignin at the surface of the biomass particles rather than by nonproductive enzyme adsorption.

CONCLUSIONS

The study suggests that lignin from hydrothermally pretreated grass biomass retards enzymatic cellulose degradation by acting as a physical barrier blocking the access of enzymes to cellulose rather than by inducing retardation through nonproductive adsorption of enzymes.

Cobalt-60 gamma-ray irradiation pretreatment and sludge protein for enhancing enzymatic saccharification of hybrid poplar sawdust

In order to improve the enzymatic saccharification of hybrid poplar sawdust, gamma irradiation pretreatment and enzymatic hydrolysis in the presence of sludge protein were investigated. The cellulose crystallinity index were significantly decreased after irradiation pretreatment, and adding sludge protein improved enzyme activity and increased the reducing sugar yield. The conditions of irradiation pretreatment and enzymatic hydrolysis in the presence of sludge protein were systematically examined. The maximum reducing sugar yield was 519mg/g under an irradiation dose of 300kGy, a sludge protein dosage of 2mg/mL, an enzymatic hydrolysis temperature of 45°C, an enzymatic hydrolysis time of 84h, and a 90FPU/g enzyme loading. This work indicated that the combined method of gamma irradiation pretreatment and enzymatic hydrolysis in the presence of sludge protein was a promising potential for the saccharification of hybrid poplar sawdust.

Valorization of lignin and cellulose in acid-steam-exploded corn stover by a moderate alkaline ethanol post-treatment based on an integrated biorefinery concept

BACKGROUND

Due to the unsustainable consumption of fossil resources, great efforts have been made to convert lignocellulose into bioethanol and commodity organic compounds through biological methods. The conversion of cellulose is impeded by the compactness of plant cell wall matrix and crystalline structure of the native cellulose. Therefore, appropriate pretreatment and even post-treatment are indispensable to overcome this problem. Additionally, an adequate utilization of coproduct lignin will be important for improving the economic viability of modern biorefinery industries.

RESULTS

The effectiveness of moderate alkaline ethanol post-treatment on the bioconversion efficiency of cellulose in the acid-steam-exploded corn stover was investigated in this study. Results showed that an increase of the alcoholic sodium hydroxide (NaOH) concentration from 0.05 to 4% led to a decrease in the lignin content in the post-treated samples from 32.8 to 10.7%, while the cellulose digestibility consequently increased. The cellulose conversion of the 4% alcoholic NaOH integrally treated corn stover reached up to 99.3% after 72 h, which was significantly higher than that of the acid steam exploded corn stover without post-treatment (57.3%). In addition to the decrease in lignin content, an expansion of cellulose I lattice induced by the 4% alcoholic NaOH post-treatment played a significant role in promoting the enzymatic hydrolysis of corn stover. More importantly, the lignin fraction (AL) released during the 4% alcoholic NaOH post-treatment and the lignin-rich residue (EHR) remained after the enzymatic hydrolysis of the 4% alcoholic NaOH post-treated acid-steam-exploded corn stover were employed to synthesize lignin-phenol-formaldehyde (LPF) resins. The plywoods prepared with the resins exhibit satisfactory performances.

CONCLUSIONS

An alkaline ethanol system with an appropriate NaOH concentration could improve the removal of lignin and modification of the crystalline structure of cellulose in acid-steam-exploded corn stover, and consequently significantly improve the conversion of cellulose through enzymatic hydrolysis for biofuel production. The lignin fractions obtained as byproducts could be applied in high performance LPF resin preparation. The proposed model for the integral valorization of corn stover in this study is worth of popularization.