1
|
Knaus T, Corrado ML, Mutti FG. One-Pot Biocatalytic Synthesis of Primary, Secondary, and Tertiary Amines with Two Stereocenters from α,β-Unsaturated Ketones Using Alkyl-Ammonium Formate. ACS Catal 2022; 12:14459-14475. [PMID: 36504913 PMCID: PMC9724091 DOI: 10.1021/acscatal.2c03052] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 06/25/2022] [Revised: 10/20/2022] [Indexed: 11/11/2022]
Abstract
The efficient asymmetric catalytic synthesis of amines containing more than one stereogenic center is a current challenge. Here, we present a biocatalytic cascade that combines ene-reductases (EReds) with imine reductases/reductive aminases (IReds/RedAms) to enable the conversion of α,β-unsaturated ketones into primary, secondary, and tertiary amines containing two stereogenic centers in very high chemical purity (up to >99%), a diastereomeric ratio, and an enantiomeric ratio (up to >99.8:<0.2). Compared with previously reported strategies, our strategy could synthesize two, three, or even all four of the possible stereoisomers of the amine products while precluding the formation of side-products. Furthermore, ammonium or alkylammonium formate buffer could be used as the only additional reagent since it acted both as an amine donor and as a source of reducing equivalents. This was achieved through the implementation of an NADP-dependent formate dehydrogenase (FDH) for the in situ recycling of the NADPH coenzyme, thus leading to increased atom economy for this biocatalytic transformation. Finally, this dual-enzyme ERed/IRed cascade also exhibits a complementarity with the recently reported EneIRED enzymes for the synthesis of cyclic six-membered ring amines. The ERed/IRed method yielded trans-1,2 and cis-1,3 substituted cyclohexylamines in high optical purities, whereas the EneIRED method was reported to yield one cis-1,2 and one trans-1,3 enantiomer. As a proof of concept, when 3-methylcyclohex-2-en-1-one was converted into secondary and tertiary chiral amines with different amine donors, we could obtain all the four possible stereoisomer products. This result exemplifies the versatility of this method and its potential for future wider utilization in asymmetric synthesis by expanding the toolbox of currently available dehydrogenases via enzyme engineering and discovery.
Collapse
|
2
|
Kumar Roy T, Sreedharan R, Ghosh P, Gandhi T, Maiti D. Ene-Reductase: A Multifaceted Biocatalyst in Organic Synthesis. Chemistry 2022; 28:e202103949. [PMID: 35133702 DOI: 10.1002/chem.202103949] [Citation(s) in RCA: 16] [Impact Index Per Article: 8.0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 11/02/2021] [Indexed: 12/13/2022]
Abstract
Biocatalysis integrate microbiologists, enzymologists, and organic chemists to access the repertoire of pharmaceutical and agrochemicals with high chemoselectivity, regioselectivity, and enantioselectivity. The saturation of carbon-carbon double bonds by biocatalysts challenges the conventional chemical methodology as it bypasses the use of precious metals (in combination with chiral ligands and molecular hydrogen) or organocatalysts. In this line, Ene-reductases (ERs) from the Old Yellow Enzymes (OYEs) family are found to be a prominent asymmetric biocatalyst that is increasingly used in academia and industries towards unparalleled stereoselective trans-hydrogenations of activated C=C bonds. ERs gained prominence as they were used as individual catalysts, multi-enzyme cascades, and in conjugation with chemical reagents (chemoenzymatic approach). Besides, ERs' participation in the photoelectrochemical and radical-mediated process helps to unlock many scopes outside traditional biocatalysis. These up-and-coming methodologies entice the enzymologists and chemists to explore, expand and harness the chemistries displayed by ERs for industrial settings. Herein, we reviewed the last five year's exploration of organic transformations using ERs.
Collapse
Affiliation(s)
- Triptesh Kumar Roy
- Department of Chemistry, Indian Institute of Science Education and Research (IISER) Tirupati, Tirupati, India
| | - Ramdas Sreedharan
- Department of Chemistry, School of Advanced Sciences, Vellore Institute of Technology, Vellore, 632014, Tamil Nadu, India
| | - Pintu Ghosh
- Department of Chemistry, Indian Institute of Technology Bombay, Powai, Mumbai, India
| | - Thirumanavelan Gandhi
- Department of Chemistry, School of Advanced Sciences, Vellore Institute of Technology, Vellore, 632014, Tamil Nadu, India
| | - Debabrata Maiti
- Chemistry Department and Interdisciplinary Program in Climate Studies, Indian Institute of Technology Bombay, Powai, Maharashtra 400076, India
| |
Collapse
|
3
|
Jongkind EPJ, Fossey‐Jouenne A, Mayol O, Zaparucha A, Vergne‐Vaxelaire C, Paul CE. Synthesis of Chiral Amines via a Bi‐Enzymatic Cascade Using an Ene‐Reductase and Amine Dehydrogenase. ChemCatChem 2021. [DOI: 10.1002/cctc.202101576] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.3] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 12/31/2022]
Affiliation(s)
- Ewald P. J. Jongkind
- Biocatalysis Department of Biotechnology Delft University of Technology Van der Maasweg 9 2629 HZ Delft The Netherlands
| | - Aurélie Fossey‐Jouenne
- Génomique Métabolique Genoscope Institut François Jacob CEA CNRS Univ Evry Université Paris-Saclay 2 rue Gaston Crémieux 91057 Evry France
| | - Ombeline Mayol
- Génomique Métabolique Genoscope Institut François Jacob CEA CNRS Univ Evry Université Paris-Saclay 2 rue Gaston Crémieux 91057 Evry France
| | - Anne Zaparucha
- Génomique Métabolique Genoscope Institut François Jacob CEA CNRS Univ Evry Université Paris-Saclay 2 rue Gaston Crémieux 91057 Evry France
| | - Carine Vergne‐Vaxelaire
- Génomique Métabolique Genoscope Institut François Jacob CEA CNRS Univ Evry Université Paris-Saclay 2 rue Gaston Crémieux 91057 Evry France
| | - Caroline E. Paul
- Biocatalysis Department of Biotechnology Delft University of Technology Van der Maasweg 9 2629 HZ Delft The Netherlands
| |
Collapse
|
4
|
Li F, Yang LC, Zhang J, Chen JS, Renata H. Stereoselective Synthesis of β-Branched Aromatic α-Amino Acids by Biocatalytic Dynamic Kinetic Resolution*. Angew Chem Int Ed Engl 2021; 60:17680-17685. [PMID: 34056805 DOI: 10.1002/anie.202105656] [Citation(s) in RCA: 16] [Impact Index Per Article: 5.3] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 04/26/2021] [Indexed: 01/18/2023]
Abstract
β-Branched noncanonical amino acids are valuable molecules in modern drug development efforts. However, they are still challenging to prepare due to the need to set multiple stereocenters in a stereoselective fashion, and contemporary methods for the synthesis of such compounds often rely on the use of rare-transition-metal catalysts with designer ligands. Herein, we report a highly diastereo- and enantioselective biocatalytic transamination method to prepare a broad range of aromatic β-branched α-amino acids. Mechanistic studies show that the transformation proceeds through dynamic kinetic resolution that is unique to the optimal enzyme. To highlight its utility and practicality, the biocatalytic reaction was applied to the synthesis of several sp3 -rich cyclic fragments and the first total synthesis of jomthonic acid A.
Collapse
Affiliation(s)
- Fuzhuo Li
- Department of Chemistry, The Scripps Research Institute, 130 Scripps Way, Jupiter, FL, 33458, USA
| | - Li-Cheng Yang
- Department of Chemistry, The Scripps Research Institute, 130 Scripps Way, Jupiter, FL, 33458, USA
| | - Jingyang Zhang
- Department of Chemistry, The Scripps Research Institute, 130 Scripps Way, Jupiter, FL, 33458, USA
| | - Jason S Chen
- Automated Synthesis Facility, The Scripps Research Institute, 10550 North Torrey Pines Road, La Jolla, CA, 92037, USA
| | - Hans Renata
- Department of Chemistry, The Scripps Research Institute, 130 Scripps Way, Jupiter, FL, 33458, USA
| |
Collapse
|
5
|
Li F, Yang L, Zhang J, Chen JS, Renata H. Stereoselective Synthesis of β‐Branched Aromatic α‐Amino Acids by Biocatalytic Dynamic Kinetic Resolution**. Angew Chem Int Ed Engl 2021. [DOI: 10.1002/ange.202105656] [Citation(s) in RCA: 2] [Impact Index Per Article: 0.7] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 12/12/2022]
Affiliation(s)
- Fuzhuo Li
- Department of Chemistry The Scripps Research Institute 130 Scripps Way Jupiter FL 33458 USA
| | - Li‐Cheng Yang
- Department of Chemistry The Scripps Research Institute 130 Scripps Way Jupiter FL 33458 USA
| | - Jingyang Zhang
- Department of Chemistry The Scripps Research Institute 130 Scripps Way Jupiter FL 33458 USA
| | - Jason S. Chen
- Automated Synthesis Facility The Scripps Research Institute 10550 North Torrey Pines Road La Jolla CA 92037 USA
| | - Hans Renata
- Department of Chemistry The Scripps Research Institute 130 Scripps Way Jupiter FL 33458 USA
| |
Collapse
|
6
|
Duan J, Li B, Qin Y, Dong Y, Ren J, Li G. Recent progress in directed evolution of stereoselective monoamine oxidases. BIORESOUR BIOPROCESS 2019. [DOI: 10.1186/s40643-019-0272-6] [Citation(s) in RCA: 9] [Impact Index Per Article: 1.8] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/10/2022] Open
Abstract
AbstractMonoamine oxidases (MAOs) use molecular dioxygen as oxidant to catalyze the oxidation of amines to imines. This type of enzyme can be employed for the synthesis of primary, secondary, and tertiary amines by an appropriate deracemization protocol. Consequently, MAOs are an attractive class of enzymes in biocatalysis. However, they also have limitations in enzyme-catalyzed processes due to the often-observed narrow substrate scope, low activity, or poor/wrong stereoselectivity. Therefore, directed evolution was introduced to eliminate these obstacles, which is the subject of this review. The main focus is on recent efforts concerning the directed evolution of four MAOs: monoamine oxidase (MAO-N), cyclohexylamine oxidase (CHAO),D-amino acid oxidase (pkDAO), and 6-hydroxy-D-nicotine oxidase (6-HDNO).
Collapse
|
7
|
Toogood HS, Scrutton NS. Discovery, Characterisation, Engineering and Applications of Ene Reductases for Industrial Biocatalysis. ACS Catal 2019; 8:3532-3549. [PMID: 31157123 PMCID: PMC6542678 DOI: 10.1021/acscatal.8b00624] [Citation(s) in RCA: 158] [Impact Index Per Article: 31.6] [Reference Citation Analysis] [Abstract] [Key Words] [Grants] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 12/31/2022]
Abstract
Recent studies of multiple enzyme families collectively referred to as ene-reductases (ERs) have highlighted potential industrial application of these biocatalysts in the production of fine and speciality chemicals. Processes have been developed whereby ERs contribute to synthetic routes as isolated enzymes, components of multi-enzyme cascades, and more recently in metabolic engineering and synthetic biology programmes using microbial cell factories to support chemicals production. The discovery of ERs from previously untapped sources and the expansion of directed evolution screening programmes, coupled to deeper mechanistic understanding of ER reactions, have driven their use in natural product and chemicals synthesis. Here we review developments, challenges and opportunities for the use of ERs in fine and speciality chemicals manufacture. The ER research field is rapidly expanding and the focus of this review is on developments that have emerged predominantly over the last 4 years.
Collapse
Affiliation(s)
- Helen S. Toogood
- School of Chemistry, Faculty of Science and Engineering, University of Manchester, 131 Princess Street, Manchester M1 7DN, U.K
| | - Nigel S. Scrutton
- School of Chemistry, Faculty of Science and Engineering, University of Manchester, 131 Princess Street, Manchester M1 7DN, U.K
| |
Collapse
|
8
|
Iorgu AI, Hedison TM, Hay S, Scrutton NS. Selectivity through discriminatory induced fit enables switching of NAD(P)H coenzyme specificity in Old Yellow Enzyme ene-reductases. FEBS J 2019; 286:3117-3128. [PMID: 31033202 PMCID: PMC6767020 DOI: 10.1111/febs.14862] [Citation(s) in RCA: 10] [Impact Index Per Article: 2.0] [Reference Citation Analysis] [Abstract] [Key Words] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 02/15/2019] [Revised: 03/22/2019] [Accepted: 04/24/2019] [Indexed: 11/30/2022]
Abstract
Most ene‐reductases belong to the Old Yellow Enzyme (OYE) family of flavin‐dependent oxidoreductases. OYEs use nicotinamide coenzymes as hydride donors to catalyze the reduction of alkenes that contain an electron‐withdrawing group. There have been many investigations of the structures and catalytic mechanisms of OYEs. However, the origin of coenzyme specificity in the OYE family is unknown. Structural NMR and X‐ray crystallographic data were used to rationally design variants of two OYEs, pentaerythritol tetranitrate reductase (PETNR) and morphinone reductase (MR), to discover the basis of coenzyme selectivity. PETNR has dual‐specificity and reacts with NADH and NADPH; MR accepts only NADH as hydride donor. Variants of a β‐hairpin motif in an active site loop of both these enzymes were studied using stopped‐flow spectroscopy. Specific attention was placed on the potential role of arginine residues within the β‐hairpin motif. Mutagenesis demonstrated that Arg130 governs the preference of PETNR for NADPH, and that Arg142 interacts with the coenzyme pyrophosphate group. These observations were used to switch coenzyme specificity in MR by replacing either Glu134 or Leu146 with arginine residues. These variants had increased (~15‐fold) affinity for NADH. Mutagenesis enabled MR to accept NADPH as a hydride donor, with E134R MR showing a significant (55‐fold) increase in efficiency in the reductive half‐reaction, when compared to the essentially unreactive wild‐type enzyme. Insight into the question of coenzyme selectivity in OYEs has therefore been addressed through rational redesign. This should enable coenzyme selectivity to be improved and switched in other OYEs.
Collapse
Affiliation(s)
- Andreea I Iorgu
- Manchester Institute of Biotechnology and School of Chemistry, Faculty of Science and Engineering, The University of Manchester, UK
| | - Tobias M Hedison
- Manchester Institute of Biotechnology and School of Chemistry, Faculty of Science and Engineering, The University of Manchester, UK
| | - Sam Hay
- Manchester Institute of Biotechnology and School of Chemistry, Faculty of Science and Engineering, The University of Manchester, UK
| | - Nigel S Scrutton
- Manchester Institute of Biotechnology and School of Chemistry, Faculty of Science and Engineering, The University of Manchester, UK
| |
Collapse
|
9
|
Foley AM, Maguire AR. The Impact of Recent Developments in Technologies which Enable the Increased Use of Biocatalysts. European J Org Chem 2019. [DOI: 10.1002/ejoc.201900208] [Citation(s) in RCA: 24] [Impact Index Per Article: 4.8] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 12/24/2022]
Affiliation(s)
- Aoife M. Foley
- School of Chemistry; Analytical & Biological Chemistry Research Facility; Synthesis & Solid State Pharmaceutical Centre; University College Cork; Cork Ireland
| | - Anita R. Maguire
- School of Chemistry & School of Pharmacy; Analytical & Biological Chemistry Research Facility; Synthesis & Solid State Pharmaceutical Centre; University College Cork; Cork Ireland
| |
Collapse
|
10
|
Development of Biotransamination Reactions towards the 3,4-Dihydro-2H-1,5-benzoxathiepin-3-amine Enantiomers. Catalysts 2018. [DOI: 10.3390/catal8100470] [Citation(s) in RCA: 3] [Impact Index Per Article: 0.5] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 01/05/2023] Open
Abstract
The stereoselective synthesis of chiral amines is an appealing task nowadays. In this context, biocatalysis plays a crucial role due to the straightforward conversion of prochiral and racemic ketones into enantiopure amines by means of a series of enzyme classes such as amine dehydrogenases, imine reductases, reductive aminases and amine transaminases. In particular, the stereoselective synthesis of 1,5-benzoxathiepin-3-amines have attracted particular attention since they possess remarkable biological profiles; however, their access through biocatalytic methods is unexplored. Amine transaminases are applied herein in the biotransamination of 3,4-dihydro-2H-1,5-benzoxathiepin-3-one, finding suitable enzymes for accessing both target amine enantiomers in high conversion and enantiomeric excess values. Biotransamination experiments have been analysed, trying to optimise the reaction conditions in terms of enzyme loading, temperature and reaction times.
Collapse
|
11
|
Winkler CK, Faber K, Hall M. Biocatalytic reduction of activated CC-bonds and beyond: emerging trends. Curr Opin Chem Biol 2018; 43:97-105. [PMID: 29275291 DOI: 10.1016/j.cbpa.2017.12.003] [Citation(s) in RCA: 84] [Impact Index Per Article: 14.0] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 09/05/2017] [Revised: 11/02/2017] [Accepted: 12/04/2017] [Indexed: 01/01/2023]
Abstract
The biocatalytic reduction of activated CC-bonds is dominated by ene-reductases from the Old Yellow Enzyme family, which gained broad practical use owing to exquisite stereoselectivity combined with wide substrate scope. Protein diversity is fostered by mining distinct protein classes and by implementing protein engineering techniques. Recent efforts are focusing on expanding the chemical complexity of the product portfolio, either through substrate functionalization or design of multi-step reactions. This review also highlights unusual chemistries catalyzed by ene-reductases and presents emerging methodologies developed to bypass the need of natural nicotinamide cofactors.
Collapse
Affiliation(s)
| | - Kurt Faber
- Department of Chemistry, University of Graz, Heinrichstrasse 28, 8010 Graz, Austria
| | - Mélanie Hall
- Department of Chemistry, University of Graz, Heinrichstrasse 28, 8010 Graz, Austria.
| |
Collapse
|
12
|
Gomm A, O'Reilly E. Transaminases for chiral amine synthesis. Curr Opin Chem Biol 2018; 43:106-112. [PMID: 29278779 DOI: 10.1016/j.cbpa.2017.12.007] [Citation(s) in RCA: 116] [Impact Index Per Article: 19.3] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 10/07/2017] [Revised: 11/28/2017] [Accepted: 12/12/2017] [Indexed: 01/13/2023]
Abstract
Amine transaminases are important biocatalysts for the synthesis of chiral primary amines. Unlike many enzymes that have been employed for the synthesis of optically active amines, amine transaminases are capable of asymmetric synthesis and do not rely on costly cofactors that must be regenerated in situ. However, their application as general catalysts for the preparation of amines is hampered by a limited substrate scope, substrate and (co)product inhibition and difficulties associated with displacing challenging reaction equilibrium. There has been important progress made to overcome these challenges, including the development of enzymes with broader substrate scope and the design of methodology to effectively displace the reaction equilibrium. Amine transaminases are also being applied in an increasing range of (chemo)enzymatic cascades and immobilized for applications in flow.
Collapse
Affiliation(s)
- Andrew Gomm
- School of Chemistry, University of Nottingham, University Park, Nottingham NG7 2RD, United Kingdom
| | - Elaine O'Reilly
- School of Chemistry, University of Nottingham, University Park, Nottingham NG7 2RD, United Kingdom.
| |
Collapse
|
13
|
Slabu I, Galman JL, Lloyd RC, Turner NJ. Discovery, Engineering, and Synthetic Application of Transaminase Biocatalysts. ACS Catal 2017. [DOI: 10.1021/acscatal.7b02686] [Citation(s) in RCA: 184] [Impact Index Per Article: 26.3] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 12/27/2022]
Affiliation(s)
- Iustina Slabu
- School
of Chemistry, The University of Manchester, Manchester Institute of Biotechnology, 131 Princess Street, M1 7DN Manchester, United Kingdom
| | - James L. Galman
- School
of Chemistry, The University of Manchester, Manchester Institute of Biotechnology, 131 Princess Street, M1 7DN Manchester, United Kingdom
| | - Richard C. Lloyd
- Dr.
Reddy’s Laboratories, Chirotech Technology Centre, CB4 0PE Cambridge, United Kingdom
| | - Nicholas J. Turner
- School
of Chemistry, The University of Manchester, Manchester Institute of Biotechnology, 131 Princess Street, M1 7DN Manchester, United Kingdom
| |
Collapse
|
14
|
Pesic M, Fernández-Fueyo E, Hollmann F. Characterization of the Old Yellow Enzyme Homolog fromBacillus subtilis(YqjM). ChemistrySelect 2017. [DOI: 10.1002/slct.201700724] [Citation(s) in RCA: 21] [Impact Index Per Article: 3.0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 12/31/2022]
Affiliation(s)
- Milja Pesic
- Department of Biotechnology; Delft University of Technology; Van der Maasewg 9 2629HZ Delft, The Netherlands
| | - Elena Fernández-Fueyo
- Department of Biotechnology; Delft University of Technology; Van der Maasewg 9 2629HZ Delft, The Netherlands
| | - Frank Hollmann
- Department of Biotechnology; Delft University of Technology; Van der Maasewg 9 2629HZ Delft, The Netherlands
| |
Collapse
|
15
|
Schrittwieser JH, Velikogne S, Hall M, Kroutil W. Artificial Biocatalytic Linear Cascades for Preparation of Organic Molecules. Chem Rev 2017; 118:270-348. [DOI: 10.1021/acs.chemrev.7b00033] [Citation(s) in RCA: 371] [Impact Index Per Article: 53.0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 12/15/2022]
Affiliation(s)
- Joerg H. Schrittwieser
- Institute
of Chemistry, Organic and Bioorganic Chemistry, University of Graz, NAWI Graz, BioTechMed Graz, Heinrichstrasse 28, 8010 Graz, Austria
| | - Stefan Velikogne
- ACIB
GmbH, Department of Chemistry, University of Graz, Heinrichstrasse
28, 8010 Graz, Austria
| | - Mélanie Hall
- Institute
of Chemistry, Organic and Bioorganic Chemistry, University of Graz, NAWI Graz, BioTechMed Graz, Heinrichstrasse 28, 8010 Graz, Austria
| | - Wolfgang Kroutil
- Institute
of Chemistry, Organic and Bioorganic Chemistry, University of Graz, NAWI Graz, BioTechMed Graz, Heinrichstrasse 28, 8010 Graz, Austria
- ACIB
GmbH, Department of Chemistry, University of Graz, Heinrichstrasse
28, 8010 Graz, Austria
| |
Collapse
|
16
|
Brenna E, Crotti M, Gatti FG, Marinoni L, Monti D, Quaiato S. Exploitation of a Multienzymatic Stereoselective Cascade Process in the Synthesis of 2-Methyl-3-Substituted Tetrahydrofuran Precursors. J Org Chem 2017; 82:2114-2122. [PMID: 28094943 DOI: 10.1021/acs.joc.6b02927] [Citation(s) in RCA: 21] [Impact Index Per Article: 3.0] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/29/2022]
Abstract
Enantiopure 2-methyl-3-substituted tetrahydrofurans are key precursors of several biologically active products (drugs, flavors, and agrochemicals). Thus, a stereocontrolled and efficient methodology for the obtainment of these synthons is highly desirable. We exploited a two-step multienzymatic stereoselective cascade reduction of α-bromo-α,β-unsaturated ketones to give the corresponding bromohydrins in good yields, with high ee and de values. The cascade process is catalyzed by an ene-reductase and an alcohol dehydrogenase. Further manipulations of these bromohydrins, by two diastereodivergent routes, allowed the preparation of the tetrahydrofuran synthons. One route is based on a lipase catalyzed cleavage of the protecting group. The second route is characterized by a camphor sulfonic acid mediated isomerization of a β-hydroxyepoxide to give the tetrahydrofuran-2-ol. Finally, the synthesis of the most odorous and pleasant stereoisomer of the roasted meat aroma, i.e., (2S,3R)-2-methyl-3-thioacetate tetrahydrofuran, is reported as well.
Collapse
Affiliation(s)
- Elisabetta Brenna
- Dipartimento di Chimica, Materiali ed Ingegneria Chimica "G. Natta", Politecnico di Milano , P.zza Leonardo da Vinci 32, 20133 Milano, Italy.,The Protein Factory, Politecnico di Milano and Università degli Studi dell'Insubria , Via Mancinelli 7, 20131 Milano, Italy
| | - Michele Crotti
- Dipartimento di Chimica, Materiali ed Ingegneria Chimica "G. Natta", Politecnico di Milano , P.zza Leonardo da Vinci 32, 20133 Milano, Italy
| | - Francesco G Gatti
- Dipartimento di Chimica, Materiali ed Ingegneria Chimica "G. Natta", Politecnico di Milano , P.zza Leonardo da Vinci 32, 20133 Milano, Italy.,The Protein Factory, Politecnico di Milano and Università degli Studi dell'Insubria , Via Mancinelli 7, 20131 Milano, Italy
| | - Ludovico Marinoni
- Dipartimento di Chimica, Materiali ed Ingegneria Chimica "G. Natta", Politecnico di Milano , P.zza Leonardo da Vinci 32, 20133 Milano, Italy
| | - Daniela Monti
- Istituto di Chimica del Riconoscimento Molecolare C.N.R. , Via Mario Bianco, 9, 20131, Milano, Italy
| | - Sara Quaiato
- Dipartimento di Chimica, Materiali ed Ingegneria Chimica "G. Natta", Politecnico di Milano , P.zza Leonardo da Vinci 32, 20133 Milano, Italy
| |
Collapse
|