Biotransformation of phosphorus in enhanced biological phosphorus removal sludge biochar

Response of phosphorus fractions transformation and microbial community to carbon-to-phosphorus ratios during sludge composting

Phosphorus (P) is one of the essential nutrient elements for plant growth and development. Sludge compost products can be used as an important source of soil P to solve the shortage of soil P. The difference in the initial carbon-to-phosphorus ratio (C/P) will lead to difference in the bacterial community, which would affect the biological pathway of P conversion in composting. However, few studies have been reported on adjusting the initial C/P of composting to explore P conversion. Therefore, this study investigated the response of P component transformations, bacterial community and P availability to C/P during sludge composting by adjusting initial C/P. The results showed that increasing C/P promoted the mineralization of organic P and significantly increased the content of the labile P. High C/P also increased the relative content of available P, especially when the C/P was at 45 and 60, it reached 60.51% and 60.47%. High C/P caused differences in the community structure, and improved the binding ability of microbial network modules and the competitiveness of microbial communities. Additionally, high C/P strengthened the effect of microbial communities on the transformation of P components. Finally, the study showed that C/P was the main contributor to P content variation (64.7%) and indirectly affected P component conversion by affecting the microbial community. Therefore, adjusting the C/P is crucial to improve the P utilization rate of composting products.

Phosphorus release and realignment in anaerobic digestion of thermal hydrolysis pretreatment sludge - Masking effects from high ammonium

Waste activated sludge (WAS) is a significant phosphorus (P) repository, and there is a growing interest in P recovery from WAS. Typically, the commercial technology for treating WAS involves thermal hydrolysis pretreatment (THP) coupled with anaerobic digestion (AD). However, there is ongoing debate regarding the transformation and distribution of P throughout this process. To address this, a long-term THP-AD process was operated in this study to comprehensively investigate P transformation and distribution. The results revealed that a substantial biodegradation of dissolved organic nitrogen (DON) raised the pH of the digestate to 8.3 during the AD process. This increased pH facilitated the dissolution of Al, leading to a reduction of 6.92 mg/L of NaOH-P. Simultaneously, sulfate reduction contributed to a decrease of 11.04 mg/L of Bipy-P in the solid. However, the reduction of Bipy-P and NaOH-P in the solid did not result in an improved P release to the supernatant. Conversely, a decrease of 23.60 mg/L P in the aqueous phase was observed after anaerobic digestion. The disappeared P was primarily precipitated with Mg and Ca, driven by the increased pH, and it contributed to the increase of HCl-P in the solid from 107.80 to 144.52 mg/L. These findings were further confirmed by results obtained from scanning electron microscopy (SEM), X-ray powder diffraction (XRD), and solid-state 31P nuclear magnetic resonance (NMR) spectroscopy. This study provides valuable insights into the mechanisms of P transformation during THP-AD process that is nearly opposite from conventional AD system.

Bioremediation system consisted with Leclercia adecarboxylata and nZVI@Carbon/Phosphate for lead immobilization: The passivation mechanisms of chemical reaction and biological metabolism in soil

Bioremediation is one of the most promising strategies for heavy metal immobilization. A new remediation system was demonstrated in this research, which combined phosphate solubilizing bacteria (PSB) with nZVI@Carbon/Phosphate (nZVI@C/P) composite to remediate lead contaminated soil. Experimental results indicated that the new system (nZVI@C/P + PSB) could effectively convert the labile Pb into the stable fraction after 30 days of incubation, which increased the maximum residual fraction percentage of Pb by 70.58%. The characterization results showed that lead may exist in the forms of Pb₅(PO₄)₃Cl, PbSO₄ and 3PbCO₃·2Pb(OH)₂·H₂O in the soil treated with nZVI@C/P + PSB. Meanwhile, soil enzyme activities and Leclercia abundance were enhanced in the treated soil compared with CK during the incubation time. In addition, the specialized functions (e.g. ABC transporters, siderophore metabolism, sulfur metabolism and phosphorus metabolism) in PSB and nZVI@C/P + PSB group were also enhanced. These phenomena proved that the key soil metabolic functions may be maintained and enhanced through the synergistic effect of incubated PSB and nZVI@C/P. The study demonstrated that this new bioremediation system provided feasible way to improve the efficacy for lead contaminated soil remediation.

Phosphate-solubilizing microorganisms regulate the release and transformation of phosphorus in biochar-based slow-release fertilizer

Coupling phosphate-solubilizing microorganisms (PSM) can improve the availability of phosphorous (P) in biochar-based slow-release P fertilizers (BPF). However, the mechanism in release and transformation of P in BPF regulated by PSM is still unclear. Herein, the biocompatibility and the adhesion behaviors of BPF and PSM (Enterobacter hormaechei Rs-198) in soil were firstly studied, and a 90 days' laboratory-scale soil incubation experiment of BPF and Rs-198 was performed to study the transformation of P of BPF. The results show that BPF has a good biocompatibility for Rs-198 due to its low aromaticity, graphitization and free radicals' content (0.084 mg/g). Rs-198 are adhered to the surface of BPF in soil due to the high negative secondary energy minimum and low total interaction energy between Rs-198 and BPF. Available P in the incubation of BPF and Rs-198 (BR treatment) is significantly higher than that of the incubation of BPF (BF treatment) at initial 60 days. However, the content of available P in BR treatment is much lower compared with that in BF treatment on day 90, which is attributed to the entrapment of released P from BPF by Rs-198 and the formation of polyphosphate (polyP) rather than bound with soil mineral. Overall, this study presents new insights into the transformation of P in BPF regulated by PSM.

Recyclable structured toxic industrial nickel-containing sludge for efficient anionic contaminant adsorption

Safe, efficient, and simultaneous treatment of toxic industrial sludge and anionic contaminant crisis in one route still remains a persistent global challenge. Herein, we proposed a facile waste-control-waste conceptual design strategy to develop low-cost and high-performance sludge-based adsorbent for not only recycling of toxic waste nickel-containing sludge (NCS) but for the efficient removal of anionic contaminants in wastewater. The as-designed Ni-Al layered double oxides/calcined NCS (Ni-Al LDOs/CNCS) (216.96 m²/g, 0.44 cm³/g) with hierarchical porous structure possessed a larger specific surface area and well-developed porosity compared with raw NCS (60.52 m²/g, 0.26 cm³/g). It was proved that a higher hydrothermal temperature (180 °C) and a longer hydrothermal time (24 h) both promote the in situ assembly of LDHs nanosheets on CNCS surface. Significantly, the sludge-based adsorbent displayed high adsorption capacity towards five representative anions including F^- (~ 31.1 mg/g), SO₄^2- (~ 37.7 mg/g), NO₃^- (~ 21.8 mg/g), Cl^- (~ 28.0 mg/g), and H₂PO₄^- (~ 35.8 mg/g). Furthermore, the adsorbent maintained desirable adsorption capacity even after 6 adsorption/desorption cycles. Therefore, this study could be potentially extended toward design of other industrial waste sludge-derived high value-added advanced materials and for wastewater treatment applications.

The effectiveness of reed-biochar in mitigating phosphorus losses and enhancing microbially-driven phosphorus dynamics in paddy soil

Biochar is a promising novel material for mitigating phosphorus (P) loss and enhancing P retention in chemical-amended agricultural soils. However, the optimal application rate for aforesaid effectiveness and potential drivers of the process are not well understood. Herein, a column-based pot experiment was carried out to investigate how and to what extent reed-biochar is effective in positively triggering P loss and availability in paddy soils treated by chemical fertilizer. Compared with chemical-only treatment, the accumulated leakage of total P, dissoluble P, and particulate P in chemical fertilizer coupled with 1-4% reed-biochar treatment decreased by 5.3-13.3%, 8.3-10.4%, and 3.0-15.4%, respectively. The accumulated leakage of total P and dissoluble P in 6-8% rate treatments was increased by 5.6-7.5% and 18.3-32.9%, respectively. Increasing reed-biochar rate from 1% to 8% caused an enhancement in soil total P and available P content and P activation coefficient, and the 4% rate achieved a similar effectiveness to the higher rate. Reed-biochar application increased the abundance and diversty of soil phoD-harboring microbes (P < 0.05), while the increment had little to do with the application rate. Soil phoD-harboring community composition and total C content were the main predictors of the P leaching losses, and meanwhile, the total C content was the dominated predictor of soil P retention and availability. These results suggest that adding 1-4% reed-biochar was more beneficial to mitigate paddy P loss and to enhance soil P availability. This study highlights the importance of understanding how microbial populations mediate P transformation to decipher the biochar-driven improvement of soil P utilization.

Thermal treatment of sewage sludge: A comparative review of the conversion principle, recovery methods and bioavailability-predicting of phosphorus

Phosphorus is a nutrient that is essential to nature and human life and has attracted attention because of its very limited reserves. Dwindling phosphorus reserves and soaring prices have made the recovery of phosphorus from waste biosolids even more urgent. Waste activated sludge, as the final destination of most of the phosphorus in human domestic and industrial water, has been considered as a reliable source of phosphorus recovery. The thermal treatment method of sewage sludge is currently a relatively environmentally friendly disposal method, which mainly includes incineration, pyrolysis and hydrothermal carbonization. This paper reviews the methods for the recovery of different forms of phosphorus (wet chemical, thermochemical and electrodialysis) from solid products obtained from different sludge thermal treatment methods (incinerated sewage sludge ash, pyrolysis of sewage sludge char and hydrochar) and the bioavailability of the recovered phosphorus products. Incineration of sewage sludge is currently the most established and effective method for recovering phosphorus from the thermal treatment products of sewage sludge. One of the wet chemical methods has been applied on a commercial scale and is expected to be further developed for future industrial applications. Pyrolysis and hydrothermal carbonation still have many research gaps in this field. Based on their principles and laboratory performance, both of them have the potential to recover phosphorus and should be further explored.

New directions and challenges in engineering biologically-enhanced biochar for biological water treatment

Cost-effective, efficient, and sustainable water treatment solutions utilising existing materials and technology will make it easier for low and middle-income countries to adopt them, improving public health. The ability of biochar to mediate and support microbial degradation of contaminants, combined with its carbon-sequestration potential, has attracted attention in recent years. Biochar is a possible candidate for use in cost-effective and sustainable biological water treatment, especially in agrarian economies with easy access to abundant biomass in the form of crop residues and organic wastes. This review evaluates the scope, potential benefits (economic and environmental) and challenges of sustainable biological water treatment using 'Biologically-Enhanced Biochar' or BEB. We discuss the various processes occurring in BEB systems and demonstrate the urgent need to investigate microbial degradation mechanisms. We highlight the need to correlate biochar properties to biofilm development, which can eventually determine process efficiency. We also demonstrate the various opportunities in adopting BEB as a cheaper and more viable alternative in Low and Middle Income Countries and compare it to the current benchmark, 'Biological Activated Carbon'. We focus on the recent advances in the areas of data science, mathematical modelling and molecular biology to systematically and sustainably design BEB filters, unlike the largely empirical design approaches seen in water treatment. 'Sequential biochar systems' are introduced as specially designed end-of-life techniques to lower the environmental impact of BEB filters and examples of their integration into biological water treatment that can fulfil zero waste criteria for BEBs are given.

Enhanced Cd phytostabilization and rhizosphere bacterial diversity of Robinia pseudoacacia L. by endophyte Enterobacter sp. YG-14 combined with sludge biochar

Robinia pseudoacacia L., a pioneer woody legume grown in mining areas, has been recognized as a remarkable accumulator of various heavy metals. Compared with other hazardous heavy metals (HMs), it is of low capacity in accumulating Cd, which, as a result, may hinder the phytoremediation efficiency. To enhance R. pseudoacacia's uptake efficiency of Cd, the individual effects of various rhizobia and arbuscular mycorrhizal fungi have been reported, however, the combined influence of endophytes and biochar receives little attention. In the current study, a Cd-adsorbing endophyte Enterobacter sp. YG-14 was inoculated to R. pseudoacacia, and its extraordinary effect on increasing R. pseudoacacia's Cd uptake was found, which was ascribed to the reinforced root Cd chelation by the strain through secreting siderophores/LMWOAs. Further, P-enriched sludge biochar was applied along with YG-14 to form a combined biochar-endophyte-accumulator system, in which biomineralization were reinforced (i.e. CdCO₃ and Cd₂P₂O₇ were generated), as the total and acid-soluble Cd in rhizosphere were reduced by 61.75% and 69.01% respectively, and soil's bacterial diversity was further improved with diversified N₂-fixing microbial biomarkers. Multiple synergistic effects (E > 0) were also found, with the optimum performance on plant growth parameters (increased by 39.61%-561.91%) in comparison to the control group. Moreover, the system exhibited a preferable Cd phytostabilization capacity with the highest increase (81.42%) in Cd accumulation and a significant reduction (72.73%) in Cd root-to-shoot translocation.

Thermal hydrolyzed food waste liquor as liquid organic fertilizer

Thermal hydrolysis (TH) is an efficient technology for food waste (FW) management. This study investigated the nutrients released from FW under various TH temperature (140, 160, 180, 200 and 220 °C) and evaluated the feasibility of the hydrolyzed liquor (HL) as liquid organic fertilizer. The phytotoxicity and biotoxicity of HL was analyzed using wheat seed and Pseudomonas putida. Results revealed that TH could effectively solubilize FW and release nutrients (N, P and K) and organic substances. The highest content of total nitrogen (TN, 1685 mgN/L) and phosphorus (TP, 235 mgP/L) in the HL was obtained under 180 °C. The K⁺ was 278-293 mg/L regardless of treatment temperature. Secondary nutrients (Ca and Mg) and micro metals (Fe, Cu, Zn, Al, Co and Mn) were all detected at relatively high level, while heavy metals (As and Cd) were generally lower than 0.5 mg/L. Twenty types of free amino acid were identified and the maximum total concentration was 4965.13 mg/L. 2% HL displayed higher germination index (>80%) and enhanced root and shoot lengths. No biotoxicity was observed as confirmed by the bioassay. This study proposes a feasible method to solubilize food waste and produce liquid organic fertilizer.

Sustainable advances on phosphorus utilization in soil via addition of biochar and humic substances

The intervention of human in phosphorus pool seems to be a vicious circle. The rapid population growth leads to the global food shortage, which leads to the massive use of phosphate fertilizer and the continuous exploitation of phosphate rocks. With the massive loss and fixation of phosphate fertilizer in the soil, the unavailable phosphorus in the soil becomes superfluous, while the phosphate mineral resources turn to scarce. Interestingly, exogenous carbonaceous materials, notably, biochar and humic substances, have been widely used as soil conditioners in agricultural production up to date, among other actions to interfere with the balance between the different phosphate species, which offer effective roles for increasing soil available phosphorus. This article reviews the regulation mechanisms of biochar and humic substances on phosphorus availability and circulation, including improving soil physicochemical characteristics, regulating microbial community structure, and directly interacting with phosphorus to affect the fate of phosphorus in soil. Finally, the prospects for future research directions are made, and it is hoped that the review of this article can arouse people's attention to the current plight of agricultural production and provide some methods for improving the efficiency of phosphate fertilizer use in the future.