Calcium induced flocculation of emulsions containing adsorbed β-casein or phosvitin

Effect of Temperature, Added Calcium and pH on the Equilibrium of Caseins between Micellar State and Milk Serum

Micellar casein and casein monomers in milk serum are in a dynamic equilibrium. At temperature below 15–20 °C a considerable amount of casein monomers, β-casein in particular, is released from the casein micelle into the aqueous serum phase. This study investigates the effects of added calcium and related variations of pH on this peculiar equilibrium in order to minimize the amount of caseins in the serum and to better understand the casein permeation during microfiltration. The pH was varied in the range of 6.3 to 7.3 and the content of calcium was increased up to 7.5 mM by adding CaCl₂. Upon equilibration, the milk was separated by ultracentrifugation and the amounts of protein in the supernatant were analyzed. It was shown that the addition of low amounts of calcium shifts the equilibrium towards the micellar casein phase and can, thus, lower the serum casein content induced at low temperatures. Relative to that, the adjustment of pH separately from the CaCl₂ addition had a minor effect on casein concentration and composition in the serum.

Combination of High Hydrostatic Pressure and Ultrafiltration to Generate a New Emulsifying Ingredient from Egg Yolk

Egg yolk granule phosvitin (45 kDa) is a phosphoprotein known for its emulsifying properties. Recently, high hydrostatic pressure (HHP) treatment of granule induced the transfer of phosvitin to the soluble plasma fraction. This project evaluated the performance of the ultrafiltration (UF) used to concentrate phosvitin from the plasma fraction to produce a natural emulsifier. Phosvitin was characterized in plasma from a pressure-treated granule (1.73 ± 0.07% w/w) and in its UF retentate (26.00 ± 4.12% w/w). The emulsifying properties of both retentates were evaluated. The emulsion prepared with phosvitin-enriched retentate was more resistant to flocculation and creaming. Confocal laser scanning microscopy showed a network of aggregated protein similar to a gel, which encapsulated oil droplets in emulsions made with UF-retentate of plasma from pressure-treated granule. However, although sodium dodecyl sulfate-polyacrylamide gel electrophoresis (SDS-PAGE) showed that β-phosvitin is recovered in the cream, it is difficult to attribute the improved emulsifying properties of the UF-retentate of plasma from pressure-treated granules only to phosvitin.

On the "Anomalous" Adsorption Behavior of Phosvitin

A statistical analysis based on the Scheutjens-Fleer theory can explain the "anomalous" adsorption behavior of the egg yolk protein phosvitin. The predicted adsorbed layer structure consists of a low surface coverage of looplike polyelectrolyte chains attached to the surface at the two ends.