Acidification of pressure-treated milk

Applicable Plant Proteins and Dietary Fibers for Simulate Plant-Based Yogurts

Effects of plant proteins and dietary fibers on the physical properties of stirred soy yogurt were investigated. Buffering capacity against lactic acid was not affected by the protein concentration for any of the four proteins that were examined: isolate soy protein (ISP), pea protein (PP), rice protein (RP), and almond protein (AP). Three proteins other than AP exhibited an increase in buffering capacity (dB/dPH) following a physical treatment, whereas AP saw a decrease in buffering capacity. Furthermore, physically treated PP revealed a significant increase in viscosity, reaching up to 497 cp in the pH 6.0~6.2 range during the titration process. Following fermentation, PP produced the highest viscosity and coagulum strength with no syneresis. In the case of dietary fiber, Acacia Fiber (AF) was completely dissolved in the solvent and did not affect the physical properties of the fermented coagulum. Soy fiber (SF) was also not suitable for fermented milk processes because precipitation occurred after the physical treatment. In the case of citrus fiber (CF), however, syneresis did not occur during storage after the physical treatment, and the viscosity also increased up to 2873 cP. Consequently, PP and CF were deemed to be a suitable plant protein and dietary fiber for stirred soy yogurt, respectively.

Molecular water motions of skim milk powder solutions during acidification studied by 17O and 1H nuclear magnetic resonance and rheology

The molecular motion of water was studied in glucono-δ-lactone-acidified skim milk powder (SMP) solutions with various pH values and dry matter contents. NMR relaxometry measurements revealed that lowering the pH in SMP solutions affected 17O and 1H T2 relaxation rates almost identically. Consequently, the present study indicates that the proteins present in the samples do not affect the 1H relaxation behavior markedly, even at relatively high SMP concentrations (15-25%). Comparison of rheological measurements and NMR measurements suggested that the collapse of κ-casein during acidification could contribute to the initial decrease in 17O and 1H relaxation rate in the pH range between 6.6 and 5.5 for 15% SMP and in the pH range between 6.6 and 5.9 for 25% SMP. However, below pH 5.5 the viscosity and 17O and 1H NMR relaxation rates did not correlate, revealing that the aggregation of casein micelles, which increases viscosity below pH 5.5, does not involve major repartitioning of water.

Isolation and Characterization of Copolymers of β-Lactoglobulin, α-Lactalbumin, κ-Casein, and αs1-Casein Generated by Pressurization and Thermal Treatment of Raw Milk

Raw skim milk was submitted to high pressure (300 to 600 MPa) and temperature (4 to 70 degrees C) treatments for 2 or 5 min. The combined effects of pressure and temperature on milk proteins induced structural changes and polymer and copolymer formation characterized by anion-exchange and size-exclusion fast protein liquid chromatography and electrophoretic techniques. Approximately half of the beta-lactoglobulin formed polymers, and the other half formed large copolymers, mainly with kappa-casein, alpha-lactalbumin via intermolecular disulfide bond exchange, and alpha(s1)-casein via physicochemical interactions, in proportions of 1.0:0.7:0.3:0.1, respectively. Minor whey proteins (serum albumin, immunoglobulins, and lactoferrin) also participated in the formation of the copolymers but to a lesser extent. Two populations of the copolymers were found with apparent molecular masses ranging from 440 to 2000 kDa for the first and more than 2000 kDa for the second. On the contrary, for heated milks the aggregation kinetics obtained by combination of high pressure and thermal treatment were very fast, as no intermediates such as dimers and small size oligomers were observed after pressurization, whatever the temperature studied. Lactosylation of proteins as well as proteolysis were very limited. A beta-casein amino-terminal peptide of 22 kDa was specifically recovered in milk samples treated under the more drastic conditions (500 MPa/55 degrees C per 5 min and 600 MPa/70 degrees C per 5 min) and might have been generated by neutral proteases such as elastase released from somatic cells present in milk. No casein was released from the micelle whatever the combination of high pressure and temperature studied.

1H nuclear magnetic resonance relaxometry study of water state in milk protein mixtures

1H NMR signal was used to characterize highly hydrated milk protein dispersions (3-20% dry matter) with various micellar casein concentrations (3-15%), whey protein concentrations (0-3%), lactose concentrations (0-7.5%), CaCl(2) concentrations (0-2 mM), and pH (6.2-6.6). The results showed the predominant effect of micellar casein concentration on water state and were consistent with the three-site relaxation model in the absence of lactose. The relaxation rates observed for these dispersions were explained by the free water relaxation rate, the hydration water relaxation rate, and the exchangeable proton relaxation rate. Hydration water was found to be mainly influenced by casein micelle concentration and structure. The variations in hydration with pH were consistent with those observed for classical measurement of voluminosity observed at this range of pH. The effects of lactose and whey protein content are discussed.

Low-fat set yogurt made from milk subjected to combinations of high hydrostatic pressure and thermal processing

The combined use of high hydrostatic pressure (300 to 676 MPa, 5 min) and thermal treatment (85 degrees C, 30 min) in milk for the manufacture of low-fat yogurt was studied. The objective was to reduce syneresis and improve the rheological properties of yogurt, reducing the need for thickeners and stabilizers. The use of high hydrostatic pressure alone, or after thermal treatment, reduced the lightness and increased the viscosity of skim milk. However, milk recovered its initial lightness and viscosity when thermal treatment was applied after high hydrostatic pressure. The MALDI-TOF spectra of skim milk presented monomers of whey proteins after a treatment of 676 MPa for 5 min. Yogurts made from skim milk subjected to 400 to 500 MPa and thermal treatment showed increased yield stress, resistance to normal penetration, and elastic modulus, while having reduced syneresis when compared to yogurts from thermally treated or raw milks. The combined use of thermal treatment and high hydrostatic pressure assures extensive whey protein denaturation and casein micelle disruption, respectively. Although reaggregation of casein submicelles occurs during fermentation, the net effect of the combined HHP and thermal treatment is the improvement of yogurt yield stress and reduction of syneresis.