Automation of the synthesis of highly concentrated 188Re-MAG3 for intracoronary radiation therapy

Synthesis of multidentate ligands with amido or amino donor groups for the preparation of rhenium and technetium radiopharmaceuticals

A new method to prepare novel semi-rigid multidentate ligands containing nitrogen atom, to coordinate with rhenium and technetium, was established. The method was based on formylation of substituted anilines, followed by Mannich reaction with glycine and paraformaldehyde. The method was very promising to design ligands of various molecular structures (L₁–L₅) to coordinate with rhenium metal ions. The complexes were prepared through ligand exchange with the complex ReOCl₃(PPh₃)₂, giving new complex of the structure ReOCl₃L_(1–5). The prepared ligands and complexes were identified by the use of UV–vis, and infrared absorption spectrometric techniques, elemental analysis, molecular weight determination by depression of freezing point. These ligands were labeled with ^99mTc pertechnetate, and the labeling efficiency of the complexes was measured using a well type scintillation gamma counter equipment and obtained a good yield.

Reduction of β-radiation exposure during preparation of 188Re-labelled Lipiodol for hepatocellular carcinoma treatment

Rhenium-188 (188Re) is of widespread interest for treating various diseases because of its attractive physical and chemical properties. The routine preparation of therapeutic doses of 188Re-labelled tracers can result in significant radiation exposure to the operator. We studied the impact of automating the preparation of 188Re-Lipiodol on the radiochemist's exposure, as well as the importance of the model of syringe shielding. To monitor radiation exposure continuously readable electronic personal dosimeters were used. Thermoluminescence dosimeters were fixed to the probable most exposed fingers of the radiochemist during preparation of the radiotracer and during the syringing. Dose rates were measured using a Babyline. Automation of the synthesis reduced personal dose equivalents from 2.60±4.35 to 1.61±1.20 µSv/GBq [Hp(10)] and from 38.37±55.28 to 21.84±16.14 µSv/GBq [Hp(0.07)]. Dose to the extremities was also reduced (-80% for the right hand; -58% for the left one). The Lemer-Pax PSWG syringe shield led to a slightly lower dose to the hands compared with the Medisystem (1.1±0.27 vs. 1.34±0.6 mSv/GBq for the right finger). Automation of the synthesis leads to a significant decrease in radiation exposure to the operator. The Lemer-Pax PSWG syringe shield provides better hand protection than the smaller Medisystem Mediclic.

Automation of labelling of Lipiodol with high-activity generator-produced 188Re

This work describes optimisation of the kit formulation for labelling of Lipiodol with high-activity generator-produced rhenium-188. Radiochemical purity (RCP) was 92.52±2.3% and extraction yield was 98.56±1.2%. The synthesis has been automated with a TADDEO module (Comecer) giving a mean final yield of 52.68±9.6%, and reducing radiation burden to the radiochemist by 80%. Radiolabelled Lipiodol ((188)Re-SSS/Lipiodol) is stable for at least 7 days (RCP=91.07±0.9%).

Inhibition of neointimal hyperplasia after stent placement with rhenium 188-filled balloon dilation in a canine iliac artery model

PURPOSE

To evaluate the efficacy of beta-irradiation therapy with rhenium 188 ((188)Re) mercaptoacetyltriglycine (MAG3)-filled balloon dilation to prevent neointimal hyperplasia after stent placement in a canine iliac artery model.

MATERIALS AND METHODS

A total of 15 stents were implanted into the iliac arteries of eight dogs (one or two stents in each dog). Rhenium 188 MAG3-filled balloon dilation was performed immediately after placement of 10 bare stents-20 Gy in group II (n = 5) and 40 Gy in group III (n = 5)-and conventional balloon dilation was performed immediately after placement of the remaining five bare stents (group I). A follow-up angiogram was obtained 8 weeks after the procedure, and percentage of luminal stenosis was calculated for the proximal and distal ends of each stent. Neointimal thickening (expressed as the neointimal area divided by the sum of neointimal area and media area) was assessed for microscopic examination.

RESULTS

All eight dogs survived until they were euthanized 8 weeks after the procedures. The mean luminal stenosis measurements at 8-week follow-up angiography in groups I, II, and III were 26.63%, -0.44%, and 10.53%, respectively. The mean neointimal thickening measurements in groups I, II, and III were 0.77, 0.21, and 0.34, respectively. The mean percentage of luminal stenosis and neointimal thickening differed significantly among the three groups (P < .05).

CONCLUSIONS

beta-Irradiation with (188)Re-MAG3-filled balloon dilation has the potential to reduce neointimal hyperplasia secondary to stent placement in a canine iliac artery model. A dose of 20 Gy may be preferable versus a dose of 40 Gy to reduce neointimal hyperplasia.

Liquid (188)Re-filled balloon dilation for the treatment of refractory benign airway strictures: preliminary experience

PURPOSE

To present the preliminary results of beta irradiation with use of liquid rhenium 188 ((188)Re)-filled balloon dilation in the treatment of refractory benign airway strictures.

MATERIALS AND METHODS

Ten sessions of beta irradiation by using liquid (188)Re-filled balloon dilation were prospectively performed in nine patients with refractory bronchial strictures between 2003 and 2006. Indications for treatment were dyspnea caused by repeat stricture or no response to previous treatment (ie, balloon dilation and/or temporary stent placement or laser therapy) in seven patients and dyspnea caused by exuberant granulation tissue formation at the distal end of the placed stent in two. To assess the treatment efficacy, the authors calculated and compared the mean intervals of interventional treatments before and after dilation with (188)Re and mercaptoacetyltriglycine (MAG(3))-filled balloons.

RESULTS

Liquid (188)Re-filled balloon dilation was successfully performed in all nine patients, with no procedure-related complications. Immediately after the procedure, all patients showed resolution of their dyspnea. Five patients remained asymptomatic at 5-25-month follow-up. Four patients experienced dyspnea caused by recurrent stricture 1-10 months after dilation. The mean intervals between interventional treatments increased significantly from 3.1 months +/- 2.1 before (188)Re-MAG(3)-filled balloon dilation to 10.8 months +/- 8.8 after (188)Re-MAG(3)-filled balloon dilation in all nine patients (Wilcoxon signed rank test, P = .025).

CONCLUSIONS

beta irradiation with liquid (188)Re-filled balloon dilation can be safely used for refractory benign airway strictures. A large study with longer follow-up is needed to draw a definite conclusion.

Rhenium-188 Mercaptoacetyltriglycine–filled Balloon Dilation in the Treatment of Recurrent Urethral Strictures: Initial Experience with Five Patients

PURPOSE

To evaluate the efficacy of beta-irradiation therapy with use of a rhenium-188 mercaptoacetyltriglycine ((188)Re-MAG(3))-filled balloon for the prevention of restenosis in urethral strictures refractory to repetitive surgical or interventional procedures.

MATERIALS AND METHODS

Five male patients with traumatic (n = 4) or postoperative anastomotic (n = 1) recurrent urethral strictures were included. One to four sessions of 20-30 Gy beta-irradiation at a 1-mm tissue depth with (188)Re-MAG(3)-filled balloon dilation were undertaken in each patient.

RESULTS

No procedural complications or toxicities were noted. During the mean follow-up period of 16.2 months, the stricture did not recur in two patients, whereas three patients required additional interventional procedures. In two of these patients, the treatment intervals between the required sessions were significantly prolonged. For the entire group, the mean treatment interval was prolonged from 2.2 months before (188)Re-MAG(3)-filled balloon dilation to 10.7 months after therapy.

CONCLUSION

(188)Re-MAG(3)-filled balloon dilation shows promise in preventing or delaying stricture recurrence in patients with recurrent urethral strictures.

Effects of irradiation using a radioisotope-filled balloon on tissue hyperplasia caused by stent placement in a canine urethral model

PURPOSE

To evaluate 20 Gy and 40 Gy of intraluminal beta-irradiation using a 188Re-7mercaptoacetyltriglycine (MAG3)-filled balloon catheter to reduce tissue hyperplasia caused by covered stent placement for 12 weeks of follow-up in a canine urethral model.

MATERIAL AND METHODS

Ten dogs underwent 188Re-MAG3-filled balloon dilatation immediately after stent placement; 20 Gy at 1-mm tissue depth in group I (n = 5) and 40 Gy in group II (n = 5), whereas 5 dogs (group III) underwent conventional balloon dilatation only.

RESULTS

There were no significant differences among the three groups for percentage diameter of stenosis, although this was highest in group III. There was a tendency toward lower mean thickness of the epithelial layer and the papillary projection for out-stent area, and thickness of the papillary projection and degree of inflammatory cells for instent area in groups I and II compared with group III. Thickness of the papillary projection in out-stent area was significantly different among the three groups (P = 0.031). It was significantly less thick in group I than in group III (P < 0.05), whereas group II was not significantly different from group III.

CONCLUSION

188Re-MAG3-filled balloon dilatation has the potential to reduce tissue hyperplasia after 12 weeks of follow-up in a canine urethral model. The use of 20 Gy compared to 40 Gy did not show significant differences.

Reduction of Tissue Hyperplasia with a Rhenium188 Mercaptoacetyltriglycine-3–filled Balloon: Preliminary Study in a Canine Urethral Model

PURPOSE

To evaluate the efficacy of beta-radiation therapy with rhenium-188 mercaptoacetyltriglycine-3 (MAG(3))-filled balloons to reduce tissue hyperplasia secondary to stent placement in 18 canine urethras.

MATERIALS AND METHODS

Eight dogs were treated with 188-Re MAG(3)-filled balloon dilation immediately after stent placement and were killed 4 weeks later (group I, n = 4) or 8 weeks later (group II, n = 4). Five dogs were treated with 188-Re MAG(3)-filled balloon dilation 2 weeks after stent placement and were killed 4 weeks after stent placement (group III). The remaining five dogs were treated with conventional balloon dilation immediately after stent placement and were killed 4 weeks later; these animals formed the control group (group IV). Retrograde urethrography (RUG) was performed during follow-up and three histologic parameters were investigated: the number of epithelial layers, papillary projection thickness, and degree of submucosal inflammatory cell infiltration. The areas inside and outside the ends of the stents were evaluated in each case after animal sacrifice. After testing statistical significance of data for RUG and histologic findings in the four study groups, the Mann-Whitney U test was used to compare groups I and II to determine delayed effects of irradiation, groups I and III to determine benefits of delayed irradiation, groups I and IV to determine efficacy of immediate irradiation for reducing tissue hyperplasia, and groups III and IV to determine efficacy of delayed irradiation for reducing tissue hyperplasia.

RESULTS

There were no significant differences in the four study groups on RUG before animal sacrifice. Between groups I and II, group II showed significantly lower mean values in five of six histologic comparisons. Between groups I and III, group III showed significantly lower mean values in only papillary projection thickness inside the stent ends. Between groups I and IV, group I showed significantly lower mean values in all three histologic parameters outside the stent ends. Between groups III and IV, group III showed significantly lower mean values in only two histologic parameters (papillary projection thickness in the in-stent area and inflammatory cell infiltration outside the stent edges).

CONCLUSION

beta-Irradiation with use of a 188-Re MAG(3)-filled balloon shows the potential to reduce tissue hyperplasia secondary to stent placement in a canine urethral model. Treatment with 188-Re MAG(3)-filled balloons at the time of stent placement shows not only favorable outcomes for reducing tissue hyperplasia but also improved delayed effects until 8 weeks.

Automated preparation of 188Re-labeled radiopharmaceuticals for endovascular radiation therapy

We have developed an automated system for the preparation of highly concentrated 188Re-perrhenate, diethylenetriamine pentaacetic acid (DTPA) and mercaptoacetyltriglycine (MAG3). The three procedural steps include concentration of 188Re-perrhanerate, chelation and purification and sterilization. The steps are operated by a small micro-controller. The eluted 188Re-perrhenate of 15 GBq/18 ml from 37 GBq 188W/188Re-generator was concentrated to 1.2 ml in 10 +/- 0.5 min with a recovery yield of 95 +/- 1.5%. We obtained the highest radiochemical yield of 95.4 +/- 2.8% and 98.5 +/- 1.2% for 188Re-DTPA and MAG3 at the oil bath temperatures of 95-97 degrees C and 93-97 degrees C, respectively.

Therapy with 188Re-Labeled Radiopharmaceuticals: An Overview of Promising Results from Initial Clinical Trials

The development of an in-house 188W/188Re-generator has greatly increased the use of 188Re for treating various diseases. 188Re is of widespread interest due to its attractive physical and chemical properties. Many new radiopharmaceuticals labeled with 188Re have been developed and are currently in clinical trials, such as: 188Re-labeled renal excreting agents like 188Re-mercaptoacetylglycylglycylglycine (MAG3) and 188Re-diethylenetriamine pentaacetic acid (DTPA) for prevention of coronary arterial restenosis; 188Re-labeled phosphonates such as 188Re-hydroxyethylidene diphosphonate (HEDP), 188Re-alendronate (ABP), and 188Re-ethylenediamine-N,N,N',N'-tetrakis(methylene phosphoric) acid (EDTMP) for palliation of metastatic bone pain; 188Re-labeled lipiodol such as 188Re-n-hexyldiaminedithiol (HDD)-lipiodol for treatment of liver cancer; and 188Re-labeled colloids and microspheres for treatment of diseases such as rheumatoid arthritis, peritoneal effusion, and other solid tumors. However, there is still a need to develop new 188Re-labeled radiopharmaceuticals that are more specific for target lesions such as cancer-specific monoclonal antibodies and peptides. The availability of 188Re from a generator at a reasonable cost may help increase not only the research activities but also the clinical applications of 188Re-labeled radiopharmaceuticals.

Intravascular ultrasound analysis of beta radiation therapy for diffuse in-stent restenosis to inhibit intimal hyperplasia

We evaluated the efficacy of beta-radiation therapy ((188)Re-MAG(3)) to inhibit intimal hyperplasia (IH) in diffuse in-stent restenosis by intravascular ultrasound (IVUS) analysis in 50 patients. Nine patients who did not agree with radiation therapy, and therefore underwent rotational atherectomy and balloon angioplasty for diffuse in-stent restenosis in the same study period, were selected for control groups. Serial IVUS comparisons were available in 44 of 50 patients with radiation therapy and 7 of 9 control patients. At 6-month follow-up, there was less significant increase of IH area in patients with radiation therapy than in control patients (Delta IH area = 0.1 +/- 0.8 mm(2) vs. 2.6 +/- 1.8 mm(2), P > 0.001 in mean values, and 0.6 +/- 1.4 mm(2) vs. 2.9 +/- 2.1 mm(2), P = 0.026 in values of follow-up lesion site, respectively). In conclusion, beta-radiation therapy might be an effective treatment modality to inhibit intimal hyperplasia in patients with diffuse in-stent restenosis.

Treatment of diffuse in-stent restenosis with rotational atherectomy followed by radiation therapy with a rhenium-188-mercaptoacetyltriglycine-filled balloon

OBJECTIVES

This study was done to evaluate the feasibility and efficacy of beta-radiation therapy with a rhenium-188-mercaptoacetyltriglycine ((188)Re-MAG(3))-filled balloon after rotational atherectomy for diffuse in-stent restenosis (ISR).

BACKGROUND

Rotational atherectomy has been shown to be safe and efficient for the treatment of ISR, but the recurrence rate is still high. Intracoronary beta-irradiation after rotational atherectomy may be a reasonable approach to prevent recurrent ISR.

METHODS

Fifty consecutive patients with diffuse ISR (length >10 mm) in native coronary arteries underwent rotational atherectomy and adjunctive balloon angioplasty, followed by beta-irradiation using a (188)Re-MAG(3)-filled balloon catheter. The radiation dose was 15 Gy at a depth of 1.0 mm into the vessel wall.

RESULTS

The mean lengths of the lesion and irradiated segment were 25.6 +/- 12.7 mm and 37.6 +/- 11.2 mm, respectively. Radiation was delivered successfully to all patients, with a mean irradiation time of 201.8 +/- 61.7 s. No adverse event, including myocardial infarction, death or stent thrombosis, occurred during the follow-up period (mean 10.3 +/- 3.7 months), and nontarget vessel revascularization was needed in one patient. The six-month binary angiographic restenosis rate was 10.4%, and the loss index was 0.17 +/- 0.31.

CONCLUSIONS

Beta-irradiation using a (188)Re-MAG(3)-filled balloon after rotational atherectomy is safe and feasible in patients with diffuse ISR, and it may improve their clinical and angiographic outcomes. Further prospective, randomized trials are warranted to evaluate the synergistic effect of debulking and irradiation in patients with diffuse ISR.