Characterization and Crystal Nucleation Kinetics of a New Metastable Polymorph of Piracetam in Alcoholic Solvents

Effect of organic acids on the solid-state polymorphic phase transformation of piracetam

Metastable polymorphs are frequently used in oral solid dosage forms to enhance the absorption of poorly water-soluble drug compounds. However, the solid phase transformation from the metastable polymorph to the thermodynamically stable polymorph during manufacturing or storage poses a major challenge for product development and quality control. Here, we report that low-content organic acids can exhibit distinct effects on the solid-state polymorphic phase transformation of piracetam (PCM), a nootropic drug used for memory enhancement. The addition of 1 mol% citric acid (CA) and tricarballylic acid (TA) can significantly inhibit the phase transformation of PCM Form I to Form II, while glutaric acid (GA) and adipic acid (AA) produce a minor effect. A molecular simulation shows that organic acid molecules can adsorb on the crystal surface of PCM Form I, thus slowing the movement of molecules from the metastable form to the stable form. Our study provides deeper insights into the mechanisms of solid-state polymorphic phase transformation of drugs in the presence of additives and facilitates opportunities for controlling the stability of metastable pharmaceuticals.

Baloxavir Marboxil Shows Anomalous Conversion of Crystal Forms from Stable to Metastable through Formation of Specific Solvate Form

Baloxavir marboxil is a novel cap-dependent endonuclease inhibitor of influenza. This study aimed to identify its polymorphs and their relationship with crystal engineering. Polymorph screening by evaporation gave forms I-III and solvate forms IV and V. Heating enabled the conversion of form III to form II, but did not enable that of forms I and II. The solvent-mediated transformation of the forms I-III by magnetic stirring in various solvents resulted in the formation of form I. These results indicate that form I is the stable form. However, all crystal forms transformed to form II after magnetic stirring in a 50% acetonitrile aqueous solution, which was not obtained from water or acetonitrile. The suspension in a 50% acetonitrile aqueous solution exhibited a novel X-ray diffraction pattern as shown in form VI. The measurement of the suspension by solid-state ¹³C-nuclear magnetic resonance revealed that the spectra of forms II and VI were similar. From these results, we conclude that the drug forms a solvate with both water and acetonitrile and spontaneously transforms to form II upon rapid desolvation under ambient conditions. This study elucidates the mechanism of unexpected convergence to a metastable form in a specific solvent and contributes to the crystal engineering of baloxavir marboxil.