1
|
Klbik I, Čechová K, Milovská S, Rusnák J, Vlasáč J, Melicherčík M, Mat'ko I, Lakota J, Šauša O. Cryoprotective Mechanism of DMSO Induced by the Inhibitory Effect on Eutectic NaCl Crystallization. J Phys Chem Lett 2022; 13:11153-11159. [PMID: 36442496 DOI: 10.1021/acs.jpclett.2c03003] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.5] [Reference Citation Analysis] [Abstract] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 06/16/2023]
Abstract
Cryopreservation is a critical procedure in autologous hematopoietic stem cell transplantation. Dimethyl sulfoxide (DMSO) is the cryoprotectant of choice. Optimization of the cryopreservation protocol in the past revealed a dramatic loss of cell viability associated with a reduction of the DMSO concentration below 2 vol % in the freezing medium. The cryoprotective mechanism of DMSO is usually ascribed to the ability to suppress ice formation and reduce the adverse effects of the freeze-concentrated solution. This work proposes an alternative hypothesis considering the detrimental impact of NaCl eutectic crystallization on cell viability. Thermoanalytical and microstructural analysis of the DMSO effect on eutectic phase transformation of cryoprotective mixtures revealed a correlation between the loss of cell viability and eutectic NaCl crystallization. DMSO inhibits the eutectic crystallization of NaCl and preserves cell viability. Thermodynamic description of the inhibitory action and possible mechanism of cryoinjury are provided.
Collapse
Affiliation(s)
- Ivan Klbik
- Institute of physics SAS, Dúbravská cesta 9, 845 11Bratislava, Slovak republic
- Department of Experimental Physics, FMFI U.K., Mlynská dolina F1, 842 48Bratislava, Slovak republic
| | - Katarína Čechová
- Department of Nuclear Physics and Biophysics, FMFI U.K., Mlynská dolina F1, 842 48Bratislava, Slovak republic
| | - Stanislava Milovská
- Earth Science Institute SAS, Ďumbierska 1, 974 01Banská Bystrica, Slovak republic
| | - Jaroslav Rusnák
- Institute of physics SAS, Dúbravská cesta 9, 845 11Bratislava, Slovak republic
| | - Jozef Vlasáč
- Earth Science Institute SAS, Ďumbierska 1, 974 01Banská Bystrica, Slovak republic
| | - Milan Melicherčík
- Department of Nuclear Physics and Biophysics, FMFI U.K., Mlynská dolina F1, 842 48Bratislava, Slovak republic
| | - Igor Mat'ko
- Institute of physics SAS, Dúbravská cesta 9, 845 11Bratislava, Slovak republic
| | - Ján Lakota
- Center of Experimental Medicine SAS, Dúbravská cesta 9, 841 04Bratislava, Slovak republic
- Faculty of Management, Comenius University, Odbojárov 10, 820 05Bratislava, Slovak republic
| | - Ondrej Šauša
- Institute of physics SAS, Dúbravská cesta 9, 845 11Bratislava, Slovak republic
- Department of Nuclear Chemistry, Faculty of Natural Sciences, Comenius University, Mlynská Dolina, Ilkovičova 6, 84215Bratislava, Slovak republic
| |
Collapse
|
2
|
Cryopreservation of NK and T Cells Without DMSO for Adoptive Cell-Based Immunotherapy. BioDrugs 2021; 35:529-545. [PMID: 34427899 DOI: 10.1007/s40259-021-00494-7] [Citation(s) in RCA: 18] [Impact Index Per Article: 6.0] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Accepted: 07/28/2021] [Indexed: 10/20/2022]
Abstract
Dimethylsufoxide (DMSO) being universally used as a cryoprotectant in clinical adoptive cell-therapy settings to treat hematological malignancies and solid tumors is a growing concern, largely due to its broad toxicities. Its use has been associated with significant clinical side effects-cardiovascular, neurological, gastrointestinal, and allergic-in patients receiving infusions of cell-therapy products. DMSO has also been associated with altered expression of natural killer (NK) and T-cell markers and their in vivo function, not to mention difficulties in scaling up DMSO-based cryoprotectants, which introduce manufacturing challenges for autologous and allogeneic cellular therapies, including chimeric antigen receptor (CAR)-T and CAR-NK cell therapies. Interest in developing alternatives to DMSO has resulted in the evaluation of a variety of sugars, proteins, polymers, amino acids, and other small molecules and osmolytes as well as modalities to efficiently enable cellular uptake of these cryoprotectants. However, the DMSO-free cryopreservation of NK and T cells remains difficult. They represent heterogeneous cell populations that are sensitive to freezing and thawing. As a result, clinical use of cryopreserved cell-therapy products has not moved past the use of DMSO. Here, we present the state of the art in the development and use of cryopreservation options that do not contain DMSO toward clinical solutions to enable the global deployment of safer adoptively transferred cell-based therapies.
Collapse
|
3
|
Hoogendoorn KH, Crommelin DJA, Jiskoot W. Formulation of Cell-Based Medicinal Products: A Question of Life or Death? J Pharm Sci 2020; 110:1885-1894. [PMID: 32649938 DOI: 10.1016/j.xphs.2020.07.002] [Citation(s) in RCA: 10] [Impact Index Per Article: 2.5] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 05/26/2020] [Revised: 06/23/2020] [Accepted: 07/06/2020] [Indexed: 12/11/2022]
Abstract
The formulation of cell-based medicinal products (CBMPs) poses major challenges because of their complexity, heterogeneity, interaction with their environment (e.g., the formulation buffer, interfaces), and susceptibility to degradation. These challenges can be quality, safety, and efficacy related. In this commentary we discuss the current status in formulation strategies of off-the-shelf and non-off-the-shelf (patient-specific) CBMPs and highlight advantages and disadvantages of each strategy. Analytical tools for the characterization and stability assessment of CBMP formulations are addressed as well. Finally, we discuss unmet needs and make some recommendations regarding the formulation of CBMPs.
Collapse
Affiliation(s)
- Karin H Hoogendoorn
- Leiden University Medical Center, Hospital Pharmacy, Interdivisional GMP Facility, Albinusdreef 2, 2333 ZA Leiden, the Netherlands
| | - Daan J A Crommelin
- Department of Pharmaceutics, Utrecht Institute for Pharmaceutical Sciences (UIPS), Utrecht University, Universiteitsweg 99, 3584 CG Utrecht, the Netherlands
| | - Wim Jiskoot
- Division of BioTherapeutics, Leiden Academic Centre for Drug Research (LACDR), Leiden University, Einsteinweg 55, 2333 CC Leiden, the Netherlands.
| |
Collapse
|
4
|
Mutsenko V, Knaack S, Lauterboeck L, Tarusin D, Sydykov B, Cabiscol R, Ivnev D, Belikan J, Beck A, Dipresa D, Lode A, El Khassawna T, Kampschulte M, Scharf R, Petrenko AY, Korossis S, Wolkers WF, Gelinsky M, Glasmacher B, Gryshkov O. Effect of 'in air' freezing on post-thaw recovery of Callithrix jacchus mesenchymal stromal cells and properties of 3D collagen-hydroxyapatite scaffolds. Cryobiology 2020; 92:215-230. [PMID: 31972153 DOI: 10.1016/j.cryobiol.2020.01.015] [Citation(s) in RCA: 8] [Impact Index Per Article: 2.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 10/21/2019] [Revised: 01/16/2020] [Accepted: 01/17/2020] [Indexed: 12/16/2022]
Abstract
Through enabling an efficient supply of cells and tissues in the health sector on demand, cryopreservation is increasingly becoming one of the mainstream technologies in rapid translation and commercialization of regenerative medicine research. Cryopreservation of tissue-engineered constructs (TECs) is an emerging trend that requires the development of practically competitive biobanking technologies. In our previous studies, we demonstrated that conventional slow-freezing using dimethyl sulfoxide (Me2SO) does not provide sufficient protection of mesenchymal stromal cells (MSCs) frozen in 3D collagen-hydroxyapatite scaffolds. After simple modifications to a cryopreservation protocol, we report on significantly improved cryopreservation of TECs. Porous 3D scaffolds were fabricated using freeze-drying of a mineralized collagen suspension and following chemical crosslinking. Amnion-derived MSCs from common marmoset monkey Callithrix jacchus were seeded onto scaffolds in static conditions. Cell-seeded scaffolds were subjected to 24 h pre-treatment with 100 mM sucrose and slow freezing in 10% Me2SO/20% FBS alone or supplemented with 300 mM sucrose. Scaffolds were frozen 'in air' and thawed using a two-step procedure. Diverse analytical methods were used for the interpretation of cryopreservation outcome for both cell-seeded and cell-free scaffolds. In both groups, cells exhibited their typical shape and well-preserved cell-cell and cell-matrix contacts after thawing. Moreover, viability test 24 h post-thaw demonstrated that application of sucrose in the cryoprotective solution preserves a significantly greater portion of sucrose-pretreated cells (more than 80%) in comparison to Me2SO alone (60%). No differences in overall protein structure and porosity of frozen scaffolds were revealed whereas their compressive stress was lower than in the control group. In conclusion, this approach holds promise for the cryopreservation of 'ready-to-use' TECs.
Collapse
Affiliation(s)
- Vitalii Mutsenko
- Institute for Multiphase Processes, Leibniz University Hannover, Hannover, Germany.
| | - Sven Knaack
- Centre for Translational Bone, Joint and Soft Tissue Research, Faculty of Medicine of Technische Universität Dresden, Dresden, Germany
| | - Lothar Lauterboeck
- Cardiovascular Center of Excellence, Louisiana State University Health Sciences Center New Orleans, USA
| | - Dmytro Tarusin
- Institute for Problems of Cryobiology and Cryomedicine, National Academy of Sciences of Ukraine, Kharkiv, Ukraine
| | - Bulat Sydykov
- Institute for Multiphase Processes, Leibniz University Hannover, Hannover, Germany
| | - Ramon Cabiscol
- Institute for Particle Technology, Technische Universität Braunschweig, Braunschweig, Germany
| | - Dmitrii Ivnev
- Institute of Power Plant Engineering and Heat Transfer, Leibniz University Hannover, Hannover, Germany
| | - Jan Belikan
- Department of Radiology, University Hospital of Giessen Marburg, Giessen, Germany
| | - Annemarie Beck
- Department of Cardiothoracic, Transplantation and Vascular Surgery, Hannover Medical School, Hannover, Germany
| | - Daniele Dipresa
- Department of Cardiothoracic, Transplantation and Vascular Surgery, Hannover Medical School, Hannover, Germany
| | - Anja Lode
- Centre for Translational Bone, Joint and Soft Tissue Research, Faculty of Medicine of Technische Universität Dresden, Dresden, Germany
| | - Thaqif El Khassawna
- Experimental Trauma Surgery, Faculty of Medicine, Justus-Liebig-Universität Gießen, Gießen, Germany
| | - Marian Kampschulte
- Department of Radiology, University Hospital of Giessen Marburg, Giessen, Germany
| | - Roland Scharf
- Institute of Power Plant Engineering and Heat Transfer, Leibniz University Hannover, Hannover, Germany
| | - Alexander Yu Petrenko
- Institute for Problems of Cryobiology and Cryomedicine, National Academy of Sciences of Ukraine, Kharkiv, Ukraine
| | - Sotirios Korossis
- Department of Cardiothoracic, Transplantation and Vascular Surgery, Hannover Medical School, Hannover, Germany; Centre for Biological Engineering, Wolfson School for Mechanical Electrical and Manufacturing Engineering, University of Loughborough, Loughborough, United Kingdom
| | - Willem F Wolkers
- Institute for Multiphase Processes, Leibniz University Hannover, Hannover, Germany
| | - Michael Gelinsky
- Centre for Translational Bone, Joint and Soft Tissue Research, Faculty of Medicine of Technische Universität Dresden, Dresden, Germany
| | - Birgit Glasmacher
- Institute for Multiphase Processes, Leibniz University Hannover, Hannover, Germany
| | - Oleksandr Gryshkov
- Institute for Multiphase Processes, Leibniz University Hannover, Hannover, Germany
| |
Collapse
|