Dynamic Characterization of Nanofiltration and Reverse Osmosis Membranes

Fabrication of High-Performance Thin-Film Composite Nanofiltration Membrane by Dynamic Calcium-Carboxyl Intra-Bridging during Post-Treatment

Widespread applications of nanofiltration (NF) and reverse osmosis (RO)-based processes for water purification and desalination call for high-performance thin-film composite (TFC) membranes. In this work, a novel and facile modification method was proposed to fabricate high-performance thin-film composite nanofiltration membrane by introducing Ca2+ in the heat post-treatment. The introduction of Ca2+ induced in situ Ca2+-carboxyl intra-bridging, leading to the embedment of Ca2+ in the polyamide (PA) layer. This post modification enhanced the hydrophilicity and surface charge of NF membranes compared to the pristine membrane. More interestingly, the modified membrane had more nodules and exhibited rougher morphology. Such changes brought by the addition of Ca2+ enabled the significant increase of water permeability (increasing from 17.9 L·m-2·h-1·bar-1 to 29.8 L·m-2·h-1·bar-1) while maintaining a high selectivity (Na2SO4 rejection rate of 98.0%). Furthermore, the intra-bridging between calcium and carboxyl imparted the NF membranes with evident antifouling properties, exhibiting milder permeability decline of 4.2% (compared to 16.7% of NF-control) during filtration of sodium alginate solution. The results highlight the potential of using Ca2+-carboxyl intra-bridging post-treatment to fabricate high-performance TFC membranes for water purification and desalination.

Effectiveness of soil washing, nanofiltration and electrochemical treatment for the recovery of metal ions coming from a contaminated soil

This research was conducted to integrate soil washing, nanofiltration (NF) membranes and electrochemical treatment as feasible methods for the remediation of contaminated soils. For this investigation, two acidic leachates (pH=2) were prepared using HCl and H(2)SO(4)-NaCl as soil-washing agents. The results of the soil washing indicated that HCl and the combined H(2)SO(4)-NaCl were effective for the extraction of ions resulting from a contaminated soil. It was observed that both leachates presented similar chemical compositions. Following this procedure, the leachate solutions were pre-filtered by microfiltration, followed by NF using the Desal-5 (DK) membrane. The experiment results showed that NF membranes presented a high ion-retention rate for the two leachates. In general, better retentions were observed with the leachate prepared with HCl than H(2)SO(4)-NaCl. In order to treat the concentrate resulting from the NF treatment, it underwent an electrochemical procedure (electrochemical deposition) as an alternative method for safe disposal. The results showed a high reduction of toxic ions, such as Pb and Cu, from the solution. These three processes applied in conjunction not only indicated that the treatment of solutions heavily contaminated with inorganic pollutants resulting from contaminated soils were feasible but also suggested the possibility of treating different types of heavy industrial effluents.