Ultra-fast vapour-liquid-solid synthesis of Si nanowires using ion-beam implanted gallium as catalyst

Modulation of GaAs nanowire growth by pre-treatment of Si substrate using a Ga focused ion beam

We reveal a novel phenomenon observed after self-catalytic growth of GaAs nanowires (NWs) on Si(111) substrates treated with a Ga focused ion beam (FIB). Depending on the ion dose, NW arrays with various geometrical parameters can be obtained. A minor treatment of the substrate enables a slight increase in the surface density of NWs relative to an unmodified substrate area. As the ion dose is increased up to ∼0.1 pCμm-2, the growth of GaAs NWs and nanocrystals is suppressed. However, a further increase in the ion dose stimulates the crystal growth leading to the formation of extremely thin NWs (39 ± 5 nm) with a remarkably high surface density of up to 15μm-2. Resting upon an analysis of the surface structure before and after stages of ion-beam treatment, ultra-high vacuum annealing and NW growth, we propose a mechanism underlying the phenomenon observed. We assume that the chemical interaction between embedded Ga ions and a native Si oxide layer leads either to the enhancement of the passivation properties of the oxide layer within FIB-modified areas (at low and middle ion doses), or to the etching of the passivating oxide layer by excess Ga atoms, resulting in the formation of pores (at high ion doses). Due to this behavior, local fabrication of GaAs NW arrays with a diverse range of characteristics can be implemented on the same substrate. This approach opens a new way for self-catalytic growth of GaAs NWs.

Effect of Si(111) Surface Modification by Ga Focused Ion Beam at 30 kV on GaAs Nanowire Growth

This paper presents the results of experimental studies of the effect of Si(111) surface modification by Ga-focused ion beam (FIB) at 30 kV accelerating voltage on the features of the epitaxial GaAs nanowire (NW) growth processes. We experimentally established the regularities of the Ga ions' dose effect during surface modification on the structural characteristics of GaAs NW arrays. Depending on the Ga ion dose value, there is one of three modes on the surface for subsequent GaAs NW growth. At low doses, the NW growth is almost completely suppressed. The growth mode of high-density (up to 6.56 µm^-2) GaAs NW arrays with a maximum fraction (up to 70%) of nanowires normally oriented to the substrate is realized in the medium ion doses range. A continuous polycrystalline base with a dense array of misoriented short (up to 0.9 µm) and thin (up to 27 nm) GaAs NWs is formed at high doses. We assume that the key role is played by the interaction of the implanted Ga ions with the surface at various process stages and its influence on the surface structure in the modification region and on GaAs NW growth conditions.

Nucleation of Ga droplets on Si and SiOx surfaces

We report on gallium droplet nucleation on silicon (100) substrates with and without the presence of the native oxide. The gallium deposition is carried out under ultra-high vacuum conditions at temperatures between 580 and 630 °C. The total droplet volume, obtained from a fit to the diameter-density relation, is used for sample analysis on clean silicon surfaces. Through a variation of the 2D equivalent Ga thickness, the droplet diameter was found to be between 250-1000 nm. Longer annealing times resulted in a decrease of the total droplet volume. Substrate temperatures of 630 °C and above led to Ga etching into the Si substrates and caused Si precipitation around the droplets. In contrast, we obtained an almost constant diameter distribution around 75 nm over a density range of more than two orders of magnitude in the presence of a native oxide layer. Furthermore, the droplet nucleation was found to correlate with the density of surface features on the 'epi-ready' wafer.

Growth of low temperature silicon nano-structures for electronic and electrical energy generation applications

This paper represents the lowest growth temperature for silicon nano-wires (SiNWs) via a vapour-liquid-solid method, which has ever been reported in the literature. The nano-wires were grown using plasma-enhanced chemical vapour deposition technique at temperatures as low as 150°C using gallium as the catalyst. This study investigates the structure and the size of the grown silicon nano-structure as functions of growth temperature and catalyst layer thickness. Moreover, the choice of the growth temperature determines the thickness of the catalyst layer to be used.The electrical and optical characteristics of the nano-wires were tested by incorporating them in photovoltaic solar cells, two terminal bistable memory devices and Schottky diode. With further optimisation of the growth parameters, SiNWs, grown by our method, have promising future for incorporation into high performance electronic and optical devices.