Accounting for radioactivity before and after nebulization of tobramycin to insure accuracy of quantification of lung deposition

Inhaled granulocyte-macrophage colony stimulating factor for mild-to-moderate autoimmune pulmonary alveolar proteinosis - a six month phase II randomized study with 24 months of follow-up

Background

Treatment of autoimmune pulmonary alveolar proteinosis (aPAP) by inhaled granulocyte-macrophage colony stimulating factor (GM-CSF) is considered safe and effective. Evidence of benefit from GM-CSG inhalation for mild to moderate aPAP patients is limited.

Methods

In this multicenter, randomized, open-labeled clinical trial, 36 aPAP patients with mild to moderate disease severity were randomized into either the GM-CSF treatment group or control group. Inhaled GM-CSF was prescribed for 6 months, and patients received follow-up for another 18 months without treatment. Physiological features of the patients were analyzed.

Results

There were 36 patients (19 in the treatment group, 17 in the control group) included. There were no significant differences in the primary endpoints as measured by the change of alveolar arterial oxygen gradient (A-aDO₂) from the baseline values to the values obtained during treatment or during the following 18-month non-treatment observation period [control group vs. treatment group: 0.51 ± 12.09 mmHg vs. -0.35 ± 13.76 mmHg, p = 0.848 (3 month); 1.85 ± 11.21 mmHg vs. 7.31 ± 8.81 mmHg, p = 0.146 (6 months); 6.05 ± 11.14 mmHg vs. 6.61 ± 10.64 mmHg, p = 0.899 (24 months)]). Percentage of diffusion capacity predicted (DLCO%) and percentage of total lung capacity predicted (TLC%), however, were significantly improved in the treatment group by the end of the study (P = 0.010 and 0.027). St. George Respiratory questionnaire (SGRQ) scores were better after 6 months treatment with GM-CSF compared to the control group, and the benefits of treatment were maintained throughout the observation period. No severe side effects were observed during the study.

Conclusion

Six months of inhaled GM-CSF treatment had no effect on the alveolar–arterial oxygen gradient in patients with mild to moderate pulmonary alveolar proteinosis. There were changes in some clinical or laboratory measures, but no clinically important changes were noted at the end of study. (Clinical Trial Registry: NCT02243228, Registered on September 17, 2014, https://www.clinicaltrials.gov/ct2/show/NCT02243228?term=NCT02243228&draw=2&rank=1)

Comparison of Phospholipid-Based Particles for Sustained Release of Ciprofloxacin Following Pulmonary Administration to Bronchiectasis Patients

The rapid clearance of ciprofloxacin hydrochloride from the lungs following administration as an aerosol leads to poor efficacy in the treatment of pulmonary infections. The development of formulations capable of sustaining ciprofloxacin concentrations in the lungs has the potential to significantly improve antibacterial activity. The present review compares two approaches for sustaining levels of ciprofloxacin in the lungs, a liposomal formulation where ciprofloxacin is encapsulated in small unilamellar vesicles, and a dry powder formulation of the practically insoluble zwitterionic form of the drug. These two formulations recently completed large multicenter, phase 3 clinical studies in bronchiectasis patients. As such, they present a unique opportunity to examine the chemistry, manufacturing, and control of the dosage forms in addition to their tolerability and efficacy in more than 1000 bronchiectasis patients. Both formulations were generally well tolerated with most adverse events found to be mild to moderate in intensity. While the formulations were effective in reducing and/or eradicating infections, this did not lead to reductions in pulmonary exacerbations, the primary endpoint. The failures speak more to the heterogeneous nature of the disease and the difficulty in identifying bronchiectasis patients likely to exacerbate, rather than an inherent limitation of the formulations. While the formulations are similar in many respects, they also present some interesting differences. This review explores the implications of these differences on the treatment of respiratory infections.

Inhaled GM-CSF for Pulmonary Alveolar Proteinosis

BACKGROUND

Pulmonary alveolar proteinosis is a disease characterized by abnormal accumulation of surfactant in the alveoli. Most cases are autoimmune and are associated with an autoantibody against granulocyte-macrophage colony-stimulating factor (GM-CSF) that prevents clearing of pulmonary surfactant by alveolar macrophages. An open-label, phase 2 study showed some therapeutic efficacy of inhaled recombinant human GM-CSF in patients with severe pulmonary alveolar proteinosis; however, the efficacy in patients with mild-to-moderate disease remains unclear.

METHODS

We conducted a double-blind, placebo-controlled trial of daily inhaled recombinant human GM-CSF (sargramostim), at a dose of 125 μg twice daily for 7 days, every other week for 24 weeks, or placebo in 64 patients with autoimmune pulmonary alveolar proteinosis who had a partial pressure of arterial oxygen (Pao₂) while breathing ambient air of less than 70 mm Hg (or <75 mm Hg in symptomatic patients). Patients with severe pulmonary alveolar proteinosis (Pao₂ <50 mm Hg) were excluded to avoid possible exacerbation of the disease in patients who were assigned to receive placebo. The primary end point was the change in the alveolar-arterial oxygen gradient between baseline and week 25.

RESULTS

The change in the mean (±SD) alveolar-arterial oxygen gradient was significantly better in the GM-CSF group (33 patients) than in the placebo group (30 patients) (mean change from baseline, -4.50±9.03 mm Hg vs. 0.17±10.50 mm Hg; P = 0.02). The change between baseline and week 25 in the density of the lung field on computed tomography was also better in the GM-CSF group (between-group difference, -36.08 Hounsfield units; 95% confidence interval, -61.58 to -6.99, calculated with the use of the Mann-Whitney U test and the Hodges-Lehmann estimate of confidence intervals for pseudo-medians). Serious adverse events developed in 6 patients in the GM-CSF group and in 3 patients in the placebo group.

CONCLUSIONS

In this randomized, controlled trial, inhaled recombinant human GM-CSF was associated with a modest salutary effect on the laboratory outcome of arterial oxygen tension, and no clinical benefits were noted. (Funded by the Japan Agency for Medical Research and Development and the Ministry of Health, Labor, and Welfare of Japan; PAGE ClinicalTrials.gov number, NCT02835742; Japan Medical Association Center for Clinical Trials number, JMA-IIA00205.).

The Rationale and Evidence for Use of Inhaled Antibiotics to Control Pseudomonas aeruginosa Infection in Non-cystic Fibrosis Bronchiectasis

Non-cystic fibrosis bronchiectasis (NCFBE) is a chronic inflammatory lung disease characterized by irreversible dilation of the bronchi, symptoms of persistent cough and expectoration, and recurrent infective exacerbations. The prevalence of NCFBE is on the increase in the United States and Europe, but no licensed therapies are currently available for its treatment. Although there are many similarities between NCFBE and cystic fibrosis (CF) in terms of respiratory symptoms, airway microbiology, and disease progression, there are key differences, for example, in response to treatment, suggesting differences in pathogenesis. This review discusses possible reasons underlying differences in response to inhaled antibiotics in people with CF and NCFBE. Pseudomonas aeruginosa infections are associated with the most severe forms of bronchiectasis. Suboptimal levels of antibiotics in the lung increase the mutation frequency of P. aeruginosa and lead to the development of mucoid strains characterized by formation of a protective polysaccharide biofilm. Mucoid strains of P. aeruginosa are associated with a chronic infection stage, requiring long-term antibiotic therapy. Inhaled antibiotics provide targeted delivery to the lung with minimal systemic toxicity and adverse events compared with oral/intravenous routes of administration, and they could be alternative treatment options to help address some of the treatment challenges in the management of severe cases of NCFBE. This review provides an overview of completed and ongoing trials that evaluated inhaled antibiotic therapy for NCFBE. Recently, several investigators conducted phase 3 randomized controlled trials with inhaled aztreonam and ciprofloxacin in patients with NCFBE. While the aztreonam trial results were not associated with significant clinical benefit in NCFBE, initial results reported from the inhaled ciprofloxacin (dry powder for inhalation and liposome-encapsulated/dual-release formulations) trials hold promise. A more targeted approach could identify specific populations of NCFBE patients who benefit from inhaled antibiotics.

Inhalation of tobramycin using simulated cystic fibrosis patient profiles

INTRODUCTION

TOBI^® Podhaler™ is a capsule-based drug-device combination (tobramycin inhalation powder [TIP] 28 mg capsules via unit-dose dry powder T-326 Inhaler [Podhaler™]) developed for treatment of Pseudomonas aeruginosa infection in cystic fibrosis (CF). We explored how inspiratory flow profiles and mouth-throat geometries affect drug delivery with the T-326 Inhaler.

METHODS

Inspiratory flow profiles were recorded from 38 subjects aged 6-71 who had CF and varying degrees of lung function impairment. Ten of the inspiratory flow profiles were simulated in the laboratory using a custom breath simulator to determine delivered dose (DD) from the T-326 Inhaler. In vitro total lung dose (TLD_{in vitro} ) was measured using four anatomical throat models, ranging from a child to a large adult.

RESULTS

Aerosol performance was assessed across a range of inspiratory flow profiles. Mean DD ranged from 88.8% to 97.0% of declared capsule content. TLD_{in vitro} ranged from 54.8% to 72.4% of capsule content between the flow profile/throat options tested, and the mean TLD_{in vitro} across the range of flow profiles and anatomical throats tested was 63 ± 5%.

CONCLUSIONS

Our findings indicate that the T-326 Inhaler provides reliable drug delivery at flow rates likely to be achieved by a broad spectrum of patients with CF. Importantly, forceful inhalation was not required to achieve a robust TLD_{in vitro} . Pediatr Pulmonol. 2016;51:1159-1167. © 2016 Wiley Periodicals, Inc.

Modeling breath-enhanced jet nebulizers to estimate pulmonary drug deposition

BACKGROUND

Predictable delivery of aerosol medication for a given patient and drug-device combination is crucial, both for therapeutic effect and to avoid toxicity. The gold standard for measuring pulmonary drug deposition (PDD) is gamma scintigraphy. However, these techniques expose patients to radiation, are complicated, and are relevant for only one patient and drug-device combination, making them less available. Alternatively, in vitro experiments have been used as a surrogate to estimate in vivo performance, but this is time-consuming and has few "in vitro to in vivo" correlations for therapeutics delivered by inhalation. An alternative method for determining inhaled mass and PDD is proposed by deriving and validating a mathematical model, for the individual breathing patterns of normal subjects and drug-device operating parameters. This model was evaluated for patients with cystic fibrosis (CF).

METHODS

This study is comprised of three stages: mathematical model derivation, in vitro testing, and in vivo validation. The model was derived from an idealized patient's respiration cycle and the steady-state operating characteristics of a drug-device combination. The model was tested under in vitro dynamic conditions that varied tidal volume, inspiration-to-expiration time, and breaths per minute. This approach was then extended to incorporate additional physiological parameters (dead space, aerodynamic particle size distribution) and validated against in vivo nuclear medicine data in predicting PDD in both normal subjects and those with CF.

RESULTS

The model shows strong agreement with in vitro testing. In vivo testing with normal subjects yielded good agreement, but less agreement for patients with chronic obstructive lung disease and bronchiectasis from CF.

CONCLUSIONS

The mathematical model was successful in accommodating a wide range of breathing patterns and drug-device combinations. Furthermore, the model has demonstrated its effectiveness in predicting the amount of aerosol delivered to "normal" subjects. However, challenges remain in predicting deposition in obstructive lung disease.

Challenges in assessing regional distribution of inhaled drug in the human lungs

INTRODUCTION

Both the total amount of drug deposited in the lungs (whole lung deposition) and the amount deposited in different lung regions (regional lung deposition) are potentially important factors that determine the safety and efficacy of inhaled drugs. Radionuclide imaging is well established for quantifying the whole lung deposition of inhaled drugs, but the assessment of regional lung deposition is less straightforward, because of the complex nature of the lung anatomy.

AREAS COVERED

This review describes the challenges and problems associated with quantifying regional lung deposition by the two-dimensional (2D) radionuclide imaging method of gamma scintigraphy, and by the three-dimensional (3D) radionuclide imaging methods of single-photon-emission computed tomography (SPECT) and positron-emission tomography (PET). The advantages and disadvantages of each method for assessing regional lung deposition are discussed.

EXPERT OPINION

Owing to its 2D nature, gamma scintigraphy provides limited information about regional lung deposition. SPECT provides regional lung deposition data in three dimensions, but usually involves a (99m)Tc radiolabel. PET enables the regional lung deposition of radiolabeled drug molecules to be quantified in three dimensions, but poses the greatest logistical and technical difficulties. Despite their more challenging nature, 3D imaging methods should be considered as an alternative to gamma scintigraphy whenever the determination of regional lung deposition of pharmaceutical aerosols is a major study objective.

Higher tobramycin concentration and vibrating mesh technology can shorten antibiotic treatment time in cystic fibrosis

Poor adherence to recommended therapy in cystic fibrosis (CF) is often because of the time demands of therapy. Tobramycin (TOBI®, 300 mg at 60 mg/ml) inhaled from the PARI LC PLUS® nebulizer requires about 20 min. This study determined if equivalent levels of pulmonary deposition could be achieved in shorter time using 1.5 ml of 100 mg/ml tobramycin solution delivered by an investigational eFlow® nebulizer. Sixteen males with stable CF, 8 children and 8 adults, and an FEV(1)  > 45% predicted inhaled both preparations on two occasions with (99m) Tc-DTPA added to the tobramycin. Blood samples were taken for quantification of tobramycin in the serum. The PARI LC PLUS® delivered 45.4 (39.3-51.6), mean and 95% CI, mg to the lungs in 17.0 ± 2.5 min (mean ± SD) with serum levels of 1,089 ± 388 µg/L. The investigational eFlow® delivered 46.3(40.3-51.7) mg in 4.0 ± 1.0 min with blood levels of 909 ± 458 µg/L. Only the time of delivery was significantly different with P < 0.0001 (paired t-test). Tolerability of the treatment was comparable for both inhalation regimes, but the shorter treatment was preferred by all patients. These results demonstrate the possibility of delivering equivalent levels of tobramycin much faster into the lungs of CF patients when using eFlow®, a very efficient electronic nebulizer.

A comparison of amount and speed of deposition between the PARI LC STAR® jet nebulizer and an investigational eFlow® nebulizer

BACKGROUND

The potency and physical properties of many of the drugs used in the treatment of cystic fibrosis necessitates the use of nebulization, a relatively time-consuming pulmonary delivery method. Newer, faster, and more efficient delivery systems are being proposed. The purposes of this study was to compare the length of time it took to deliver the equivalent of normal saline nebulized for 10 min in a PARI LC STAR(®) nebulizer to that of an investigational PARI eFlow(®).

METHODS

Six normal adults inhaled a 4-mL (36-mg) charge volume of saline from the LC STAR(®) or a 2.5-mL (22.5-mg) charge volume from the investigational eFlow(®). The saline was mixed with (99m)Tc-DTPA to allow two-dimensional imaging. The inhalation was preceded by a xenon equilibration scan to allow more accurate separation of deposition into central and peripheral lung regions.

RESULTS

The investigational eFlow(®) delivered 8.6 ± 1.0 mg, approximately 90% of the lung dose compared to the LC STAR(®), 9.6 ± 1.0 mg, but did in less than half the time (p < 0.02 for both). There were no differences in central versus peripheral distribution for either device.

CONCLUSIONS

In conclusion the investigational eFlow(®) was both faster and more efficient than the LC STAR(®).

Successful respiratory immunization with dry powder live-attenuated measles virus vaccine in rhesus macaques

Measles remains an important cause of childhood mortality worldwide. Sustained high vaccination coverage is the key to preventing measles deaths. Because measles vaccine is delivered by injection, hurdles to high coverage include the need for trained medical personnel and a cold chain, waste of vaccine in multidose vials and risks associated with needle use and disposal. Respiratory vaccine delivery could lower these barriers and facilitate sustained high coverage. We developed a novel single unit dose, dry powder live-attenuated measles vaccine (MVDP) for respiratory delivery without reconstitution. We tested the immunogenicity and protective efficacy in rhesus macaques of one dose of MVDP delivered either with a mask or directly intranasal with two dry powder inhalers, PuffHaler and BD Solovent. MVDP induced robust measles virus (MeV)-specific humoral and T-cell responses, without adverse effects, which completely protected the macaques from infection with wild-type MeV more than one year later. Respiratory delivery of MVDP was safe and effective and could aid in measles control.

Inhaled granulocyte/macrophage-colony stimulating factor as therapy for pulmonary alveolar proteinosis

RATIONALE

Inhaled granulocyte/macrophage-colony stimulating factor (GM-CSF) is a promising therapy for pulmonary alveolar proteinosis (PAP) but has not been adequately studied.

OBJECTIVES

To evaluate safety and efficacy of inhaled GM-CSF in patients with unremitting or progressive PAP.

METHODS

We conducted a national, multicenter, self-controlled, phase II trial at nine pulmonary centers throughout Japan. Patients who had lung biopsy or cytology findings diagnostic of PAP, an elevated serum GM-CSF antibody level, and a Pa(O(2)) of less than 75 mm Hg entered a 12-week observation period. Those who improved (i.e., alveolar-arterial oxygen difference [A-aDO(2)] decreased by 10 mm Hg) during observation were excluded. The rest entered sequential periods of high-dose therapy (250 microg Days 1-8, none Days 9-14; x six cycles; 12 wk); low-dose therapy (125 microg Days 1-4, none Days 5-14; x six cycles; 12 wk), and follow-up (52 wk).

MEASUREMENTS AND MAIN RESULTS

Fifty patients with PAP were enrolled in the study. During observation, nine improved and two withdrew; all of these were excluded. Of 35 patients completing the high- and low-dose therapy, 24 improved, resulting in an overall response rate of 62% (24/39; intention-to-treat analysis) and reduction in A-aDO(2) of 12.3 mm Hg (95% confidence interval, 8.4-16.2; n = 35, P < 0.001). No serious adverse events occurred, and serum GM-CSF autoantibody levels were unchanged. A treatment-emergent correlation occurred between A-aDO(2) and diffusing capacity of the lung, and high-resolution CT revealed improvement of ground-glass opacity. Twenty-nine of 35 patients remained stable without further therapy for 1 year.

CONCLUSIONS

Inhaled GM-CSF therapy is safe, effective, and provides a sustained therapeutic effect in autoimmune PAP. Clinical trial registered with www.controlled-trials.com/isrctn (ISRCTN18931678), www.jmacct.med.or.jp/english (JMA-IIA00013).

Rapid pulmonary delivery of inhaled tobramycin for Pseudomonas infection in cystic fibrosis: a pilot project

BACKGROUND

Patients with cystic fibrosis spend as much 30 min a day inhaling tobramycin. Could a new rapid system deposit the equivalent amount of tobramycin faster?

METHODS

Six healthy adult males inhaled 5 ml (300 mg) of tobramycin from a breath enhanced nebulizer and either 125 mg (n = 3) or 150 mg (n = 3) from a vibrating membrane system with a large or small aerosol mixing chamber respectively. A radiolabel was added to the solution and shown to "track" with the tobramycin. Imaging was done with a dual headed gamma camera. Because the radiolabel will be cleared by mucociliary action during administration, algorithms were developed to allow the comparison of a slower system to a faster one.

RESULTS

Both formulations were well tolerated. The lung deposition was 16.6 +/- 3.2% (mean +/- SD) of the charge dose delivered in 10.9 +/- 1.0 min for the breath enhanced nebulizer versus 32.0 +/- 5.1% delivered in 2.5 +/- 0.4 min from the vibrating membrane system. The absolute pulmonary delivery of tobramycin was 49.9 +/- 9.6 versus 43.9 +/- 4.8 mg for the two systems respectively, differences that were statistically significant (pair t-test) but unlikely to be clinically significant. There was a similar deposition of tobramycin for the 125 and 150 mg dose.

CONCLUSIONS

It is possible to deliver an equivalent amount of tobramycin in a shorter period of time with the new vibrating membrane system and a more concentrated formulation. These data will allow the design of a comparison in patients with CF.

The Challenges of Quantitative Measurement of Lung Deposition Using 99mTc-DTPA from Delivery Systems with Very Different Delivery Times

In quantifying aerosol delivery, the drug is often mixed with a radiolabel such as (99m)Tc-DTPA whose deposition is used as a proxy for the drug. (99m)Tc-DTPA deposited in the lung is cleared by a combination of absorption into the pulmonary circulation and mucociliary clearance. If administration is not instantaneous, the image will not include that clearance during administration, a problem raised if comparing devices with different administration times. However, if rates of clearance are measured, it will be possible to "correct" the initial image for the clearance that occurred during administration and before counting. Five adult males inhaled a 5-mL solution containing (99m)Tc-DTPA from a breath enhanced jet nebulizer (LC Plus)over the course of 10 min and a 1.25-mL solution from a vibrating membrane device (eFlow), which was delivered in 2.5 min. Quality assurance was the radioactivity count balance (RCB) defined as the difference in the total radioactivity pre-nebulization less post, divided by pre, and expressed as a percentage. Attenuation calculations used a (57)Co flood source (Macey and Marshall). The "correction" for the clearance of (99m)Tc-DTPA was 0.91 +/- 0.04 (mean +/- SD) for the LC Plus) and 0.96 +/- 0.02 for the eFlow). RCB was -0.6 +/- 3.5% for the LC Plus and -4.7 +/- 6.4% for the eFlow, implying acceptable accuracy. For the LC Plus, lung deposition was 15.9(13.4, 18.4)% (mean and 95% CI) of the charge dose, and for the eFlow it was 32.0(29.0, 35.0)%. This technique gave an acceptable level of accuracy for quantitative planar imaging and allowed the comparison of delivery from devices with very different rates of delivery.

Optimizing aerosol gene delivery and expression in the ovine lung

We have developed the sheep as a large animal model for optimizing cystic fibrosis gene therapy protocols. We administered aerosolized gene transfer agents (GTAs) to the ovine lung in order to test the delivery, efficacy, and safety of GTAs using a clinically relevant nebulizer. A preliminary study demonstrated GTA distribution and reporter gene expression throughout the lung after aerosol administration of plasmid DNA (pDNA):GL67 and pDNA:PEI complexes. A more comprehensive study examined the dose-response relationship for pDNA:PEI and assessed the influence of adjunct therapeutic agents. We found that the sheep model can differentiate between doses of GTA and that the anticholinergic, glycopyrrolate, enhanced transgene expression. Dose-related toxicity of GTA was reduced by aerosol administration compared to direct instillation. This large animal model will allow us to move toward clinical studies with greater confidence.

Calculating expected lung deposition of aerosolized administration of AAV vector in human clinical studies

BACKGROUND

Cystic fibrosis is an autosomal recessive disease affecting approximately 1 in 2500 live births. Introducing the cDNA that codes for normal cystic fibrosis transmembrane conductance regulator (CFTR) to the small airways of the lung could result in restoring the CFTR function. A number of vectors for lung gene therapy have been tried and adeno-associated virus (AAV) vectors offer promise. The vector is delivered to the lung using a breath-actuated jet nebulizer. The purpose of this project was to determine the aerosolized AAV (tgAAVCF) particle size distribution (PSD) in order to calculate target doses for lung delivery.

METHODS

A tgAAVCF solution was nebulized using the Pari LC Plus (n = 3), and the PSD was determined by coupling laser diffraction and inertial impaction (NGI) techniques. The NGI allowed for quantification of the tgAAVCF at each stage of impaction, ensuring that rAAV-CFTR vector is present and not empty particles. Applying the results to mathematical algorithms allowed for the calculation of expected pulmonary deposition.

RESULTS

The mass median diameter (MMD) for the tgAAVCF was 2.78 +/- 0.43 microm. If the system works ideally and the patient only receives aerosol on inspiration, the patient would receive 47 +/- 0% of the initial dose placed in the nebulizer, with 72 +/- 0.73% of this being deposited beyond the vocal cords.

CONCLUSIONS

This technology for categorizing the pulmonary delivery system for lung gene therapy vectors can be adapted for advanced aerosol delivery systems or other vectors.

Towards zero prevalence of chronic Pseudomonas aeruginosa infection in children with cystic fibrosis

BACKGROUND

Data from the Belgian Cystic Fibrosis Registry consistently show that in one of the seven reference centres, the prevalence of Pseudomonas aeruginosa is half that observed at the national level.

OBJECTIVES

To report the characteristics of non-transplanted patients in this clinic at the end of 2003, with special focus on paediatric patients. To describe and discuss our policy of inhaled antibiotic therapy.

FINDINGS

The prevalence of P. aeruginosa among 116 patients is 20.7%. The chronic colonization rate is 19.8% but only 2.8% in patients aged under 18 (n=72). Serologic data strongly support these results. Most paediatric patients (95%) are prescribed inhaled antibiotics, at least on an intermittent basis but the mean number of days of intravenous antibiotic treatment is four times lower than in other CF children in Belgium. 70% of children have an FEV1> or =90% predicted.

DISCUSSION

We have reported a distinctly low rate of chronic colonization by P. aeruginosa in a cohort of CF children and suspect that a strategy of early, often <<prophylactic>> use of inhaled antibiotics, progressively implemented for over 15 years has substantially contributed to these results. Given the major impact of chronic P. aeruginosa colonization on prognosis in CF, it is suggested that a large prospective study of this approach is warranted.

Nebulized therapies for childhood pulmonary hypertension: an in vitro model

OBJECTIVES

Sildenafil, tezosentan, and prostacyclin reduce pulmonary vascular pressures in pulmonary hypertension, but have potential to vasodilate the systemic circulation. Nebulized vasodilators allow targeted drug delivery, high local drug concentrations, less systemic hypotension, and better matching of the lung's ventilation and perfusion. We aimed to estimate pulmonary deposition of these drugs from commonly employed nebulizers using in vitro techniques and to create a mathematical model to predict inspired mass of aerosol.

DESIGN

Lung deposition was estimated by characterization of drug output and particle size distribution (PSD) of nebulizers using helium-neon laser diffraction techniques. A mathematical model for each device was created to estimate pulmonary deposition using patients' breathing patterns and was verified with a mechanical-breathing model.

RESULTS

Total output and PSD were similar for the Hudson Updraft II and Whisperjet nebulizers, consisting of half the nebulizer's charge, with (1/4) of particles < or = 5 microm, in the respirable fraction (RF). Drug output increased with inspiratory flow for the Pari LC Star. Differences were noted in device performance, depending on the drug tested. Estimated pulmonary deposition (mean, 95% CI) was 8.1 (7.2, 9.0)% of the initial drug charge for the Hudson Updraft II, 6.4 (5.8, 7.0)% for the Whisperjet, and 33.0 (28.3, 37.9)% for the Pari LC Star. A mechanical model was consistent with our mathematical model.

CONCLUSIONS

All drugs could be nebulized, but expected pulmonary deposition varied depending on the nebulizer and drug.

Lung Deposition after Electronically Breath-Controlled Inhalation and Manually Triggered Conventional Inhalation in Cystic Fibrosis Patients

The present work aimed to investigate whether lung deposition can be improved by using a device that optimizes the breathing pattern through electronic control. The relative lung deposition was estimated by inhalation of the marker substance, sodium cromoglycate (SCG), and measurement of urinary excretion of SCG. Thirteen cystic fibrosis (CF) patients (aged 8-20 years) received 20 mg of SCG as nebulizer solution by means of (a) conventional inhalation (Parimaster + Pari LC Star nebulizer, manual interrupter) and (b) electronically breath-controlled inhalation (AKITA + Pari LC Star nebulizer). Inhalations were trained and supervised by a physiotherapist. Patients were asked to provide answers to a questionnaire about the convenience of electronically breath-controlled inhalation. Urine was collected in five fractions until 12 h p.a., and the excreted SCG was determined by means of high-performance liquid chromatography (HPLC). Following breath-controlled inhalation, the amount of SCG excreted in urine was significantly greater than after conventional inhalation (2.22 +/- 0.61 mg vs. 1.63 +/- 0.59 mg, p < 0.001). The absorption half-life for SCG following breath-controlled inhalation was significantly shorter when compared with conventional inhalation (78 +/- 23 min vs. 107 +/- 29 min; p < 0.01), suggestive of a more peripheral deposition for the former. Ninety-two percent of the patients judged that the electronically breath-controlled inhalation was good or very good. In conclusion, inhalation with an electronically optimized breathing pattern yields a greater and more peripheral lung deposition of SCG compared with the manually triggered conventional nebulizer technique in CF patients with several years of aerosol inhalation experience.

Comparison of Breath-Enhanced to Breath-Actuated Nebulizers for Rate, Consistency, and Efficiency

OBJECTIVES

To evaluate differences between three new-generation nebulizers-Pari LC Star (Pari Respiratory Equipment; Mississauga, ON, Canada), AeroEclipse (Trudell Medical International, London, ON, Canada), and Halolite (Medic-Aid Limited, West Sussex, UK)-in terms of rate and amount of expected deposition as well as the consistency of the doses delivered.

METHODS

The in vitro performance characteristics were determined and then coupled to the respiratory pattern of seven patients with cystic fibrosis (age range, 4 to 18 years) in order to calculate expected deposition. The Pari LC Star and AeroEclipse were characterized while being driven by the Pari ProNeb Ultra compressor (Pari Respiratory Equipment) for home use, and by a 50-psi medical air hospital source. The Halolite has its own self-contained compressor. Algorithms for the rate of output for the inspiratory flow were developed for each device. Patient flow patterns were divided into 5-ms epochs, and the expected deposition for each epoch was calculated from the algorithms. Summed over a breath, this allowed the calculation of the estimated deposition for each patient's particular pattern of breathing.

RESULTS

The rate of deposition was highest for the Pari LC Star and lowest for the Halolite. Rate of deposition was independent of respiratory pattern for the Pari LC Star and AeroEclipse, but proportional to respiratory rate for the Halolite. The differences between the Pari LC Star and AeroEclipse were less when driven by the 50-psi source. The AeroEclipse had the least amount of drug wastage. As designed, the Halolite delivered a predetermined amount of drug very accurately, whereas expected deposition when run to dryness of the other two devices had significant variations.

CONCLUSIONS

To minimize treatment time, the Pari LC Star would be best. To minimize drug wastage, the AeroEclipse would be best. To accurately deliver a specific drug dose, the Halolite would be best.

Does wearing a noseclip during inhalation improve lung deposition?

Using nebulization, only a small proportion of the dose reaches the lungs, while the remainder is swallowed, exhaled into the atmosphere, or remains in the nebulizer. It was the purpose of this study to investigate whether wearing a noseclip during inhalation can improve lung deposition. Relative lung deposition was compared by inhalation of the marker substance, sodium cromoglycate (SCG), and measurement of urinary excretion of SCG. The SCG absorption half-life allows one to differentiate indirectly between a more or less peripheral deposition. Ten CF patients (9-18 years old) inhaled, under routine conditions, a solution containing 20 mg of SCG in a randomized crossover design through a mouthpiece, without and with a noseclip being worn. Following inhalation without and with a noseclip, no statistically significant difference was seen in the amount of SCG excreted in urine (0.9 +/- 0.4 mg vs. 1.0 +/- 0.5 mg; p = 0.402) and absorption half-life (93 +/- 25 min vs. 113 +/- 36 min; p = 0.083). In conclusion, wearing a noseclip during inhalation under conditions relevant to practice does not increase the amount deposited into the lungs of CF patients and, also, there has been no indication of a more peripheral lung deposition.

Tear lipocalin: potential for selective delivery of rifampin

The potential of ligand binding proteins as drug carriers and delivery systems has recently sparked great interest. We investigated the potential of tear lipocalin (TL) to bind the antibiotic, rifampin, and the environmental conditions for controlled release. To determine if TL binds rifampin, gel filtration was used to isolate protein fractions of tears. Rifampin was detected by absorbance spectroscopy in the elution fractions containing TL. The bound complex of rifampin-TL generates optical activity at about 360 nm, indicating a unique conformation at the binding site. Rifampin has a higher affinity for TL (Kd=128 microM) than albumin. Rifampin is released from the TL calyx in acidic conditions and is displaced by palmitic acid. Autooxidation of free rifampin begins in minutes but is delayed by at least 3 h in the presence of TL. These properties are conducive to stabilization and delivery of rifampin to tubercles that are acidic and rich in fatty acids. These studies show the potential of TL as a carrier for rifampin with controlled release to a targeted environment.

Improvement of alveolar glutathione and lung function but not oxidative state in cystic fibrosis

Chronic neutrophilic inflammation leads to oxidative damage, which may play an important role in the pathogenesis of cystic fibrosis lung disease. Bronchoalveolar lavage levels of the antioxidant glutathione are diminished in patients with cystic fibrosis. Here we evaluated the effects of glutathione aerosol on lower airway glutathione levels, lung function, and oxidative status. Pulmonary deposition of a radiolabeled monodisperse aerosol generated with a Pari LC Star nebulizer (Allergy Asthma Technology, Morton Grove, IL) connected to an AKITA inhalation device (Inamed, Gauting, Germany) was determined in six patients. In 17 additional patients bronchoalveolar lavage fluid was assessed before and after 14 days of inhalation with thrice-daily doses of 300 or 450 mg of glutathione. Intrathoracic deposition was 86.3 +/- 1.4% of the emitted dose. Glutathione concentration in lavage 1 hour postinhalation was increased three- to fourfold and was still almost doubled 12 hours postinhalation. FEV(1) transiently dropped after inhalation but increased compared with pretreatment values after 14 days (p < 0.001). This improvement was not related to the lavage content of oxidized proteins and lipids, which did not change with treatment. These results show that, using a new inhalation device with high efficacy, glutathione treatment of the lower airways is feasible. Reversion of markers of oxidative injury may need longer treatment, higher doses, or different types of antioxidants.

Radionuclide imaging technologies and their use in evaluating asthma drug deposition in the lungs

Whole lung and regional lung deposition of inhaled asthma drugs in the lungs can be quantified using either two-dimensional or three-dimensional radionuclide imaging methods. The two-dimensional method of gamma scintigraphy has been the most widely used, and is currently considered the industry standard, but the three-dimensional methods (SPECT, single photon emission computed tomography; and PET, positron emission tomography) give superior regional lung deposition data and will undoubtedly be used more frequently in future. Recent developments in radionuclide imaging are described, including an improved algorithm for assessing regional lung deposition in gamma scintigraphy, and a patent-protected radiolabelling method (TechneCoat), applicable to both gamma scintigraphy and SPECT. Radionuclide imaging data on new inhaled asthma products provide a milestone assessment, and the data form a bridge between in vitro testing and a full clinical trials program, allowing the latter to be entered with increased confidence.

Evaluation of four breath-enhanced nebulizers for home use

The objective of this study was to evaluate relative efficiency in vitro of four reusable breath-enhanced nebulizers (Pari LC Star, Medic-Aid Ventstream, Devilbiss PermaNeb, Salter Ultramist), and to integrate the in vitro performance data of the nebulizers with the respiratory patterns of four cystic fibrosis (CF) patients to compare efficiency in vivo of each device for each individual patient. Six nebulizers of each type were used to nebulize a solution of 2.5 mg (0.5 mL) albuterol with 3.5 mL of 0.9% saline. Total albuterol output and the rate of albuterol output of each device were measured until end-nebulization and for 4 min, respectively, using entrained flows from 0 to 20 L/min through the inspiratory valve of the device. Particle size distributions and the respirable fraction (RF) were evaluated by laser diffraction technique. Regression analysis of the change in rate of output and change in RF values with inspiratory flows was done to characterize each nebulizer's performance over the complete range of interest. Actual breath tracings of four CF patients were integrated with the equations specific to the in vitro performance of each nebulizer and in vivo nebulizer efficiency was calculated. The change in efficiency in vitro from 0 to 20 L/min flow, respectively, was highest for the Star (44-57%) and lowest for the Ultramist (13-15%). The mean predicted efficiency in vivo for the Star was threefold that of the Ultramist. Although all four nebulizers are breath-enhanced in design, clearly there are measurable differences in the performance and efficiency of each type. The Pari LC Star nebulizer has proven to be the nebulizer of choice among the devices tested.

A brief history of gamma scintigraphy

Gamma scintigraphy involves the radiolabeling of inhaled drug formulations, followed by in vivo imaging of deposition in two dimensions. This permits whole lung deposition to be quantified as mass of drug or percentage of the dose, and regional deposition patterns to be assessed. Gamma scintigraphy is the method by which the majority of inhaled drug deposition data have been obtained, and scintigraphic studies have become viewed as milestone assessments in the development of new pulmonary drug products. Lung deposition data are used to show "proof of concept" in vivo for these products, and act as a bridge between in vitro laboratory testing and a clinical trials program. Gamma scintigraphy is likely to remain the method of choice for assessing inhaled drug deposition for some time to come.

Nebulizer choice for inhaled colistin treatment in cystic fibrosis

STUDY OBJECTIVES

To develop practical ways of nebulizing colistin by determining the rate of drug output, total drug output, and particle-size distribution of two commercially available jet nebulizers, the disposable Hudson 1730 Updraft II (Hudson Respiratory Care; Temecula, CA) and the reusable Pari LC Star breath-enhanced nebulizer (Pari Respiratory Equipment; Midlothian, VA).

METHODS

The nebulizers contained colistin, 75 mg, in 4 mL of isotonic solution. Particle-size distribution was measured by helium-neon laser diffraction, allowing calculation of the respirable fraction (RF), the mass of aerosol comprised of droplets < 5 microm.

RESULTS

The mean (95% confidence interval [CI]) total rate of output of the Updraft II was 2.6 mg/min (2.0, 3.1; n = 4) with 1.3 mg/min (1.0, 1.5) mg/min within the RF. The rate of output of the LC Star increased in a quadratic relationship to the inspiratory flow, delivering 1.8 mg/min (0.7, 2.0; n = 4) with 1.4 mg/min (1.3, 1.6) within the RF, and 6.2 mg/min (5.6, 6.8) with 5.3 mg/min (4.8, 5.7) within the RF, at 0 L/min and 20 L/min inspiratory flows, respectively. Efficiency, as the rate of expected pulmonary deposition divided by rate of total output, was then calculated. The LC Star estimated 56% (51, 61) efficiency, with pulmonary delivery of 29% (26, 32) of the charge of the nebulizer, compared to the Updraft II at 22% (22, 23) efficiency and expected pulmonary deposition of 10% (10, 10) of the dose.

CONCLUSIONS

Colistin can be successfully nebulized with both nebulizers tested. This study provides an estimate of in vivo efficiency and expected pulmonary deposition that may be used in future trials.