Transdermal Evaluation of Caffeine in Different Formulations and Excipients

Convective Solvent Transport Pathways for Absorption of Drugs from Topical Formulation

Physicochemical and formulation factors influencing penetration of drugs from topical products into the skin and mechanisms of drug permeation are well investigated and reported in the literature. However, mechanisms of drug absorption during short-term exposure have not been given sufficient importance. In this project, the extent of absorption of drug molecules into the skin from aqueous and ethanolic solutions following a 5-min application period was investigated. The experiments demonstrated measurable magnitude of absorption into the skin for all the molecules tested despite the duration of exposure being only few minutes. Among the two solvents used, absorption was greater from aqueous than ethanolic solution. The results suggest that an alternative penetration pathway, herein referred to as the convective transport pathway, is likely responsible for the rapid, significant uptake of drug molecules during initial few minutes of exposure. Additionally, absorption through the convective transport pathways is a function of the physicochemical nature of the formulation vehicle rather than the API.

Effect of Application Amounts on In Vitro Dermal Absorption Test Using Caffeine and Testosterone

Dermal absorption of chemicals is a key factor in risk assessment. This study investigated the effects of different amounts of application on dermal absorption and suggested an appropriate application dose for proper dermal absorption. Caffeine and testosterone were chosen as test compounds. An in vitro dermal absorption test was performed using a Franz diffusion cell. Different amounts (5, 10, 25, and 50 mg (or µL)/cm²) of semisolid (cream) and liquid (solution) formulations containing 1% caffeine and 0.1% testosterone were applied to rat and minipig (Micropig^®) skins. After 24 h, the concentrations of both compounds remaining on the skin surface and in the stratum corneum, dermis and epidermis, and receptor fluid were determined using LC-MS / MS or HPLC. Dermal absorption of both compounds decreased with increasing amounts of application in both skin types (rat and minipig) and formulations (cream and solution). Especially, dermal absorptions (%) of both compounds at 50 mg (or µL)/cm² was significantly lower compared to 5 or 10 mg (or µL)/cm² in both rat and minipig skins. Therefore, a low dose (5 or 10 mg (or µL)/cm²) of the formulation should be applied to obtain conservative dermal absorption.

Transdermal Permeation of Caffeine Aided by Ionic Liquids: Potential for Enhanced Treatment of Cellulitis

Ginoid hydrolipodystrophy (HDLG) or "cellulite" involves alteration of the cutaneous relief and occurs in 80-90% of the female population. Several topical treatments are available with the use of substances capable of stimulating lipolysis, such as caffeine. However, the effectiveness of topical therapy is related to the processes of release and permeation of the active in skin cells. In this sense, ionic liquids, such as choline geranate, are considered to facilitate topical permeation agents. In this way, the aim of this research was to develop and evaluation of the effectiveness of a cosmetic product for topical treatment of cellulite with caffeine in association with choline geranate. The choline geranate was synthesized by the reaction between geranic acid and choline hydroxide [1: 2]. The gel was prepared using 2% Carpobol 940®, 5% caffeine, and 1% choline geranate. Preliminary and accelerated stability tests were performed by checking pH, spreadability, and organoleptic characteristics. The transdermal permeation capacity of caffeine in vitro was evaluated by the Franz cell permeation assay, and the gel cytotoxicity by the MTS method. To prove the efficacy in the treatment of cellulite, a pilot type 1 clinical trial was carried out. The formulation was considered stable and the product maintained your characteristics during 180 days of storage. The product showed moderate cytotoxicity and high skin permeation capacity. In the clinical trial, it showed results superior to the caffeine gel without ionic liquid. The developed gel favored the cutaneous permeation of caffeine, showing a promising product in the treatment of cellulite.