Expression of monovalent and bivalent antibody fragments in Escherichia coli

Selection of gonadotrophin surge attenuating factor phage antibodies by bioassay

BACKGROUND

We aimed to combine the generation of "artificial" antibodies with a rat pituitary bioassay as a new strategy to overcome 20 years of difficulties in the purification of gonadotrophin surge-attenuating factor (GnSAF).

METHODS

A synthetic single-chain antibody (Tomlinson J) phage display library was bio-panned with partially purified GnSAF produced by cultured human granulosa/luteal cells. The initial screening with a simple binding immunoassay resulted in 8 clones that were further screened using our in-vitro rat monolayer bioassay for GnSAF. Initially the antibodies were screened as pooled phage forms and subsequently as individual, soluble, single-chain antibody (scAbs) forms. Then, in order to improve the stability of the scAbs for immunopurification purposes, and to widen the range of labelled secondary antibodies available, these were engineered into full-length human immunoglobulins. The immunoglobulin with the highest affinity for GnSAF and a previously described rat anti-GnSAF polyclonal antiserum was then used to immunopurify bioactive GnSAF protein. The two purified preparations were electrophoresed on 1-D gels and on 7 cm 2-D gels (pH 4-7). The candidate GnSAF protein bands and spots were then excised for peptide mass mapping.

RESULTS

Three of the scAbs recognised GnSAF bioactivity and subsequently one clone of the purified scAb-derived immunoglobulin demonstrated high affinity for GnSAF bioactivity, also binding the molecule in such as way as to block its bioactivity. When used for repeated immunopurification cycles and then Western blot, this antibody enabled the isolation of a GnSAF-bioactive protein band at around 66 kDa. Similar results were achieved using the rat anti-GnSAF polyclonal antiserum. The main candidate molecules identified from the immunopurified material by excision of 2-D gel protein spots was human serum albumin precursor and variants.

CONCLUSION

This study demonstrates that the combination of bioassay and phage display technologies is a powerful tool in the study of uncharacterised proteins that defy conventional approaches. In addition, we conclude that these data support suggestions that GnSAF may be structurally related to serum albumin or very tightly bound to serum albumin.

Neutralisation and binding of VHS virus by monovalent antibody fragments

We have previously reported the cloning and characterisation of the heavy and light chain variable domain genes encoding three monoclonal antibodies (Mabs) that bind viral haemorrhagic septicaemia virus (VHSV). Two of these antibodies, 3F1H10 and 3F1A2 both neutralised the virus though 3F1A2 appeared to recognise a broader range of virus isolates. The variable domains of these two antibodies differ by only four residues (Lorenzen et al., 2000a. Fish Shellfish Immunol. 10, 129-142). To further study the mechanism of neutralisation, Fab fragments as well as a series of recombinant bacterial single chain antibody (scAb) fragments were generated from the three anti-VHSV Mabs and their variable domain genes, respectively. Fabs and scAbs derived from the neutralising Mabs were both able to neutralise the VHSV type 1 isolate DK-F1. In addition, a series of scAb fragments were produced using the 3F1H10 variable heavy (VH) chain and variable light (Vkappa) chain domains but containing, either alone or in dual combination, each of the four different residues present in 3F1A2. The dissociation constants of Mabs 3F1H10 and 3F1A2 and their respective Fab and scAb fragments were measured by BIAcore analysis and found to correlate with the capacity of each molecule to neutralise DK-F1. These investigations, together with computer assisted molecular analysis of the theoretical influence of each mutation on antigen binding, led to the identification of a single mutation at position 35a in the VH domain as having the most marked impact on viral neutralisation.

Improved expression characteristics of single-chain Fv fragments when fused downstream of the Escherichia coli maltose-binding protein or upstream of a single immunoglobulin-constant domain

The expression of single-chain Fv fragments (scFv) targeted to the periplasm of Escherichia coli often results in very low yields of soluble protein frequently accompanied by host cell growth arrest and sometimes lysis. Single-chain antibody fragments (scAb) are scFv with a human kappa light chain constant (HuCkappa) domain attached C-terminally and share similar problems of expression. By fusing the E. coli maltose-binding protein (mbp) gene either 3' or 5' to a scAb specific for the herbicide atrazine, a reduction in growth arrest was observed that was dependent on the order of gene fusion. The scAb-mbp fusion delayed the onset of growth arrest following induction while the mbp-scAb fusion appeared to ablate growth arrest completely. Cell fractionation revealed barely detectable levels of scAb-mbp in the periplasm while mbp-scAb was detected at equivalent levels as scAb in the periplasmic compartment, indicating that periplasmic scAb solubility is unrelated to propensity to cause growth arrest. IMAC purification of scAb and mbp-scAb proteins followed by liquid competition ELISA revealed the IC(50) for atrazine to be approximately 1 nM for both proteins demonstrating that 5'-mbp fusion does not alter antigen binding. The equivalent scFv and mbp-scFv vectors expressed far less material in both periplasmic and insoluble fractions indicating that the HuCkappa domain can have a positive effect on scFv expression when expressed either alone or as a mbp fusion. The ablation of growth arrest by a 5'-mbp fusion and enhancement of expression by a 3'-HuCkappa domain fusion were extended to a second scFv specific for the herbicide diuron. Therefore, by expressing scFv as tripartite fusions (mbp-scFv-HuCkappa) enhanced levels of soluble periplasmic expression can be achieved without causing growth arrest of the host cell, realizing the potential for constitutive expression of hapten-binding scFv in the E. coli periplasm.

Comparative sensitivity of immunoassays for haptens using monomeric and dimeric antibody fragments

A single-chain anti-atrazine antibody fragment, scAb (single-chain Fv with a CK domain), was expressed in Escherichia coli, and monomeric and dimeric species were preferentially purified from periplasmic extracts by chromatography upon nickel chelate immunosorbent columns or by immunoaffinity purification using a constant domain (CK) tag. Recombinant monomeric and dimeric antibody fragments, Fab, and intact monoclonal antibodies were compared in assays by competition between free atrazine in solution and (a) immobilized atrazine-bovine serum albumin conjugate (indirect assay) or (b) atrazine-alkaline phosphatase (direct assay). Recombinant antibody fragments provided a lower detection limit than either Fab or intact monoclonal antibody in both assay formats. Monomeric fragments displayed a sensitivity of detection down to 0.1 ppb, compared to 1.0 ppb for dimeric fragments and the parental monoclonal.

Binding characteristics of anti-atrazine monoclonal antibodies and their fragments synthesised in bacteria and plants

Single-chain antibody fragments (scAb), specific for the herbicide atrazine, have been expressed in the bacterium Escherichia coli and in transgenic tobacco plants. The scAb could be purified as a monomer (monovalent) via a hexa-histidine tail or as a dimer (divalent) by antibody affinity chromatography. In competition ELISA, the bacterial scAb showed the same specificity for atrazine and related triazine herbicides as the parental mAb cell line, but both plant and bacterial monomeric scAbs showed increased sensitivity to free atrazine. Surface plasmon resonance (BIAcore 2000) analysis confirmed that purified scAb, derived from plant or bacteria, retained similar association rates as the mAb. However, the monomeric plant and bacterial scAbs showed a lower affinity for immobilised antigen, than the equivalent dimeric scAbs or mAb. This decrease in affinity was due to a 10 fold slower dissociation rate and is likely due to loss of the avidity contribution of dimeric molecules.