Efficacy of three heat-stable microbial phytases on growth performance and bone development and strength of broilers fed diets deficient in available phosphorus

This study evaluated the response of broilers to either of three phytase enzymes in a P-deficient diet. A total of 2340 as-hatched Cobb500 chicks were allocated to nine treatments, each with 13 replicate pens. Starter and finisher diets consisted of a positive control (PC), negative control 1 and 2 (NC1, NC2). The PC, NC1 and NC2 diets had Ca:avP ratios of 0.50, 0.33 and 0.43 in the starter feed; and 0.46, 0.22 and 0.35 in the finisher feed; NC1 diets were then supplemented with Phytaverse, Quantum Blue and Axtra-PHY at 500 and 1000 FTU/kg. Enzyme type had a significant effect on body weight gain, feed conversion ratio (FCR) and production efficiency factor (PEF) during the 0-7 d period. Interactions between enzyme type and inclusion levels had a significant effect on feed intake (FI) at 1-21 d (P =0.02) and 1-35 d (P =0.031) age. While FI decreased as Axtra-PHY inclusion levels increased from 500 to 1000 FTU/kg feed, FI increased in birds supplemented with Quantum Blue, but with no effects on Phytaverse supplemented birds. Increasing enzyme dose to 1000 FTU/kg feed improved bone breaking strength but did not affect growth performance, tibia ash, Ca or P concentration of the birds.

Effects of high non-phytate phosphorus starter diet on subsequent growth performance and carcass characteristics of broiler chickens

The trial was performed to investigate the effects of different concentrations of non-phytate phosphorus (nPP) in the starter and grower (with phytase inclusion) periods on carcass characteristics, organ weight and weekly variations of growth performance in the grower period. Seven hundred and twenty-day-old male broiler chickens were randomly assigned to 12 treatments in a completely randomized design. Chickens received two dietary treatments (4.5 g/kg and 6 g/kg nPP) in the starter (0-21 days) and six experimental diets (4 g/kg, 3.1 g/kg, 2.3 g/kg and 2.3 g/kg + 1000 FTU/Kg of feed phytase, 1.5 g/kg, 1.5 g/kg nPP + 1000 FTU/Kg of feed phytase) in the grower period (22-42 days). Results showed that phytase inclusion in the second and third weeks of grower period could increase feed intake significantly. Also, decrease in the concentrations of nPP to 1.5 g/kg caused to decline body weight gain markedly. Moreover, there is a significant difference between 4.5 g/kg and 6 + 4 g/kg nPP (starter+grower) and 1.5 g/kg nPP. Phytase inclusion increased carcass yield and declined liver weight significantly. Dietary treatment of 4.5 + 1.5 g/kg nPP enhanced heart and liver weight markedly. It is concluded that starter diets with increased concentration of nPP (6 g/kg nPP) had no beneficial effects on growth performance in the starter and grower period in the total (0-42 days). Also, it is possible to decrease nPP concentration of grower diets to 1.5 and 2.3 g/kg with and without phytase inclusion respectively.

Phosphorus utilization in finishing broiler chickens: effects of dietary calcium and microbial phytase

A decrease in dietary P, especially in finishing broilers (21 to 38 d old), is a crucial issue in poultry production from an environmental and economic point of view. Nevertheless, P must be considered together with other dietary components such as Ca and microbial phytase. Different corn and soybean meal-based diets varying in Ca [low (LCa) 0.37, medium (MCa) 0.57, and high (HCa) 0.77%], and nonphytate P [nPP; low (LnPP) 0.18 and high (HnPP) 0.32%] content were tested with and without microbial phytase [0 or 500 phytase units (FTU)/kg]. Feed intake, BW gain, bone mineralization, and mineral retention were examined in 144 Ross PM3 broilers (22 to 38 d old) reared in individual cages. Growth performance was not significantly affected by the treatments. Nevertheless, a numerical decrease of ADG and ADFI was observed in HCa-LnPP and LCa-HnPP associated with an increase of feed conversion ratio. Decreased dietary Ca reduced tibia ash content (Ca, linear: P < 0.001; quadratic: P = 0.034) and tibia ash weight for the highest level of nPP (Ca × nPP; P = 0.035). In parallel, increasing dietary Ca reduced the flow of retained P (P = 0.022) but also tibia ash weight in LnPP diets (Ca × nPP; P = 0.035). The responses of the animals in terms of tibia ash content and P retention were improved by the addition of microbial phytase especially for the lowest P diets (nPP × phytase, P = 0.021 and P = 0.009; respectively). Phytase increased dry tibia weight, bone breaking strength, and tibia diameter in broilers fed the highest Ca diets (Ca × phytase; P < 0.05). We conclude that is possible to decrease P levels in finishing broilers, if the Ca content is appropriate. Nevertheless, decreasing the dietary P and Ca cannot allow a maximization of bone mineralization, but the optimal threshold remains to be determined.

Response of Broilers to Feeding Low-Calcium and Phosphorus Diets Plus Phytase Under Different Environmental Conditions: Body Weight and Tibiotarsus Mineralization

Three experiments on Ross broiler chickens were conducted in 3 locations: cages (Experiment 1), floor pens (Experiment 2), and commercial farms (Experiment 3). The effect of low-total P (TP) wheat-soybean based diets plus microbial phytase (Natuphos) was evaluated. Four experimental starter and finisher diets were used in a 2-phase feeding program, as follows: control diet (SC until 21 d, FC from 22 to 42 d); 2 diets (SL400 and SL600 until 21 d, FL400 and FL600 from 22 to 42 d) with low TP (0.61% for starter and 0.54% for finisher), including 400 and 600 U/kg of phytase, respectively; and a very low-TP (0.52% for starter and 0.44% for finisher) diet (SVL600 until 21 d, FVL600 from 22 to 42 d) with 600 U/kg of phytase. In Experiment 1 (broilers in cages had movement limitation and no access to litter), no differences in BW, tibiotarsus mineralization, or mineral metabolism were observed among diets. In Experiment 2 (broilers in floor pens had movement limitation and access to litter), at 21 d of age, the lowest tibiotarsus ash percentage and BW were shown by birds fed the SVL600 diet. At 42 d of age, broilers fed the FC diet were the lightest. For the rest of the parameters of tibiotarsus mineralization and mineral metabolism measured in Experiment 2, no differences were shown. In Experiment 3 (broilers in commercial farms had access to litter without movement limitation), the BW of broilers fed the SC diet was the highest at 21 d of age. At 42 d of age, the broilers fed FL400 and FL600 diets were the heaviest. At the end of Experiment 3, broilers fed the FC diet had the highest dry litter Ca and P, whereas broilers fed the FVL600 diet had the lowest values. In conclusion, the very low-TP wheat-soybean based diet supplemented with 600 U/kg of phytase was sufficient to optimize all the parameters measured in Experiment 1 but not in Experiments 2 and 3. Therefore, when evaluating Ca and P in phytase-supplemented diets for broilers, it is necessary to bear in mind the environmental conditions of experimentation.