Flammability of Common Ocular Lubricants in an Oxygen-Rich Environment

Flammability of Ocular Surface Lubricants

PURPOSE

Surgical fires pose a substantial risk to patients and can cause significant injury, especially in oculofacial surgery. Ocular surface lubricants can potentially act as fuel for an operating room fire. We present an experimental analysis of the flammability of 9 commonly used ophthalmic lubricants under 4 ignition sources used in oculofacial surgery with and without supplemental oxygen.

METHODS

The flammability of 9 ophthalmic lubricants were tested under various operating room conditions. Each lubricant was exposed to 4 different ignition sources: an open flame lighter, monopolar cautery, bipolar cautery, and hand-held high temperature cautery, and the response of the lubricant was recorded. The testing was conducted both in room air and with 6 L/minute of 100% oxygen directed at the lubricant through a nasal cannula. Any reaction in which there was ignition, sparking, smoking, or a transient or permanent change in appearance of the lubricant was deemed notable.

RESULTS

Of the 9 lubricants tested, 4 displayed a reaction to the ignition source. Without supplemental oxygen, 100% petrolatum and neomycin-polysporin-bacitracin-hydrocortisone ointment produced some smoke when applied with the high temperature cautery. Notably, under both the conditions of no supplemental oxygen and with the addition of 6 L/minute of 100% oxygen, the carboxymethylcellulose drops and lidocaine jelly both conducted and sparked with the monopolar cautery leaving visible burn marks on the paper.

CONCLUSIONS

The overall fire hazard posed by ocular surface lubricants is low. Some topical lubricants can conduct electricity from monopolar cautery, which could increase the risk of inadvertent electrical burns. Certain lubricants could potentially become a fuel source when used in combination with hand-held high temperature battery cautery. Bipolar cautery was not associated with either increased conductivity or flammability with any of the lubricants tested.

Patient fire during dental care: A case report and call for safety

BACKGROUND AND OVERVIEW

Fire risk is present whenever there is a convergence of fuel, oxidizer, and an ignition source, which is called the fire triangle. A heightened awareness of fire risk is necessary whenever a fire triangle is present. The authors provide a sentinel event case report of fire in a dental office.

CASE DESCRIPTION

A 72-year-old woman received second-degree facial burns from a fire that ignited near the nasal hood supplying a nitrous oxide-oxygen mixture. The presumed ignition source was heat generated during the preparation of a titanium post with a high-speed, irrigated carbide bur. The patient was transferred to the local emergency department and subsequently discharged after possible pulmonary complications were ruled out. The patient was then transferred to a regional burn unit and was discharged home with second-degree burns.

CONCLUSIONS AND PRACTICAL IMPLICATIONS

When the source of a fuel cannot be removed from the immediate area, soaked with water, or covered with a water-soluble jelly, the dentist should stop the open flow of oxygen or nitrous oxide-oxygen mixtures to the patient for 1 minute before the use of a potential ignition source, and intraoral suction should be used to clear the ambient atmosphere of oxidizer-enriched exhaled gas.

Effect of nasal cannula oxygen administration on oxygen concentration at facial and adjacent landmarks

An oxygen-enriched atmosphere enhances the potential for operating-room fires. We thus determined oxygen concentrations at various facial landmarks during oxygen administration via nasal cannulae. Thirteen supine volunteers were draped similarly to patients undergoing a cervical-node biopsy. Oxygen was delivered in random order through nasal cannulae at rates of 2, 4, and 6 l x min(-1). Oxygen concentration was measured at pre-determined facial landmarks and also distal to the drape at non-facial sites. At a flow of 2 l x min(-1), oxygen concentrations exceeded 23% only within a few centimetres of the nasal cannula. Concentration increased as a function of flow, but rarely exceeded 26%. At all flow rates, concentrations distal to the drape were < 24%. To reduce combustion risk, ignition sources should be kept at least 10 cm from the oxygen outlet when using nasal cannula at a flow rate > or = 4 l x min(-1).

Anesthesia machine as a cause of intraoperative "code red" in the labor and delivery suite

Fire is a rare but potentially disastrous operating room misadventure. I herein describe the first reported case of a fire in the labor and delivery suite, which also happens to be the first case of a fire caused by malfunctioning anesthesia machine.