Laboratory studies on salmonella-contaminated cheese involved in a major outbreak of gastroenteritis

Enumeration of Escherichia coli O157 in Outbreak-Associated Gouda Cheese Made with Raw Milk

In this article, we discuss the enumerative analysis for Escherichia coli O157 in two raw milk Gouda cheese products (A and B), implicated in an outbreak of 29 cases of E. coli O157:H7 illness that occurred across Canada in 2013. Samples were enumerated for E. coli O157 by most probable number (MPN) over a period of 30 to 60 days after the end of the outbreak. Samples (55.55 g) of product A (n = 14) were analyzed at 146 to 180 days postproduction. E. coli O157 was isolated from six samples at 19.9 to 44.6 MPN/kg. The E. coli O157 concentration of product A estimated from the results of all 14 samples was 9.5 MPN/kg. Samples (55.55 g) of product B (n = 20) were analyzed at 133 to 149 days postproduction. E. coli O157 was isolated from four samples at 19.9 MPN/kg. The E. coli O157 concentration of product B estimated from the results of all 20 samples was 3.7 MPN/kg. Analysis of a 305-g sample of product A (n = 1) stored at 4°C until 306 days postproduction revealed that the E. coli O157 concentration had declined to 3.6 MPN/kg. E. coli O157 could not be isolated from 555-g samples of product B (n = 5) after 280 days postproduction. The physicochemical parameters (pH, water activity, percent moisture, and percent salt) of both cheese products were found to be in the normal range for this type of product. The results of this study demonstrate that E. coli O157 could not replicate during storage at 4°C in the products tested but was capable of survival following aging and prolonged storage. This indicates that, if contaminated, the minimum 60-day aging period, which is required for raw milk Gouda cheeses, is not sufficient in all cases to ensure that the product does not contain viable cells of E. coli O157. The results also indicate that samples sizes greater than 100 g may be required to reliably detect E. coli O157 in cheese products associated with outbreaks.

Potential application of spice and herb extracts as natural preservatives in cheese

This study investigated the antibacterial efficiency of five spice and herb extracts (cinnamon stick, oregano, clove, pomegranate peel, and grape seed) against Listeria monocytogenes, Staphylococcus aureus, and Salmonella enterica in cheese at room temperature (~ 23°C). The lipid oxidation (thiobarbituric acid-reactive substances) of cheese was periodically tested by oxidative analyses. The results showed that all five plant extracts were effective against three foodborne pathogens in cheese. Treatments with these extracts increased the stability of cheese against lipid oxidation. Clove showed the highest antibacterial and antioxidant activity. The reduction of foodborne pathogen numbers and the inhibition of lipid oxidation in cheese indicated that the extracts of these plants (especially clove) have potential as natural food preservatives.

A prolonged outbreak of Salmonella Typhimurium infection related to an uncommon vehicle: hard cheese made from raw milk

In 2006, in The Netherlands, an outbreak of Salmonella Typhimurium phage type 561 (STM DT7, corresponding to the rare DT7 in the international typing scheme) was detected, accumulating to over 200 cases. By telephone interviews, data were collected from all laboratory-confirmed cases. In addition, in August 2006, a case-control study was performed in a subset of cases. Environmental and microbiological investigation was performed on a suspected dairy farm. In the case-control study (51 cases, 105 matched controls), hard cheese purchased from a farm, specifically farm X, and from a market stall were found to be associated with infection. The dairy production room of farm X tested STM DT7-positive in August. However, it was only in November, after earlier unsuccessful attempts, that a low-level contamination was confirmed in the hard farmhouse cheese, triggering control measures. A timely and adequate response was hampered during this outbreak for several reasons. Measures for improvement in handling future similar incidents are discussed.

Effect of phage on survival of Salmonella enteritidis during manufacture and storage of cheddar cheese made from raw and pasteurized milk

The ability of Salmonella Enteritidis to survive in the presence of phage, SJ2, during manufacture, ripening, and storage of Cheddar cheese produced from raw and pasteurized milk was investigated. Raw milk and pasteurized milk were inoculated to contain 10(4) CFU/ml of a luminescent strain of Salmonella Enteritidis (lux) and 10(8) PFU/ml SJ2 phage. The milks were processed into Cheddar cheese following standard procedures. Cheese samples were examined for Salmonella Enteritidis (lux), lactic acid bacteria, molds and yeasts, coliforms, and total counts, while moisture, fat, salt, and pH values were also measured. Salmonella Enteritidis (lux) was enumerated in duplicate samples by surface plating on MacConkey novobiocin agar. Bioluminescent colonies of Salmonella Enteritidis were identified in the NightOwl molecular imager. Samples were taken over a period of 99 days. Counts of Salmonella Enteritidis (lux) decreased by 1 to 2 log cycles in raw and pasteurized milk cheeses made from milk containing phage. In cheeses made from milks to which phage was not added, there was an increase in Salmonella counts of about 1 log cycle. Lower counts of Salmonella Enteritidis (lux) were observed after 24 h in pasteurized milk cheese containing phage compared to Salmonella counts in raw milk cheese with phage. Salmonella Enteritidis (lux) survived in raw milk and pasteurized milk cheese without phage, reaching a final concentration of 10(3) CFU/g after 99 days of storage at 8 degrees C. Salmonella did not survive in pasteurized milk cheese after 89 days in the presence of phage. However, Salmonella counts of approximately 50 CFU/g were observed in raw milk cheese containing phage even after 99 days of storage. In conclusion, this study demonstrates that the addition of phage may be a useful adjunct to reduce the ability of Salmonella to survive in Cheddar cheese made from both raw and pasteurized milk.

Relation between resistance to beta-lactam antibiotics and cadmium in salmonellae isolated from pigs

Of 50 Salmonella species isolated from pigs, 30 were resistant to cadmium and 18 of these also to azlocillin. The azlocillin-resistant isolates were resistant to cadmium at 80-500 mg/L CdSO4. A broader spectrum of resistance to azlocillin, ampicillin and cephazolin was found in strains resistant to < 200 mg/L CdSO4. Resistance to silver, mercury, chloramphenicol and streptomycin was independent of the resistance to beta-lactam antibiotics and Cd2+. Production and levels of beta-lactamase do not correlate with the spectrum of resistance.

The influence of Lactobacillus plantarum culture inoculation on the fate of Staphylococcus aureus and Salmonella typhimurium in Montasio cheese

The growth and survival of Staphylococcus aureus and Salmonella typhimurium were investigated during the manufacturing and ripening of raw milk Montasio cheese. Initial inoculated populations in the cheese milk were about 10(5) cfu/ml for S. aureus and 10(6) cfu/ml for S. typhimurium. Samples of curds and cheeses were taken during manufacturing and storage and analysed for pH and microbial populations. S. aureus increased slightly in number during the early period of ripening and attained a population of about 10(6) cfu/ml during the remaining period of storage. S. typhimurium decreased during cheesemaking and storage but persisted through 90 days. The addition of Lactobacillus plantarum culture (0.2% v/v) produced a marked reduction in populations of the test strains in 10 days of storage. Enterotoxin A was not detected in Montasio cheese even with a S. aureus population of 1.1 X 10(7) cfu/ml. L. plantarum strains were also tested by the spot method and the associative growth approach for their antagonistic activity against S. aureus and S. typhimurium. The compound excreted by L. plantarum was active only toward S. aureus. Furthermore, its activity was destroyed by protease treatment. These results indicated that while the growth of S. typhimurium is reduced by the acid production, S. aureus inhibition can be ascribed to bacteriocin production.