Safety aspects of delivery and monitoring of nitric oxide during mechanical ventilation

Maintenance of nitric oxide inhalation to a patient with hemoperitonium and acute respiratory distress syndrome during anesthesia -A case report-

Inhaled nitric oxide (NO) is occasionally used to treat hypoxemia for patients with acute respiratory distress syndrome (ARDS) in the intensive care unit (ICU). However, it is controversial whether or not to maintain inhalation of NO during general anesthesia because of complications, such as nitrogen dioxide (NO(2)) production, methemoglobinemia, and inhibition of platelet aggregation. In this case, a 67-year-old male fell from a roof and was brought to an emergency care center. During management, he vomited gastric contents and aspirated. In spite of tracheal intubation and mechanical ventilation with high oxygen therapy, the hypoxia did not improve. NO inhalation with mechanical ventilation was performed to treat hypoxemia due to ARDS in the ICU. We maintained the NO inhalation during the surgery for a hemoperitonium. The surgery was completed without intra-operative hemodynamic instability or any complications.

An evaluation of nitric oxide and nitrogen dioxide absorbers and filters

The absorbance of NO (5-90 ppm) and NO2 (0.5-4 ppm) by a number of absorbers and filters was assessed via bench testing. All absorbers (Sodasorb, Purafil CP, Purafil Select, Sofnolime, Sofnofil and 50/50 mix of Sofnolime/Sofnofil) except Sodasorb absorbed NO almost completely. Only Sofnolime absorbed NO2 completely while Sodasorb and the Sofnolime/Sofnofil 50/50 mix had absorbances between 47% and 90%. The absorbance of four filters (ILF100, ILF150, ILF200 and HgCONO) as well as Sofnolime and the Sofnolime/Sofnofil 50/50 mix was tested in the expiratory port of a Servo 900C ventilator All absorbers and filters produced a change in ventilator pressures. The HgCONO filter Sofnolime and the Sofnolime/Sofnofil 50/50 mix all absorbed NO. At 80 ppm NO, the HgCONO filter had 100% absorbance for four hours while Sofnolime's absorbance was significantly reduced after one hour. All filters and absorbers tested on the ventilator except the Sofnolime/Sofnofil 50/50 mix and the ILF150 filter absorbed NO2 completely for a period ranging from 90 minutes to four hours. We recommend the HgCONO filter and Sofnolime to absorb both NO and NO2. If absorption of NO2 only is required we recommend the HgCONO, ILF100 or ILF200 filters or the Sofnolime absorber.

Inhaled nitric oxide fraction is influenced by both the site and the mode of administration

OBJECTIVE

Inhaled nitric oxide (NO) can be delivered continuously or sequentially (= during inspiration) at different locations of the ventilation circuit. We have tested the influence of locations, modes of NO administration and the ratio of the inspiratory time over the respiratory cycle time (I/I + E ratio) on the accuracy of NO fractions, delivered by 2 devices: Opti-NO and Flowmeter.

METHODS

We used a simplified lung model consisting of a ventilation circuit with a Y piece, a tracheal tube, a 150 ml dead-space volume and a 5 liter balloon. Three fractions (3, 6, 9 ppm) were administered continuously or sequentially, in controlled volume, in 4 different sites on the inspiratory branch above the Y piece: i) just after the water trap, ii) just before the Y piece; below the Y piece: iii) just after the Y piece, iv) into the endotracheal tube. In addition, different I/I + E ratios (25, 33, 50, 80%) were studied. The delivered NO fractions were measured in the balloon by chemiluminescence (CLD 700, Ecophysics). A linear regression analysis was used to test the relationship between administered and measured NO fractions for the 3 fractions (3, 6 and 9 ppm) in sequential and continuous modes. Intercept values were compared to zero and slopes to the identity line.

RESULTS

When NO was administered in the continuous mode upstream the Y piece, NO fractions measured in the balloon corresponded to the administered fractions. In contrast, below the Y piece, the measured NO fractions were significantly lower than the administered NO fractions. In the sequential mode, above and below the Y piece, the delivered NO fractions were within the manufacturer's range.

CONCLUSIONS

For the continuous NO delivery, locations above the Y piece are mandatory. However, locations below the Y piece imposes a sequential system, which can also be used for the sites located above the Y piece.

Inhaled nitric oxide: technical aspects of administration and monitoring

OBJECTIVES

Clinical applications of inhaled nitric oxide (NO) therapy resulted in the development of delivery systems and monitoring devices applicable to routine clinical care. This article presents the various components necessary for an adequate clinical use of inhaled NO, and discusses the NO gas mixture cylinders, inhaled NO delivery techniques and specifications, monitoring devices, and ending with an exhaustive description of the scavengers of nitrogen oxides (NOx).

DATA SOURCES

Computerized search (CURRENT CONTENTS, MEDLINE) of published original research and review articles (approximately 200), conference abstracts and compendiums up to May 1997 (approximately 50), personal files, and contact with expert informants.

STUDY SELECTION

Technical, experimental, and clinical reports were selected from the recent English, French, German, and Spanish literature, if pertinent to the administration or monitoring of inhaled NO.

DATA EXTRACTION

The authors extracted all applicable data.

DATA SYNTHESIS

The production of NO gas mixture cylinders must be certified with respect to gas purity, stability, and concentration (limits between 100 and 1000 ppm), guaranteed calibration, and specific color. An ideal inhaled NO delivery device requires a synchronized delivery, a minimal production of nitrogen dioxide (NO2), and should be simple to use (verification, calibration, convenient flushing, cylinder change possible while in use and a simple alarm setting) with full information (high and low alarms and available precision monitoring of NO, NO2, and O2). Emergency and transport systems must be readily available. The choice of the monitoring device (chemiluminescence or electrochemistry) should be made based on the knowledge of their strength and weakness for a particular clinical application. Finally, scavengers of NOx should be used with caution until specific filters are proven safe and effective.

CONCLUSIONS

The great expectancies generated by inhaled NO action have led researchers to design personal inhaled NO delivery systems, but only with mitigated results. At present, medical companies are finding a financial interest in designing a delivery system which will suit the needs of clinicians and this, along with official governmental approval, will only then permit the use of inhaled NO safely and on a larger scale.

Uptake of inhaled nitric oxide in acute lung injury

BACKGROUND

Despite the widespread use of inhaled nitric oxide (NO), little is known of its pulmonary uptake in patients with acute respiratory failure.

METHODS

Fourteen patients with acute lung injury (ALI) and ongoing NO therapy were studied. Three doses of NO (5, 10 and 40 ppm) were given for 20 min and at each dose level the following parameters were recorded: minute ventilation, inspiratory NO conc., mixed expired NO conc., end-tidal NO conc., mixed expired CO2 conc., end-tidal CO2 conc, and arterial CO2 tension. Total uptake was calculated and correlated to the total amount of NO inhaled, the amount of NO administered to the alveolar space, and the amount of NO administered to the perfused alveolar space.

RESULTS

About 35% of the total amount of NO delivered is taken up by the lungs, 70% of NO administered to the alveolar space is taken up, and 95-100% of the NO administered to perfused alveolar space is taken up. The size of the alveolar dead space varied between 10 and 60% of the alveolar space. At 40 ppm of inhaled NO there was no difference between inspired and mixed expired NO2 concentration, indicating that there is no significant NO2 formation taking place in the lungs during NO inhalation at the concentrations studied.

CONCLUSIONS

Practically all NO administered to the perfused alveolar space is taken up. The total uptake differs from that of healthy persons probably because of differences in the alveolar dead space.

Nitric oxide administration after the ventilator: evaluation of mixing conditions

BACKGROUND

Because of the potential toxicity of nitric oxide (NO) and its oxidising product nitrogen dioxide (NO2), any system for the delivery of inhaled NO must aim at stable and predictable levels of NO and as low concentrations as possible of NO2.

METHODS

In a laboratory set-up, we have evaluated mixing conditions in a system where NO is added after the ventilator with continuous flow. Mixing was studied by using carbon dioxide (CO2) as a tracer gas since capnography has a short response time (360 ms) in comparison with measurements of NO with electrochemical fuel cells (response time of 18 s). CO2 (in volumes corresponding to an ideal mixture of 1, 3 and 6%) was fed, after the ventilator, either into plain breathing tubing, into one or two soda lime absorbers, or into an empty and a soda lime-filled canister, at different ventilatory rates and different I:E ratios. Samples were drawn from the inspiratory limb close to the Y-piece. NO was added in the same way and in the same volume as the highest concentration of CO2.

RESULTS

CO2 added to plain tubing resulted in peak levels up to five times the set levels, while addition to a mixing box with an empty and a soda lime-filled canister resulted in even mixing with gas concentrations close to the ideal. When NO was fed into plain tubing, low levels were measured at the Y-piece, indicating poor mixing. Gas supply to a mixing chamber resulted in even concentrations.

CONCLUSION

Even and predictable levels of NO can be obtained with continuous flow of NO to the inspiratory limb, after the ventilator, if a mixing chamber is used. To obtain adequate mixing, the volume of the mixing box should be greater than the tidal volume.

Response to nitric oxide inhalation in early acute lung injury

OBJECTIVE

To evaluate the dose response of inhaled nitric oxide (NO) on gas exchange and central haemodynamics in patients with early acute lung injury (ALI).

DESIGN

Prospective, multicentre clinical study.

SETTING

General ICUs in university and regional hospitals.

PATIENTS

18 Patients with early ALI according to specified criteria.

INTERVENTIONS

During controlled ventilation an inhalation system was used to deliver NO (1000 ppm in N2) and O2/air to the low pressure fresh gas inlet of a Siemens 900C ventilator. Haemodynamics and pulmonary gas exchange variables were measured at baseline and at stepwise increased inspiratory NO concentrations of 0.1, 0.3, 1, 3, 10, 30 and 100 ppm, each dose being maintained for 15 min. Dose testing was repeated the next day, and the response to prolonged (2 h) NO inhalation at 1 and 10 ppm was also tested.

MEASUREMENTS AND RESULTS

Inhalation of NO produced a significant increase in PaO2 (P < 0.0025). The degree of response, as well as the optimal NO dose varied in individual patients and between different days. Venous admixture (QVA/QT) was reduced (P < 0.02) from 38% (31-46%) to 33% (26-41%). In our patients with early acute lung injury and only a moderate elevation in pulmonary arterial pressure NO inhalation did not reduce mean pulmonary artery pressure significantly, being 27.0 (21-30) mmHg at baseline and 26.0 (21-30) mm Hg at 100 ppm.

CONCLUSIONS

This study shows that improvements in arterial oxygenation in response to inhaled NO may show great inter- as well as intraindividual variability, and that improvements in arterial oxygenation occur without any measurable lowering of the pulmonary artery pressure.