Factors determining quality of plasma

Factors affecting the quality of cryoprecipitate

BACKGROUND:

Many variables affect the quality of cryoprecipitate (CRYO). We investigated the effect of freezing techniques and ABO blood groups on the quality of CRYO with respect to factor VIII: C and fibrinogen levels.

MATERIALS AND METHODS:

Ninety-six whole blood units each collected from in-house (Group I) and blood donation camps outside the hospital premises (Group II) were processed for CRYO preparation. Within each group, half the number of plasma units was frozen using blast freezer and another half using the conventional freezer. The CRYOs from blood groups A, B, and O were equally distributed, i.e. 32 within each of the Groups I and II. The fibrinogen and factor VIII: C levels in CRYO were analyzed using single-stage clotting assay.

RESULTS:

In Group I, the mean ± standard deviation percentage recovery of factor VIII levels in CRYO prepared using the conventional freezer and blast freezer were 58.5% ±16.2% and 66.7% ±16.4%, respectively, and in Group II, it was 55.3% ±17.6% and 70.4% ±13.4%, respectively. Recovery of factor VIII was higher in CRYO prepared using blast freezer than that of CRYO prepared using conventional freezer (P < 0.000). In Group II, CRYOs prepared using blast freezer had higher percent recovery of fibrinogen than that of Group I. In both the groups, the mean factor VIII levels in blood group A were higher than that of factor VIII levels in the blood group O CRYO.

CONCLUSION:

The factor VIII recovery in CRYO improves significantly with higher baseline factor VIII: C levels, blood group A donor, and rapid freezing using blast freezer. Rapid freezing also increases the fibrinogen yield.

Factor VIII and fibrinogen recovery in plasma after Theraflex methylene blue-treatment: effect of plasma source and treatment time

BACKGROUND

The quality of fresh-frozen plasma is affected by different factors. Factor VIII is sensitive to blood component storage processes and storage as well as pathogen-reduction technologies. The level of fibrinogen in plasma is not affected by the collection processes but it is affected by preparation and pathogen-reduction technologies.

MATERIALS AND METHODS

The quality of plasma from whole blood and apheresis donations harvested at different times and treated with a pathogen-reduction technique, methylene blue/light, was investigated, considering, in particular, fibrinogen and factor VIII levels and recovery.

RESULTS

The mean factor VIII level after methylene blue treatment exceeded 0.5 IU/mL in all series. Factor VIII recovery varied between 78% and 89% in different series. The recovery of factor VIII was dependent on plasma source as opposed to treatment time. The interaction between the two factors was statistically significant. Mean levels of fibrinogen after methylene blue/light treatment exceeded 200 mg/dL in all arms. The level of fibrinogen after treatment correlated strongly with the level before treatment. There was a negative correlation between fibrinogen level before treatment and recovery. Pearson's correlation coefficient between factor VIII recovery and fibrinogen recovery was 0.58.

DISCUSSION

These results show a difference in recovery of factor VIII and fibrinogen correlated with plasma source. The recovery of both factor VIII and fibrinogen was higher in whole blood plasma than in apheresis plasma. Factor VIII and fibrinogen recovery did not appear to be correlated.

A comparative study of the effects of temperature, time and factor VIII assay type on factor VIII activity in cryoprecipitate in Iran

BACKGROUND

In Iran, cryoprecipitate is an important plasma product to provide coagulation factors such as factor VIII (FVIII) in patients with factor VIII deficiency. FVIII is one of the labile coagulation factors and as such is also used as a quality marker of fresh-frozen plasma and cryoprecipitate. It is, therefore, important to optimise plasma production in order to prevent a reduction of FVIII activity. In this study we assessed the effect of temperature, time and FVIII assay type on FVIII activity in cryoprecipitate produced in Iran.

METHODS

Ninety-six whole blood units were kept at two different temperatures (48 units kept at 1-6 °C and 48 kept at 20-24 °C) for periods of 4, 6, 8 or 10 hours before plasma freezing. FVIII activity was then measured by both chromogenic and one-stage clotting assays.

RESULTS

At both temperatures, FVIII activity in plasma prepared after 8 and 10 hours was lower than that in plasma prepared after 4 and 6 hours. A significant decrease of FVIII activity was not seen in samples kept for 4 and 6 hours. Compared to storage between 1-6 °C, storage at 20-24 °C appears to cause a reduction in FVIII activity. There was a significant difference in apparent FVIII activity measured by the one-stage clot-based and chromogenic assays.

CONCLUSION

In Iran, to improve cryoprecipitate quality, freezing should begin within 6 hours after donation and whole blood should be kept at 1-6 °C until the plasma can be frozen. In this study although a good correlation was seen between the results of the one-stage clot-based and chromogenic assays for measuring FVIII activity in cryoprecipitate, the absolute values were significantly different.

Quality control of recovered plasma for fractionation: an extensive Italian study

BACKGROUND

This study was aimed at obtaining significant information on the quality of whole-blood plasma (WBP) delivered to a private pharmaceutical company by the blood transfusion centers (BTCs) of 10 Italian regions.

STUDY DESIGN AND METHODS

A statistical sampling plan of plasma units took into account the contribution each selected blood transfusion center, belonging to the 10 regions, made to the plasma pool annually delivered to the pharmaceutical company. A total of 1787 plasma units were selected for coagulation Factor VIII (FVIII:C) and Factor VIII antigen (FVIII:Ag) analysis.

RESULTS

The FVIII:C mean value was 0.99 IU per mL; it was significantly lower in O units (0.86 IU/mL) than in non-O units (1.08 IU/mL). The mean value of FVIII:Ag was 0.90 IU per mL; it was significantly lower in O units (0.78 IU/mL) than in non-O units (0.99 IU/mL). In units with a FVIII:C level of less than 0.70 IU per mL, the FVIII:Ag mean value (0.62 IU/mL) was higher in comparison to the FVIII:C mean value (0.57 IU/mL). Instead, in the units with a FVIII:C level of at least 0.70 IU per mL, the mean level of FVIII:C (1.08 IU/mL) was higher than that of FVIII:Ag (0.96 IU/mL).

CONCLUSIONS

The mean value of FVIII:C (0.99 IU/mL) in whole-blood plasma produced by the 10 Italian regions is higher than that reported in other studies. A total of 83.1 percent of units have a FVIII:C level of at least 0.70 IU per mL. The mean level of FVIII:Ag is lower than that of FVIII:C. FVIII:Ag is higher in those units with a FVIII:C level of less than 0.70 IU per mL, while it gradually decreases as FVIII:C exceeds 0.70 IU per mL, thus showing a greater resistance to handling of plasma in the production steps mostly affecting FVIII:C stability.

Warm storage of whole blood for 72 hours

BACKGROUND

In field emergency medicine, fresh whole-blood units are stored at room temperature up to 24 hours or occasionally longer. Few data exist on the integrity and in vitro functional properties of whole blood stored warm beyond 24 hours.

STUDY DESIGN AND METHODS

Ten citrate phosphate dextrose solution whole-blood units were collected and divided into two equal volumes. One-half of each unit was stored at 19 degrees C and the other half was stored at 25 degrees C, encompassing the accepted range for room temperature storage. At 6, 24, 48, and 72 hours, aliquots were collected from each unit and whole blood analyzed for cell counts, gases, and clotting function with thromboelastography, red cells for intracellular analytes, platelet (PLT)-rich plasma for aggregometry, and the supernatant for hemoglobin, potassium, glucose, lactate, and plasma clotting studies.

RESULTS

Whole-blood units stored at room temperature maintained cellular counts and coagulation activity for up to 72 hours. Units stored at 19 degrees C demonstrated greater RBC adenosine triphosphate and 2,3-diphosphoglycerate (DPG) content and stronger responses in PLT aggregation studies when compared with 25 degrees C storage. No significant hemolysis was observed, and no bacterial growth was detected.

CONCLUSION

Storage of whole blood at room temperature for 72 hours leads to marked reductions in pH and DPG, but the observed reduction in PLT function and plasma coagulation factor activity was surprisingly modest compared to literature values. These findings should prompt additional investigation, given their potential importance for whole blood processing and field-expedient transfusion.

Characterization of blood components prepared from whole-blood donations after a 24-hour hold with the platelet-rich plasma method

BACKGROUND

The preparation of platelet (PLT) concentrates (PCs) from PLT-rich plasma (PRP) requires that whole blood (WB) be processed within 8 hours of collection. Increasing WB storage time to 24 hours would be logistically attractive. This study compares the in vitro quality of blood components prepared from WB stored for 8 and 24 hours at room temperature before processing with the PRP method.

STUDY DESIGN AND METHODS

WB units were collected from ABO-matched blood donors. To reduce individual variations, paired donations were drawn in parallel, pooled, and split back in the collection bag. One unit was held for 6 to 8 hours and the other for 22 to 24 hours at 20 to 24 degrees C. Prestorage leukoreduced components were prepared with the PRP as intermediate product and analyzed during storage.

RESULTS

RBC units prepared after an 8- or 24-hour hold were comparable in terms of hemolysis, sodium, pH, and ATP levels. RBC 2,3- diphosphoglycerate (2,3-DPG) was significantly lower in RBCs prepared from 24-hour hold donations immediately after processing but not after 20 days of storage. Residual white blood cells were approximately fivefold higher (p < 0.05) in 24-hour RBC units. For PCs, measurements for glucose, ATP, lactate, pH, extent of shape change, hypotonic shock response, and CD62p activation were similar. No differences were observed in the von Willebrand factor, factor (F)V, FVIII, and fibrinogen content of fresh-frozen plasma.

CONCLUSIONS

The decrease in FVIII and RBC 2,3-DPG can be acceptable as a compromise to improve blood component logistics, but leukoreduction efficiency must be improved before considering the adoption of an overnight storage of WB before PRP processing.

Factors influencing factor VIII activity in frozen plasma

BACKGROUNDS AND OBJECTIVES

Fresh frozen human plasma is an important raw material in the production of coagulation factor concentrates used in patients with haemorrhagic disorders. The aim of the study was to determine how the handling of plasma influences the recovery of coagulation factor VIII activity (FVIII:C), i.e. the influence of time between donation and freezing, of the freezing time and of the ice front velocity. We also studied a tentative eutectic point in human plasma.

MATERIALS AND METHODS

Aliquots of plasma from 12 different donors were kept at room temperature for 2, 4 and 6 h before start of freezing. We achieved fast freezing with a freezer that blows cooled air at a high velocity on the plasma containers. Freezing times were 0.5, 1, 4 and 24 h. Temperature was registered continuously during freezing. Plasma and NaCl solutions were frozen slowly to investigate the eutectic point.

RESULTS

Storage at room temperature for 6 h caused a small but statistically significant decrease in FVIII:C. Slow freezing with programmed freezing times of 4 and 24 h caused a more pronounced drop in FVIII:C as compared to that of 30 and 60 min. We found no eutectic point in plasma or in plasma with addition of 2 % (w/v) NaCl.

CONCLUSION

For an optimal yield of FVIII, freezing should start within 4 h after plasma donation. We propose the use of the term 'ice front velocity' instead of 'freezing speed', taking into consideration that the volume and shape of plasma containers may differ. We found only a marginal loss of FVIII:C when the ice front velocity was 26 mm/h or faster, but a significant loss when it was 9 mm/h or slower. We recommend freezing times of 60 min or shorter. We were not able to demonstrate any eutectic point in human plasma. We therefore recommend that the term eutectic point should not be used as a reference temperature in guidelines on plasma handling.

Protein composition and activation markers in plasma collected by three apheresis procedures

BACKGROUND

Scientific and technical advances made in transfusion medicine sustain the need for more comprehensive understanding of the impact of collection procedures on the quality of plasma for fractionation and for transfusion. This prospective work evaluated protein composition and markers of activation in plasma donations collected with three different automatic collection procedures (performed on Haemonetics machines), including a new procedure using a high-separation core-molded bowl.

STUDY DESIGN AND METHODS

A total of 90 collection procedures have been performed from a population of 37 donors, under comprehensively standardized conditions. Plasma aliquots were taken from the plasma units within 30 minutes of the end of the collection procedures and immediately frozen at -70 degrees C. Content in an extended range of proteins and of markers of activation of the coagulation and fibrinolytic systems has been measured using standard in vitro testing methods.

RESULTS

Plasma donations had normal mean total protein, IgG, IgM, and fibrinogen content. The mean levels in coagulation FV, FVII, FVIII, and FXI and in antithrombin were above the standard international requirements. There was no sign of activation of the hemostasis system, as assessed by activated FVII, thrombin antithrombin complex, Prothrombin fragment 1+2, and D-dimers. Activated complement component C3 and C5 were low.

CONCLUSION

Data indicates the good and consistent protein composition of plasma obtained by those automatic apheresis procedures. In particular, the new high-separation core procedure yields a high-quality plasma meeting requirements for transfusion and fractionation.