Influence of some polyvalent organic acids and salts on the colloidal stability of milk

Effect of Trisodium Citrate on Rheological and Physical Properties and Microstructure of Yogurt

The effect of trisodium citrate (TSC) on the rheological and physical properties and microstructure of yogurt was investigated. Reconstituted skim milk was heated at 85 degrees C for 30 min, and various concentrations (5 to 40 mM) of TSC were added to the milk, which was then readjusted to pH 6.50. Milk was inoculated with 2% yogurt culture and incubated at 42 degrees C until pH was 4.6. Acid-base titration was used to determine changes in the state of colloidal calcium phosphate (CCP) in milk. Total and soluble Ca contents of the milk were determined. The storage modulus (G') and loss tangent (LT) values of yogurts were measured as a function of pH using dynamic oscillatory rheology. Large deformation rheological properties were also measured. Microstructure of yogurt was observed using confocal scanning laser microscopy, and whey separation was also determined. Addition of TSC reduced casein-bound Ca and increased the solubilization of CCP. The G' value of gels significantly increased with addition of low levels of TSC, and highest G' values were observed in samples with 10 to 20 mM TSC; higher (> 20 mM) TSC concentrations resulted in a large decrease in G' values. The LT of yogurts increased after gelation to attain a maximum at pH approximately 5.1, but no maximum was observed in yogurts made with > or = 25 mM of TSC because CCP was completely dissolved prior to gelation. Partial removal of CCP resulted in an increase in the LT value at pH 5.1. At low TSC levels, the removal of CCP crosslinks may have facilitated greater rearrangement and molecular mobility of the micelle structure, which may have helped to increase G' and LT values of gels by increasing the formation of crosslinks between strands. At high TSC concentrations the micelles were completely disrupted and CCP crosslinks were dissolved, both of which resulted in very weak yogurt gels with large pores obvious in confocal micrographs. Gelation pH and yield stress significantly decreased with the use of high TSC levels. Lowest whey separation levels were observed in yogurt made with 20 mM TSC, and whey separation greatly increased at > 25 mM TSC. In conclusion, low concentrations of TSC improved several important yogurt characteristics, whereas the use of levels that disrupted casein micelles resulted in poor gel properties. We also conclude that the LT maximum observed in yogurts made from heated milk is due to the presence of CCP because the modification of the CCP content altered this peak and the removal of CCP eliminates this feature in the LT profiles.

Effects of Two Types of Emulsifying Salts on the Functionality of Nonfat Pasta Filata Cheese

Effects of 2 types of emulsifying salts (ES) on the functionality of nonfat pasta filata cheese were examined. Nonfat pasta filata cheese was made from skim milk by direct acidification. Trisodium citrate (TSC) and tetrasodium pyrophosphate (TSPP) were added to curds (at 1, 3, and 5%, wt/wt) at the dry-salting step, together with glucono-delta-lactone to maintain a constant pH. When TSC was added, there were no significant compositional differences, although insoluble Ca and P contents significantly decreased with the addition of TSC. When TSPP was added, fat content was not significantly different, but protein content decreased with increasing concentrations of TSPP. Both insoluble Ca and P contents increased with the addition of 1% TSPP. The addition of ES affected textural and functional properties. With increasing concentrations of TSC, meltability increased, whereas increasing the TSPP content decreased meltability. Cheese made with 1% TSC had better stretchability compared with control cheese. However, the addition of more than 3% TSC decreased stretchability. Addition of TSPP caused a considerable decrease in stretchabilty. Scanning electron microscopy revealed that the size and number of serum pockets decreased and protein appeared more hydrated with the addition of both ES. These results suggested that TSC and TSPP influenced the functionality of nonfat pasta filata cheese differently; that is, the effects of TSC were probably caused by a decrease in the number of colloidal calcium phosphate cross-links and an increase in electrostatic repulsion, whereas the effects of TSPP may have been related to the formation of new TSPP-induced casein-casein interactions.

Effects of Emulsifying Salts on the Turbidity and Calcium-Phosphate–Protein Interactions in Casein Micelles

Influence of emulsifying salts (ES) on some physical properties of casein micelles was investigated. A reconstituted milk protein concentrate (MPC) solution (5% wt/wt) was used as the protein source and the effects of ES [0 to 2.0% (wt/wt)] were estimated by measuring turbidity, acid-base titration curves and amount of casein-bound Ca and inorganic P (P(i)). Various ES, trisodium citrate (TSC), or sodium phosphates (ortho-, pyro-, or hexameta-) were added to MPC solution, and all samples were adjusted to pH 5.8. Acid-base buffering curves were used to observe changes in the amount and type of insoluble Ca phosphates. An increase in the concentration of TSC added to MPC solution decreased turbidity, buffering at pH approximately 5 (contributed by colloidal Ca phosphate), and amount of casein-bound Ca and P(i). Addition of up to 0.7% disodium orthophosphate (DSP) did not significantly influence turbidity, buffering curves, or amount of casein-bound Ca and P(i). When higher concentrations (i.e., > or =1.0%) of DSP were added, there was a slow decrease in turbidity. With increasing concentration of added tetrasodium pyrophosphate (TSPP), turbidity and buffering at pH approximately 5 decreased, and amount of casein-bound Ca and P(i) increased. When small concentrations (i.e., 0.1%) of sodium hexameta-phosphate were added, effects were similar to those when TSPP were added but when higher concentrations (i.e., > or =0.5%) were added, the buffering peak shifted to a higher pH value, and amount of casein-bound Ca and P(i) decreased. These results suggested that each type of ES influenced casein micelles by different mechanisms.

Effect of Sodium Citrate on Structure-Function Relationships of Cheddar Cheese

The objective of this study was to determine the effect of sodium citrate on the structure and functionality of Cheddar cheese. The hypothesis was that citrate (sodium citrate) injection would affect cheese properties mainly through its effect on bound calcium (calculated as the difference between total calcium and the water-soluble calcium content of a cheese extract). A 9-kg block of Cheddar cheese was made, vacuum-packaged, and then stored for 2 wk at 4 degrees C. After storage, the cheese was cut into 0.5- to 0.6-kg blocks that were vacuum-packaged and stored for 1 wk at 4 degrees C prior to injection. Cheese blocks were then high-pressure injected with a buffer solution (pH 5.27) containing 40% (wt/ wt) citric acid trisodium dihydrate and 6.25% (wt/wt) anhydrous citric acid, from zero (control) to five times (successive injections performed 24 h apart). Increased citric acid content of cheese from 0.22 (uninjected) to 1.39% (after five injections) caused phosphate solubilization. Thus, the calculated bound phosphate content of cheese decreased from 0.54 to 0.45 mmol/g of protein. However, unexpectedly, the soluble calcium content decreased from 0.34 (control) to 0.28 mmol/g of protein (after five injections), whereas the bound calcium content remained unchanged (0.42 mmol/g of protein). The decrease in soluble calcium probably resulted from the formation and concentration of crystals in the cheese surface, which was not included in samples for analysis, and from the expulsion of serum from within the cheese. Higher concentration of solutes in the water phase of cheese would increase the volume of serum, but the cheese had limited holding capacity and serum was expelled. Citrate injection increased the sodium content of cheese from 0.63 to 0.93%, but it had no effect on cheese pH (5.2). After five injections, the protein matrix expanded, occupying an increased area of cheese matrix (83 vs. 78%). Even though citrate injection had no effect on bound calcium, and thus the rate and extent of cheese flow were unaffected, increased phosphate solubilization, and possibly decreased ionic calcium content, resulted in expansion of the protein matrix and increased cheese hardness.