Three-dimensional visualization of Salmonella attachment to poultry skin using confocal scanning laser microscopy

Reduction of Salmonella contamination on the surface of chicken skin using bacteriophage

Background

Enteric infections caused by Salmonella spp. remain a major public health burden worldwide. Chickens are known to be a major reservoir for this zoonotic pathogen. The presence of Salmonella in poultry farms and abattoirs is associated with financial costs of treatment and a serious risk to human health. The use of bacteriophages as a biocontrol is one possible intervention by which Salmonella colonization of chickens could be reduced. In a prior study, phages Eϕ151 and Tϕ7 significantly reduced broiler chicken caecal colonization by S. Enteritidis and S. Typhimurium respectively.

Methods

Salmonella-free Ross broiler chickens were orally infected with S. Enteritidis P125109 or S. Typhimurium 4/74. After 7 days of infection, the animals were euthanased, and 25cm² sections of skin were collected. The skin samples were sprayed with a phage suspension of either Eϕ151 (S. Enteritidis), Tϕ7 phage suspension (S. Typhimurium) or SM buffer (Control). After incubation, the number of surviving Salmonellas was determined by direct plating and Most Probable Number (MPN). To determine the rate of reduction of Salmonella numbers on the skin surface, a bioluminescent S. Typhimurium DT104 strain was cultured, spread on sections of chicken breast skin, and after spraying with a Tϕ11 phage suspension, skin samples were monitored using photon counting for up to 24 h.

Results

The median levels of Salmonella reduction following phage treatment were 1.38 log₁₀ MPN (Enteritidis) and 1.83 log₁₀ MPN (Typhimurium) per skin section. Treatment reductions were significant when compared with Salmonella recovery from control skin sections treated with buffer (p < 0.0001). Additionally, significant reduction in light intensity was observed within 1 min of phage Tϕ11 spraying onto the skin contaminated with a bioluminescent Salmonella recombinant strain, compared with buffer-treated controls (p < 0.01), implying that some lysis of Salmonella was occurring on the skin surface.

Conclusions

The results of this study suggest that phages may be used on the surface of chicken skin as biocontrol agents against Salmonella infected broiler chicken carcasses. The rate of bioluminescence reduction shown by the recombinant Salmonella strain used supported the hypothesis that at least some of the reduction observed was due to lysis occurred on the skin surface.

Population Analyses Reveal Preenrichment Method and Selective Enrichment Media Affect Salmonella Serovars Detected on Broiler Carcasses

Poultry is a major Salmonella reservoir, but conventional culture-based methods typically identify the most abundant serovars while those less abundant remain undetected. Choice of enrichment procedure also introduces bias, and for broiler carcasses, a 1-min rinse before preenrichment is insufficient to release all Salmonella present. The inability to assess serovar diversity means that serovars more often associated with human illness may be masked by more abundant Salmonella. CRISPR-SeroSeq (serotyping by sequencing clustered regularly interspaced short palindromic repeats), an amplicon-based, next-generation sequencing tool, allows detection of multiple serovars and maps the relative serovar frequencies in a sample. To address the preceding limitations, CRISPR-SeroSeq was used on broiler carcasses collected prechilled at a commercial plant. Standard carcass rinse aliquot preenrichments and whole carcass preenrichments that were enriched in Rappaport-Vassiliadis (RV) and tetrathionate (TT) broths were compared. On average, five serovars were observed per carcass, including nine on one carcass. CRISPR-SeroSeq detected serovars comprising as little as 0.005% of the population. CRISPR-SeroSeq data matched (28 of 32) standard culture analysis for abundant serovars. Salmonella serovars Kentucky, Typhimurium, and Schwarzengrund were found on each carcass. Overall, serovar diversity was higher in whole carcass preenrichments that were enriched in RV (P < 0.05). Serovar Schwarzengrund was present at higher frequencies in whole carcass preenrichments compared with rinse aliquot preenrichments (t test, P < 0.05), suggesting it adheres more strongly to the carcass. Salmonella serovar Enteritidis was enriched eightfold more in TT than in RV, and serovars Schwarzengrund and Reading were preferentially enriched in RV. Comparison of preenriched and enriched samples suggests that selective enrichment in RV or TT was inhibitory to some serovars. This article addresses limitations of Salmonella surveillance protocols and provides information related to Salmonella population dynamics.

Effects of Cetylpyridinium Chloride and Peroxyacetic Acid Treatment of Broiler Frames on Salmonella Incidence and Mechanically Separated Chicken Quality

Mechanically separated chicken (MSC) has a high incidence of Salmonella since it is separated and homogenized from multiple broiler frames. In addition, limited research has been reported on the reduction of naturally contaminated Salmonella on chicken carcasses or chicken frames. Therefore, broiler frames were treated with antimicrobial solutions of 0.1% peroxyacetic acid (PAA) or 0.5% cetylpyridinium chloride with Citrilow (CPC) for contact times of 30, 60, 90, or 120 s and evaluated for their effectiveness at reducing the incidence of naturally contaminated Salmonella spp. on broiler frames and decreasing Salmonella counts on inoculated frames that were ground and sieved into MSC. Treatment times for PAA and CPC did not affect (P > 0.05) % incidence of Salmonella on naturally contaminated broiler frames. While CPC30 showed a greater % reduction in incidence (P < 0.05) than PAA30, CPC90 and CPC120 did not differ (P > 0.05) from PAA90 and PAA120. However, the CPC treatments imparted a greater decrease in incidence of Salmonella on frames than PAA. For inoculated frames, both antimicrobial treatments at all treatment times had fewer (P < 0.05) Salmonella counts in MSC than their controls. Treated MSC samples were evaluated for pH, color, cook loss and protein bind. On average, CPC treatments were lighter (CIE L*; P < 0.05) than PAA treatments, and PAA treatments were more red (CIE a*) and more yellow (CIE b*; P < 0.05) than CPC treatments. All treatments produced MSC with lesser hue values than their controls. Protein bind and cook loss results indicated that the PAA treatments had no significant impact on MSC quality. Frames that were treated with CPC for 60 s yielded less protein bind than the control, which indicates less protein functionality.

Food Grade Pimenta Leaf Essential Oil Reduces the Attachment of Salmonella enterica Heidelberg (2011 Ground Turkey Outbreak Isolate) on to Turkey Skin

Salmonella attached to the poultry skin is a major source of carcass contamination during processing. Once attached to the poultry skin, it is difficult to detach and inactivate Salmonella by commonly used antimicrobial agents since the pathogen is entrapped deeply in the feather follicles and the crevices on the skin. Essential oils could be natural, safe, and effective alternatives to synthetic antimicrobial agents during commercial and organic processing setup. The present study evaluated the efficacy of pimenta (Pimenta officinalis Lindl.) leaf essential oil (PEO), and its nanoemulsion in reducing Salmonella Heidelberg attachment on to turkey (Meleagris gallopavo) skin during simulated scalding (65°C) and chilling (4°C) steps in poultry processing. A multidrug resistant S. Heidelberg isolate from the 2011 ground turkey outbreak in the United States was used in the study. Results showed that PEO and the nanoemulsion resulted in significant reduction of S. Heidelberg attachment on turkey skin. Turkey skin samples treated with 1.0% PEO for 5 min resulted in >2 log10 CFU/sq. inch reduction of S. Heidelberg at 65 and 4°C, respectively (n = 6; P < 0.05). Similarly, skin samples treated with 1.0% pimenta nanoemulsion (PNE) for 5 min resulted in 1.5- and 1.8- log10 CFU/sq. inch reduction of S. Heidelberg at 65 and 4°C, respectively (n = 6; P < 0.05). In addition, PEO and PNE were effective in reducing S. Heidelberg on skin during short-term storage at 4 and 10°C (temperature abuse) (n = 6; P < 0.05). No Salmonella was detected in the dipping solution containing 0.5 or 1.0% PEO or PNE, whereas a substantial population of the pathogen survived in the control dipping solution. The results were validated using scanning electron -, and confocal - microscopy techniques. PEO or PNE could be utilized as an effective antimicrobial agent to reduce S. Heidelberg attachment to turkey skin during poultry processing.

Review: Confocal scanning laser microscopy. A powerful tool in food science Revision: Microscopía láser confocal de barrido. Una potente herramienta en la ciencia de los alimentos

Confocal scanning laser microscopy (CSLM) is a recently developed light microscopy technique which permits observation of selected levels within thick samples. CSLM improves the resolution along the viewing axis and permits optical sectioning of the sample. Sample preparation is not time consuming and changes the original structure of the specimen only minimally. In this way structures involved in kinetic processes of food materials exposed to external stress situations can be visualized. In this review the contributions of CSLM to improving the understanding of various processes in different fields of food science are discussed. The fundamentals of the operations required are considered, including a discussion of common laser sources and different kinds of fluorescent dyes. Attention is paid to the peculiarities of sample preparation, as well as to the possibilities of image processing in order to improve and analyze the images collected. The quantitative analysis of plant organizations and cellular structures in plant material by CSLM is reported as well as the use of CSLM to image the structure of emulsions of different complexity and to locate microorganisms in a wide range of food products.

Identification of Salmonella enterica serovar Kentucky genes involved in attachment to chicken skin

BACKGROUND

Regardless of sanitation practices implemented to reduce Salmonella prevalence in poultry processing plants, the problem continues to be an issue. To gain an understanding of the attachment mechanism of Salmonella to broiler skin, a bioluminescent-based mutant screening assay was used. A random mutant library of a field-isolated bioluminescent strain of Salmonella enterica serovar Kentucky was constructed. Mutants' attachment to chicken skin was assessed in 96-well plates containing uniform 6 mm diameter pieces of circular chicken skin. After washing steps, mutants with reduced attachment were selected based on reduced bioluminescence, and transposon insertion sites were identified.

RESULTS

Attachment attenuation was detected in transposon mutants with insertion in genes encoding flagella biosynthesis, lipopolysaccharide core biosynthesis protein, tryptophan biosynthesis, amino acid catabolism pathway, shikimate pathway, tricarboxylic acid (TCA) cycle, conjugative transfer system, multidrug resistant protein, and ATP-binding cassette (ABC) transporter system. In particular, mutations in S. Kentucky flagellar biosynthesis genes (flgA, flgC, flgK, flhB, and flgJ) led to the poorest attachment of the bacterium to skin.

CONCLUSIONS

The current study indicates that attachment of Salmonella to broiler skin is a multifactorial process, in which flagella play an important role.

Salmonella Levels Associated with Skin of Turkey Parts

Turkey skin is used as a source of fat in finished ground turkey products. Salmonella-contaminated skin may potentially disseminate this pathogen to ground turkey. The objective of this study was to determine and compare Salmonella levels (presence and numbers) associated with the skin of turkey parts (i.e., drumstick, thigh, and wing). Over a 10-month period, 20 turkey flocks expected to be highly contaminated with Salmonella based on boot-sock testing data of turkey houses were sampled. A total of 300 samples per type of turkey part were collected postchill and were tested for Salmonella using the most-probable-number (MPN) and enrichment methods. Overall, Salmonella was detected in 13.7, 19.7, and 25.0% of drumstick skin, thigh skin, and wing skin samples, respectively. Salmonella prevalence from wing skin was significantly higher (P < 0.05) than in drumstick skin, but the difference was not significant (P > 0.05) when compared with thigh skin. Salmonella was 2.4 times more likely to be present from thigh skin (odds ratio = 2.4; P < 0.05) when the pathogen was found from wing skin. Salmonella mean numbers from drumstick, thigh, and wing were 1.18, 1.29, and 1.45 log MPN per sample, respectively; these values were not significantly different (P > 0.05). Based on our findings, the high prevalence of Salmonella associated with the skin of turkey parts could be a potential source for ground turkey contamination.

Salmonella Levels in Turkey Neck Skins, Drumstick Bones, and Spleens in Relation to Ground Turkey

The objective of this study was to determine Salmonella levels (presence and numbers) in turkey drumstick bone, spleen, and neck skin samples in relation to Salmonella contamination levels in ground turkey at the flock level. Over a 10-month period, a total of 300 samples of each turkey part (i.e., neck skin, spleen, and drumstick) from 20 flocks were collected at a commercial turkey processing plant after the evisceration step. Turkey flocks included in this study were classified as "targeted" and "nontargeted" based on the company's historical ground turkey contamination data. A flock that originated from a turkey farm that had previously produced one or more flocks with ≥20% Salmonella prevalence in ground turkey was labeled as a targeted flock (n = 13). The remaining seven flocks with <20% prevalence were labeled as nontargeted. All samples collected were tested for Salmonella presence and numbers by using most-probable-number and selective enrichment methods. Further genotypic analysis (pulsed-field gel electrophoresis) of the isolates was performed. Ground turkey samples were collected and analyzed for Salmonella levels by the cooperating turkey company. The outside surface of bone and spleen were sterilized prior to Salmonella analysis. The overall Salmonella prevalence in neck skin, drumstick bone, spleen, and ground turkey samples was 42.0, 9.3, 6.7, and 14.5%, respectively. Salmonella prevalence in neck skin, spleen, drumstick bone, and ground turkey from the targeted flocks was significantly (P < 0.05) higher than those from nontargeted flocks. There was a significant relationship between Salmonella presence in neck skin (when most probable numbers were ≥2 log) and Salmonella-positive ground turkey lot. Based on our findings, Salmonella was detected internally in drumstick bones and spleens at low levels, whereas Salmonella presence at higher levels in neck skin may indicate a flock with greater potential for Salmonella contamination of ground turkey.

Quantification of loosely associated and tightly associated bacteria on broiler carcass skin using swabbing, stomaching, and grinding methods

This research was conducted to quantify bacterial populations after swabbing or stomaching, followed by grinding the swabbed or stomached broiler skins. For each of 3 replications, 3 eviscerated broilers were randomly taken from a processing line in a local broiler processing plant. Ten swabs and 10 stomachs per bird were conducted on the left- and the right-side skins (10×7 cm), respectively, which were then finally ground. Results indicated that mesophilic aerobic bacteria (MAB) in the first swabbed sample were significantly lower than those in the first stomached sample (P<0.05), with no difference seen for the remaining sampling times (P>0.05). During 10 swabbings followed by final grinding, 8, 9, and 83% of MAB were detected after the first swabbing, after the second through 10th swabbings, and after final grinding of the skin, respectively. During 10 stomachings followed by the final grinding, 17, 18, and 65% of MAB were detected after the first stomaching, after the second through 10th stomachings, and after final grinding of the skin, respectively. Escherichia coli (E. coli) and coliforms were significantly higher in the first stomaching than those in the first swabbing (P<0.05), with no difference seen between the 2 sampling methods for the rest sampling times (P>0.05). Populations of E. coli and coliforms decreased step-wisely from the highest after grinding to the intermediate after first and second sampling, and to the least after 10th sampling (P<0.05), regardless of swabbing or grinding. In this study, less than 35% of MAB seemed loosely associated in the skin of eviscerated broiler, whereas more than 65% of MAB looked tightly associated, which were not recovered by stomaching or swabbing even 10 times but were recovered by grinding the skin.

Prevalence of salmonella in neck skin and bone of chickens

Bone-in and boneless parts, such as drumsticks, are used in ground chicken production. In addition, neck skin is used as a source of fat in ground products. Contaminated chicken neck skin and bones containing internalized Salmonella are potential sources of this pathogen in ground chicken. This study determined the prevalence of Salmonella and serotype distribution in drumstick bones and neck skin of postchill chicken carcasses. One week prior to slaughter, chicken houses (n = 26) at nine farms were tested for the presence of Salmonella, using the boot sock method. Chicken flocks from these houses originated from Salmonella-positive breeders. Eight Salmonella-positive chicken flocks and one flock with undetermined Salmonella status were monitored through processing. Three hundred postchill drumsticks and 299 neck skin samples were analyzed for Salmonella prevalence. Skin samples were rinsed and stomached prior to analysis. Bones were extracted from the drumsticks, external surfaces were sterilized, and bones were crushed for analysis. One Salmonella isolate from each positive sample was serogrouped. Half of the isolates representing different sample types were serotyped. Overall, Salmonella was found in 0.8, 21.4, and 80.1% of bone marrow, neck skin, and farms, respectively. Prevalence of Salmonella on rinsed skin samples (2.3%) and stomached skin samples (20.7%) differed significantly (P ≤ 0.05). Serogroups B, C2, D, and E were found at 23.4, 31.9, 11.7, and 29.8%, respectively. Six Salmonella serotypes were identified: Liverpool (37.9%), Kentucky (27.6%), and Typhimurium (27.6%) were isolated most frequently from neck skin; the two bone isolates were Kentucky; and more than 50% of the farm isolates were Kentucky and Ouakam. Salmonella-contaminated neck skin might be a more significant source of this contamination in ground chicken than Salmonella internalized in bones.

The evaluation of combined chemical and physical treatments on the reduction of resident microorganisms and Salmonella Typhimurium attached to chicken skin

This study was conducted to evaluate the efficacy of sodium hypochlorite (NaOCl, 0-200 mg/kg), thiamine dilauryl sulfate (TDS, 1,000 mg/kg), and ultrasound (37 kHz, 380 W) on reducing Salmonella Typhimurim, mesophilic aerobic bacteria (MAB), and coliforms on chicken skin. Chemical and physical treatments were applied for 5 min either singly or jointly, and Salmonella previously inoculated on chicken skin were quantitatively assessed using brilliant green agar, and the populations of MAB and coliforms in the native flora were enumerated using plate count agar and violet red bile agar, respectively. In the evaluation of bacterial attachment/detachment, chicken skin was quantitatively assessed for loosely, intermediately, and tightly attached bacteria. The treatment effects on bacteria detachment were also visualized using field emission scanning electron microscopy. In addition, color and textural properties of the skin after treatments were evaluated using a color difference meter and texture analyzer. Antimicrobial activity of NaOCl increased as the NaOCl concentration was increased, especially for loosely attached cells. The combination of 200 mg/kg NaOCl and ultrasound (NaOCl/ultrasound) significant reduced loosely, intermediately, and tightly attached bacteria populations by 0.75 to 0.47, 0.43 to 0.41, and 0.83 to 0.54 log cfu/g for MAB, coliforms, and Salmonella Typhimurium, respectively. However, the combination of NaOCl and TDS (NaOCl/TDS) did not sufficiently reduce those cells on chicken skins, except for loosely attached MAB and coliforms. The NaOCl/ultrasound combination produced a higher reduction in numbers of inoculated and native bacteria flora than any single application, with no negative effect on skin color or texture. Generally, the loosely attached bacteria were less resistant to the chemical and physical treatments than the intermediately and tightly attached bacteria in chicken skin, presumably due to their location in deeper skin layer and crevices. Further research is needed to investigate how the intermediately and tightly attached microorganisms can be effectively eliminated from chicken skin.

Effect of hot water spray on broiler carcasses for reduction of loosely attached, intermediately attached, and tightly attached pathogenic (Salmonella and Campylobacter) and mesophilic aerobic bacteria

Chickens are known to harbor many bacteria, including pathogenic microorganisms such as Salmonella and Campylobacter. The objective of this study was to evaluate the efficacy of hot water spray (HWS, 71°C for 1 min) in reducing bacterial contamination of prechilled broiler carcasses. For each of 4 replications, skin samples from 5 broilers were collected at 3 processing stages: after bleeding (feathers removed manually), after evisceration (with/without HWS), and after water chilling. Broiler skin was quantitatively assessed for loosely attached (by rinsing the skin), intermediately attached (by stomaching the rinsed skin), and tightly attached (by grinding the rinsed/stomached skin) mesophilic aerobic bacteria (MAB) and Campylobacter as well as for the prevalence of Salmonella and Campylobacter. Broiler skins possessed 6.4 to 6.6 log cfu/g, 3.8 to 4.1 log cfu/g, and 2.8 to 3.5 log cfu/g of MAB populations after bleeding, evisceration, and chilling, respectively. The HWS resulted in more than 1 log unit of reduction in MAB immediately after evisceration and immediately after chilling regardless of microbial sampling method. Compared with MAB, the contamination of Campylobacter was low (1.7 to 2.6 log cfu/g) after bleeding, but the level was not reduced throughout the processing steps regardless of HWS. The application of HWS reduced the prevalence of Salmonella after chilling, but not for Campylobacter except for loosely attached cells. After hot water exposure, a partially cooked appearance was seen on both broiler skin and skinless breast surface. More research is required to effectively eliminate pathogenic organisms during processing and suppress any recovery of bacteria regardless of attachment type after chilling.

Initial contamination of chicken parts with Salmonella at retail and cross-contamination of cooked chicken with Salmonella from raw chicken during meal preparation

The current study was undertaken to acquire data on contamination of chicken parts with Salmonella at retail and to acquire data on cross-contamination of cooked chicken with Salmonella from raw chicken during meal preparation. Whole raw chickens (n = 31) were obtained from local retail stores and cut into two wings, two breasts without skin or bones, two thighs, and two drumsticks. Data for cross-contamination were obtained by cutting up a sterile, cooked chicken breast with the same board and knife used to cut up the raw chicken. The board, knife, and latex gloves used by the food handler were not rinsed or washed before cutting up the sterile, cooked chicken breast, thus providing a worst-case scenario for cross-contamination. Standard curves for the concentration of Salmonella bacteria in 400 ml of buffered peptone water after 6 h of incubation of chicken parts as a function of the initial log number of Salmonella bacteria inoculated onto chicken parts were developed and used to enumerate Salmonella bacteria. Standard curves were not affected by the type of chicken part but did differ (P < 0.05) among the five isolates of Salmonella examined. Consequently, Salmonella bacteria were enumerated on naturally contaminated chicken parts using a standard curve developed with the serotype of Salmonella that was isolated from the original sample. The prevalence of contamination was 3 % (4 of 132), whereas the incidence of cross-contamination was 1.8 % (1 of 57). The positive chicken parts were a thigh from chicken 4, which contained 3 CFU of Salmonella enterica serotype Kentucky, and both wings, one thigh, and one cooked breast portion from chicken 15, which all contained 1 CFU of serotype 8,20:-:z(6). These results indicated that the poultry industry is providing consumers in the studied area with chicken that has a low prevalence and low number of Salmonella bacteria at retail and that has a low incidence and low level of cross-contamination of cooked chicken with Salmonella from raw chicken during meal preparation under a worst-case scenario.

Cold atmospheric gas plasma disinfection of chicken meat and chicken skin contaminated with Listeria innocua

Gas plasmas generated at atmospheric pressure and ambient temperatures offer a possible decontamination method for poultry products. The efficacy of cold atmospheric gas plasmas for decontaminating chicken skin and muscle inoculated with Listeria innocua was examined. Optimization of operating conditions for maximal bacterial inactivation was first achieved using membrane filters on which L. innocua had been deposited. Higher values of AC voltage, excitation frequency and the presence of oxygen in the carrier gas resulted in the greatest inactivation efficiency, and this was confirmed with further studies on chicken muscle and skin. Under optimal conditions, a 10 s treatment gave > 3 log reductions of L. innocua on membrane filters, an 8 min treatment gave 1 log reduction on skin, and a 4 min treatment gave > 3 log reductions on muscle. These results show that the efficacy of gas plasma treatment is greatly affected by surface topography. Scanning electron microscopy (SEM) images of chicken muscle and skin revealed surface features wherein bacteria could effectively be protected from the chemical species generated within the gas plasma. The developments in gas plasma technology necessary for its commercial application to foods are discussed.

Qualitative map of Salmonella contamination on young chicken carcasses

Salmonella contamination of poultry is a global public health problem. The objective of this study was to map the distribution of Salmonella on the young chicken carcass, to improve poultry inspection and food safety. Young chickens (n = 70) in the Cornish game hen class were obtained at retail over a 3-year period. Carcasses were aseptically sectioned into 12 parts, and then Salmonella was isolated from whole-part incubations by conventional culture methods. Isolates were characterized for serotype and antibiotic resistance, and by pulsed-field gel electrophoresis (PFGE). Salmonella incidence was 21.5% (181 of 840) for parts and 57.1% (40 of 70) for carcasses. The number of contaminated parts per carcass ranged from 0 to 12, with a mean of 4.5 among contaminated carcasses. Chi-square analysis indicated that Salmonella incidence differed (P < 0.05) among parts, with rib back (38.6%) and sacral back (34.3%) being the most contaminated. Among the 40 contaminated carcasses, there were 37 different patterns of contamination among parts. Of the 33 carcasses with more than one contaminated part, 12.1% contained two serotypes, 33.3% contained two or more antibiotic resistance profiles, and 100% contained two or more PFGE patterns. The most common serotype was Typhimurium (94.5%), and most (97.2%) isolates were resistant to multiple antibiotics. These results indicated a diverse pattern of Salmonella contamination among carcasses and that multiple subtypes of Salmonella were often present on contaminated carcasses. Thus, whole-carcass incubation succeeded by characterization of multiple isolates per carcass is needed to properly assess and manage this risk to public health.

Decisive role of structure in food microbial colonization and implications for predictive microbiology

Predictive models must consider the significant effect of the physical structure of the food on the magnitude and type of microbial growth. Before such models are developed, a thorough characterization of the food structure is mandatory because this information will determine the modeling approach. In this work, several physical structures common in poultry products were classified and described. Chicken breast skin and flesh and minced breasts were examined by scanning electron microscopy and compared with a meat-based model food. Such systems were surface or internally inoculated with Listeria innocua and incubated at 25 degrees C for 24 h. Different structures, including several substructures, found in the studied systems affected microbial distribution and growth. Based on these experimental findings, the most suitable type of model for each physical structure was determined. This information provides further clarification for predictive microbiology models.

Decontamination of chicken skin surfaces inoculated with Listeria innocua, Salmonella enteritidis and Campylobacter jejuni by contact with a concentrated lactic acid solution

1. The aim was to establish how poultry skin could be efficiently decontaminated without changing its organoleptic properties. 2. Chicken skins were surface inoculated with Listeria innocua and treated with different acid solutions (2 and 10% lactic acid for 1 and 30 min). Surviving bacteria were enumerated immediately after treatment and after 7 d storage at 4 degrees C. 3. Reductions of up to 2.6 log were reached immediately after treatment. The treatment effect persisted for 7 d storage, when the reduction exceeded 4.59 log for the strongest treatment. 4. Residual levels of lactic acid were not significantly higher than in untreated controls, except for the strongest treatment. A tasting panel found no significant difference between controls and samples. 5. After the initial results, an apparently optimal treatment (5% lactic acid for 1 min) was applied on chicken skins' surface inoculated with a mix of Listeria innocua, Salmonella enteritidis and Campylobacter jejuni. Treatment efficacy was assessed immediately after treatment and after 1, 4 and 7 d storage. 6. This treatment seems to be very promising from a food processing standpoint, being fast and allowing decimal reductions of 2.00 log for Listeria innocua and 2.38 log for Salmonella enteritidis after 7 d storage, neither significantly increasing skin lactic acid nor causing any organoleptic modifications to the product. The effect of the treatment is significant after one day storage for Listeria innocua and after 4 d storage for Salmonella enteritidis.

An approach for mapping the number and distribution of Salmonella contamination on the poultry carcass

Mapping the number and distribution of Salmonella on poultry carcasses will help guide better design of processing procedures to reduce or eliminate this human pathogen from poultry. A selective plating media with multiple antibiotics (xylose-lysine agar medium [XL] containing N-(2-hydroxyethyl)piperazine-N'-(2-ethanesulfonic acid) and the antibiotics chloramphenicol, ampicillin, tetracycline, and streptomycin [XLH-CATS]) and a multiple-antibiotic-resistant strain (ATCC 700408) of Salmonella Typhimurium definitive phage type 104 (DT104) were used to develop an enumeration method for mapping the number and distribution of Salmonella Typhimurium DT104 on the carcasses of young chickens in the Cornish game hen class. The enumeration method was based on the concept that the time to detection by drop plating on XLH-CATS during incubation of whole chicken parts in buffered peptone water would be inversely related to the initial log number (N0) of Salmonella Typhimurium DT104 on the chicken part. The sampling plan for mapping involved dividing the chicken into 12 parts, which ranged in average size from 36 to 80 g. To develop the enumeration method, whole parts were spot inoculated with 0 to 6 log Salmonella Typhimurium DT104, incubated in 300 ml of buffered peptone water, and detected on XLH-CATS by drop plating. An inverse relationship between detection time on XLH-CATS and N0 was found (r = -0.984). The standard curve was similar for the individual chicken parts and therefore, a single standard curve for all 12 chicken parts was developed. The final standard curve, which contained a 95% prediction interval for providing stochastic results for N0, had high goodness of fit (r2 = 0.968) and was N0 (log) = 7.78 +/- 0.61 - (0.995 x detention time). Ninety-five percent of N0 were within +/- 0.61 log of the standard curve. The enumeration method and sampling plan will be used in future studies to map changes in the number and distribution of Salmonella on carcasses of young chickens fed the DT104 strain used in standard curve development and subjected to different processing procedures.

Bacterial biofilms within the clinical setting: what healthcare professionals should know

Bacterial biofilm formation is the prevailing microbial lifestyle in natural and manmade environments and occurs on all surface types. Biofilm formation develops in several phases and is influenced by various parameters, both environmental and inherent to the attaching cell. Biofilms also serve as protective niches for particular pathogens when outside a host. Although it is accepted that biofilms are ubiquitous in nature, the significance of biofilms in clinical settings, especially with regard to their role in medical-related infections, is often underestimated. It has been found that several aspects of human pathogenesis within a clinical context are directly related to biofilm development. Various types of surfaces in clinical settings are prone to biofilm development and an increased risk of disease may be a direct consequence of their formation. This review describes the process of biofilm formation, highlights the importance of bacterial associations with surfaces in clinical settings and describes various methods for biofilm visualization and control.

Bacteria recovery from genetically feathered and featherless broiler carcasses after immersion chilling

Feathered and featherless (scaleless) sibling broilers were reared and processed together to evaluate the influence of feathers and feather follicles on carcass bacteria recovery after chilling. In each experiment, broilers were inoculated 1 wk prior to processing by oral gavage with a suspension of salmonellae or Campylobacter at 106 cells/mL. Broilers were stunned and bled, and carcasses were single-tank or triple-tank scalded, defeathered, eviscerated, and washed. Carcasses were chilled for 45 min in ice and water immersion chillers with or without 20 mg of chlorine/L added. Postchill carcass rinsates were evaluated for Escherichia coli, coliforms, total aerobes, and salmonellae or Campylobacter. Following processing and immersion chilling, genetically featherless carcasses had slightly higher counts (by log10 0.35 cfu/100 mL of carcass rinsate) for E. coli, coliforms, and total aerobes than feathered carcasses. However, there were no significant differences in the prevalence of salmonellae (25%) or Campylobacter (93%) between feathered and featherless carcasses. Recovery of E. coli, coliforms, and total aerobic bacteria were lower for carcasses that were single-tank scalded, and following enrichment, salmonellae were recovered from fewer carcasses subjected to the single-tank (71%) than triple-tank (86%) scalding. Addition of chlorine to chiller water significantly decreased carcass bacteria recovery (by log10 0.43 cfu/100 mL of carcass rinsate) for E. coli, coliforms, total aerobes, and Campylobacter but did not affect salmonellae recovery. The presence of feathers and feather follicles during processing and immersion chilling appears to have minimal influence on the recovery of salmonellae or Campylobacter from carcasses sampled after immersion chilling.

Impact of feathers and feather follicles on broiler carcass bacteria

Genetically featherless and feathered broiler siblings were used to test the contribution of feathers and feather follicles to the numbers of aerobic bacteria, Escherichia coli, and Campylobacter in whole-carcass rinse samples taken immediately after carcasses were defeathered for 30 or 60 s. Numbers of spoilage bacteria were counted after the same fully processed carcasses were stored for 1 wk at 2 degrees C. In each of 3 replications, twenty-eight 11-wk-old, mixed-sex, genetically featherless or feathered broilers were processed in a laboratory processing facility. Immediately after individual defeathering in a mechanical picker, carcasses were sampled using a carcass rinse technique. Carcasses were eviscerated, immersion chilled at 2 degrees C for 30 min, individually bagged, and stored for 1 wk at 2 degrees C, after which all carcasses were rinsed again, and spoilage bacteria in the rinsate were enumerated. There were no significant differences (P < or = 0.05) between the featherless and feathered broilers in numbers of aerobic bacteria, E. coli, and Campylobacter in rinse samples taken immediately after defeathering and no differences between carcasses picked for 30 or 60 s. There were no differences in numbers of spoilage bacteria after 1 wk of refrigeration for any of the feather presence-picking length combinations. Although the defeathering step in poultry processing has been identified as an opportunity for bacterial contamination from the intestinal tract and cross-contamination between carcasses, the presence of feathers and feather follicles does not make a significant difference in carcass bacterial contamination immediately after defeathering or in spoilage bacteria after 1 wk of refrigeration.

Bacterial recovery from breast skin of genetically feathered and featherless broiler carcasses immediately following scalding and picking

Genetically feathered and featherless sibling broilers selected for matched BW were killed, scalded, and defeathered to determine the consequences of feathers and empty feather follicles on the recovery of bacteria from carcass breast skin. In trial 1, the vents of all carcasses were plugged and sutured before scalding to prevent the expulsion of cloacal contents during picking. In trial 2, half of the carcasses had their vents plugged and sutured. Immediately after defeathering, breast skin was aseptically removed, and bacteria associated with it were enumerated. In trial 1, the levels of bacteria recovered did not differ between feathered and featherless carcasses: Campylobacter log10 1.4 cfu/mL of rinse, coliform log10 1.8, Escherichia coli log10 1.6, and total aerobic bacteria log10 3.1. In trial 2, the carcasses that had vents plugged and sutured had lower levels of all four types of bacteria (differences of Campylobacter log10 0.7 cfu/mL, coliform log10 1.8, E. coli log10 1.7, and total aerobic bacteria log10 0.5) than those carcasses with open vents. The lower levels of bacteria recovered from carcasses with the vents plugged and sutured during picking enabled detection of small but significant differences between feathered and featherless carcasses. The level of coliform and E. coli recovered was slightly higher by log10 0.7 cfu for feathered carcasses, but featherless carcasses had marginally higher levels of total aerobic bacteria by log10 0.4 cfu. Feathered and featherless carcasses with open vents during picking did not differ in the levels of recovery of coliform, E. coli, and total aerobic bacteria from breast skin.

Direct microscopic observation and viability determination of Campylobacter jejuni on chicken skin

A method was developed to determine the survival of Campylobacter jejuni at specific sites on chicken skin, and this method was used to observe the survival of C. jejuni at various locations on the skin during storage. This method uses confocal scanning laser microscopy to visualize C. jejuni transformed with P(c)gfp plasmid (GFP-Campylobacter) and stained with 5-cyano-2,3-ditolyl tetrazolium chloride (CTC). The green fluorescence of dead C. jejuni cells and the red fluorescent CTC-formazan in viable Campylobacter cells were clearly visible on chicken skin. The GFP-Campylobacter remaining on the chicken skin surface after rinsing was mostly located in crevices, entrapped inside feather follicles with water, and entrapped in the surface water layer. Most viable cells were entrapped with water in the skin crevices and feather follicles. These sites provide a suitable microenvironment for GFP-Campylobacter to survive. The population of C. jejuni on chicken skin decreased by 1 log unit during storage at 25 degrees C for 24 h. C. jejuni located in sites 20 to 30 microm beneath the chicken skin surface maintained viability during incubation at 25 degrees C. C. jejuni on chicken skin stored at 4 degrees C maintained constant numbers during a 72-h incubation with no significant changes in population feather follicles or crevices. Live and dead cells were initially retained with water on the skin and penetrated into the skin follicles and channels during storage. Microscopic observations of GFP-producing cells allowed the identification of survival niches for C. jejuni present on chicken skin.

Confocal microscopy and microbial viability detection for food research

Confocal microscopy offers several advantages over other conventional microscopic techniques as a tool for studying the interaction of bacteria with food and the role of food microstructure in product quality and safety. When using confocal microscopy, samples can be observed without extensive preparation processes, which allows for the evaluation of food without introducing artifacts. In addition, observations can be made in three dimensions without physically sectioning the specimen. The confocal microscope can be used to follow changes over a period of time, such as the development of the food structure or changes in microbial population during a process. Microbial attachment to and detachment from food and food contact surfaces with complex three-dimensional (3-D) structures can be observed in situ. The fate of microbial populations in food system depends on processing, distribution, and storage conditions as well as decontamination procedures that are applied to inactivate and remove them. The ability to determine the physiological status of microorganisms without disrupting their physical relationship with a food system can be useful for determining the means by which microorganisms survive decontamination treatments. Conventional culturing techniques can detect viable cells; however, these techniques lack the ability to locate viable cells in respect to the microscopic structures of food. Various microscopic methods take advantage of physiological changes in bacterial cells that are associated with the viability to assess the physiologic status of individual cells while retaining the ability to locate the cell within a food tissue system. This paper reviews the application of confocal microscopy in food research and direct observation of viable bacteria with emphasis on their use in food microbiology.

Real-time monitoring of Escherichia coli O157:H7 adherence to beef carcass surface tissues with a bioluminescent reporter

A method for studying bacteria that are attached to carcass surfaces would eliminate the need for exogenous sampling and would facilitate understanding the interaction of potential human food-borne pathogens with food animal tissue surfaces. We describe such a method in which we used a bioluminescent reporter strain of Escherichia coli O157:H7 that was constructed by transformation with plasmid pCGLS1, an expression vector that contains a complete bacterial luciferase (lux) operon. Beef carcass surface tissues were inoculated with the bioluminescent strain, and adherent bacteria were visualized in real time by using a sensitive photon-counting camera to obtain in situ images. The reporter strain was found to luminesce from the tissue surfaces whether it was inoculated as a suspension in buffer or as a suspension in a bovine fecal slurry. With this method, areas of tissues inoculated with the reporter strain could be studied without obtaining, excising, homogenizing, and culturing multiple samples from the tissue surface. Use of the complete lux operon as the bioluminescent reporter eliminated the need to add exogenous substrate. This allowed detection and quantitation of bacterial inocula and rapid evaluation of adherence of a potential human pathogen to tissue surfaces. Following simple water rinses of inoculated carcass tissues, the attachment duration varied with different carcass surface types. On average, the percent retention of bioluminescent signal from the reporter strain was higher on lean fascia-covered tissue (54%) than on adipose fascia-covered tissue (18%) following water washing of the tissues. Bioluminescence and culture-derived viable bacterial counts were highly correlated (r2 = 0.98). Real-time assessment of microbial attachment to this complex menstruum should facilitate evaluation of carcass decontamination procedures and mechanistic studies of microbial contamination of beef carcass tissues.