Thin‐layer drying of sadabahar ( Catharanthus roseus ) leaves using different drying techniques and fate of bioactive compounds

Assessment of microwave drying for rapid and convenient analysis of medicinal plants for quality assurance

INTRODUCTION

The safety and quality of many medicinally important herbs are compromised since farmers and small organizations are involved in the cultivation, aggregation, and primary processing of these herbs. Such organizations often lack adequate quality control facilities. To improve the safety and quality of herbal products, simple, rapid, and affordable quality control systems are required.

OBJECTIVES

The aim of this study was to assess the suitability of microwave oven-drying for moisture content (MC) determination and sample preparation of herbs in small organizations.

METHODS

Microwave oven-drying (720 W) and convective oven-drying at 105°C for MC determination were compared. The effects of three different drying methods (microwave oven-drying, low-temperature convective drying, and freeze-drying) on in vitro antioxidant and polyphenol oxidase (PPO) activity were determined, similarity analysis was conducted using HPLC signature spectra, and validation was performed with LC-MS focusing on one herb.

RESULTS

Microwave oven-drying at 720 W significantly reduced the drying time (from hours to minutes), whereas the spatial variation of temperature in convective ovens set at 105°C can cause about 10% underestimation of MC. Microwave oven-drying showed similar macro-properties like freeze-drying and higher extractability (10%-20%) and in vitro antioxidant capacity (33%-66%) and lower PPO activity compared to low-temperature convective drying. HPLC signature spectra revealed strong similarity of soluble components between freeze-dried and microwave oven-dried herbs. LC-MS analysis demonstrated more common compounds between freeze-dried and microwave oven-dried Centella asiatica extracts, whereas convective tray-dried samples had fewer compounds common with samples obtained by freeze-drying or microwave oven-drying.

CONCLUSIONS

Microwave oven-drying is rapid (tens of min) and shows small batch-to-batch variation compared to oven-drying at 105°C. The in vitro antioxidant assays and signature spectra can be used for assessing the source and purity or quality of a specific herb variety.

Effect of dielectric barrier discharge (DBD) cold plasma-activated water pre-treatment on the drying properties, kinetic parameters, and physicochemical and functional properties of Centella asiatica leaves

Centella asiatica L. (CA) is a medicinal plant that gained significant commercial and research interest because of its bioactive compounds, which have functional properties such as antioxidant activity. However, it must be dried before use to improve its shelf life and prepare it for food and pharmaceutical applications. Therefore, in this investigation CA leaves were pre-treated with blanching and cold plasma activated water (CPAW), followed by recirculatory hot air and vacuum drying at 40, 50, and 60 °C. Vacuum-drying took 150-720 min, while hot-air drying took 60-180 min to dry. Page and Logarithmic models best fit for leaf drying kinetics, according to AIC, with R² between 0.966 and 0.999 and RMSE between 0.001 and 0.069. CPAW pre-treatment increased leaf quality more than blanching in vacuum drying. Drying leaves at 40 °C boosted antioxidants (4021.462 μg TE (g dw)^-1 and 3.356 mg GAEAC (g dw)^-1), TPC (35.049 mg GAE (g dw)^-1), and TFC (311.274 mg QE (g dw)^-1) and is recommended. Vacuum-drying with CPAW pre-treatment preserved leaf microstructure better than hot-air drying. This study illuminates CA leaf drying behaviour and allow mass production without damaging bioactive components. These results could be used as a roadmap for future technological advances that will make it possible to use the bioactive components of CA in food formulation.