Evaluation of the safety and efficacy of a new hemostatic powder using a quantitative surface bleeding severity scale

Proof-of-principle of a lung sealant based on functionalized polyoxazolines: experiments in an ovine acute aerostasis model

OBJECTIVES

More effective lung sealants are needed to prevent prolonged pulmonary air leakage (AL). Polyoxazoline-impregnated gelatin patch (N-hydroxysuccinimide ester functionalized poly(2-oxazoline)s; NHS-POx) was promising for lung sealing ex vivo. The aim of this study is to confirm sealing effectiveness in an in vivo model of lung injury.

METHODS

An acute aerostasis model was used in healthy adult female sheep, involving bilateral thoracotomy, amputation lesions (bronchioles Ø > 1.5 mm), sealant application, digital chest tube for monitoring AL, spontaneous ventilation, obduction and bursting pressure measurement. Two experiments were performed: (i) 3 sheep with 2 lesions per lung (N = 4 NHS-POx double-layer, N = 4 NHS-POx single-layer, N = 4 untreated) and (ii) 3 with 1 lesion per lung (N = 3 NHS-POx single-layer, N = 3 untreated). In pooled linear regression, AL was analysed per lung (N = 7 NHS-POx, N = 5 untreated) and bursting pressure per lesion (N = 11 NHS-POx, N = 7 untreated).

RESULTS

Baseline AL was similar between groups (mean 1.38-1.47 l/min, P = 0.90). NHS-POx achieved sealing in 1 attempt in 8/11 (72.7%) and in 10/11 (90.9%) in >1 attempt. Application failures were only observed on triangular lesions requiring 3 folds around the lung. No influences of methodological variation between experiments was detected in linear regression (P > 0.9). AL over initial 3 h of drainage was significantly reduced for NHS-POx [median: 7 ml/min, length of interquartile range: 333 ml/min] versus untreated lesions (367 ml/min, length of interquartile range: 680 ml/min, P = 0.036). Bursting pressure was higher for NHS-POx (mean: 33, SD: 16 cmH2O) versus untreated lesions (mean: 19, SD: 15 cmH2O, P = 0.081).

CONCLUSIONS

NHS-POx was effective for reducing early AL, and a trend was seen for improvement of bursting strength of the covered defect. Results were affected by application characteristics and lesion geometry.

Thrombin and Thrombin-Incorporated Biomaterials for Disease Treatments

Thrombin, a coagulation-inducing protease, has long been used in the hemostatic field. During the past decades, many other therapeutic uses of thrombin have been developed. For instance, burn treatment, pseudoaneurysm therapy, wound management, and tumor vascular infarction (or tumor vasculature blockade therapy) can all utilize the unique and powerful function of thrombin. Based on their therapeutic effects, many thrombin-associated products have been certificated by the Food and Drug Administration, including bovine thrombin, human thrombin, recombinant thrombin, fibrin glue, etc. Besides, several thrombin-based drugs are currently undergoing clinical trials. In this article, the therapeutic uses of thrombin (from the initial hemostasis to the latest cancer therapy), the commercially available drugs associated with thrombin, and the pros and cons of thrombin-based therapeutics (e.g., adverse immune responses related to bovine thrombin, thromboinflammation, and vasculogenic "rebounds") are summarized. Further, the current challenges and possible future research directions of thrombin-incorporated biomaterials and therapies are discussed. It is hoped that this review may provide a valuable reference for researchers in this field and help them to design safer and more effective thrombin-based drugs for fighting against various intractable diseases.

The Use of Hemostatic Agents to Decrease Bleeding Complications in Breast Cancer Surgery

INTRODUCTION

Following breast cancer surgery, patients often require adjuvant radiation and chemotherapy for locoregional and systemic disease control. These procedures may result in postoperative complications, which may delay adjuvant therapy. To potentially decrease these complications, hemostatic agents may be used. This study evaluated the rate of postoperative bleeding complications and duration of Jackson-Pratt (JP) drain use in oncologic breast surgery with and without hemostatic agents.

METHODS

After obtaining institutional review board approval, a retrospective chart review was performed. Patients who underwent oncoplastic breast surgery, mastectomy with or without expander/implant-based reconstruction, and subsequent reconstruction with expander to implant exchange were included. Data collected included indication for surgery, type of operation, use of hemostatic agent, specifically fibrin sealant (FS, EVICEL^®, Ethicon, USA) or combination powder (CP, HEMOBLAST^™ Bellows, biom'up, France), length of follow-up, time to JP drain removal, and post-operative complications (seroma, hematoma, or operating room (OR) takeback). This was a consecutive experience where initially no hemostatic agent was used, followed by use of FS, and then CP.

RESULTS

The use of a hemostatic agent resulted in fewer bleeding complications and significantly decreased time until JP drain removal. Although not significant, subgroup analysis demonstrated that this was more pronounced in the CP group. JP drain duration was decreased among all procedures for CP compared to FS.

CONCLUSIONS

The use of hemostatic agents in oncologic breast surgery may result in decreased postoperative complications and significantly reduce time to JP drain removal.

Will Renorrhaphy Become Obsolete? Evaluation of a New Hemostatic Sealant

Background: In robot-assisted partial nephrectomy (RAPN) renorrhaphy is used to achieve hemostatic control of the tumoral resection bed, with detrimental impact on renal function. Hemostatic agents are used to achieve rapid and optimal hemostasis. GATT-Patch is a new hemostatic sealant that has already demonstrated promising results. Objective: Compare GATT-Patch and standard renorrhaphy in terms of hemostatic capacity, ischemia time, and prevention of urinary leakage after RAPN in a porcine model. Design, Setting, and Participants: In this preclinical randomized controlled trial, four pigs underwent 32 RAPNs. After resection, GATT-Patch application and performance of classic renorrhaphy were randomized. After the procedure, the resection bed was reinspected. A necropsy study evaluated the adhesiveness of the patch, and retrograde pyelography was performed to determine the leakage burst pressure. Intervention: Application of GATT-Patch and performance of classic renorrhaphy were randomized and surgeons blinded to the hemostatic technique to be performed. Outcome Measurements and Statistical Analysis: Warm ischemia, hemostatic control, active bleeding during hemostatic control, total procedure time, bleeding at reinspection, and presence of urinary leakage on retrograde pyelography were recorded. Continuous variables were compared using the Student t-test. Categorical variables were compared using the Chi-square or Fisher's exact test. Results and Limitations: GATT-Patch reduced warm ischemia time (WIT), time to achieve hemostatic control, active bleeding time, and total procedure time, achieving hemostasis in 100% of the cases. Rebleeding at reinspection occurred in 0% of the GATT-Patch group. Renal parenchyma damage was observed in 100% of renorrhaphy cases and in 0% of GATT-Patch cases. Conclusions: GATT-Patch guaranteed optimal hemostasis and urine sealant effect after RAPN in porcine models. Compared to renorrhaphy, we observed a reduction in WIT, total procedure time, and potential reduction in healthy parenchyma loss. Patient Summary: GATT-Patch stops bleeding and provides hemostasis faster than suturing after resection of portions of the kidney in pigs. It might be tested in patients undergoing partial nephrectomy for kidney cancer.

The Use of Hemostatic Agents to Decrease Bleeding Complications in General Plastic Surgery Procedures

Within plastic surgery, hematomas and seromas are frequently reported complications that can negatively impact wound healing and result in significant morbidity in patients. As a result, there has been considerable interest in hemostatic agents to complement traditional methods of hemostasis. The purpose of this study was to evaluate postoperative bleeding complications and duration of Jackson-Pratt (JP) drain use in general plastic surgery procedures with and without hemostatic agents.

Evaluation of the Safety and Efficacy of a Novel Thrombin Containing Combination Hemostatic Powder Using a Historical Control

This clinical study compares 2 hemostatic agents, a novel combination powder (CP) (HEMOBLAST^™ Bellows) and an established polysaccharide starch powder (PP) (Arista^™ AH) to assess the usefulness of CP. Retrospective comparative analysis of CP (July 2018 to July 2019, 68 patients) to PP (January 2011 to January 2013, 94 patients) in cardiothoracic patients was performed using linear regression models adjusting for age, sex, and procedure type for the endpoints: blood loss; protamine to skin closure time (hemostasis time); chest tube output and blood products required 48 hours postoperatively; ICU stay; postoperative comorbidities; and 30 day mortality. 162 patients (108 M: 54 F) underwent 162 cardiothoracic surgical procedures including: transplantation (n = 44), placement of ventricular assist device (n = 87), and others (n = 31). Use of CP compared to PP (Estimated Mean Difference [95% CI], P-value) produced significant reductions: blood loss (mL) (-886.51 [-1457.76, -312.26], P = 0.003); protamine to skin closure time (min) (-16.81 [-28.03, -5.59], P = 0.004); chest tube output (48 hrs, mL) (-445.76 [-669.38, -222.14], P < 0.001); packed red blood cell transfusions (units) (-0.98 [-1.56, -0.4], P = 0.001); and postoperative comorbidities (-0.31 [-0.55, -0.07], P = 0.012). There were no differences in the ICU stay (4.07 [-2.01, 10.15], P = 0.188) or 30-day mortality (0.57 [0.20, 1.63], P = 0.291). The use of CP in complex cardiothoracic operations resulted in improved hemostasis and significant clinical benefits in blood loss, transfusion requirements, morbidity, and time in operating room.

Rapid Hemostatic Biomaterial from a Natural Bath Sponge Skeleton

Uncontrolled bleeding is the main cause of mortality from trauma. Collagen has been developed as an important hemostatic material due to its platelet affinity function. A bath sponge skeleton is rich in collagen, also known as spongin. To understand the hemostatic effect of spongin, spongin materials, SX, SFM and SR were prepared from the bath sponge Spongia officinalis, and hemostatic experiments were performed. The SX, SFM and SR were significantly better than the positive control, type I collagen, in shortening the whole blood clotting time in vitro and hemostasis upon rat tail amputation. In a hemostatic experiment of rabbit common carotid artery injury, the hemostatic time and 3 h survival rate of the SFM group were 3.00 ± 1.53 min and 100%, respectively, which are significantly better than those of the commercial hemostat CELOX-A (10.33 ± 1.37 min and 67%, respectively). Additionally, the SFM showed good coagulation effects in platelet-deficient blood and defibrinated blood, while also showing good biocompatibility. Through a variety of tests, we speculated that the hemostatic activity of the SFM is mainly caused by its hyperabsorbency, high affinity to platelets and high effective concentration. Overall, the SFM and spongin derivates could be potential hemostatic agents for uncontrolled bleeding and hemorrhagic diseases caused by deficiency or dysfunction of coagulation factors.

Evaluation of the Hemostatic Efficacy of Two Powdered Topical Absorbable Hemostats Using a Porcine Liver Abrasion Model of Mild to Moderate Bleeding

INTRODUCTION

Topical hemostatic agents, used alone or in combination, have become common adjuncts to manage tissue and organ bleeding resulting from trauma and surgical procedures. Oxidized regenerated cellulose (ORC) is one of the most commonly used adjunctive hemostatic agents. The aim of the present study was to compare the hemostatic efficacy of a novel ORC-based product, SURGICEL® Powder Absorbable Hemostat (Surgicel-P) to that of HEMOBLAST™ Bellows (Hemoblast-B), a collagen-based combination powder.

METHODS

Using an established porcine liver abrasion model, we randomly tested Surgicel-P and Hemoblast-B in 60 experimental lesion sites (30 per product tested). Primary endpoints included hemostatic efficacy measured by absolute time to hemostasis (TTH) within 5 minutes. We also examined number of applications required to achieve hemostasis, and sustained hemostasis following saline irrigation of test sites that achieved hemostasis.

RESULTS

Surgicel-P demonstrated significantly higher hemostatic efficacy and lower TTH (p < 0.01) than Hemoblast-B. Surgicel-P-treated lesion sites achieved hemostasis in 73.3% of cases following one product application vs. 3.3% of Hemoblast-B-treated sites. Of all sites that were assessed, hemostasis was achieved and sustained following irrigation at 93.3% of Surgicel-P-treated sites vs. 50.0% of Hemoblast-B-treated sites. The average number of Surgicel-P applications per site was 51% lower than the average number of applications used for Hemoblast-B.

CONCLUSION

Surgicel-P provided more effective and sustained hemostasis and faster TTH than Hemoblast-B. Surgicel-P represents a novel clinical alternative to provide adjunctive control of diffuse mild and moderate bleeding. Surgicel-P combines an ORC powder formulation and a delivery system in a device that is particularly useful for application on large surfaces and difficult-to-access anatomical locations where application of other forms of topical hemostats may be impractical.

SPOT GRADE II: Clinical Validation of a New Method for Reproducibly Quantifying Surgical Wound Bleeding: Prospective, Multicenter, Multispecialty, Single-Arm Study

The SPOT GRADE (SG), a Surface Bleeding Severity Scale, is a unique visual method for assessing bleeding severity based on quantitative determinations of blood flow. This study assessed the reliability of the SG scale in a clinical setting and collected initial data on the safety and efficacy of HEMOBLAST Bellows (HB), a hemostatic agent, in abdominal and orthopedic operations. Twenty-seven patients were enrolled across 3 centers and received the investigational device. Bleeding severity and hemostasis were independently assessed by 2 surgical investigators at baseline and at 3, 6, and 10 minutes after application of HB and compared for agreement. The mean paired κ statistic for assignment of SG scores was .7754. The mean paired κ statistics for determining eligibility for participation in the trial based on bleeding severity and the mean paired κ statistics determining the presence of hemostasis were .9301 and .9301, respectively. The proportion of patients achieving hemostasis within 3, 6, and 10 minutes of HB application were 50.0%, 79.2%, and 91.7%, respectively. There were no unanticipated adverse device effects and one possible serious adverse device effect, as determined by the Independent Data Monitoring Committee (IDMC). The reliability of the SG scale was validated in a clinical setting. Initial data on the safety and efficacy of HB in abdominal and orthopedic operations were collected, and there were no concerns raised by the investigators or the IDMC.

Application techniques of a novel hemostat in cardiac operations: HEMOBLAST

BACKGROUND

Postoperative bleeding complications are associated with less favorable outcomes in cardiac surgery and contribute to excessive overall healthcare costs. HEMOBLAST (Biom'up, Lyon, France) (HB) is a novel ready-to-use hemostatic powder that consists of porcine collagen, bovine chondroitin sulfate, and human pooled plasma thrombin that may help reduce surgical bleeding.

AIMS

The aim of this study was to describe the techniques of application for this new combination powder-based hemostat, HB, and demonstrate its use employing photographs of application methods during cardiac procedures.

MATERIALS AND METHODS

The initial 24 procedures in which HB was used at our institution included: left ventricular assist device (LVAD) insertions, lung transplants, heart transplants, aortic valve replacements, coronary artery bypass grafting, and mitral valve repair.

RESULTS

Hemostasis was achieved in all cases and there were no instances of mediastinitis, sternal infections, allergic reactions, or 30-day mortality.

DISCUSSION

This report describes the best methods of application of HB including use for treatment of mediastinal bleeding in a re-operative procedure in a patient on antiplatelet agents and sternal bleeding during an LVAD insertion. Proper application can facilitate excellent hemostasis using this powder.

CONCLUSION

HB is a novel powder-based multiple component hemostatic agent that promotes focal or large area hemostasis. We have presented the techniques of use that are important to the successful application of HB to facilitate hemostasis.

Evaluation of a novel collagen hemostatic matrix in a porcine heart and cardiac vessel injury model

Background

Flowable hemostatic agents may be more advantageous than nonflowable hemostats, as they have capability to cover irregular wound surfaces, fill deep lesions, and easily remove excess materials with irrigation. In this study, we evaluated the hemostatic efficacy of the collagen hemostatic matrix (CHM) compared to FloSeal^® via incisions in the heart and cardiac vessels in a porcine model.

Methods

In each of the two female pigs, a total of two incisions were made in seven locations: right atrium (RA), right ventricle (RV), and cardiac vessels, such as the innominate vein (IV), superior vena cava (SVC), pulmonary artery (PA), coronary artery (CA), and aorta. Hemostatic agents were applied directly to the bleeding wounds. In certain location, one incision was treated with the CHM and the other with FloSeal^®, and the time to hemostasis and the degree of bleeding of the two agents were assessed and compared. One week after surgery, the animals were sacrificed, and specimens were collected for histologic evaluation.

Results

Bleeding from the vessels with relatively low pressure (the IV, SVC, and RA) was controlled within 1-2 minutes using both a CHM and FloSeal^®. Bleeding from the vessels with high blood pressure (the RV, PA, CA, and aorta) was controlled within 3-10 minutes with the CHM. However, hemostasis in the PA and CA was not achieved with FloSeal^®. Histological analysis revealed that the use of both the CHM and FloSeal^® resulted in foreign body reactions of similar severity.

Conclusions

The hemostatic effect and safety of the CHM may be similar to that of FloSeal^®. Further clinical studies must be conducted to validate our results.