Simple method for isolation of 4-deoxynivalenol from rice inoculated with Fusarium graminearum

Critical evaluation of indirect methods for the determination of deoxynivalenol and its conjugated forms in cereals

A critical assessment of three previously published indirect methods based on acidic hydrolysis using superacids for the determination of “free” and “total” deoxynivalenol (DON) was carried out. The modified mycotoxins DON-3-glucoside (D3G), 3-acetyl-DON (3ADON), and 15-acetyl-DON (15ADON) were chosen as model analytes. The initial experiments focused on the stability/degradation of DON under hydrolytic conditions and the ability to release DON from the modified forms. Acidic conditions that were capable of cleaving D3G, 3ADON, and 15ADON to DON were not found, raising doubts over the efficacy of previously published indirect methods for total DON determination. Validation of these indirect methods for wheat, maize, and barley using UHPLC-MS/MS was performed in order to test the accuracy of the generated results. Validation data for DON, D3G, 3ADON, and 15ADON in nonhydrolyzed and hydrolyzed matrices were obtained. Under the tested conditions, DON was not released from D3G, 3ADON, or 15ADON after hydrolysis and thus none of the published methods were able to cleave the modified forms of DON. In addition to acids, alkaline hydrolysis with KOH for an extended time and at elevated temperatures was also tested. 3ADON and 15ADON were cleaved under the alkaline pH caused by the addition of KOH or aqueous K₂CO₃ to “neutralize” the acidic sample extracts in the published studies. The published additional DON increase after hydrolysis may have been caused by huge differences in matrix effects and the recovery of DON in nonhydrolyzed and hydrolyzed matrices as well as by the alkaline cleavage of 3ADON or 15ADON after the neutralization of hydrolyzed extracts.

Biosynthesis, isolation, purification and seperation of Zearalenone, deoxynivalenol and 15-Acetyldeoxynivalenol

Fusarium graminearum KF-376 isolate was found to be able to form simultaneously three toxic metabolites: zearalenone (FF-2), deoxynivalenol (DON) and 15-acetyldeoxynivalenol (15-AcDON). Toxins were extracted with methanol - water 3:1 (v/v) and purified by liquid chromatography on charcoal - Kieselgel 60 column (preliminary) and Aluminiumoxid 90 column. Final separation of the metabolites was achived on Kieselgel 60 - Aluminiumoxid 90 column.

Isolation and determination of deoxynivalenol by reversed-phase high-pressure liquid chromatography

Deoxynivalenol (DON) is a mycotoxin produced by food contamination. It is a pharmacologically active compound that acts on the serotonin receptor, leading to several neuroendocrine and hematological disorders. In this article we describe a simple, accurate, and sensitive method for the quantification of DON. DON was quantified using a Phenomenex(®) ODS analytical C18 column (150 mm × 46 mm, 5 μm) with a mobile phase composed of mixture of water-acetonitrile-methanol (5:4:1, v/v/v) at a flow rate of 1.5 ml/min and at 254 nm in an ultraviolet (UV) detector The method has been validated with isolated samples of DON and provides a tool for the control of substandard and counterfeit commercial food products.

Purification of deoxynivalenol from Fusarium graminearum rice culture and mouldy corn by high-speed counter-current chromatography

Deoxynivalenol (DON) is a mycotoxin produced by several Fusarium species and is toxic to a wide range of organisms, including human beings and livestock. To produce large amounts of pure DON for research purposes, a novel method using high-speed counter-current chromatography (HSCCC) was developed. Rice cultured with Fusarium graminearum and field mouldy corn infected by F. graminearum were extracted with methanol and found to contain 1.16 and 1.30 mg DON/g, respectively. The extracts were concentrated and then separated using a biphasic solvent system consisting of ethyl acetate-water (1:1, v/v). Collected fractions were analyzed by high-performance liquid chromatography (HPLC) and identified by congruent retention time and UV/vis spectrum and mass spectrometric data. Fractions containing DON were combined and freeze-dried. This method produced 116 mg and 65 mg DON with a purity of greater than 94.9% from 200 g of the rice culture and the mouldy corn, respectively. The HSCCC method had a recovery rate of DON at 88% from the crude extracts of both samples. This one-step purification method provided a simple and effective tool for obtaining a large amount of DON, an essential material for studies related to toxicology and detoxification of this mycotoxin.

Toxic Alterations in Chick Embryonic Liver and Spleen by Acute Exposure to Fusarium-Producing Mycotoxin Deoxynivalenol

Food mycotoxin deoxynivalenol (vomitoxin, DON) produced by Fusarium graminearum and F. culmorum can induce rapid diminution of lymphoid tissues and lymphopenia in the growing chickens and mammals. We first investigated the direct acute effects of DON on the chick immune-related embryo tissues such as embryonic liver and spleen. Direct DON administration into the embryonic eggs caused toxin accumulation in liver in a time-dependent manner. Electron microscopic observation showed a notable accumulation of fat droplet in the liver tissue and the re-exposed hatched chicken showed more distinguishing enlarged fat globules, so-called fatty cysts like human steatosis. Regarding effects of deoxynivalenol on the chick embryonic spleen, fatty change was also observed in splenocytes. Functionally, mitogen-stimulated cellular and humoral lympho-proliferations were suppressed in the DON-treated embryo. Conclusively, acute direct exposure to deoxynivalenol in the chick embryo caused toxic histological alterations in the liver and spleen and suppressed in vitro lymphoblastogenesis.

Natural occurrence of Fusarium mycotoxins in field samples from the 1992 Wisconsin corn crop

Analysis of 98 moldy corn samples collected in Wisconsin between November 1992 and January 1993 for Fusarium toxins by various immunochemical assays revealed overall average mycotoxin concentrations of 305.6, 237.7, and 904.3 ng/g for type A trichothecenes (TCTCs), deoxynivalenol (DON)-related type B TCTCs (total DON), and zearalenone (ZE), respectively. A small portion (5.1%) of the samples was found to be contaminated with high levels ( > 1 microgram/g) of type A TCTCs and total DON during the whole survey. Over 40% of the samples had 100 to 1,000 ng of total DON per g, while 17% of the samples had the same levels of type A TCTCs. The analytical data were consistent with those from mycological examinations for the samples in which various toxic Fusarium spp., including F. sporotrichioides, F. poae, and F. graminearum, were found. The samples received in November 1992 had relatively low concentrations of toxin; the average levels of type A TCTCs and total DON were 9.9 and 79 ng/g, respectively. The toxin concentrations became progressively higher in the samples received in December. The average levels for the type A TCTCs and total DON increased to 920 and 335 ng/g, respectively. However, the levels of ZE were higher in the samples collected earlier. The average levels for samples collected in November and late December were 1,195 and 242 ng/g, respectively. Analysis of selected samples by high-performance liquid chromatography monitoring with an enzyme-linked immunosorbent assay revealed that T-2 toxin, HT-2 toxin, diacetoxyscirpenol, neosolaniol, and T-2 tetraol (T-2-4ol) were common in these samples. Statistical analysis revealed a weak correlation between the levels of total type A TCTCs and total DON in the samples (r = 0.18, P = 0.09), but a strong correlation between the levels of ZE and total type B TCTCs (r = 0.75, P < 0.0001) was found. The mycotoxin levels of total type A TCTCs, total DON-related type B TCTCs, and ZE in the cobs (5.2, 3.9, and 21 micrograms/g, respectively) were considerably higher than those in the kernels (1.0, 0.5, and 0.5 microgram/g, respectively). The type A toxin levels increased from a range of 14 to 35 ng/g to a range of 110 to 538 ng/g after the moldy corn samples were held at 5 degrees C for 8 days in the laboratory.

Production and characterization of antibodies against nivalenol tetraacetate

Antibody against nivalenol tetraacetate (tetra-Ac-NIV) was prepared by immunization of rabbits with triacetyl-15-pimelate-NIV conjugated to bovine serum albumin. By using tritiated tetra-Ac-NIV as the test ligand, antibody titers were demonstrated as early as 4 weeks after immunization. Useful antibody for radioimmunoassay (RIA) of tetra-Ac-NIV was obtained 7 weeks after immunization, with one booster injection. Results of competitive RIA revealed that the antibody was most specific to tetra-Ac-NIV. The relative cross-reactivity of this antibody with tetra-Ac-NIV, deoxynivalenol triacetate, and neosolaniol triacetate was found to be 100, 2.2, and less than 1, respectively. Practically no cross-reaction was found with deoxynivalenol, fusarenon X, and NIV. The detection limit for tetra-Ac-NIV by RIA was about 5.0 ng/ml (0.5 ng per assay). The use of this antibody for quantitation of NIV in cereals after acetylation of sample extracts is proposed.

Preparation of scirpentriol and triacetoxyscirpenol in good yield from cultures of Fusarium sambucinum NRRL 13495

Crude extracts of filtrates of cultures of Fusarium sambucinum NRRL 13495 were acetylated or hydrolyzed. After chromatography on cartridge columns of silica gel and recrystallization three times from mixtures of ethyl acetate and hexane, 3,4,15-triacetoxyscirpenol (435 +/- 10 mg/liter of filtrate; mean +/- standard error [n = 3]) and the parent alcohol scirpentriol were isolated (261 +/- 29 mg/liter of filtrate; mean +/- standard error [n = 3]) in 68 and 53% yield for a 130- and 14-fold improvement, respectively, over prior reports.

Production and characterization of antibodies against HT-2 toxin and T-2 tetraol tetraacetate

Three new immunogens which were prepared by conjugation of the carboxymethyl oxime (CMO) derivatives of HT-2 toxin, T-2 tetraol (T-2 4ol), and T-2 tetraol tetraacetate (T-2 4Ac) to bovine serum albumin (BSA) were tested for the production of antibodies against the major metabolites of T-2 toxin. Antibodies against HT-2 toxin and T-2 4Ac were obtained from rabbits 5 to 10 weeks after immunizing the animals with CMO-HT-2-BSA and CMO-T-2 4Ac-BSA conjugates. Immunization with CMO-T-2 4ol-BSA resulted in no antibody against T-2 4ol. The antibody produced against HT-2 toxin had great affinity for HT-2 toxin as well as good cross-reactivity with T-2 toxin. The relative cross-reactivities of anti-HT-2 toxin antibody with HT-2 toxin, T-2 toxin, iso-T-2 toxin, acetyl-T-2 toxin, 3'-OH HT-2, 3'-OH T-2, T-2 triol, and 3'-OH acetyl-T-2, were 100, 25, 10, 3.3, 0.25, 0.15, 0.12 and 0.08%, respectively. Antibody against CMO-T-2 4Ac was very specific for T-2 4Ac and had less than 0.1% cross-reactivity with T-2 toxin, HT-2 toxin, acetyl-T-2 toxin, diacetoxyscirpenol, deoxynivalenol, and deoxynivalenol triacetate as compared with T-2 4Ac. The detection limits for HT-2 toxin and T-2 4ol by radioimmunoassay were approximately 0.1 and 0.5 ng per assay, respectively.

Improved method for production of antibodies against T-2 toxin and diacetoxyscirpenol in rabbits

A new, improved approach for the production of antibodies against T-2 toxin and diacetoxyscirpenol (DAS) was developed. The method involves the use of immunogens which were prepared by conjugating O-carboxymethoxyl oxime (CMO) derivatives of both toxins to bovine serum albumin (BSA). Isomers a and b of CMO-T-2 toxin and isomer b of CMO-DAS were tested. Antibodies against both toxins were demonstrated as early as 4 weeks after immunization. a-CMO-T-2-BSA conjugate was a better immunogen than the b isomer, and the highest titers (6,000) were reached 14 weeks after immunization and one booster injection. Antibody titers for rabbits immunized with the b isomer of CMO-T-2 never reached more than 2,000. The specificity of antibodies obtained from rabbits after immunization with CMO-T-2-BSA was similar to that of hemisuccinate-T-2-BSA. Anti-b-T-2 antibodies had slightly higher cross-reactivity with H-T-2 toxin than did the antibody obtained from rabbits immunized with the conjugate of the a isomer. The relative cross-reactivities of anti-a-CMO-T-2 antibody with T-2, acetyl-T-2, H-T-2, T-2-triol, 3'-OH-T-2, and T-2 tetraol were 1, 4.5, 5.7, 250, 500, and 3,000, respectively. The relative cross-reactivities of anti-b-T-2 antibody with T-2, acetyl-T-2, H-T-2, and T-2 triol were 1, 2, 3, and 488, respectively. Antibodies against b-CMO-DAS showed a high degree of cross-reactivity with monoacetoxyscirpenols (MAS). The relative cross-reactivities of anti-B-DAS antibody with DAS, 4-MAS, 15-MAS, acetyl-deoxynivalenol, T-2-toxin, acetyl-T-2, and neosolaniol were 1, 4, 5, 76, 107, 147, and 266, respectively.(ABSTRACT TRUNCATED AT 250 WORDS)

Thin-layer chromatography of mycotoxins

TLC has become an extremely powerful, rapid and in most instances inexpensive separation technique in mycotoxicology. This review presents achievements of its applications in this field. General technical aspects of the TLC of mycotoxins that are discussed include extraction and clean-up procedures, adsorbents and solvent systems, detection methods, two-dimensional TLC, high-performance TLC (HPTLC), quantitation and preparative TLC (PLC). Special applications of TLC deal with multi-mycotoxin analyses and with structurally related or individual mycotoxins (aflatoxins, sterigmatocystins, versicolorins, ochratoxins, rubratoxins, patulin, penicillic acid, mycophenolic acid, butenolide, citreoviridin, trichothecenes, cytochalasans, tremorgenic toxins, epipolythiopiperazine-3,6-diones, hydroxyanthraquinones, zearalenone, citrinin, secalonic acids, cyclopiazonic acid, PR toxin, roquefortine, xanthomegnin, viomellein and naphtho-gamma-pyrones).