Purification and some properties of carbon monoxide dehydrogenase from Acinetobacter sp. strain JC1 DSM 3803

Two-stage conversion of syngas and pyrolysis aqueous condensate into L-malate

Hybrid thermochemical-biological processes have the potential to enhance the carbon and energy recovery from organic waste. This work aimed to assess the carbon and energy recovery potential of multifunctional processes to simultaneously sequestrate syngas and detoxify pyrolysis aqueous condensate (PAC) for short-chain carboxylates production. To evaluate relevant process parameters for mixed culture co-fermentation of syngas and PAC, two identical reactors were run under mesophilic (37 °C) and thermophilic (55 °C) conditions at increasing PAC loading rates. Both the mesophilic and the thermophilic process recovered at least 50% of the energy in syngas and PAC into short-chain carboxylates. During the mesophilic syngas and PAC co-fermentation, methanogenesis was completely inhibited while acetate, ethanol and butyrate were the primary metabolites. Over 90% of the amplicon sequencing variants based on 16S rRNA were assigned to Clostridium sensu stricto 12. During the thermophilic process, on the other hand, Symbiobacteriales, Syntrophaceticus, Thermoanaerobacterium, Methanothermobacter and Methanosarcina likely played crucial roles in aromatics degradation and methanogenesis, respectively, while Moorella thermoacetica and Methanothermobacter marburgensis were the predominant carboxydotrophs in the thermophilic process. High biomass concentrations were necessary to maintain stable process operations at high PAC loads. In a second-stage reactor, Aspergillus oryzae converted acetate, propionate and butyrate from the first stage into L-malate, confirming the successful detoxification of PAC below inhibitory levels. The highest L-malate yield was 0.26 ± 2.2 molL-malate/molcarboxylates recorded for effluent from the mesophilic process at a PAC load of 4% v/v. The results highlight the potential of multifunctional reactors where anaerobic mixed cultures perform simultaneously diverse process roles, such as carbon fixation, wastewater detoxification and carboxylates intermediate production. The recovered energy in the form of intermediate carboxylates allows for their use as substrates in subsequent fermentative stages.

Identification and characterization of the genes encoding carbon monoxide dehydrogenase in Terrabacter carboxydivorans

Terrabacter carboxydivorans is able to grow aerobically at low concentrations of carbon monoxide (CO) as a sole source of carbon and energy. The genes for carbon monoxide dehydrogenase (CO-DH) were cloned from T. carboxydivorans and analyzed. The operon encoding T. carboxydivorans CO-DH was composed of three structural genes with the transcriptional order of cutB, cutC and cutA, as well as an additional accessory gene (orf4). Phylogenetic analysis of CutA revealed that T. carboxydivorans CO-DH was classified into a group distinct from previously characterized CO-DHs. Expression of antisense RNA for the cutB or cutA gene in T. carboxydivorans led to a decrease in CO-DH activity, confirming that cutBCA genes are the functional genes encoding CO-DH. The CO-DH operon was expressed even in the absence of CO and further inducible by CO. In addition, CO-DH synthesis was increased in the stationary phase compared to the exponential phase during heterotrophic growth on glucose and glycerol. Point mutations of a partially inverted repeat sequence (TCGGA-N₆-GCCCA) in the upstream region of the cutB gene almost abolished expression of the CO-DH operon, indicating that the inverted-repeat sequence might be a cis-acting regulatory site for the positive regulation of the CO-DH operon.

Microbiology and genetics of CO utilization in mycobacteria

Although extensive studies on the oxidation of carbon monoxide (CO) in aerobic carboxydotrophic bacteria have been carried out for over 30 years, utilization of CO as a source of carbon and energy by mycobacteria was recognized only recently. Studies on pathogenic and nonpathogenic mycobacteria have revealed that the basis for CO utilization in these bacteria is different in many aspects from that of other aerobic carboxydobacteria. We review the basis for CO utilization in mycobacterial carboxydobacteria, which is unique from physiological, biochemical, molecular, genetic and phylogenetic points of view.

Identification of trans- and cis-control elements involved in regulation of the carbon monoxide dehydrogenase genes in Mycobacterium sp. strain JC1 DSM 3803

The cutR gene was identified 314 bp upstream of the divergently oriented cutB1C1A1 operon encoding carbon monoxide (CO) dehydrogenase in Mycobacterium sp. strain JC1. Its deduced product was composed of 320 amino acid residues with a calculated molecular mass of 34.1 kDa and exhibits a basal sequence similarity to the regulatory proteins belonging to the LysR family. Using a cutR deletion mutant, it was demonstrated that CutR is required for the efficient utilization of CO by Mycobacterium sp. strain JC1 growing with CO as the sole source of carbon and energy. CutR served as a transcriptional activator for expression of the duplicated cutBCA operons (cutB1C1A1 and cutB2C2A2) and was involved in the induction of the cutBCA operons by CO. The cutBCA operons were also subjected to catabolite repression. An inverted repeat sequence (TGTGA-N(6)-TCACA) with a perfect match with the binding motif of cyclic AMP receptor protein was identified immediately upstream of and overlapping with the translational start codons of cutB1 and cutB2. This palindrome sequence was shown to be involved in catabolite repression of the cutBCA operons. The transcription start point of cutR was determined to be the nucleotide G located 36 bp upstream of the start codon of cutR. Expression of cutR was higher in Mycobacterium sp. strain JC1 grown with glucose than that grown with CO.

Cloning and expression analysis of the duplicated genes for carbon monoxide dehydrogenase of Mycobacterium sp. strain JC1 DSM 3803

Carbon monoxide dehydrogenase (CO-DH) is an enzyme catalysing the oxidation of CO to carbon dioxide in Mycobacterium sp. strain JC1 DSM 3803. Cloning of the genes encoding CO-DH from the bacterium and sequencing of overlapping clones revealed the presence of duplicated sets of genes for three subunits of the enzyme, cutB1C1A1 and cutB2C2A2, in operons, and a cluster of genes encoding proteins that may be involved in CO metabolism, including a possible transcriptional regulator. Phylogenetic analysis based on the amino acid sequences of large subunits of CO-DH suggested that the CO-DHs of Mycobacterium sp. JC1 and other mycobacteria are distinct from those of other types of bacteria. The growth phenotype of mutant strains lacking cutA genes and of a corresponding complemented strain showed that both of the duplicated sets of CO-DH genes were functional in this bacterium. Transcriptional fusions of the cutB genes with lacZ revealed that the cutBCA operons were expressed regardless of the presence of CO and were further inducible by CO. Primer extension analysis indicated two promoters, one expressed in the absence of CO and the other induced in the presence of CO. This is believed to be the first report to show the presence of multiple copies of CO-DH genes with identical sequences and in close proximity in carboxydobacteria, and to present the genetic evidence for the function of the genes in mycobacteria.

Cloning, expression and characterization of the catalase-peroxidase (KatG) gene from a fast-growing Mycobacterium sp. strain JC1 DSM 3803

The gene encoding a catalase-peroxidase (KatG) was cloned from chromosomal DNA of a fast-growing Mycobacterium sp. strain JC1 DSM 3803. The nucleotide sequence of a 5.7 kb EcoRI fragment containing the katG and its flanking regions was determined. The fragment (5,706 bps) contained two complete open reading frames (ORFs) encoding putative ferric uptake regulator A (FurA) and KatG proteins. The cloned gene, katG, had an ORF of 2241 nt, encoding a protein with calculated molecular mass of 81,748 Da. The furA was located in the upstream of the katG with the same transcriptional direction and there was a 38 bp gap space between them. The deduced KatG and FurA protein sequences showed significant homologies to KatG2 and Fur2 of Mycobacterium smegmatis and clustered with other mycobacterial KatG and Fur-like proteins in phylogenetic trees, respectively. The recombinant KatG overproduced in Escherichia coli was nearly indistinguishable from the native JC1 catalase-peroxidase in enzymatic properties and also possessed the resistance to organic solvents, indicating that the cloned katG truly encodes the Mycobacterium sp. JC1 catalase-peroxidase. Difference spectroscopy revealed Mn(II) binding near the haem of the KatG. Transcript analysis of the furA-katG using RT-PCR suggests that the katG is independently transcribed from the furA.

Purification and characterization of a copper-containing amine oxidase from Mycobacterium sp. strain JC1 DSM 3803 grown on benzylamine

A bacterial semicarbazide-sensitive amine oxidase (SSAO) was purified and characterized from Mycobacterium sp. strain JC1 DSM 3803 grown on benzylamine. During the purification procedures, the enzyme was tending to aggregate and exhibited heterogeneity in native PAGE. The heterogeneous forms having amine oxidase (AO) activity could be separated by their native molecular weights using gel-filtration chromatography. Most of the AOs behaved as dimers (M(r) 150,000) composed of a 75-kDa subunit, but some aggregated to form tetramers (M(r) 300,000). Besides their native molecular weight, subunit composition and V(max) value, both forms (dimer and tetramer) have almost identical biochemical properties (e.g. subunit size, optimum pH and temperature, activation energy, K(m) value on benzylamine, substrate and inhibitor specificities). When AO activity was observed by activity staining, the best-oxidized substrate was benzylamine, although the AO also oxidized tyramine and histamine. The AO was strongly inhibited by semicarbazide and isoniazid, but KCN did not affect its activity. The purified enzyme was shown to contain 2.39 mol of copper per mole of subunit, but there were no evidences of topaquinone co-factor involvement, when tested by absorption spectrum analysis and redox-cycling staining for quinoprotein detection.

Cloning, characterization and expression of a gene encoding dihydroxyacetone synthase in Mycobacterium sp. strain JC1 DSM 3803

Dihydroxyacetone synthase (DHAS) is a key enzyme involved in the assimilation of methanol in Mycobacterium sp. strain JC1 DSM 3803. The structural gene encoding DHAS in Mycobacterium sp. strain JC1 was cloned using random-primed probes synthesized after PCR with synthetic primers based on the amino acid sequences conserved in two yeast DHASs and several transketolases. The cloned gene, dasS, had an ORF of 2193 nt, encoding a protein with a calculated molecular mass of 78,197 Da. The deduced amino acid sequence of dasS contained an internal sequence of Mycobacterium sp. strain JC1 DHAS and exhibited 29.2 and 27.3 % identity with those of Candida boidinii and Hansenula polymorpha enzymes, respectively. Escherichia coli transformed with the cloned gene produced a novel protein with a molecular mass of approximately 78 kDa, which cross-reacted with anti-DHAS antiserum and exhibited DHAS activity. Primer-extension analysis revealed that the transcriptional start site of the gene was the nucleotide A located 31 bp upstream from the dasS start codon. RT-PCR showed that dasS was transcribed as a monocistronic message. Northern hybridization and beta-galactosidase assay with the putative promoter region of dasS revealed that the gene was transcribed only in cells growing on methanol. The expression of dasS in Mycobacterium sp. strain JC1 was free from catabolite repression.

Carbon monoxide dehydrogenase in mycobacteria possesses a nitric oxide dehydrogenase activity

CO dehydrogenase (CO-DH) catalyzes the oxidation of CO to CO(2) in carboxydobacteria. Cell-free extracts prepared from several mycobacteria, including Mycobacterium tuberculosis H37Ra, showed NO dehydrogenase (NO-DH) activity in a reaction mixture containing sodium nitroprusside (SNP) as the source of NO. The association of the NO-DH activity with CO-DH was revealed by activity staining and confirmed by enzyme assay with purified CO-DH from Mycobacterium sp. strain JC1, a carboxydotrophic mycobacterium. SNP stimulated the production of CO-DH with a coincidental increase in NO-DH activity in the bacterium, further supporting this association and implying the existence of a possible SNP-induced CO-DH gene expression. The addition of purified CO-DH to cultures of Escherichia coli revealed that the enzyme protected E. coli from SNP-induced killing in a dose-dependant way. The present results indicate that mycobacterial CO-DH also acts as a NO-DH, which may function in the protection of mycobacterial pathogens from nitrosative stress during infection.

Growth of mycobacteria on carbon monoxide and methanol

Several mycobacterial strains, such as Mycobacterium flavescens, Mycobacterium gastri, Mycobacterium neoaurum, Mycobacterium parafortuitum, Mycobacterium peregrinum, Mycobacterium phlei, Mycobacterium smegmatis, Mycobacterium tuberculosis, and Mycobacterium vaccae, were found to grow on carbon monoxide (CO) as the sole source of carbon and energy. These bacteria, except for M. tuberculosis, also utilized methanol as the sole carbon and energy source. A CO dehydrogenase (CO-DH) assay, staining by activity of CO-DH, and Western blot analysis using an antibody raised against CO-DH of Mycobacterium sp. strain JC1 (formerly Acinetobacter sp. strain JC1 [J. W. Cho, H. S. Yim, and Y. M. Kim, Kor. J. Microbiol. 23:1-8, 1985]) revealed that CO-DH is present in extracts of the bacteria prepared from cells grown on CO. Ribulose bisphosphate carboxylase/oxygenase (RubisCO) activity was also detected in extracts prepared from all cells, except M. tuberculosis, grown on CO. The mycobacteria grown on methanol, except for M. gastri, which showed hexulose phosphate synthase activity, did not exhibit activities of classic methanol dehydrogenase, hydroxypyruvate reductase, or hexulose phosphate synthase but exhibited N,N-dimethyl-4-nitrosoaniline-dependent methanol dehydrogenase and RuBisCO activities. Cells grown on methanol were also found to have dihydroxyacetone synthase. Double immunodiffusion revealed that the antigenic sites of CO-DHs, RuBisCOs, and dihydroxyacetone synthases in all mycobacteria tested are identical with those of the Mycobacterium sp. strain JC1 enzymes.

Selenium-dependent metabolism of purines: A selenium-dependent purine hydroxylase and xanthine dehydrogenase were purified from Clostridium purinolyticum and characterized

During purification of the selenium-dependent xanthine dehydrogenase (XDH) from Clostridium purinolyticum, another hydroxylase was uncovered that also contained selenium and exhibited similar spectral properties. This enzyme was purified to homogeneity. It uses purine, 2OH-purine, and hypoxanthine as substrates, and based on its substrate specificity, this selenoenzyme is termed purine hydroxylase (PH). The product of hydroxylation of purine by PH is xanthine. A concomitant release of selenium from the enzyme and loss of catalytic activity on treatment with cyanide indicates that selenium is essential for PH activity. Selenium-dependent XDH, also purified from C. purinolyticum, was found to be insensitive to oxygen during purification and to use both potassium ferricyanide and 2,6-dichloroindophenol as electron acceptors. Selenium is required for the xanthine-dependent reduction of 2, 6-dichloroindophenol by XDH. Kinetic analyses of both enzymes revealed that xanthine is the preferred substrate for XDH and purine and hypoxanthine are preferred by PH. This characterization of these selenium-requiring hydroxylases involved in the interconversion of purines describes an extension of the pathway for purine fermentation in the purinolytic clostridia.

Cloning and molecular characterization of the genes for carbon monoxide dehydrogenase and localization of molybdopterin, flavin adenine dinucleotide, and iron-sulfur centers in the enzyme of Hydrogenophaga pseudoflava

Carbon monoxide dehydrogenases (CO-DH) are the enzymes responsible for the oxidation of CO to carbon dioxide in carboxydobacteria and consist of three nonidentical subunits containing molybdopterin flavin adenine dinucleotide (FAD), and two different iron-sulfur clusters (O. Meyer, K. Frunzke, D. Gadkari, S. Jacobitz, I. Hugendieck, and M. Kraut, FEMS Microbiol. Rev. 87:253-260, 1990). The three structural genes of CO-DH in Hydrogenophaga pseudoflava were cloned and characterized. The genes were clustered on the chromosome in the transcriptional order cutM-cutS-cutL. The cloned cutM, cutS, and cutL genes had open reading frames of 864, 492, and 2,412 nucleotides, coding for proteins with calculated molecular weights of 30,694, 17,752, and 87,224, respectively. The overall identities in the nucleotide sequence of the genes and the amino acid sequence of the subunits with those of other carboxydobacteria were 64.5 to 74.3% and 62.8 to 72.3%, respectively. Primer extension analysis revealed that the transcriptional start site of the genes was the nucleotide G located 47 bp upstream of the cutM start codon. The deduced amino acid sequences of the three subunits of CO-DH implied the presence of molybdenum cofactor, FAD, and iron-sulfur centers in CutL, CutM, and CutS, respectively. Fluorometric analysis coupled with denaturing polyacrylamide gel electrophoresis of fractions from hydroxyapatite column chromatography in the presence of 8 M urea of active CO-DH and from gel filtration of spontaneously inactivated enzyme revealed that the large and medium subunits of CO-DH in H. pseudoflava bind molybdopterin and FAD cofactors, respectively. Iron-sulfur centers of the enzyme were identified to be present in the small subunit on the basis of the iron content in each subunit eluted from the denaturing polyacrylamide gels.

The structural genes encoding CO dehydrogenase subunits (cox L, M and S) in Pseudomonas carboxydovorans OM5 reside on plasmid pHCG3 and are, with the exception of Streptomyces thermoautotrophicus, conserved in carboxydotrophic bacteria

Employing deoxyoligonucleotide probes and Southern hybridizations, we have examined in carboxydotrophic bacteria the localization on the genome of genes encoding the large, medium and small subunits of CO dehydrogenase (coxL, M and S, respectively). In Pseudomonas carboxydovorans OM5 coxL, M and S were identified on the plasmid pHCG3; they were absent on the chromosome. This was evident from positive hybridizations with plasmid DNA of the wild-type strain OM5 and the absence of hybridizations with chromosomal DNA from the plasmid cured mutant strain OM5-12. The genes coxL, M and S were found on plasmids in all other plasmid-containing carboxydotrophic bacteria e.g. Alcaligenes carboxydus, Azomonas B1, Pseudomonas carboxydoflava, Pseudomonas carboxydovorans OM2 and OM4. Cox L, M and S could be identified on the chromosome of the plasmid-free bacteria Arthrobacter 11/x, Bacillus schlegelii, Pseudomonas carboxydohydrogena, and Pseudomonas carboxydovorans OM3. These results essentially confirm and extend former reports that cox genes are rather conserved among carboxydotrophic bacteria of distinct taxonomic position. However, Streptomyces thermoautotrophicus is an noteworthy exception since none of the three cox genes could be detected. This refers to a new type of CO dehydrogenase and is in accord with results indicating that the S. thermoautotrophicus CO dehydrogenase has an unusual electron acceptor specificity and some other properties setting it apart from the 'classical' CO dehydrogenases.

Xanthine dehydrogenase and 2-furoyl-coenzyme A dehydrogenase from Pseudomonas putida Fu1: two molybdenum-containing dehydrogenases of novel structural composition

The constitutive xanthine dehydrogenase and the inducible 2-furoyl-coenzyme A (CoA) dehydrogenase could be labeled with [185W]tungstate. This labeling was used as a reporter to purify both labile proteins. The radioactivity cochromatographed predominantly with the residual enzymatic activity of both enzymes during the first purification steps. Both radioactive proteins were separated and purified to homogeneity. Antibodies raised against the larger protein also exhibited cross-reactivity toward the second smaller protein and removed xanthine dehydrogenase and 2-furoyl-CoA dehydrogenase activity up to 80 and 60% from the supernatant of cell extracts, respectively. With use of cell extract, Western immunoblots showed only two bands which correlated exactly with the activity stains for both enzymes after native polyacrylamide gel electrophoresis. Molybdate was absolutely required for incorporation of 185W, formation of cross-reacting material, and enzymatic activity. The latter parameters showed a perfect correlation. This evidence proves that the radioactive proteins were actually xanthine dehydrogenase and 2-furoyl-CoA dehydrogenase. The apparent molecular weight of the native xanthine dehydrogenase was about 300,000, and that of 2-furoyl-CoA dehydrogenase was 150,000. Sodium dodecyl sulfate-polyacrylamide gel electrophoresis of both enzymes revealed two protein bands corresponding to molecular weights of 55,000 and 25,000. The xanthine dehydrogenase contained at least 1.6 mol of molybdenum, 0.9 ml of cytochrome b, 5.8 mol of iron, and 2.4 mol of labile sulfur per mol of enzyme. The composition of the 2-furoyl-CoA dehydrogenase seemed to be similar, although the stoichiometry was not determined. The oxidation of furfuryl alcohol to furfural and further to 2-furoic acid by Pseudomonas putida Fu1 was catalyzed by two different dehydrogenases.

Carbon monoxide dehydrogenase inhibitor in cell extracts of Pseudomonas carboxydovorans

Extracts of heterotrophically grown cells of Pseudomonas carboxydovorans were found to contain an inhibitor of carbon monoxide dehydrogenase (CO-DH). The inhibitor activity was not detected in CO-autotrophically grown cells. The inhibitor was extremely stable to heat treatment based on the extent of inhibition of CO-DH activity. The extent of inhibition was proportional to the amount of cell extract added to the reaction mixture. The inhibition was independent of a prior incubation period of the extracts with CO-DH. The inhibitor was precipitable with ammonium sulfate, phenol, and trichloroacetic acid. It was passed through benzoylated dialysis tubing and Amicon ultrafiltration membrane YM2. Denaturing and nondenturing polyacrylamide gel electrophoresis of CO-DH inactivated by inhibitor revealed that the mobilities of native enzyme and subunits were identical to those of active CO-DH. The inhibitor-treated CO-DH retained its original antigenic sites and exhibited enzyme activity upon activity staining. The CO-DH inhibitor of P. carboxydovorans was also active on CO-DHs from Pseudomonas carboxydohydrogena, Acinetobacter sp. strain JC1, and Pseudomonas carboxydoflava.

Homology and distribution of CO dehydrogenase structural genes in carboxydotrophic bacteria

The 17 (S), 30 (M) and 87 kDa (L) subunits of CO dehydrogenases from the CO-oxidizing bacteria Pseudomonas carboxydoflava, Pseudomonas carboxydohydrogena and Pseudomonas carboxydovorans OM5 were isolated and purified. The N-terminal sequences of same subunits from different bacteria showed distinct homologies. Dot blot hybridization employing oligonucleotide probes derived from the sequences of the S-subunit of P. carboxydovorans OM5 and the M-subunit of P. carboxydohydrogena and DNA of the plasmid-containing CO-oxidizing bacteria Alcaligenes carboxydus, Azomonas B1, P. carboxydoflava, P. carboxydovorans OM2, OM4 and OM5 indicated that all genes encoding these subunits reside on plasmids. That in P. carboxydovorans OM5 CO dehydrogenase structural genes are located entirely on plasmid pHCG3 was evident from the absence of hybridization employing DNA from the cured mutant strain OM5-12. CO dehydrogenase structural genes could be identified on the chromosome of the plasmid-free bacteria Arthrobacter 11/x, Bacillus schlegelii, P. carboxydohydrogena and P. carboxydovorans OM3. There was no example of a plasmid-harboring carboxydotrophic bacterium that did not carry CO dehydrogenase structural genes on the plasmid. The N-terminal sequences of CO dehydrogenase structural genes were found to be conserved among carboxydotrophic bacteria of distinct taxonomic position, independent of the presence of plasmids. It is discussed whether this might be the consequence of horizontal gene transfer.