Effects of radiation pasteurization on Salmonella. I. Parameters affecting survival an recovery from chicken

Survival of Salmonella typhimurium ATCC 14028 on the surface of chicken legs or in mechanically deboned chicken meat gamma irradiated in air or vacuum at temperatures of -20 to +20 C

Response-surface methodology was used to develop predictive equations for the response of Salmonella typhimurium ATCC 14028 on the surface of chicken legs or within mechanically deboned chicken meat (MDCM) to the effects of gamma radiation doses of 0 to 3.60 kGy (100 krad = 1 kGy) at temperatures of -20 to +20 C in air or vacuum. A streptomycin-resistant mutant was used in these studies to allow accurate estimations of the surviving salmonellae in the presence of residual normal flora. This strain has been demonstrated to have no significant shift in its biological properties nor in its resistance to ionizing radiation. The response of S. typhimurium to gamma radiation was similar on both chicken legs and MDCM. The radiation was significantly more lethal to the bacterial cells at temperatures above freezing. The response-surface equations developed from the studies predict that the number of viable cells per gram of MDCM or per square centimeter of the surface of chicken legs would be reduced approximately 2.8 to 5.1 log units at 0 C by radiation doses within the range of 1.5 to 3.0 kGy. The results of the present studies are similar to those obtained previously with sterile mechanically deboned chicken meat.

Effect of ionizing radiation dose, temperature, and atmosphere on the survival of Salmonella typhimurium in sterile, mechanically deboned chicken meat

The response to gamma radiation (0 to 3.60 kGy; 100 krad = 1 kGy) of Salmonella typhimurium was tested in otherwise sterile, mechanically deboned chicken meat (MDCM) in the absence of competing microflora. Response was determined at temperatures of -20 to +20 C and when the MDCM was packaged in vacuum or in the presence of air. A central composite response-surface design was used to test the response of the pathogen to the treatments in a single experiment. Predictive equations were developed from the analyses of variances of the resulting data. The accuracy of each predictive equation was tested by further studies of the effects of gamma radiation on S. typhimurium in the presence or absence of air at -20, 0, and +20 C. All data were then analyzed to refine the predictive equations further. Both the original and the refined equations adequately predicted the response of S. typhimurium in MDCM to gamma radiation doses up to 3.60 kGy in the presence of air or in vacuo. Gamma irradiation was significantly more lethal for S. typhimurium in the presence of air and at higher temperatures. The final equations predict a reduction in the number of surviving Salmonella in MDCM irradiated to 1.50 kGy at -20 C of 2.53 logs in air or 2.12 logs if irradiated in vacuum. If the contaminated MDCM were to receive a dose of 3.0 kGy at -20 C in air, the number of Salmonella would be decreased by 4.78 logs, and if irradiated in vacuum, by 4.29 logs.(ABSTRACT TRUNCATED AT 250 WORDS)

Inactivation and injury of Yersinia enterocolitica by radiation and freezing

Cell inactivation and cell injury by irradiation and freezing of the potentially enteropathogenic, food-borne gram-negative rod Yersinia enterocolitica strain WA was investigated. The radiation dose necessary to kill 90% of the initial population, i.e., one D-value, was 10.0, 14,3, and 24.0 krad when irradiation was carried out at 2 to 0, -18, and -75 degrees C, respectively. On the other hand, cell injury, i.e., inability to form colonies in agar containing 2.5% NaCl, was 32, 42 and 54% when cells were irradiated to one D-value at 2 to 0, -18, and -75 degrees C, respectively. Freezing alone (without irradiation) at -18 and -75 degrees C for 1 h resulted in 7 and 42% cell inactivation and 55 and 83% cell injury, respectively. These data show that given the same extent of cell inactivation, freezing caused substantially greater cell injury than radiation. For purposes of radiation sterilization, doses of 100 and 150 krad would be sufficient to inactivate 10 log cycles of Y. enterocolitica strain WA if irradiated at 2 to 0 and -18 degrees C, respectively. Presence of 2.5% NaCl may result in a further 50% reduction of the dose required to achieve sterility.

Radiation resistance and injury of Yersinia enterocolitica

The D values of Yersinia enterocolitica strains IP134, IP107, and WA, irradiated at 25 degrees C in Trypticase soy broth, ranged from 9.7 to 11.8 krad. When irradiated in ground beef at 25 and -30 degrees C, the D value of strain IP107 was 19.5 and 38.8 krad, respectively. Cells suspended in Trypticase soy broth were more sensitive to storage at -20 degrees C than those mixed in ground beef. The percentages of inactivation and of injury (inability to form colonies in the presence of 3.0% NaCl) of cells stored in ground beef for 10 days at -20 degrees C were 70 and 23%, respectively. Prior irradiation did not alter the cell's sensitivity to storage at -20 degrees C, nor did storage at -20 degrees C alter the cell's resistance to irradiation at 25 degrees C. Added NaCl concentrations of up to 4.0% in Trypticase soy agar (TSA) (which contains 0.5% NaCl) had little effect on colony formation at 36 degrees C of unirradiated Y. enterocolitica. With added 4.0% NaCl, 79% of the cells formed colonies at 36 degrees C; with 5.0% NaCl added, no colonies were formed. Although 2.5% NaCl added to ground beef did not sensitize Y. enterocolitica cells to irradiation, when added to TSA it reduced the number of apparent radiation survivors. Cells uninjured by irradiation formed colonies on TSA when incubated at either 36 or 5 degrees C. More survivors of an exposure to 60 krad were capable of recovery and forming colonies on TSA when incubated at 36 degrees C for 1 day than at 5 degrees C for 14 days. This difference in count was considered a manifestation of injury to certain survivors of irradiation.