Bi-national survey of intraoperative cuff pressure monitoring of endotracheal tubes and supraglottic airway devices in operating theatres

Pressure changes in the endotracheal tube cuff in otorhinolaryngologic surgery: a prospective observational study

Objective

Inflation of the endotracheal tube cuff is needed for providing ventilation. Cuff pressure should be maintained inside the appropriate range to prevent critical airway complications. The purpose of this study is to evaluate the pressure changes in the endotracheal tube cuff during otorhinolaryngologic surgery.

Design and method

This single-center observational study was conducted at Severance Hospital in Korea between April 2020 and November 2020. Patients aged >20 years scheduled to undergo otorhinolaryngological surgical procedures were enrolled. Patients undergoing planned tracheostomy and those who were slated for uncuffed endotracheal tube use were excluded. Intubation was performed after the induction of general anesthesia. A pressure transducer was connected to the pilot balloon of the endotracheal tube, and cuff pressure was continuously monitored until extubation. If the cuff pressure was not appropriate for more than 5 min, it was adjusted to the appropriate range by injecting or removing air. The percentage of time for which the cuff pressure remained within the appropriate range was calculated and defined as the time in the therapeutic range (TTR). The presumed cause for the rise or fall in cuff pressure was identified.

Results

In total 199 patients, alterations in cuff pressure outside the appropriate range occurred in 191 patients (96.0%). The mean TTR was 79.7% (SD 25.0%), and head and neck surgery had the lowest mean TTR of 69.0% compared to ear and nose surgeries (94.2 and 82.1%, respectively). Sixty-eight patients (34.2%) demonstrated inadequate endotracheal tube cuff pressure for more than 20% of the total anesthesia time. Twenty-six patients (13.1%) demonstrated optimal endotracheal tube cuff pressure for less than 50% of the total anesthesia time. The causative factors inducing inappropriate cuff pressure were found to vary, including positional changes, surgical procedure, anatomical manipulation, and anesthetic procedure.

Conclusion

In otorhinolaryngologic surgery, cuff pressure increased or decreased outside the appropriate range due to various factors. Therefore, we suggest close continuous monitoring of cuff pressure during anesthesia for otorhinolaryngologic surgery.

Clinical trial registration

clinicaltrials.gov, identifier NCT03938493.

Accuracy of pilot balloon palpation for cuff pressure assessment in small versus large sized tubes: a prospective non-randomized observational study

Pilot balloon palpation is still a commonly used method to evaluate cuff pressure of the endotracheal tube after intubation. This study determined whether the size of the tracheal tube influenced the accuracy of pilot balloon palpation. A prospective observational analysis of 208 patients intubated with an endotracheal tube of internal diameter (ID) 6.0 or 8.0 was conducted. An anesthesiologist judged the cuff pressure by manual pilot balloon palpation, and then measured the cuff pressure with a pressure gauge. Cuff pressure exceeding 20-30 cmH₂O was defined as false recognition. The intracuff pressure was significantly higher in ID 6.0 tube than in the ID 8.0 tube (41.9 ± 18.8 cmH₂O vs. 30.3 ± 11.9 cmH₂O, p < 0.001). The number of patients that were mistakenly perceived to have appropriate cuff pressure by pilot balloon palpation was significantly higher in the ID 6.0 group compared to the ID 8.0 group (85 (81.7%) vs. 64 (61.5%), p = 0.001). Therefore, a smaller tube size may further increase risk of inaccurate measurement by pilot balloon palpation and although pressure gauge is recommended for all sizes to maximize accuracy, groups with increased risk factors should be targeted for standardized use of the pressure gauge.

Knowledge and practice of tracheal tube cuff pressure monitoring: a multicenter survey of anaesthesia and critical care providers in a developing country

BACKGROUND

Tracheal tubes are routinely used during anaesthesia and in the intensive care unit. Subjective monitoring of cuff pressures have been reported to produce consistently inappropriate cuffs pressures, with attendant morbidity. But this practice of unsafe care remains widespread. With the proliferation of intensive care units in Nigeria and increasing access to surgery, morbidity relating to improper tracheal cuff pressure may assume a greater toll. We aimed to evaluate current knowledge and practice of tracheal cuff pressure monitoring among anaesthesia and critical care providers in Nigeria.

METHODS

This was a multicenter cross-sectional study conducted from March 18 to April 30, 2021. The first part (A) was conducted at 4 tertiary referral hospitals in Nigeria by means of a self-administered questionnaire on the various cadre of anaesthesia and critical care providers. The second part (B) was a nation-wide telephone survey of anaesthesia faculty fellows affiliated to 13 tertiary hospitals in Nigeria, selected by stratified random sampling.

RESULTS

Only 3.1% (6/196) of the care providers admitted having ever used a tracheal cuff manometer, while 31.1% knew the recommended tracheal cuff pressure. The nationwide telephone survey of anaesthesia faculty fellows revealed that tracheal cuff manometer is neither available, nor has it ever been used in any of the 13 tertiary hospitals surveyed. The 'Pilot balloon palpation method' and 'fixed volume of air from a syringe' were the most commonly utilized method of cuff pressure estimation by the care providers, at 64.3% and 28.1% respectively in part A survey (84.6% and 15.4% respectively, in the part B survey).

CONCLUSION

The use of tracheal cuff manometer is very limited among the care providers surveyed in this study. Knowledge regarding tracheal cuff management among the providers is adjudged to be fair, despite the poor practice and unsafe care.