Realisation and assessment of a low-cost LED device for contact lens disinfection by visible violet light

This study presents a device for efficient, low-cost and eye-friendly overnight disinfection of contact lenses by visible violet light as an alternative to disinfection with biocide-containing solutions. Bacterial solutions with one Pseudomonas and one Staphylococcus strain each were irradiated for up to 8 h in commercial transparent contact lens cases by the presented light-emitting diode (LED) device. Samples were taken at different intervals and distributed on agar plates. The surviving bacteria were determined by counting of colony-forming units and compared to the specific requirements of the stand-alone test for contact lens disinfection of the hygiene standard ISO 14729. The concentration of both microorganisms was reduced by three orders of magnitude after less than 4 h of irradiation. The LED current and intensity have not yet been at maximum and could be further increased if necessary for other microorganisms. The presented device fulfils the requirement of the stand-alone test of the contact lens hygienic standard ISO 14729 for the tested Pseudomonas and Staphylococcus strains. According to literature data, the inactivation of Serratia marcescens, Candida albicans and Fusarium solani seems also possible, but may require increased LED current and intensity.

Enhanced Biofilm Eradication and Reduced Cytotoxicity of a Novel Polygalacturonic and Caprylic Acid Wound Ointment Compared with Common Antiseptic Ointments

Antiseptic wound ointments are widely used to treat dermal wounds that are microbially contaminated. Polygalacturonic acid (PG)+caprylic acid (CAP) is a novel combination that has been shown to eradicate biofilms. We developed a novel PG+CAP ointment and compared the biofilm eradication capability and cytotoxicity of PG+CAP with that of commercially available antiseptic wound ointments. We used a well-established biofilm model to quantitatively assess the eradication of organisms following exposure to the wound ointments for 2 hours. PG+CAP ointment completely eradicated Candida albicans, multidrug-resistant Pseudomonas aeruginosa, and methicillin-resistant Staphylococcus aureus biofilms, whereas MediHoney, polyhexamethylene biguanide (PHMB), and benzalkonium chloride (BZK) ointments failed to eradicate all biofilms within 2 hours. We assessed cytotoxicity by exposing L-929 fibroblasts to extracts of each ointment; Trypan blue exclusion was used to assess cell viability, and Alamar blue conversion was used to assess metabolic function. After exposure to PG+CAP and MediHoney, fibroblast viability was 96.23% and 95.23%, respectively (Trypan blue), and was comparable to untreated cells (98.77%). PHMB and BZK showed reduced viability (83.25% and 77.83%, respectively, p < 0.05). Metabolic activity results followed a similar pattern. Cytotoxicity of PG+CAP ointment towards erythrocytes was comparable to saline. PG+CAP ointment seems to be safe and can rapidly eradicate microbial biofilm; thus, PG+CAP ointment merits further in vivo testing as a potential antimicrobial wound ointment.

Enhancement of Contact Lens Disinfection by Combining Disinfectant with Visible Light Irradiation

Multiple use contact lenses have to be disinfected overnight to reduce the risk of infections. However, several studies demonstrated that not only microorganisms are affected by the disinfectants, but also ocular epithelial cells, which come into contact via residuals at reinsertion of the lens. Visible light has been demonstrated to achieve an inactivation effect on several bacterial and fungal species. Combinations with other disinfection methods often showed better results compared to separately applied methods. We therefore investigated contact lens disinfection solutions combined with 405 nm irradiation, with the intention to reduce the disinfectant concentration of ReNu Multiplus, OptiFree Express or AOSept while maintaining adequate disinfection results due to combination benefits. Pseudomonads, staphylococci and E. coli were studied with disk diffusion assay, colony forming unit (cfu) determination and growth delay. A log reduction of 4.49 was achieved for P. fluorescens in 2 h for 40% ReNu Multiplus combined with an irradiation intensity of 20 mW/cm² at 405 nm. For AOSept the combination effect was so strong that 5% of AOSept in combination with light exhibited the same result as 100% AOSept alone. Combination of disinfectants with visible violet light is therefore considered a promising approach, as a reduction of potentially toxic ingredients can be achieved.

Adverse health effects of humidifier disinfectants in Korea: lung toxicity of polyhexamethylene guanidine phosphate

Exposure to humidifier disinfectants was identified in 2011 as the potential cause of an outbreak of lung disease in Korea. It is estimated that over 8 million people have been exposed to humidifier disinfectants-chemicals added to the water used in humidifiers to prevent the growth of microorganisms-since their commercial introduction. The primary component of humidifier disinfectant products involved was polyhexamethylene guanidine phosphate (PHMG-P), a guanidine-based antimicrobial agent. Lesions observed in the lungs of patients were similar to those observed in laboratory animals exposed to PHMG-P. In this review, we outline the physicochemical and toxicological properties of PHMG-P, and introduce a putative mechanism for its lung toxicity based in large part on research findings to date.

In vitro inflammatory effects of polyhexamethylene biguanide through NF-κB activation in A549 cells

Polyhexamethylene biguanide (PHMB) is a member of the polymeric guanidine family, which is used as a biocide and preservative in industrial, medicinal, and consumer products. Some studies reported that polyhexamethylene guanidine phosphate, which is also a member of the guanidine family, induced severe inflammation and fibrosis in the lungs. However, limited studies have evaluated the pulmonary toxicity of PHMB associated with inflammatory responses. The aim of this study was to elucidate the inflammatory responses and its mechanisms induced by PHMB in lung cells. A549 cells exposed to PHMB showed decreased viability, reactive oxygen species (ROS) generation, inflammatory cytokine secretion, and nuclear factor kappa B (NF-κB) activation. The cells showed dose-dependent cytotoxicity and slight generation of ROS. PHMB triggered inflammatory cytokine secretion and NF-κB activation by modulating the degradation of IκB-α and the accumulation of nuclear p65. TNF-α plays important roles in IL-8 expression as well as NF-κB activation. Moreover, IL-8 production induced by PHMB was completely suppressed by a NF-κB inhibitor, but not by a ROS scavenger. In conclusion, we suggest that PHMB induces the inflammatory responses via the NF-κB signaling pathway.