1
|
Degradation of P(3HB-co-4HB) Films in Simulated Body Fluids. Polymers (Basel) 2022; 14:polym14101990. [PMID: 35631874 PMCID: PMC9143980 DOI: 10.3390/polym14101990] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.5] [Reference Citation Analysis] [Abstract] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 04/06/2022] [Revised: 05/09/2022] [Accepted: 05/10/2022] [Indexed: 02/01/2023] Open
Abstract
A novel model of biodegradable PHA copolymer films preparation was applied to evaluate the biodegradability of various PHA copolymers and to discuss its biomedical applicability. In this study, we illustrate the potential biomaterial degradation rate affectability by manipulation of monomer composition via controlling the biosynthetic strategies. Within the experimental investigation, we have prepared two different copolymers of 3-hydroxybutyrate and 4-hydroxybutyrate—P(3HB-co-36 mol.% 4HB) and P(3HB-co-66 mol.% 4HB), by cultivating the thermophilic bacterial strain Aneurinibacillus sp. H1 and further investigated its degradability in simulated body fluids (SBFs). Both copolymers revealed faster weight reduction in synthetic gastric juice (SGJ) and artificial colonic fluid (ACF) than simple homopolymer P3HB. In addition, degradation mechanisms differed across tested polymers, according to SEM micrographs. While incubated in SGJ, samples were fragmented due to fast hydrolysis sourcing from substantially low pH, which suggest abiotic degradation as the major degradation mechanism. On the contrary, ACF incubation indicated obvious enzymatic hydrolysis. Further, no cytotoxicity of the waste fluids was observed on CaCO-2 cell line. Based on these results in combination with high production flexibility, we suggest P(3HB-co-4HB) copolymers produced by Aneurinibacillus sp. H1 as being very auspicious polymers for intestinal in vivo treatments.
Collapse
|
2
|
Miu DM, Eremia MC, Moscovici M. Polyhydroxyalkanoates (PHAs) as Biomaterials in Tissue Engineering: Production, Isolation, Characterization. MATERIALS 2022; 15:ma15041410. [PMID: 35207952 PMCID: PMC8875380 DOI: 10.3390/ma15041410] [Citation(s) in RCA: 8] [Impact Index Per Article: 4.0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Figures] [Subscribe] [Scholar Register] [Received: 12/10/2021] [Revised: 01/30/2022] [Accepted: 02/07/2022] [Indexed: 12/21/2022]
Abstract
Polyhydroxyalkanoates (PHAs) are biodegradable and biocompatible biopolymers. These biomaterials have grown in importance in the fields of tissue engineering and tissue reconstruction for structural applications where tissue morphology is critical, such as bone, cartilage, blood vessels, and skin, among others. Furthermore, they can be used to accelerate the regeneration in combination with drugs, as drug delivery systems, thus reducing microbial infections. When cells are cultured under stress conditions, a wide variety of microorganisms produce them as a store of intracellular energy in the form of homo- and copolymers of [R]—hydroxyalkanoic acids, depending on the carbon source used for microorganism growth. This paper gives an overview of PHAs, their biosynthetic pathways, producing microorganisms, cultivation bioprocess, isolation, purification and characterization to obtain biomaterials with medical applications such as tissue engineering.
Collapse
Affiliation(s)
- Dana-Maria Miu
- The National Institute for Chemical Pharmaceutical Research & Development, 031299 Bucharest, Romania; (D.-M.M.); (M.M.)
- Faculty of Applied Chemistry and Materials Science, University Politehnica of Bucharest, 011061 Bucharest, Romania
| | - Mihaela Carmen Eremia
- The National Institute for Chemical Pharmaceutical Research & Development, 031299 Bucharest, Romania; (D.-M.M.); (M.M.)
- Correspondence:
| | - Misu Moscovici
- The National Institute for Chemical Pharmaceutical Research & Development, 031299 Bucharest, Romania; (D.-M.M.); (M.M.)
| |
Collapse
|
3
|
Polymer pollution and its solutions with special emphasis on Poly (butylene adipate terephthalate (PBAT)). Polym Bull (Berl) 2022. [DOI: 10.1007/s00289-021-04065-2] [Citation(s) in RCA: 2] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 12/18/2022]
|
4
|
Screening and characterization of novel lipase producing Bacillus species from agricultural soil with high hydrolytic activity against PBAT poly (butylene adipate co terephthalate) co-polyesters. Polym Bull (Berl) 2022. [DOI: 10.1007/s00289-021-03992-4] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 10/19/2022]
|
5
|
Muthuraj R, Valerio O, Mekonnen TH. Recent developments in short- and medium-chain- length Polyhydroxyalkanoates: Production, properties, and applications. Int J Biol Macromol 2021; 187:422-440. [PMID: 34324901 DOI: 10.1016/j.ijbiomac.2021.07.143] [Citation(s) in RCA: 21] [Impact Index Per Article: 7.0] [Reference Citation Analysis] [Abstract] [Key Words] [Journal Information] [Subscribe] [Scholar Register] [Received: 04/29/2021] [Revised: 07/12/2021] [Accepted: 07/20/2021] [Indexed: 02/07/2023]
Abstract
Developing renewable resource-based plastics with complete biodegradability and a minimal carbon footprint can open new opportunities to effectively manage the end-of-life plastics waste and achieve a low carbon society. Polyhydroxyalkanoates (PHAs) are biobased and biodegradable thermoplastic polyesters that accumulate in microorganisms (e.g., bacterial, microalgal, and fungal species) as insoluble and inert intracellular inclusion. The PHAs recovery from microorganisms, which typically involves cell lysis, extraction, and purification, provides high molecular weight and purified polyesters that can be compounded and processed using conventional plastics converting equipment. The physio-chemical, thermal, and mechanical properties of the PHAs are comparable to traditional synthetic polymers such as polypropylene and polyethylene. As a result, it has attracted substantial applications interest in packaging, personal care, coatings, agricultural and biomedical uses. However, PHAs have certain performance limitations (e.g. slow crystallization), and substantially more expensive than many other polymers. As such, more research and development is required to enable them for extensive use. This review provides a critical review of the recent progress achieved in PHAs production using different microorganisms, downstream processing, material properties, processing avenues, recycling, aerobic and anaerobic biodegradation, and applications.
Collapse
Affiliation(s)
- Rajendran Muthuraj
- Worn Again Technologies Ltd, Bio City, Pennyfoot St, NG1 1GF Nottingham, Nottinghamshire, United Kingdom
| | - Oscar Valerio
- Departamento de Ingeniería Química, Universidad de Concepción, Concepción, Chile
| | - Tizazu H Mekonnen
- Department of Chemical Engineering, Institute of Polymer Research, Waterloo Institute for Nanotechnology, University of Waterloo, 200 University Avenue West, Waterloo, ON, Canada.
| |
Collapse
|
6
|
|
7
|
Tarazona NA, Machatschek R, Lendlein A. Unraveling the Interplay between Abiotic Hydrolytic Degradation and Crystallization of Bacterial Polyesters Comprising Short and Medium Side-Chain-Length Polyhydroxyalkanoates. Biomacromolecules 2020; 21:761-771. [PMID: 31841314 DOI: 10.1021/acs.biomac.9b01458] [Citation(s) in RCA: 6] [Impact Index Per Article: 1.5] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/30/2022]
Abstract
Polyhydroxyalkanoates (PHAs) have attracted attention as degradable (co)polyesters which can be produced by microorganisms with variations in the side chain. This structural variation influences not only the thermomechanical properties of the material but also its degradation behavior. Here, we used Langmuir monolayers at the air-water (A-W) interface as suitable models for evaluating the abiotic degradation of two PHAs with different side-chain lengths and crystallinity. By controlling the polymer state (semicrystalline, amorphous), the packing density, the pH, and the degradation mechanism, we could draw several significant conclusions. (i) The maximum degree of crystallinity for a PHA film to be efficiently degraded up to pH = 12.3 is 40%. (ii) PHA made of repeating units with shorter side-chain length are more easily hydrolyzed under alkaline conditions. The efficiency of alkaline hydrolysis decreased by about 65% when the polymer was 40% crystalline. (iii) In PHA films with a relatively high initial crystallinity, abiotic degradation initiated a chemi-crystallization phenomenon, detected as an increase in the storage modulus (E'). This could translate into an increase in brittleness and reduction in the material degradability. Finally, we demonstrate the stability of the measurement system for long-term experiments, which allows degradation conditions for polymers that could closely simulate real-time degradation.
Collapse
Affiliation(s)
- Natalia A Tarazona
- Institute of Biomaterial Science and Berlin-Brandenburg Center for Regenerative Therapies , Helmholtz-Zentrum Geesthacht , Kantstrasse 55 , 14513 Teltow , Germany
| | - Rainhard Machatschek
- Institute of Biomaterial Science and Berlin-Brandenburg Center for Regenerative Therapies , Helmholtz-Zentrum Geesthacht , Kantstrasse 55 , 14513 Teltow , Germany
| | - Andreas Lendlein
- Institute of Biomaterial Science and Berlin-Brandenburg Center for Regenerative Therapies , Helmholtz-Zentrum Geesthacht , Kantstrasse 55 , 14513 Teltow , Germany.,Institute of Chemistry , University of Potsdam , Karl-Liebknecht-Strasse 24-25 , 14469 Potsdam , Germany
| |
Collapse
|
8
|
Wang X, Jiang X, Wu F, Ma Y, Che X, Chen X, Liu P, Zhang W, Ma X, Chen G. Microbial Poly‐3‐Hydroxybutyrate (PHB) as a Feed Additive for Fishes and Piglets. Biotechnol J 2019; 14:e1900132. [PMID: 31119892 DOI: 10.1002/biot.201900132] [Citation(s) in RCA: 18] [Impact Index Per Article: 3.6] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 04/13/2019] [Revised: 05/13/2019] [Indexed: 12/20/2022]
Affiliation(s)
- Xuan Wang
- School of Life Sciences, Tsinghua‐Peking Center for Life Sciences, Center for Synthetic and Systems BiologyTsinghua UniversityBeijing 100084 China
| | - Xiao‐Ran Jiang
- School of Life Sciences, Tsinghua‐Peking Center for Life Sciences, Center for Synthetic and Systems BiologyTsinghua UniversityBeijing 100084 China
| | - Fuqing Wu
- School of Life Sciences, Tsinghua‐Peking Center for Life Sciences, Center for Synthetic and Systems BiologyTsinghua UniversityBeijing 100084 China
- Center for Nano and Micro‐MechanicsTsinghua UniversityBeijing 100084 China
- MOE Key Lab for Industrial BiocatalysisTsinghua UniversityBeijing 100084 China
| | - Yiming Ma
- School of Life Sciences, Tsinghua‐Peking Center for Life Sciences, Center for Synthetic and Systems BiologyTsinghua UniversityBeijing 100084 China
- Center for Nano and Micro‐MechanicsTsinghua UniversityBeijing 100084 China
| | - Xuemei Che
- School of Life Sciences, Tsinghua‐Peking Center for Life Sciences, Center for Synthetic and Systems BiologyTsinghua UniversityBeijing 100084 China
- Center for Nano and Micro‐MechanicsTsinghua UniversityBeijing 100084 China
| | - Xiyue Chen
- State Key Laboratory of Animal NutritionChina Agricultural UniversityNo. 2 Yuanmingyuan West Road Beijing 100193 China
| | - Ping Liu
- State Key Laboratory of Animal NutritionChina Agricultural UniversityNo. 2 Yuanmingyuan West Road Beijing 100193 China
| | - Wenbing Zhang
- The Key Laboratory of Aquaculture Nutrition and Feeds, Ministry of Agriculture, The Key Laboratory of Mariculture (Ministry of Education)Ocean University of ChinaQingdao 266003 China
| | - Xi Ma
- State Key Laboratory of Animal NutritionChina Agricultural UniversityNo. 2 Yuanmingyuan West Road Beijing 100193 China
| | - Guo‐Qiang Chen
- School of Life Sciences, Tsinghua‐Peking Center for Life Sciences, Center for Synthetic and Systems BiologyTsinghua UniversityBeijing 100084 China
- Center for Nano and Micro‐MechanicsTsinghua UniversityBeijing 100084 China
- MOE Key Lab for Industrial BiocatalysisTsinghua UniversityBeijing 100084 China
| |
Collapse
|
9
|
Lakshmanan M, Foong CP, Abe H, Sudesh K. Biosynthesis and characterization of co and ter-polyesters of polyhydroxyalkanoates containing high monomeric fractions of 4-hydroxybutyrate and 5-hydroxyvalerate via a novel PHA synthase. Polym Degrad Stab 2019. [DOI: 10.1016/j.polymdegradstab.2019.03.005] [Citation(s) in RCA: 4] [Impact Index Per Article: 0.8] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 10/27/2022]
|
10
|
Sharma PK, Mohanan N, Sidhu R, Levin DB. Colonization and degradation of polyhydroxyalkanoates by lipase-producing bacteria. Can J Microbiol 2019; 65:461-475. [PMID: 30897336 DOI: 10.1139/cjm-2019-0042] [Citation(s) in RCA: 8] [Impact Index Per Article: 1.6] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/22/2022]
Abstract
Biodegradation of short-chain-length polyhydroxyalkanoates (scl-PHAs) and medium-chain-length polyhydroxyalkanoates (mcl-PHAs) was studied using 2 bacteria, Pseudomonas chlororaphis and Acinetobacter lwoffii, which secrete an enzyme, or enzymes, with lipase activity. These bacteria produced clear zones of depolymerization on Petri plates containing colloidal solutions of PHA polymers with different monomer compositions. Lipase activity in these bacteria was measured using p-nitrophenyl octanoate as a substrate. In liquid medium, scl-PHA (e.g., PHBV) and mcl-PHA (e.g., PHO) films were used as the sole carbon source for growth, and after 7 days, 5%-18% loss in mass of PHA films was observed. Scanning electron microscopy of these films revealed bacterial colonization of the polymers, with cracks and pitting in the film surfaces. Degradation of polymers released 3-hydroxyhexanoate, 3-hydroxyoctanoate, and 3-hydroxydecanoate monomers into the liquid medium, depending on the starting polymer. Genes encoding secretory lipases, with amino acid consensus sequences for lipase boxes and oxyanion holes, were identified in the genomes of P. chlororaphis and A. lwoffii. Although amino acid consensus sequences for lipase boxes and oxyanion holes are also present in PHA depolymerases identified in the genomes of other PHA-degrading bacteria, the P. chlororaphis and A. lwoffii lipases had low homology with these depolymerases.
Collapse
Affiliation(s)
- Parveen K Sharma
- a Department of Biosystems Engineering, University of Manitoba, Winnipeg, MB R3T 5V6, Canada
| | - Nisha Mohanan
- a Department of Biosystems Engineering, University of Manitoba, Winnipeg, MB R3T 5V6, Canada
| | - Ravinder Sidhu
- b Manitoba Institute for Materials & Faculty of Science, University of Manitoba, Winnipeg, MB R3T 5V6, Canada
| | - David B Levin
- a Department of Biosystems Engineering, University of Manitoba, Winnipeg, MB R3T 5V6, Canada
| |
Collapse
|