Behavior of rock wool in rat lungs after exposure by nasal inhalation

Insulation fiber deposition in the airways of men and rats. A review of experimental and computational studies

The typical insulation rock, slag and glass wool fibers are high volume materials. Current exposure levels in industry (generally ≤ 1 fiber/cm³ with a median diameter ∼1 μm and length ≥10 μm) are not considered carcinogenic or causing other types of severe lung effects. However, epidemiological studies are not informative on effects in humans at fiber levels >1 fiber/cm³. Effects may be inferred from valid rat studies, conducted with rat respirable fibers (diameter ≤ 1.5 μm). Therefore, we estimate delivery and deposition in human and rat airways of the industrial fibers. The deposition fractions in humans head regions by nasal (∼0.20) and by mouth breathing (≤0.08) are lower than in rats (0.50). The delivered dose into the lungs per unit lung surface area during a 1-day exposure at a similar air concentration is estimated to be about two times higher in humans than in rats. The deposition fractions in human lungs by nasal (∼0.20) and by mouth breathing (∼0.40) are higher than in rats (∼0.04). The human lung deposition may be up to three times by nasal breathing and up to six times higher by oral breathing than in rats, qualifying assessment factor setting for deposition.

Safety evaluation of rock wool after nasal inhalation in rats

Asbestos is reported to cause pulmonary fibrosis, and its use has been banned. We examined the biopersistence and histopathological effect of rock wool (RW) fibers in rat lungs by a nose-only inhalation exposure study. Twenty-four rats were exposed to RW fibers for 6 h daily for 5 consecutive days. Six rats each were sacrificed shortly and 1, 2, and 4 wk after exposure, and the fiber numbers and sizes in lungs were determined. The fiber number in the lungs 4 wk after exposure significantly decreased. The clearance half time was 28 d for fibers with L>20 μm and 50 d for World Health Organization fibers. The reasons for the decrease in number and size of fibers include: 1) discharge outside of the body by mucociliary movement, 2) dissolution by body fluid, and 3) phagocytosis and digestion by alveolar macrophages. Twelve rats were used for histopathological examination, and the pathological changes were classified by Wagner's criteria. As a result, changes up to only Grade 2 were observed. The reason for the increase in macrophage number was considered to be a transient reaction of body defense. These results suggest that RW has low biopersistence and only a limited pathological effect.

Effects of rock wool on the lungs evaluated by magnetometry and biopersistence test

BACKGROUND

Asbestos has been reported to cause pulmonary fibrosis, and its use has been banned all over the world. The related industries are facing an urgent need to develop a safer fibrous substance. Rock wool (RW), a kind of asbestos substitute, is widely used in the construction industry. In order to evaluate the safety of RW, we performed a nose-only inhalation exposure study in rats. After one-month observation period, the potential of RW fibers to cause pulmonary toxicity was evaluated based on lung magnetometry findings, pulmonary biopersistence, and pneumopathology.

METHODS

Using the nose-only inhalation exposure system, 6 male Fischer 344 rats (6 to 10 weeks old) were exposed to RW fibers at a target fiber concentration of 100 fibers/cm3 (length [L] > 20 mum) for 6 hours daily, for 5 consecutive days. As a magnetometric indicator, 3 mg of triiron tetraoxide suspended in 0.2 mL of physiological saline was intratracheally administered after RW exposure to these rats and 6 unexposed rats (controls). During one second magnetization in 50 mT external magnetic field, all magnetic particles were aligned, and immediately afterwards the strength of their remanent magnetic field in the rat lungs was measured in both groups. Magnetization and measurement of the decay (relaxation) of this remanent magnetic field was performed over 40 minutes on 1, 3, 14, and 28 days after RW exposure, and reflected cytoskeleton dependent intracellular transport within macrophages in the lung. Similarly, 24 and 12 male Fisher 344-rats were used for biopersistence test and pathologic evaluation, respectively.

RESULTS

In the lung magnetometric evaluation, biopersistence test and pathological evaluation, the arithmetic mean value of the total fiber concentration was 650.2, 344.7 and 390.7 fibers/cm3, respectively, and 156.6, 93.1 and 95.0 fibers/cm3 for fibers with L > 20 mum, respectively. The lung magnetometric evaluation revealed that impaired relaxation indicating cytoskeletal toxicity did not occur in the RW exposure group. In addition, clearance of the magnetic tracer particles was not significantly affected by the RW exposure. No effects on lung pathology were noted after RW exposure.

CONCLUSION

These findings indicate that RW exposure is unlikely to cause pulmonary toxicity within four weeks period. Lung magnetometry studies involving long-term exposure and observation will be necessary to ensure the safety of RW.

Biopersistence of rock wool in lungs after short-term inhalation in rats

To evaluate the safety of rock wool (RW), an asbestos substitute, we examined the biopersistence of RW fibers in rat lungs based on the changes of fiber number and fiber size (length and diameter) by a nose-only inhalation exposure study. Twenty-four male Fischer 344 rats were exposed to RW fibers at a concentration of 30 mg/m(3) continuously for 3 h daily for 5 consecutive days. Six rats each were sacrificed shortly and at 1, 2, and 4 wk after exposure, and their lung tissues were ashed by a low-temperature plasma asher. Then the fiber numbers and fiber sizes in lungs were determined using a phase-contrast microscope and computed image analyzer. During the study period, the arithmetic mean (SD) values of fiber and weight concentrations were 78.5 (35.7) fibers/cm(3), and 29.9 (28.3) mg/m(3), respectively. The fiber number in lungs 4 wk after exposure significantly decreased from the baseline value (shortly after exposure) (p < .05). The half-life of fibers calculated from the approximate curve was 28 days for all fibers and 16 days for fibers with L > 20 microm, and the rate of decrease in fiber number was 46.3% at 4 wk after exposure (shortly-after group = 100%). Likewise, both length and diameter significantly decreased at 4 wk after exposure (p < .05), probably because fibers were phagosytosed and digested by alveolar macrophages, discharged to outside of the body by mucociliary movement, or dissolved by body fluid. It will be necessary in the future to further confirm the safety of RW fibers by assessing the biopersistence of fibers in the lungs and their pathological effects in our ongoing study performed in accordance with the guidelines established in the "Methods for Determination of Hazardous Properties for Human Health of Man Made Mineral Fibers" (EC protocol).