1
|
Srivastava R, Srivastava N, Kaur S, Kant K, Gaurav K. The potential of magnesium oxide nanoparticles (MgONPs) in the transesterification of lipids produced by Rhodotorula minuta. ENVIRONMENTAL SCIENCE AND POLLUTION RESEARCH INTERNATIONAL 2024; 31:56024-56041. [PMID: 39249616 DOI: 10.1007/s11356-024-34935-x] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 01/29/2024] [Accepted: 09/04/2024] [Indexed: 09/10/2024]
Abstract
The urgent need to address energy security risks and global warming has led to exploration of renewable energy sources. One such avenue is biodiesel specifically focusing on the potential of Rhodotorula minuta, a type of yeast known for producing lipids that can be used as a sustainable alternative for production of biodiesel. In the current study, this promising yeast was evaluated for its potential to produce lipids. The morphological characterization was carried out by scanning electron microscope (SEM), and intracellular detail was studied by transmission electron microscope (TEM). Changes in content and cellular biomass were monitored at time intervals with the highest biomass yield of 12.4 g/l and lipid content of 6.2 g/l achieved after 72 h. In the present work, magnesium oxide nanoparticles (MgO NPs) were synthesized and extensively characterized through Fourier transform infrared spectroscopy (FTIR), thermogravimetric analysis (TGA), Brunauer-Emmett-Teller (BET), SEM, TEM, and X-ray diffraction (XRD). By employing response surface methodology (RSM) with Box-Behnken design (BBD), optimal process conditions for transesterification could be determined. The best result achieved was a yield of 88.6% when the conditions were optimized, using methanol to oil ratio of 18:1 and 8% (w/w) amount of catalyst maintaining a reaction temperature of 55 °C and allowing the reaction to proceed for 120 min.
Collapse
Affiliation(s)
- Richa Srivastava
- Department of Applied Chemistry, Delhi Technological University, Delhi, 110042, India
| | - Niti Srivastava
- Amity Institute of Biotechnology, Amity University Haryana, Gurugram, 122413, India
| | - SonamPreet Kaur
- Amity Institute of Biotechnology, Amity University Haryana, Gurugram, 122413, India
| | - Kamal Kant
- Amity Institute of Biotechnology, Amity University Haryana, Gurugram, 122413, India
| | - Kumar Gaurav
- Amity Institute of Biotechnology, Amity University Haryana, Gurugram, 122413, India.
| |
Collapse
|
2
|
Khawaja MK, Alkayyali K, Almanasreh M, Alkhalidi A. Waste-to-energy barriers and solutions for developing countries with limited water and energy resources. THE SCIENCE OF THE TOTAL ENVIRONMENT 2024; 926:172096. [PMID: 38556009 DOI: 10.1016/j.scitotenv.2024.172096] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Subscribe] [Scholar Register] [Received: 09/07/2023] [Revised: 03/27/2024] [Accepted: 03/28/2024] [Indexed: 04/02/2024]
Abstract
The environmental risks of conventional waste disposal methods, along with the resource and energy value of waste, have formed the foundation for waste-to-energy (WtE) technology. WtE systems that work on recovering energy present a suitable solution to generate energy and sustainably manage waste. This type of waste management system in the Middle East and North Africa (MENA) region is still considered underutilized as WtE technology is rarely used due to a lack of experience in their specific local conditions, lack of qualified competencies, and the absence of an appropriate regulatory and legislative structure. This study reviews the existing WtE policies and regulations, and it investigates the potential of WtE techniques in the MENA region. Moreover, sustainability in water consumption is critical; therefore, various water-conservation techniques were reviewed and considered when selecting regulatory actions. The radiative sky cooling technique was recommended to reduce water consumption. Barriers to implementing WtE and solutions for developing countries were presented to enable proper WtE implementation.
Collapse
Affiliation(s)
- Mohamad K Khawaja
- Energy Engineering Department, German Jordanian University, Amman 11180, Jordan.
| | - Khaled Alkayyali
- Energy Engineering Department, German Jordanian University, Amman 11180, Jordan
| | - Marah Almanasreh
- Energy Engineering Department, German Jordanian University, Amman 11180, Jordan
| | - Ammar Alkhalidi
- Energy Engineering Department, German Jordanian University, Amman 11180, Jordan; Sustainable and Renewable Energy Department, University of Sharjah, Sharjah, United Arab Emirates
| |
Collapse
|
3
|
Study of Technological Process of Fermentation of Molasses Vinasse in Biogas Plants. Processes (Basel) 2022. [DOI: 10.3390/pr10102011] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/06/2022] Open
Abstract
The volume of ethanol production waste—molasses waste in Ukraine—reaches up to 4 million m3 per year. It is not easy to dispose of and is polluting the environment. Currently, the development of an effective technology for using molasses in biogas plants to obtain energy gas—biogas—is an urgent problem. The purpose of our work is to determine the rational volume of loading molasses bard into the methane tank in a quasi-continuous mode to obtain the maximum volume of biogas. To achieve this goal, the following experimental studies were carried out: mono-fermentation of molasses and combined fermentation of cattle manure and molasses on a laboratory biogas plant in a periodic mode; on the basis of the obtained laboratory studies, a special simulation model of biogas output during the quasi-continuous fermentation of substrates was established and the amount of molasses added to obtain the maximum biogas output was determined. The maximum output of biogas under the periodic system of loading the methane tank when adding 10.5% molasses to cattle manure is 1.462 l/(h kg DOM); when adding 26.1% molasses to cattle manure, it is 3.594 l/(h kg DOM). In order to increase the yield of biogas, it is advisable to add molasses in the amount of 30% of the volume of the substrate to the substrate based on cattle manure, which allows the discounted payback period of the biogas plant to be reduced to 1.2 years.
Collapse
|
4
|
Salama ES, El-Fatah Abomohra A. Introductory Chapter: From Biogas Lab-Scale towards Industrialization. BIOGAS - BASICS, INTEGRATED APPROACHES, AND CASE STUDIES 2022. [DOI: 10.5772/intechopen.104500] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 09/01/2023]
|
5
|
Igbokwe VC, Ezugworie FN, Onwosi CO, Aliyu GO, Obi CJ. Biochemical biorefinery: A low-cost and non-waste concept for promoting sustainable circular bioeconomy. JOURNAL OF ENVIRONMENTAL MANAGEMENT 2022; 305:114333. [PMID: 34952394 DOI: 10.1016/j.jenvman.2021.114333] [Citation(s) in RCA: 3] [Impact Index Per Article: 1.5] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 03/01/2021] [Revised: 12/11/2021] [Accepted: 12/16/2021] [Indexed: 06/14/2023]
Abstract
The transition from a fossil-based linear economy to a circular bioeconomy is no longer an option but rather imperative, given worldwide concerns about the depletion of fossil resources and the demand for innovative products that are ecocompatible. As a critical component of sustainable development, this discourse has attracted wide attention at the regional and international levels. Biorefinery is an indispensable technology to implement the blueprint of the circular bioeconomy. As a low-cost, non-waste innovative concept, the biorefinery concept will spur a myriad of new economic opportunities across a wide range of sectors. Consequently, scaling up biorefinery processes is of the essence. Despite several decades of research and development channeled into upscaling biorefinery processes, the commercialization of biorefinery technology appears unrealizable. In this review, challenges limiting the commercialization of biorefinery technologies are discussed, with a particular focus on biofuels, biochemicals, and biomaterials. To counteract these challenges, various process intensification strategies such as consolidated bioprocessing, integrated biorefinery configurations, the use of highly efficient bioreactors, simultaneous saccharification and fermentation, have been explored. This study also includes an overview of biomass pretreatment-generated inhibitory compounds as platform chemicals to produce other essential biocommodities. There is a detailed examination of the technological, economic, and environmental considerations of a sustainable biorefinery. Finally, the prospects for establishing a viable circular bioeconomy in Nigeria are briefly discussed.
Collapse
Affiliation(s)
- Victor C Igbokwe
- Bioconversion and Renewable Energy Research Unit, University of Nigeria, Nsukka, Enugu State, Nigeria; Department of Materials Science and Engineering, Université de Pau et des Pays de l'Adour, 64012, Pau Cedex, France
| | - Flora N Ezugworie
- Department of Microbiology, Faculty of Biological Sciences, University of Nigeria, Nsukka, Enugu State, Nigeria; Bioconversion and Renewable Energy Research Unit, University of Nigeria, Nsukka, Enugu State, Nigeria
| | - Chukwudi O Onwosi
- Department of Microbiology, Faculty of Biological Sciences, University of Nigeria, Nsukka, Enugu State, Nigeria; Bioconversion and Renewable Energy Research Unit, University of Nigeria, Nsukka, Enugu State, Nigeria.
| | - Godwin O Aliyu
- Department of Microbiology, Faculty of Biological Sciences, University of Nigeria, Nsukka, Enugu State, Nigeria; Bioconversion and Renewable Energy Research Unit, University of Nigeria, Nsukka, Enugu State, Nigeria
| | - Chinonye J Obi
- Department of Microbiology, Faculty of Biological Sciences, University of Nigeria, Nsukka, Enugu State, Nigeria
| |
Collapse
|
6
|
Satriadi H, Pratiwi IY, Khuriyah M, Prameswari J. Geothermal solid waste derived Ni/Zeolite catalyst for waste cooking oil processing. CHEMOSPHERE 2022; 286:131618. [PMID: 34346337 DOI: 10.1016/j.chemosphere.2021.131618] [Citation(s) in RCA: 5] [Impact Index Per Article: 2.5] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 04/18/2021] [Revised: 07/16/2021] [Accepted: 07/19/2021] [Indexed: 06/13/2023]
Abstract
The main aim of this work was to develop a sustainable Ni/Zeolite catalyst derived from geothermal solid waste for waste cooking oil processing. The effects of catalyst concentration and operation temperature on the transesterification process for biodiesel production which used waste cooking oil as feedstock were investigated to determine the optimum biodiesel process condition. Results have shown the synthesized Ni/Zeolite catalyst was granular in shape and crystalline with increased surface area and pore volume, 80.661 m2 g-1, and 0.123 cc g-1 respectively. Meanwhile, the highest biodiesel yield obtained was 89.4 % at 3 % w/w Ni/Zeolite catalyst addition and 60 °C operating temperature. The reusability of the synthesized catalyst was also investigated, with results showing the biodiesel yield decreasing to 73.3 % after three cycles.
Collapse
Affiliation(s)
- Hantoro Satriadi
- Chemical Engineering Department, Faculty of Engineering, Diponegoro University, Semarang, 50275, Indonesia
| | - Isdayana Yogi Pratiwi
- Chemical Engineering Department, Faculty of Engineering, Diponegoro University, Semarang, 50275, Indonesia
| | - Malikhatul Khuriyah
- Chemical Engineering Department, Faculty of Engineering, Diponegoro University, Semarang, 50275, Indonesia
| | - Jedy Prameswari
- Chemical Engineering Department, Faculty of Engineering, Diponegoro University, Semarang, 50275, Indonesia
| |
Collapse
|
7
|
A Short Review on Catalyst, Feedstock, Modernised Process, Current State and Challenges on Biodiesel Production. Catalysts 2021. [DOI: 10.3390/catal11111261] [Citation(s) in RCA: 5] [Impact Index Per Article: 1.7] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 12/12/2022] Open
Abstract
Biodiesel, comprising mono alkyl fatty acid esters or methyl ethyl esters, is an encouraging option to fossil fuels or diesel produced from petroleum; it has comparable characteristics and its use has the potential to diminish carbon dioxide production and greenhouse gas emissions. Manufactured from recyclable and sustainable feedstocks, e.g., oils originating from vegetation, biodiesel has biodegradable properties and has no toxic impact on ecosystems. The evolution of biodiesel has been precipitated by the continuing environmental damage created by the deployment of fossil fuels. Biodiesel is predominantly synthesised via transesterification and esterification procedures. These involve a number of key constituents, i.e., the feedstock and catalytic agent, the proportion of methanol to oil, the circumstances of the reaction and the product segregation and purification processes. Elements that influence the yield and standard of the obtained biodiesel encompass the form and quantity of the feedstock and reaction catalyst, the proportion of alcohol to feedstock, the temperature of the reaction, and its duration. Contemporary research has evaluated the output of biodiesel reactors in terms of energy production and timely biodiesel manufacture. In order to synthesise biodiesel for industrial use efficaciously, it is essential to acknowledge the technological advances that have significant potential in this sector. The current paper therefore offers a review of contemporary progress, feedstock categorisation, and catalytic agents for the manufacture of biodiesel and production reactors, together with modernised processing techniques. The production reactor, form of catalyst, methods of synthesis, and feedstock standards are additionally subjects of discourse so as to detail a comprehensive setting pertaining to the chemical process. Numerous studies are ongoing in order to develop increasingly efficacious techniques for biodiesel manufacture; these acknowledge the use of solid catalytic agents and non-catalytic supercritical events. This review appraises the contemporary situation with respect to biodiesel production in a range of contexts. The spectrum of techniques for the efficacious manufacture of biodiesel encompasses production catalysed by homogeneous or heterogeneous enzymes or promoted by microwave or ultrasonic technologies. A description of the difficulties to be surmounted going forward in the sector is presented.
Collapse
|
8
|
Singh T, Alhazmi A, Mohammad A, Srivastava N, Haque S, Sharma S, Singh R, Yoon T, Gupta VK. Integrated biohydrogen production via lignocellulosic waste: Opportunity, challenges & future prospects. BIORESOURCE TECHNOLOGY 2021; 338:125511. [PMID: 34274587 DOI: 10.1016/j.biortech.2021.125511] [Citation(s) in RCA: 30] [Impact Index Per Article: 10.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 05/30/2021] [Revised: 06/30/2021] [Accepted: 07/02/2021] [Indexed: 06/13/2023]
Abstract
Hydrogen production through biological route is the cleanest, renewable and potential way to sustainable energy generation. Productions of hydrogen via dark and photo fermentations are considered to be more sustainable and economical approach over numerous existing biological modes. Nevertheless, both the biological modes suffer from certain limitations like low yield and production rate, and because of these practical implementations are still far away. Therefore, the present review provides an assessment and feasibility of integrated biohydrogen production strategy by combining dark and photo-fermentation as an advanced biochemical processing while using lignocellulosics biomass to improve and accelerate the biohydrogen production technology in a sustainable manner. This review also evaluates practical viability of the integrated approach for biohydrogen production along with the analysis of the key factors which significantly influence to elevate this technology on commercial ground with the implementation of various environment friendly and innovative approaches.
Collapse
Affiliation(s)
- Tripti Singh
- School of Biosciences IMS Ghaziabad UC Campus, Ghaziabad, Uttar Pradesh 201015, India
| | - Alaa Alhazmi
- Medical Laboratory Technology Department Jazan University, Jazan, Saudi Arabia; SMIRES for Consultation in Specialized Medical Laboratories, Jazan University, Jazan, Saudi Arabia
| | - Akbar Mohammad
- School of Chemical Engineering, Yeungnam University, Gyeongsan-si, Gyeongbuk 38541, South Korea
| | - Neha Srivastava
- Department of Chemical Engineering and Technology, Indian Institute of Technology (BHU), Varanasi 221005 India
| | - Shafiul Haque
- Research and Scientific Studies Unit, College of Nursing and Allied Health Sciences, Jazan University, Jazan 45142, Saudi Arabia; Bursa Uludağ University Faculty of Medicine, Görükle Campus, 16059, Nilüfer, Bursa, Turkey
| | - Shalini Sharma
- School of Biosciences IMS Ghaziabad UC Campus, Ghaziabad, Uttar Pradesh 201015, India
| | - Rajeev Singh
- Department of Environmental Studies, Satyawati College, University of Delhi, Delhi 110052, India
| | - Taeho Yoon
- School of Chemical Engineering, Yeungnam University, Gyeongsan-si, Gyeongbuk 38541, South Korea
| | - Vijai Kumar Gupta
- Biorefining and Advanced Materials Research Center, Scotland's Rural College (SRUC), Kings Buildings, West Mains Road, Edinburgh EH9 3JG, UK; Center for Safe and Improved Food, Scotland's Rural College (SRUC), Kings Buildings, West Mains Road, Edinburgh EH9 3JG, UK.
| |
Collapse
|
9
|
Microbial lipid biosynthesis from lignocellulosic biomass pyrolysis products. Biotechnol Adv 2021; 54:107791. [PMID: 34192583 DOI: 10.1016/j.biotechadv.2021.107791] [Citation(s) in RCA: 6] [Impact Index Per Article: 2.0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 02/10/2021] [Revised: 05/18/2021] [Accepted: 06/24/2021] [Indexed: 01/08/2023]
Abstract
Lipids are a biorefinery platform to prepare fuel, food and health products. They are traditionally obtained from plants, but those of microbial origin allow for a better use of land and C resources, among other benefits. Several (thermo)chemical and biochemical strategies are used for the conversion of C contained in lignocellulosic biomass into lipids. In particular, pyrolysis can process virtually any biomass and is easy to scale up. Products offer cost-effective, renewable C in the form of readily fermentable molecules and other upgradable intermediates. Although the production of microbial lipids has been studied for 30 years, their incorporation into biorefineries was only described a few years ago. As pyrolysis becomes a profitable technology to depolymerize lignocellulosic biomass into assimilable C, the number of investigations on it raises significantly. This article describes the challenges and opportunities resulting from the combination of lignocellulosic biomass pyrolysis and lipid biosynthesis with oleaginous microorganisms. First, this work presents the basics of the individual processes, and then it shows state-of-the-art processes for the preparation of microbial lipids from biomass pyrolysis products. Advanced knowledge on separation techniques, structure analysis, and fermentability is detailed for each biomass pyrolysis fraction. Finally, the microbial fatty acid platform comprising biofuel, human food and animal feed products, and others, is presented. Literature shows that the microbial lipid production from anhydrosugars, like levoglucosan, and short-chain organic acids, like acetic acid, is straightforward. Indeed, processes achieving nearly theoretical yields form the latter have been described. Some authors have shown that lipid biosynthesis from different lignin sources is biochemically feasible. However, it still imposes major challenges regarding strain performance. No report on the fermentation of pyrolytic lignin is yet available. Research on the microbial uptake of pyrolytic humins remains vacant. Microorganisms that make use of methane show promising results at the proof-of-concept level. Overall, despite some issues need to be tackled, it is now possible to conceive new versatile biorefinery models by combining lignocellulosic biomass pyrolysis products and robust oleaginous microbial cell factories.
Collapse
|
10
|
Selection of Indigenous Algal Species for Potential Biodiesel Production. JOURNAL OF PURE AND APPLIED MICROBIOLOGY 2021. [DOI: 10.22207/jpam.15.2.40] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/20/2022] Open
Abstract
Currently, India utilizes an enormous amount of fossil fuels and a major quantity of fossil fuels are imported from other countries. It’s a giant load on the Indian Economy. The burning of fossil fuels causes global warming. Carbon neutral, renewable fuels are essential for environmental protection and it’s economically sustainable for India. Biofuels attention day by day due to a rise in energy demands and environmental concerns. Biodiesel produced from algal oil a possible renewable and carbon-neutral substitute to fossil fuels. The feasibility of the algal-based biodiesel industry depends on the selection of adequate species regarding commercial oil yields and oil quality. Present research work to bioprospecting and screening of 19 algal and blue-green algal species, the oil percentage and the fatty acid profiles, used for analyzing the biodiesel fuel properties. Oil from Tolypothrix phyllophila algal strain and compared it with another eighteen algal and blue-green algal strains from different literature. Tolypothrix phyllophila algal strain contains approximately 12.6% lipid on a dry weight basis. We also compared the FAME profile of 19 algal and blue-green algal strains and calculated and compared the fuel properties such as cetane number, Iodine Value, etc. of the biodiesel derived from these algal and blue-green algal oils based on chain length and saturation. We also investigated the 19 algal and blue-green algal fatty acid profiles and its suitability for biodiesel production and strains selection through PROMETHEE (Preference Ranking Organization Method for Enrichment Evaluations) and GAIA (geometrical analysis for interactive aid) analysis.
Collapse
|
11
|
Bharti MK, Chalia S, Thakur P, Sridhara SN, Thakur A, Sharma PB. Nanoferrites heterogeneous catalysts for biodiesel production from soybean and canola oil: a review. ENVIRONMENTAL CHEMISTRY LETTERS 2021; 19:3727-3746. [PMID: 33967660 PMCID: PMC8094988 DOI: 10.1007/s10311-021-01247-2] [Citation(s) in RCA: 12] [Impact Index Per Article: 4.0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Figures] [Subscribe] [Scholar Register] [Received: 03/24/2021] [Accepted: 04/23/2021] [Indexed: 06/12/2023]
Abstract
Fossil fuel depletion and pollution are calling for alternative, renewable energies such as biofuels. Actual challenges include the design of efficient processes and catalysts to convert various feedstocks into biofuels. Here, we review nanoferrites heterogeneous catalysts to produce biodiesel from soybean and canola oil. For that, transesterification is the main synthesis route and offers simplicity, cost-effectiveness, better process control, and high conversion yield. Catalysis with nanoferrites and composites allow to obtain yields higher than 95% conversion with less than 5.0 wt.% of catalyst loading at 80 °C in 1-2 h. More than 90% conversion yields can be achieved with a moderate alcohol/oil molar ratio, i.e., between 12:1 to 16:1. Catalyst recovery is easy due to the magnetic properties of nanoferrite, which can be effectively reused up to 4 times with less than 10% loss of catalytic efficiency.
Collapse
Affiliation(s)
- Manish Kumar Bharti
- Department of Aerospace Engineering, Amity University Haryana, Gurugram, Haryana 122413 India
| | - Sonia Chalia
- Department of Aerospace Engineering, Amity University Haryana, Gurugram, Haryana 122413 India
| | - Preeti Thakur
- Department of Physics, Amity University Haryana, Gurugram, Haryana 122413 India
| | - S. N. Sridhara
- Hindustan University of Technology and Science, Tamil Nadu, Chennai, 603103 India
| | - Atul Thakur
- Amity Institute of Nanotechnology, Amity University Haryana, Gurugram, Haryana 122413 India
| | - P. B. Sharma
- Department of Aerospace Engineering, Amity University Haryana, Gurugram, Haryana 122413 India
| |
Collapse
|
12
|
Argiz L, González-Cabaleiro R, Val Del Río Á, González-López J, Mosquera-Corral A. A novel strategy for triacylglycerides and polyhydroxyalkanoates production using waste lipids. THE SCIENCE OF THE TOTAL ENVIRONMENT 2021; 763:142944. [PMID: 33148431 DOI: 10.1016/j.scitotenv.2020.142944] [Citation(s) in RCA: 3] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 08/01/2020] [Revised: 09/21/2020] [Accepted: 10/04/2020] [Indexed: 06/11/2023]
Abstract
Lipids are one of the main components of the organic matter present in the effluents of the food-processing industry. These waste streams can be biotransformed into valuable triacylglycerides (TAGs) and polyhydroxyalkanoates (PHAs), precursors of biofuels and biomaterials alternative to petroleum-based products. These compounds are yielded by mixed microbial cultures, and considering that both TAG and PHA accumulators may coexist within the community, it seems crucial to define those operational strategies that might control the selection of the dominant metabolic pathways (TAG or PHA accumulation). In this work, residual fish-canning oil was used as a carbon source in a two-stage process (culture selection and intracellular compounds accumulation) in which the substrate was simultaneously hydrolyzed in these two stages without the need for a previous fermentation unit. It was pretended to maximize preferential TAG or PHA storage in the accumulation reactor by the imposition of certain selective pressures in the enrichment one. Uncoupling C and N feedings and limiting nitrogen availability in the medium, allowed to maximize PHA production (82.3 wt% of PHAs, 0.80 CmmolPHA/CmmolS). Besides, when low pH in the famine phase was considered as additional selective pressure, it was possible to shift the ratio TAG:PHA from 4:96 obtaining 43.0 wt% of TAGs (0.67 CmmolTAG/CmmolS). Therefore, this novel and simplified process demonstrated versatility and efficiency in the storage of TAGs and PHAs from a unique residual feedstock and using an open culture proving that product selection can be harnessed if choosing the right operational conditions in the enrichment stage.
Collapse
Affiliation(s)
- Lucía Argiz
- CRETUS Institute, Department of Chemical Engineering, Universidade de Santiago de Compostela, 15782 Santiago de Compostela, Galicia, Spain.
| | - Rebeca González-Cabaleiro
- Department of Infrastructure and Environment, University of Glasgow, Rankine Building, Glasgow G12 8LT, UK
| | - Ángeles Val Del Río
- CRETUS Institute, Department of Chemical Engineering, Universidade de Santiago de Compostela, 15782 Santiago de Compostela, Galicia, Spain
| | - Jesús González-López
- Department of Microbiology, Institute of Water Research, Universidad de Granada, Granada, Spain
| | - Anuska Mosquera-Corral
- CRETUS Institute, Department of Chemical Engineering, Universidade de Santiago de Compostela, 15782 Santiago de Compostela, Galicia, Spain
| |
Collapse
|
13
|
Tikhomirova TS, But SY. Laboratory scale bioreactor designs in the processes of methane bioconversion: Mini-review. Biotechnol Adv 2021; 47:107709. [PMID: 33548452 DOI: 10.1016/j.biotechadv.2021.107709] [Citation(s) in RCA: 8] [Impact Index Per Article: 2.7] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 09/10/2020] [Revised: 01/29/2021] [Accepted: 01/31/2021] [Indexed: 02/07/2023]
Abstract
Global methane emissions have been steadily increasing over the past few decades, exerting a negative effect on the environment. Biogas from landfills and sewage treatment plants is the main anthropogenic source of methane. This makes methane bioconversion one of the priority areas of biotechnology. This process involves the production of biochemical compounds from non-food sources through microbiological synthesis. Methanotrophic bacteria are a promising tool for methane bioconversion due to their ability to use this greenhouse gas and to produce protein-rich biomass, as well as a broad range of useful organic compounds. Currently, methane is used not only to produce biomass and chemical compounds, but also to increase the efficiency of water and solid waste treatment. However, the use of gaseous substrates in biotechnological processes is associated with some difficulties. The low solubility of methane in water is one of the major problems. Different approaches have been involved to encounter these challenges, including different bioreactor and gas distribution designs, solid carriers and bulk sorbents, as well as varying air/oxygen supply, the ratio of volumetric flow rate of gas mixture to its consumption rate, etc. The aim of this review was to summarize the current data on different bioreactor designs and the aspects of their applications for methane bioconversion and wastewater treatment. The bioreactors used in these processes must meet a number of requirements such as low methane emission, improved gas exchange surface, and controlled substrate supply to the reaction zone.
Collapse
Affiliation(s)
- Tatyana S Tikhomirova
- Institute for Biological Instrumentation of the Russian Academy of Sciences, Federal Research Center «Pushchino Scientific Center for Biological Research of the Russian Academy of Sciences», Institutskaya 7, Pushchino, Moscow Region 142290, Russia.
| | - Sergey Y But
- G.K. Skryabin Institute of Biochemistry and Physiology of Microorganisms of the Russian Academy of Sciences, Federal Research Center «Pushchino Scientific Center for Biological Research of the Russian Academy of Sciences», Prospect Nauki 5, Pushchino, Moscow Region 142290, Russia
| |
Collapse
|
14
|
Heterogeneous Catalysts Using Strontium Oxide Agglomerates Depositing upon Titanium Plate for Enhancing Biodiesel Production. Catalysts 2020. [DOI: 10.3390/catal11010030] [Citation(s) in RCA: 7] [Impact Index Per Article: 1.8] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 12/20/2022] Open
Abstract
Strontium oxide (SrO) is an effective catalyst for transesterification. SrO powder that is firmly deposited onto a light titanium plate (TiO2_P), denoted as SrO/TiO2_P, can be reinforced by forming strontium titanate (SrTiO3) at the interface. Exposed SrO agglomerates can promote subsequent continuous transesterification process. In this work, conversion efficiency and production of biodiesel from olive oil on SrO/TiO2_P is investigated. The as-designed SrO/TiO2_P was followed by dip-coating and heat treatment. The physical properties of SrO/TiO2_P were verified through ASTM D3359; the chemical structures before and after transesterification, were respectively identified by X-ray photoelectron spectroscopy and Raman spectroscopy. A focused microwave heating system was utilized for transesterification. In the optimized sample SrO/TiO2_P (x) (x = 0.5 M), SrO firmly bonds with TiO2_P and forms the SrTiO3 structure. With the support of TiO2_P, the tested oil with SrO agglomerates subsequently reacts with SrO under microwave heating. The biodiesel conversion rate reaches 87.7% after a reaction time of 4 min, while the biodiesel product has an average of 39.37 MJ/kg of combustion heat and less than 1 vol% of water content. The as-designed SrO/TiO2_P (0.5) thus has great potential for biodiesel production and is promising with high stability in particular for a continuous fluid flow system.
Collapse
|
15
|
Assessing the Camelina (Camelina sativa (L.) Crantz) Seed Harvesting Using a Combine Harvester: A Case-Study on the Assessment of Work Performance and Seed Loss. SUSTAINABILITY 2020. [DOI: 10.3390/su13010195] [Citation(s) in RCA: 11] [Impact Index Per Article: 2.8] [Reference Citation Analysis] [Abstract] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 12/27/2022]
Abstract
The growing demand in food and non-food industries for camelina oil is driving the interest of farmers and contractors in investing in such feedstock. Nonetheless, the cost, performance and critical aspects related to the harvesting stage are still not properly investigated. In the present study, an ad-hoc test was performed in Spain in order to fulfill this gap. The results support the hypothesis to harvest camelina seeds with the same combine harvester used for cereal harvesting without further investment. Theoretical field capacity (TFC), effective field capacity (EFC), material capacity (MC), and field efficiency (FE) were 4.34 ha h−1, 4.22 ha h−1, 4.66 Mg h−1 FM, and 97.24%, respectively. The harvesting cost was estimated in 48.51 € ha−1. Approximately, the seed loss of 0.057 ± 0.028 Mg ha−1 FM was due to the impact of the combine harvester header and dehiscence of pods, whilst 0.036 ± 0.006 Mg ha−1 FM of seeds were lost due to inefficiency of the threshing system of the combine harvester. Adjustment of the working speed of the combine and the rotation speed of the reel may help to reduce such loss.
Collapse
|
16
|
You SK, Ko YJ, Shin SK, Hwang DH, Kang DH, Park HM, Han SO. Enhanced CO 2 fixation and lipid production of Chlorella vulgaris through the carbonic anhydrase complex. BIORESOURCE TECHNOLOGY 2020; 318:124072. [PMID: 32911368 DOI: 10.1016/j.biortech.2020.124072] [Citation(s) in RCA: 19] [Impact Index Per Article: 4.8] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 07/15/2020] [Revised: 08/27/2020] [Accepted: 08/30/2020] [Indexed: 06/11/2023]
Abstract
Photosynthesis of C. vulgaris shows slow growth and low lipid production due to the low solubility of CO2, and it is thus necessary to increase the dissolved inorganic carbon source to solve this problem. In this study, carbonic anhydrase (CA) was fused with dockerin to form a CA complex by cohesion-dockerin interaction. The CA complex was displayed on the surface of C. vulgaris by a cellulose binding module. The CA complex increased activity and stability compared to those of a single enzyme. Additionally, C. vulgaris showed an average of 1.6-fold rapid growth during log phase through the influence of the CA complex. The bicarbonate produced by the CA complex increased the lipid production about 1.7-fold (23.3%), compared to 13.6% for the control group. The present results suggest that the CA complex successfully enhances the CO2 fixation, which should be an essential study for 4th generation biofuels.
Collapse
Affiliation(s)
- Seung Kyou You
- Department of Biotechnology, Korea University, Seoul 02841, Republic of Korea
| | - Young Jin Ko
- Department of Biotechnology, Korea University, Seoul 02841, Republic of Korea
| | - Sang Kyu Shin
- Department of Biotechnology, Korea University, Seoul 02841, Republic of Korea
| | - Dong-Hyeuk Hwang
- Department of Biotechnology, Korea University, Seoul 02841, Republic of Korea
| | - Dae Hee Kang
- Department of Biotechnology, Korea University, Seoul 02841, Republic of Korea
| | - Hyeon Min Park
- Department of Biotechnology, Korea University, Seoul 02841, Republic of Korea
| | - Sung Ok Han
- Department of Biotechnology, Korea University, Seoul 02841, Republic of Korea.
| |
Collapse
|
17
|
Sustainable Use of Wastewater in Agriculture: A Bibliometric Analysis of Worldwide Research. SUSTAINABILITY 2020. [DOI: 10.3390/su12218948] [Citation(s) in RCA: 10] [Impact Index Per Article: 2.5] [Reference Citation Analysis] [Abstract] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 12/22/2022]
Abstract
It is estimated that at least one quarter of the world’s population will be affected by water shortages in the coming years and by 2030 there will be a global water deficit of 40% if urgent action is not taken. Currently, the main consumer of water globally is agriculture. In addition, it has been estimated that to meet the demand for food by 2050, the water available for agricultural irrigation would have to increase by 70%. In this context, wastewater could become a relevant water resource to meet this growing demand. This article aims to show the state of the global research on sustainable use of wastewater in agriculture. To this end, a systematic qualitative analysis and a quantitative bibliometric analysis were conducted. The search was carried out for the period 2000–2019, and the analyzed sample comprised 1986 articles. The results show that this line of research is one of the most outstanding within agriculture and has gained special relevance during the last five years. Research has improved significantly at a technical level, but problems such as energy consumption, and the elimination of heavy metals and elements of chemical and pharmacological products, still need to be refined. There is a particular lack of contributions covering social aspects. This article can serve as a reference for both researchers and stakeholders interested in this topic.
Collapse
|
18
|
The Major Driving Forces of the EU and US Ethanol Markets with Special Attention Paid to the COVID-19 Pandemic. ENERGIES 2020. [DOI: 10.3390/en13215614] [Citation(s) in RCA: 4] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [Abstract] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 11/16/2022]
Abstract
Ethanol is a widely produced fuel, as well as a fuel additive. Its price is closely related to the price of gasoline, its major substitute. This paper focuses on the impacts of the related variables on regional ethanol prices. Additionally, the length of the price dataset made it possible to isolate the impacts of COVID-19 on the ethanol prices. Using multiple regression and Confirmatory Factor Analyses, we found no significant correlation between the European and US ethanol prices because the major influencing factors were regionally different. In the case of the European ethanol markets, the positive factors were wheat, maize, and potassium chloride prices, while the European sugar and diammonium phosphate prices were negative. In the US markets, gasoline, sugar, and most of the artificial fertilizer prices were positive, while wheat prices were negative. Based on factor analysis, artificial fertilizers and maize factors proved to be important to the European markets, while US ethanol prices were driven by the crude oil-gasoline and raw materials factors. The COVID variable showed no significant connection with the EU prices, but negatively affected the US ethanol prices. This is explained by the different market characteristics, as the US is not only the major consumer, but also the major producer of the different oil products. Therefore, COVID-19 had a double effect on their oil and ethanol markets.
Collapse
|
19
|
Mechanical Harvesting of Camelina: Work Productivity, Costs and Seed Loss Evaluation. ENERGIES 2020. [DOI: 10.3390/en13205329] [Citation(s) in RCA: 8] [Impact Index Per Article: 2.0] [Reference Citation Analysis] [Abstract] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 12/26/2022]
Abstract
Camelina is a low input crop than can be cultivated in rotation with cereals to provide vegetable oil suitable for bioenergy production, industrial applications and even as source of food for livestock. At large scale farming, camelina seeds are currently harvested using a combine harvester, equipped with a cereal header, but the literature still lacks the knowledge of the performance of the machine, the harvesting cost and the related loss of seeds. The present study aims to fulfill that gap by reporting the results obtained from an ad hoc harvest field test. Camelina seed yield was 0.95 Mg ha−1 which accounted for the 18.60% of the total above ground biomass. Theoretical field capacity, effective field capacity and field efficiency were 3.38 ha h−1, 3.17 ha h−1 and 93.7% respectively, albeit the seed loss was 80.1 kg ha−1 FM (7.82% w/w of the potential seed yield). The presence of material other than grain was rather high, 31.77% w/w, which implies a second step of cleaning to avoid undesired modification of the seed quality. Harvesting cost was estimated in 65.97 € ha−1. Our findings provide evidence on the suitability to use a conventional combine harvester equipped with a cereal header for the harvesting of camelina seeds, although some improvements are required to reduce both seed loss and impurities.
Collapse
|
20
|
Yan P, Zhao Y, Zhang H, Chen S, Zhu W, Yuan X, Cui Z. A comparison and evaluation of the effects of biochar on the anaerobic digestion of excess and anaerobic sludge. THE SCIENCE OF THE TOTAL ENVIRONMENT 2020; 736:139159. [PMID: 32485390 DOI: 10.1016/j.scitotenv.2020.139159] [Citation(s) in RCA: 25] [Impact Index Per Article: 6.3] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 02/09/2020] [Revised: 04/27/2020] [Accepted: 04/30/2020] [Indexed: 06/11/2023]
Abstract
The mechanisms and enhancing effects of different biochar loadings on the digesters receiving low and high excess (or anaerobic) sludge loadings were thoroughly examined in the present study. This was done to explore an efficient method for converting excess sludge to anaerobic sludge. Biochar had an obvious effect on the anaerobic digestion of excess sludge but not on the anaerobic sludge. When the amount of biochar added was equivalent to 100% of the sludge TS, the cumulative methane yields of anaerobic digestion inoculated with small and large amounts of excess sludge were respectively 30.2 and 1.7 times that of those without biochar. The number of methanogens in the digesters that received small and large inoculations of excess sludge with 100% biochar, were respectively 105.4% and 20.6% higher than those without biochar. The biochar enhanced the systems performance because it selectively enriched the Trichococcus and Methanomicrobiales tightly attach to it. This enhanced the synergy and overall activity of the system by promoting biofilm development. Ultimately, the integration of 100% biochar and excess sludge can be used as a substitute for anaerobic sludge as an inoculum by giving similar overall performance.
Collapse
Affiliation(s)
- Puxiang Yan
- College of Agronomy and Biotechnology, China Agricultural University, Beijing 100193, China
| | - Yubin Zhao
- College of Agronomy and Biotechnology, China Agricultural University, Beijing 100193, China
| | - Huan Zhang
- College of Resources and Environmental Sciences, Nanjing Agricultural University, Nanjing 210095, China
| | - Shanshuai Chen
- College of Agronomy and Biotechnology, China Agricultural University, Beijing 100193, China
| | - Wanbin Zhu
- College of Agronomy and Biotechnology, China Agricultural University, Beijing 100193, China
| | - Xufeng Yuan
- College of Agronomy and Biotechnology, China Agricultural University, Beijing 100193, China.
| | - Zongjun Cui
- College of Agronomy and Biotechnology, China Agricultural University, Beijing 100193, China
| |
Collapse
|
21
|
Developments in the Use of Lipase Transesterification for Biodiesel Production from Animal Fat Waste. APPLIED SCIENCES-BASEL 2020. [DOI: 10.3390/app10155085] [Citation(s) in RCA: 22] [Impact Index Per Article: 5.5] [Reference Citation Analysis] [Abstract] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 12/17/2022]
Abstract
Biodiesel constitutes an attractive source of energy because it is renewable, biodegradable, and non-polluting. Up to 20% biodiesel can be blended with fossil diesel and is being produced and used in many countries. Animal fat waste represents nearly 6% of total feedstock used to produce biodiesel through alkaline catalysis transesterification after its pretreatment. Lipase transesterification has some advantages such as the need of mild conditions, absence of pretreatment, no soap formation, simple downstream purification process and generation of high quality biodiesel. A few companies are using liquid lipase formulations and, in some cases, immobilized lipases for industrial biodiesel production, but the efficiency of the process can be further improved. Recent developments on immobilization support materials such as nanoparticles and magnetic nanomaterials have demonstrated high efficiency and potential for industrial applications. This manuscript reviews the latest advances on lipase transesterification and key operational variables for an efficient biodiesel production from animal fat waste.
Collapse
|
22
|
Chen SJ, Kuan IC, Tu YF, Lee SL, Yu CY. Surfactant-assisted in situ transesterification of wet Rhodotorula glutinis biomass. J Biosci Bioeng 2020; 130:397-401. [PMID: 32586661 DOI: 10.1016/j.jbiosc.2020.05.009] [Citation(s) in RCA: 2] [Impact Index Per Article: 0.5] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 03/11/2020] [Revised: 05/12/2020] [Accepted: 05/24/2020] [Indexed: 10/24/2022]
Abstract
In situ transesterification of oleaginous microbes with short chain alcohol has been developed as a renewable process for the production of biodiesel. Dry biomass is often a requisite for the process to avoid the adverse effect of water on the productivity. As a consequence, large amount of energy consumption is required for prior biomass drying. In this study, the wet biomass of Rhodotorula glutinis, an oleaginous yeast, was used directly in in situ transesterification without biomass drying. The reaction conditions were optimized for the production of fatty acid methyl esters (FAME) and the effects of adding different surfactants were also studied. The highest FAME yield of 110% was achieved with a methanol loading of 1:100 at 90°C for 8 h as catalyzed by 0.36 M H2SO4, and the FAME content was 97%, which meets the 96.5% specified in both European biodiesel standards and Taiwanese biodiesel standards. The addition of 50 mM 3-(N,N-dimethylmyristylammonio)propanesulfonate (3-DMAPS, a zwitterionic surfactant) improved the FAME yield from 69% to 83%, which was obtained with a low methanol loading of 1:10 at 90°C for 10 h. Hence, the production of FAME with wet biomass under optimized reaction conditions was as effective as that with the dry form. This clearly indicates that using wet R. glutinis as the feedstock is feasible for the production of biodiesel by in situ transesterification.
Collapse
Affiliation(s)
- Shih-Jie Chen
- Department of Chemical Engineering and Biotechnology, Tatung University, 40 Chungshan N. Rd. Sec. 3, Taipei 10452, Taiwan
| | - I-Ching Kuan
- Department of Chemical Engineering and Biotechnology, Tatung University, 40 Chungshan N. Rd. Sec. 3, Taipei 10452, Taiwan
| | - Yu-Feng Tu
- Department of Chemical Engineering and Biotechnology, Tatung University, 40 Chungshan N. Rd. Sec. 3, Taipei 10452, Taiwan
| | - Shiow-Ling Lee
- Department of Chemical Engineering and Biotechnology, Tatung University, 40 Chungshan N. Rd. Sec. 3, Taipei 10452, Taiwan
| | - Chi-Yang Yu
- Department of Chemical Engineering and Biotechnology, Tatung University, 40 Chungshan N. Rd. Sec. 3, Taipei 10452, Taiwan.
| |
Collapse
|
23
|
Abstract
The agro-food industry generates large amounts of waste that contribute to environmental contamination. Animal fat waste constitutes some of the most relevant waste and the treatment of such waste is quite costly because environmental regulations are quite strict. Part of such costs might be reduced through the generation of bioenergy. Biodiesel constitutes a valid renewable source of energy because it is biodegradable, non-toxic and has a good combustion emission profile and can be blended up to 20% with fossil diesel for its use in many countries. Furthermore, up to 70% of the total cost of biodiesel majorly depends on the cost of the raw materials used, which can be reduced using animal fat waste because they are cheaper than vegetable oil waste. In fact, 6% of total feedstock corresponded to animal fat in 2019. Transesterification with alkaline catalysis is still preferred at industrial plants producing biodiesel. Recent developments in heterogeneous catalysts that can be easily recovered, regenerated and reused, as well as immobilized lipases with increased stability and resistance to alcohol denaturation, are promising for future industrial use. This manuscript reviews the available processes and recent advances for biodiesel generation from animal fat waste.
Collapse
|
24
|
Ng HS, Kee PE, Yim HS, Chen PT, Wei YH, Chi-Wei Lan J. Recent advances on the sustainable approaches for conversion and reutilization of food wastes to valuable bioproducts. BIORESOURCE TECHNOLOGY 2020; 302:122889. [PMID: 32033841 DOI: 10.1016/j.biortech.2020.122889] [Citation(s) in RCA: 69] [Impact Index Per Article: 17.3] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 11/18/2019] [Revised: 01/21/2020] [Accepted: 01/22/2020] [Indexed: 05/28/2023]
Abstract
The increasing amounts of food wastage and accumulation generated per annum due to the growing human population worldwide often associated with environmental pollution issues and scarcity of natural resources. In view of this, science community has worked towards in finding sustainable approaches to replace the common practices for food waste management. The agricultural and food processing wastes rich in nutrients are often the attractive substrates for the bioconversion for valuable bioproducts such as industrial enzymes, biofuel and bioactive compounds. The sustainable approaches on the re-utilization of food wastes as the industrial substrates for production of valuable bioproducts has meet the goals of circular bioeconomy, results in the diversify applications and increasing market demands for the bioproducts. This review discusses the current practice and recent advances on reutilization of food waste for bioconversion of valuable bioproducts from agricultural and food processing wastes.
Collapse
Affiliation(s)
- Hui Suan Ng
- Faculty of Applied Sciences, UCSI University, UCSI Heights, 56000 Cheras, Kuala Lumpur, Malaysia
| | - Phei Er Kee
- Faculty of Applied Sciences, UCSI University, UCSI Heights, 56000 Cheras, Kuala Lumpur, Malaysia
| | - Hip Seng Yim
- Faculty of Applied Sciences, UCSI University, UCSI Heights, 56000 Cheras, Kuala Lumpur, Malaysia
| | - Po-Ting Chen
- Department of Biotechnology and Food Technology, Southern Taiwan University of Science and Technology, Tainan 710, Taiwan
| | - Yu-Hong Wei
- Biorefinery and Bioprocess Engineering Laboratory, Department of Chemical Engineering and Materials Science, Yuan Ze University, Chungli, Taoyuan 320, Taiwan
| | - John Chi-Wei Lan
- Biorefinery and Bioprocess Engineering Laboratory, Department of Chemical Engineering and Materials Science, Yuan Ze University, Chungli, Taoyuan 320, Taiwan.
| |
Collapse
|
25
|
Impacts of International Commodity Trade on Conventional Biofuels Production. SUSTAINABILITY 2020. [DOI: 10.3390/su12072626] [Citation(s) in RCA: 8] [Impact Index Per Article: 2.0] [Reference Citation Analysis] [Abstract] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 01/18/2023]
Abstract
The study gives an overview of raw materials and biofuel generation, markets, production, and regulation. The major aim of this study was to reveal the impacts of biofuel production on international commodity trade. According to the results of the country-level regressions, the export of corn and sugar cane have generally negatively impacted ethanol production. This effect was positive at the global level which indicates that some of the imported raw materials are used for ethanol production. Although the explanatory power of the models was relatively high (from 0.35 (EU) to 0.94 (USA)), none of models proved to be significant, even at the 10% level. These values were higher for the biodiesel models (from 0.53 (USA) to 0.97 (Brazil)) and the EU model results were significant at the 5% level. The export of raw materials had a positive impact on biodiesel production. This implies that some part of the biodiesel was produced from the imported raw materials. The export of processed products (different oils) had a negative impact on biodiesel production, as they are normally used for other purposes.
Collapse
|
26
|
Wu Q, Cao Y, Chen C, Gao Z, Yu F, Guy RD. Transcriptome analysis of metabolic pathways associated with oil accumulation in developing seed kernels of Styrax tonkinensis, a woody biodiesel species. BMC PLANT BIOLOGY 2020; 20:121. [PMID: 32183691 PMCID: PMC7079523 DOI: 10.1186/s12870-020-2327-4] [Citation(s) in RCA: 14] [Impact Index Per Article: 3.5] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Grants] [Track Full Text] [Subscribe] [Scholar Register] [Received: 06/19/2019] [Accepted: 03/02/2020] [Indexed: 05/04/2023]
Abstract
BACKGROUND Styrax tonkinensis (Pierre) Craib ex Hartwich has great potential as a woody biodiesel species having seed kernels with high oil content, excellent fatty acid composition and good fuel properties. However, no transcriptome information is available on the molecular regulatory mechanism of oil accumulation in developing S. tonkinensis kernels. RESULTS The dynamic patterns of oil content and fatty acid composition at 11 time points from 50 to 150 days after flowering (DAF) were analyzed. The percent oil content showed an up-down-up pattern, with yield and degree of unsaturation peaking on or after 140 DAF. Four time points (50, 70, 100, and 130 DAF) were selected for Illumina transcriptome sequencing. Approximately 73 million high quality clean reads were generated, and then assembled into 168,207 unigenes with a mean length of 854 bp. There were 5916 genes that were differentially expressed between different time points. These differentially expressed genes were grouped into 9 clusters based on their expression patterns. Expression patterns of a subset of 12 unigenes were confirmed by qRT-PCR. Based on their functional annotation through the Basic Local Alignment Search Tool and publicly available protein databases, specific unigenes encoding key enzymes, transmembrane transporters, and transcription factors associated with oil accumulation were determined. Three main patterns of expression were evident. Most unigenes peaked at 70 DAF, coincident with a rapid increase in oil content during kernel development. Unigenes with high expression at 50 DAF were associated with plastid formation and earlier stages of oil synthesis, including pyruvate and acetyl-CoA formation. Unigenes associated with triacylglycerol biosynthesis and oil body development peaked at 100 or 130 DAF. CONCLUSIONS Transcriptome changes during oil accumulation show a distinct temporal trend with few abrupt transitions. Expression profiles suggest that acetyl-CoA formation for oil biosynthesis is both directly from pyruvate and indirectly via acetaldehyde, and indicate that the main carbon source for fatty acid biosynthesis is triosephosphate originating from phosphohexose outside the plastid. Different sn-glycerol-3-phosphate acyltransferases are implicated in diacylglycerol biosynthesis at early versus late stages of oil accumulation. Triacylglycerol biosynthesis may be accomplished by both diacylglycerol and by phospholipid:diacylglycerol acyltransferases.
Collapse
Affiliation(s)
- Qikui Wu
- Collaborative Innovation Centre of Sustainable Forestry in Southern China, College of Forest Science, Nanjing Forestry University, 159 Longpan Road, Nanjing, 210037 Jiangsu China
- Department of Forest and Conservation Sciences, Faculty of Forestry, University of British Columbia, 2424 Main Mall, Vancouver, BC V6T 1Z4 Canada
| | - Yuanyuan Cao
- Collaborative Innovation Centre of Sustainable Forestry in Southern China, College of Forest Science, Nanjing Forestry University, 159 Longpan Road, Nanjing, 210037 Jiangsu China
| | - Chen Chen
- Collaborative Innovation Centre of Sustainable Forestry in Southern China, College of Forest Science, Nanjing Forestry University, 159 Longpan Road, Nanjing, 210037 Jiangsu China
| | - Zhenzhou Gao
- Collaborative Innovation Centre of Sustainable Forestry in Southern China, College of Forest Science, Nanjing Forestry University, 159 Longpan Road, Nanjing, 210037 Jiangsu China
| | - Fangyuan Yu
- Collaborative Innovation Centre of Sustainable Forestry in Southern China, College of Forest Science, Nanjing Forestry University, 159 Longpan Road, Nanjing, 210037 Jiangsu China
| | - Robert D. Guy
- Department of Forest and Conservation Sciences, Faculty of Forestry, University of British Columbia, 2424 Main Mall, Vancouver, BC V6T 1Z4 Canada
| |
Collapse
|
27
|
Schiessl S. Regulation and Subfunctionalization of Flowering Time Genes in the Allotetraploid Oil Crop Brassica napus. FRONTIERS IN PLANT SCIENCE 2020; 11:605155. [PMID: 33329678 PMCID: PMC7718018 DOI: 10.3389/fpls.2020.605155] [Citation(s) in RCA: 14] [Impact Index Per Article: 3.5] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Subscribe] [Scholar Register] [Received: 09/11/2020] [Accepted: 10/29/2020] [Indexed: 05/03/2023]
Abstract
Flowering is a vulnerable, but crucial phase in building crop yield. Proper timing of this period is therefore decisive in obtaining optimal yields. However, genetic regulation of flowering integrates many different environmental signals and is therefore extremely complex. This complexity increases in polyploid crops which carry two or more chromosome sets, like wheat, potato or rapeseed. Here, I summarize the current state of knowledge about flowering time gene copies in rapeseed (Brassica napus), an important oil crop with a complex polyploid history and a close relationship to Arabidopsis thaliana. The current data show a high demand for more targeted studies on flowering time genes in crops rather than in models, allowing better breeding designs and a deeper understanding of evolutionary principles. Over evolutionary time, some copies of rapeseed flowering time genes changed or lost their original role, resulting in subfunctionalization of the respective homologs. For useful applications in breeding, such patterns of subfunctionalization need to be identified and better understood.
Collapse
Affiliation(s)
- Sarah Schiessl
- Department of Plant Breeding, IFZ Research Centre for Biosystems, Land Use and Nutrition, Justus Liebig University Giessen, Giessen, Germany
- Department of Botany and Molecular Evolution, Senckenberg Research Institute and Natural History Museum Frankfurt, Frankfurt, Germany
- *Correspondence: Sarah Schiessl,
| |
Collapse
|
28
|
Biodiesel-Derived Glycerol Obtained from Renewable Biomass-A Suitable Substrate for the Growth of Candida zeylanoides Yeast Strain ATCC 20367. Microorganisms 2019; 7:microorganisms7080265. [PMID: 31426397 PMCID: PMC6722897 DOI: 10.3390/microorganisms7080265] [Citation(s) in RCA: 21] [Impact Index Per Article: 4.2] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 08/06/2019] [Revised: 08/14/2019] [Accepted: 08/15/2019] [Indexed: 12/17/2022] Open
Abstract
Used kitchen oil represents a feasible and renewable biomass to produce green biofuels such as biodiesel. Biodiesel production generates large amounts of by-products such as the crude glycerol fraction, which can be further used biotechnologically as a valuable nutrient for many microorganisms. In this study, we transesterified used kitchen oil with methanol and sodium hydroxide in order to obtain biodiesel and crude glycerol fractions. The crude glycerol fraction consisting of 30% glycerol was integrated into a bioreactor cultivation process as a nutrient source for the growth of Candida zeylanoides ATCC 20367. Cell viability and biomass production were similar to those obtained with batch cultivations on pure glycerol or glucose as the main nutrient substrates. However, the biosynthesis of organic acids (e.g., citric and succinic) was significantly different compared to pure glycerol and glucose used as main carbon sources.
Collapse
|