Use of wood-based materials in beef bedded manure packs: 2. Effect on odorous volatile organic compounds, odor activity value, , and nutrient concentrations

Ammonia, Hydrogen Sulfide, and Greenhouse Gas Emissions from Lab-Scaled Manure Bedpacks with and without Aluminum Sulfate Additions

The poultry industry has successfully used aluminum sulfate (alum) as a litter amendment to reduce NH3 emissions from poultry barns, but alum has not been evaluated for similar uses in cattle facilities. A study was conducted to measure ammonia (NH3), greenhouse gases (GHG), and hydrogen sulfide (H2S) emissions from lab-scaled bedded manure packs over a 42-day period. Two frequencies of application (once or weekly) and four concentrations of alum (0, 2.5, 5, and 10% by mass) were evaluated. Frequency of alum application was either the entire treatment of alum applied on Day 0 (once) or 16.6% of the total alum mass applied each week for six weeks. Ammonia emissions were reduced when 10% alum was used, but H2S emissions increased as the concentration of alum increased in the bedded packs. Nitrous oxide emissions were not affected by alum treatment. Methane emissions increased as the concentration of alum increased in the bedded packs. Carbon dioxide emissions were highest when 5% alum was applied and lowest when 0% alum was used. Results of this study indicate that 10% alum is needed to effectively reduce NH3 emissions, but H2S and methane emissions may increase when this concentration of alum is used.

Lab-Scale Model to Evaluate Odor and Gas Concentrations Emitted by Deep Bedded Pack Manure

A lab-scaled simulated bedded pack model was developed to study air quality and nutrient composition of deep-bedded packs used in cattle mono-slope facilities. This protocol has been used to effectively evaluate many different bedding materials, environmental variables (temperature, humidity), and potential mitigation treatments that can improve air quality in commercial deep-bedded mono-slope facilities. The model is dynamic and allows researchers to easily collect many chemical and physical measurements from the bedded pack. Weekly measurements, collected over the course of six to seven weeks, allows sufficient time to see changes in air quality measurements over time as the bedded pack matures. The data collected from the simulated bedded packs is within the range of concentrations previously measured in commercial deep-bedded mono-slope facilities. Past studies have demonstrated that 8 - 10 experimental units per treatment are sufficient to detect statistical differences among the simulated bedded packs. The bedded packs are easy to maintain, requiring less than 10 minutes of labor per bedded packs per week to add urine, feces, and bedding. Sample collection using the gas sampling system requires 20 - 30 minutes per bedded pack, depending on the measurements that are being collected. The use of lab-scaled bedded packs allows the researcher to control variables such as temperature, humidity, and bedding source that are difficult or impossible to control in a research or commercial facility. While not a perfect simulation of "real-world" conditions, the simulated bedded packs serve as a good model for researchers to use to examine treatment differences among bedded packs. Several lab-scale studies can be conducted to eliminate possible treatments before trying them in a research or commercial-sized facility.

Odorous Volatile Organic Compounds, Escherichia coli, and Nutrient Concentrations when Kiln-Dried Pine Chips and Corn Stover Bedding Are Used in Beef Bedded Manure Packs

Pine ( spp.) bedding has been shown to lower the concentration of odorous volatile organic compounds (VOCs) and pathogenic bacteria compared with corn ( L.) stover bedding, but availability and cost limit the use of pine bedding in cattle confinement facilities. The objectives of this study were to determine if the addition of pine wood chips to laboratory-scaled bedded packs containing corn stover (i) reduced odorous VOC emissions; (ii) reduced total ; and (iii) changed the nutrient composition of the resulting manure-bedded packs. Bedding treatments included 0, 10, 20, 30, 40, 60, 80, and 100% pine chips, with the balance being corn stover. Four bedded packs for each mixture were maintained for 42 d ( = 4 observations per bedding material). The production of total sulfur compounds increased significantly when 100% pine chips were used (44.72 ng L) compared with bedding mixture containing corn stover (18.0-24.56 ng L). The carbon-to-nitrogen ratio exceeded the ideal ratio of 24:1 for the optimum activity of soil microorganisms when ≥60% pine chips (25.3-27.5 ng L) were included in the mixture. The use of 100% pine chips as bedding increased sulfide concentration in the facility 1.8 to 2.4 times over the use of corn stover bedding. was not influenced by the addition of pine chips to the corn stover bedding material but did decrease as the bedded pack aged. Bedding material mixtures containing 30 to 60% pine and 40 to 70% corn stover may be the ideal combination to mitigate odors from livestock facilities using deep bedded systems.

Livestock GRACEnet: A Workgroup Dedicated to Evaluating and Mitigating Emissions from Livestock Production

Ammonia, greenhouse gases, and particulate emissions from livestock operations can potentially affect air quality at local, regional, and even global scales. These pollutants, many of which are generated through various anthropogenic activities, are being increasingly scrutinized by regulatory authorities. Regulation of emissions from livestock production systems will ultimately increase on farm costs, which will then be passed onto consumers. Therefore, it is essential that scientifically based emission factors are developed for on-farm emissions of air quality constituents to improve inventories and assign appropriate reduction targets. To generate a larger database of on-farm emissions, the USDA-ARS created the workgroup Livestock GRACEnet (Greenhouse gas Reduction through Agricultural Carbon Enhancement Network). This introduction for the special section of papers highlights some of the research presently being conducted by members of Livestock GRACEnet with the intent of drawing attention to critical information gaps, such as (i) improving emissions measurements; (ii) developing emissions factors; (iii) developing and validating tools for estimating emissions; and (iv) mitigating emissions. We also provide a synthesis of the literature with respect to key research areas related to livestock emissions, including feeding strategies, animal housing, manure management, and manure land application, and discuss future research priorities and directions.