Dry heating, moist heating, and microwave irradiation of cold-climate-adapted barley grain-Effects on ruminant-relevant carbohydrate and molecular structural spectral profiles

Different feed processing techniques affect barley digestibility and nutrient utilization in ruminants. To our knowledge, there are few studies on the interactive relationship between carbohydrate molecular structure profiles of cool-season-adapted barley grain and nutritional characteristics for ruminants. The objectives of this study were: (1) to investigate the effect of different technological processing methods on carbohydrate chemical profiles, Cornell Net Carbohydrate and Protein System-carbohydrate subfractions, ruminal and intestinal carbohydrate digestion of barley grain in dairy cows; (2) to study the effect of heat processing on carbohydrate molecular structure of barley grain using advanced molecular spectroscopy; and (3) to associate processing-induced changes in carbohydrate molecular structure with changes in carbohydrate metabolic profiles in dairy cows. Barley grain samples collected from Crop Research Field in Western Canada underwent four different processing treatments: control, dry heating (120°C for 60 min in an air-ventilated oven), moist heating (120°C for 60 min in an autoclave), and microwave irradiation (900 W and 2450 MHz for 5 min in a microwave). The heating conditions used in the current study induced some changes in rumen-degradable and -undegradable digestible fibre (CB3) fraction. Intestinally digestible CB3 was decreased after moist heating. Moist heating decreased starch digestibility compared to the other three treatments. The processing-induced carbohydrate molecular structure changes, which was revealed by advanced vibrational molecular spectroscopic technique (attenuated total reflectance-Fourier transform infrared), could be used to predict carbohydrate nutritional value.

Inclusion of Cocoa Bean Shell in the Diet of Dairy Goats: Effects on Milk Production Performance and Milk Fatty Acid Profile

The use of agro-industrial by-products in animal nutrition is a promising strategy to reduce the food-feed competition, the diet cost at farm level and the environmental impact of animal-derived food production. In this study, the suitability of cocoa bean shell (CBS), a by-product of the cocoa industry, as a feed ingredient in the diet of dairy goats was evaluated, with a focus on the related implications on feed intake, milk yield, milk main constituents, and fatty acid (FA) profile of milk fat. Twenty-two Camosciata delle Alpi goats were divided into two balanced groups. All the goats were fed mixed hay ad libitum. The control group (CTRL; n = 11) also received 1.20 kg/head × day of a commercial concentrate, while in the experimental group (CBS; n = 11) 200 g of the CTRL concentrate were replaced by the same amount of pelleted CBS. The total dry matter intake of the goats was reduced by the dietary inclusion of CBS (P ≤ 0.01). The milk yield, as well as the milk fat, protein, and casein contents and yields were unaffected by the treatment. Milk from the CBS-fed goats showed decreased urea content when compared to the CTRL group (P ≤ 0.001). Milk from the CBS group of goats also showed increased concentrations of total branched-chain FA (both iso and anteiso forms; P ≤ 0.001) and total monounsaturated FA (P ≤ 0.05), as well as a decreased ∑ n6/∑ n3 FA ratio (P ≤ 0.05). De novo saturated FA, total polyunsaturated FA, total conjugated linoleic acids, and the majority of ruminal biohydrogenation intermediates remained unaffected by the dietary treatment. These results suggest that CBS can be strategically used as an alternative non-conventional raw material in diets intended for lactating goats, with no detrimental effects on their milk production performance. The use of CBS in goat nutrition may be hindered by the presence of theobromine, a toxic alkaloid. Special attention is needed by nutritionists to avoid exceeding the theobromine limits imposed by the current legislation. Detheobromination treatments are also suggested in literature to prevent toxic phenomena.

Review: Markers and proxies to monitor ruminal function and feed efficiency in young ruminants

Developing the rumen's capacity to utilise recalcitrant and low-value feed resources is important for ruminant production systems. Early-life nutrition and management practices have been shown to influence development of the rumen in young animals with long-term consequences on their performance. Therefore, there has been increasing interest to understand ruminal development and function in young ruminants to improve feed efficiency, health, welfare, and performance of both young and adult ruminants. However, due to the small size, rapid morphological changes and low initial microbial populations of the rumen, it is difficult to study ruminal function in young ruminants without major invasive approaches or slaughter studies. In this review, we discuss the usefulness of a range of proxies and markers to monitor ruminal function and nitrogen use efficiency (a major part of feed efficiency) in young ruminants. Breath sulphide and methane emissions showed the greatest potential as simple markers of a developing microbiota in young ruminants. However, there is only limited evidence for robust indicators of feed efficiency at this stage. The use of nitrogen isotopic discrimination based on plasma samples appeared to be the most promising proxy for feed efficiency in young ruminants. More research is needed to explore and refine potential proxies and markers to indicate ruminal function and feed efficiency in young ruminants, particularly for neonatal ruminants.

Enzymatic effects of Pleurotus ostreatus spent substrate on whole-plant corn silage and performance of lactating goats

Pleurotus ostreatus (oyster mushroom) synthesizes enzymes that degrade lignin, cellulose, and hemicellulose. The objectives of this study were to evaluate the effect of Pleurotus ostreatus spent substrate (POSS) on whole-plant corn silage (WPCS) chemical composition, antioxidant capacity, lignin monomers, and in vitro digestibility, as well as the performance of lactating goats fed corn silage treated with different levels of POSS. In experiment 1, 4 levels of lignocellulolytic enzymes were tested in a complete randomized design: 0, 10, 20, and 30 mg of lignocellulosic enzymes per kilogram of fresh matter, 4 replicates per treatment (vacuum-sealed bags). The bags were opened 60 d after ensiling. In experiment 2, corn silage treated with 3 enzyme levels (0, 10, or 30 mg/kg of fresh matter) was fed to lactating goats as part of the total mixed ration. Nine lactating Saanen goats (62.68 ± 7.62 kg BW; 44 ± 8 d in milk; 2.91 ± 0.81 kg of milk/day, mean ± SD) were assigned to three 3 × 3 Latin squares. Data were analyzed using the GLIMMIX procedure of SAS (version 9.4, SAS Institute Inc.), and means were compared by linear and quadratic orthogonal contrast. In experiment 1, neutral detergent fiber (NDF), acid detergent fiber (ADF), lignin, and cellulose quadratically decreased in the WPCS treated with POSS. At the nadir point, POSS decreased NDF by 14.1%, ADF by 19.5%, lignin by 9.07%, and cellulose by 22.1% compared with the untreated silage. Therefore, POSS led to a quadratic increase in in vitro dry matter digestibility of WPCS (+8.88% at the vertex) compared with the untreated silage. In experiment 2, POSS quadratically increased the in vivo total-tract ADF digestibility. Also, the concentration of polyphenols in the milk of goats linearly increased with the addition of POSS, and no differences were observed among treatments for milk yield and composition. In summary, adding 10 mg of lignocellulolytic enzymes from POSS per kilogram of fresh matter of whole-plant corn at ensiling had a more evident reduction in lignin and cellulose concentration, leading to greater in vitro digestibility, as well as greater in vivo ADF digestibility; however, milk yield was not different among treatments.

Diets for Dairy Cows with Different Proportions of Crude Protein Originating from Red Clover Silage versus Soybean Meal: Ruminal Degradation and Intestinal Digestibility of Amino Acids

The purpose was to assess the effect of exchanging crude protein (CP) of soybean meal (SBM) with red clover silage (RCS) in total mixed rations (TMR) on ruminal degradation and intestinal digestibility (ID) of essential amino acids (EAA). Four TMR and their individual feed components were studied. The TMR were composed of forage and concentrates (75:25), with proportions of RCS in TMR of 0.15, 0.30, 0.45, and 0.60 on a dry matter basis, resulting in diet groups RCS15, RCS30, RCS45, and RCS60, respectively. The ruminal degradation of EAA was determined using the nylon bag technique. For this, samples of TMR and their individual feed components were ruminally incubated for 16 h. The feed residues of TMR obtained after 16 h of incubation were used for the determination of ID of EAA using the mobile-bag technique. Increasing RCS and reducing SBM proportions linearly increased (p < 0.01) the in situ ruminal degradation of individual EAA from 75.5% to 83.5%. The degradation of EAA followed the trend of CP degradation among TMR, except for Cys that was lower (p < 0.05) than that of CP in RCS60 (79.7% vs. 86.3%). The degradation of EAA in individual feed ingredients not always corresponded to the degradation of CP and was feed dependent. Increasing the proportions of RCS in the TMR linearly reduced (p < 0.001) the ID of EAA (except for Ile) from 78.2% to 67.3%. However, the ID of EAA did not always reflect the ID of CP, and in general, the differences between the ID of CP and EAA increased as RCS increased in the TMR. The ID values of most of the EAA were similar (p > 0.05) to ID of CP in RCS15 and RCS30, while they mostly differed (p < 0.05) in RCS45 and RCS60, and being higher for EAA than CP (except for Cys that was lower than CP, p < 0.05). Similar trends were observed for intestinal absorbable AA, resulting in higher values (p < 0.05) of intestinal absorbable for all EAA than of CP in diet RCS60. In conclusion, increasing levels of RCS in TMR reduced the extent of EAA flow into the small intestine, the ID of EAA, and consequently the intestinal absorbable EAA. Therefore, accurate determination of metabolizable AA must be considered for optimal diet formulation when including high proportions of RCS in diets of high-producing dairy cows.

Effects of Heat Treatment of Green Protein on in Situ Protein Disappearance and in Vitro Fatty Acid Biohydrogenation

Soluble protein extracted from leaves and stems of grasses and forage legumes is defined as green protein. The present study was conducted to evaluate in situ green protein degradability, intestinal protein disappearance, and in vitro fatty acids biohydrogenation (BH) in dairy cows. Three green protein concentrates (red clover, ryegrass, and grass clover) were heat treated as follows: oven-drying at 70 °C, subsequent autoclaving at 121 °C for 45 min, and for grass clover also spin flash-drying. Freeze-dried green protein was considered as a control (untreated). Autoclaving and oven-drying of green protein reduced the crude protein and dry matter degradability. The linolenic acid BH rate was lowest in heat-treated grass clover concentrate ( P < 0.01). In conclusion, green proteins are heat sensitive, and oven-drying can be an appropriate method to increase the amount of protein and unsaturated fatty acids escaping from the rumen.

Effects of heat treatment on protein feeds evaluated in vitro by the method of estimating utilisable crude protein at the duodenum

The effect of heat treatment on the protein value of field beans, lupins and peas was studied using an in vitro method. Protein feeds were subjected to heat treatment for 30, 60 and 90 min in forced air oven at 120, 140 and 160 °C and in autoclave at 105, 120 and 135 °C. The heat-treated protein feeds were incubated in buffered rumen fluid together with grass silage and barley in complete isonitrogenous diets. The gas production (GP) was recorded continuously, and ammonia-N (NH₃ -N) concentrations were determined during the in vitro incubation at 8, 24 and 48 h and used to determine the utilisable crude protein (uCP) at the duodenum at 16 h of incubation (uCP₁₆ ). Heat treatments decreased the concentration of soluble crude protein and increased neutral detergent insoluble CP (NDICP) in all protein feeds compared to untreated. Inclusion of protein feeds to basal diet showed no increase in the uCP₁₆ in untreated field bean diet and only a small numerical increase in the uCP₁₆ concentrations from 160 g/kg dry matter (DM) to 166 and 172 g/kg DM in untreated lupine and pea diets, respectively, indicating high degradability of untreated feeds. Increasing the time and temperature of the heat treatment linearly increased the uCP₁₆ concentrations in field bean and pea diets, but not in lupin diets. Autoclave treatment was more effective in decreasing uCP₁₆ than oven treatment despite the lower temperatures used. However, the combination of highest temperatures and treatment time in autoclave increased acid detergent insoluble CP (ADICP) concentrations in protein feeds, indicating protein damage and decreased intestinal digestibility. Determining in vitro uCP and ADICP shows to be a promising method for evaluating protein value in heat-treated animal feeds.

The Cornell Net Carbohydrate and Protein System: Updates to the model and evaluation of version 6.5

New laboratory and animal sampling methods and data have been generated over the last 10 yr that had the potential to improve the predictions for energy, protein, and AA supply and requirements in the Cornell Net Carbohydrate and Protein System (CNCPS). The objectives of this study were to describe updates to the CNCPS and evaluate model performance against both literature and on-farm data. The changes to the feed library were significant and are reported in a separate manuscript. Degradation rates of protein and carbohydrate fractions were adjusted according to new fractionation schemes, and corresponding changes to equations used to calculate rumen outflows and postrumen digestion were presented. In response to the feed-library changes and an increased supply of essential AA because of updated contents of AA, a combined efficiency of use was adopted in place of separate calculations for maintenance and lactation to better represent the biology of the cow. Four different data sets were developed to evaluate Lys and Met requirements, rumen N balance, and milk yield predictions. In total 99 peer-reviewed studies with 389 treatments and 15 regional farms with 50 different diets were included. The broken-line model with plateau was used to identify the concentration of Lys and Met that maximizes milk protein yield and content. Results suggested concentrations of 7.00 and 2.60% of metabolizable protein (MP) for Lys and Met, respectively, for maximal protein yield and 6.77 and 2.85% of MP for Lys and Met, respectively, for maximal protein content. Updated AA concentrations were numerically higher for Lys and 11 to 18% higher for Met compared with CNCPS v6.0, and this is attributed to the increased content of Met and Lys in feeds that were previously incorrectly analyzed and described. The prediction of postruminal flows of N and milk yield were evaluated using the correlation coefficient from the BLUP (R(2)BLUP) procedure or model predictions (R(2)MDP) and the concordance correlation coefficient. The accuracy and precision of rumen-degradable N and undegradable N and bacterial N flows were improved with reduced bias. The CNCPS v6.5 predicted accurate and precise milk yield according to the first-limiting nutrient (MP or metabolizable energy) with a R(2)BLUP=0.97, R(2)MDP=0.78, and concordance correlation coefficient=0.83. Furthermore, MP-allowable milk was predicted with greater precision than metabolizable energy-allowable milk (R(2)MDP=0.82 and 0.76, respectively, for MP and metabolizable energy). Results suggest a significant improvement of the model, especially under conditions of MP limitation.

In situ ruminal degradation of amino acids and in vitro protein digestibility of undegraded CP of dried distillers' grains with solubles from European ethanol plants

The objectives of this study were to compare the in situ ruminal degradation of CP and amino acids (AAs) of dried distillers' grains with solubles (DDGS), and to estimate intestinal digestibility (ID) of undegradable crude protein (UDP) with the in vitro pepsin-pancreatin solubility of CP (PPS), using either DDGS samples (DDGS-s) or DDGS residues (DDGS-r) obtained after 16 h ruminal incubation. Thirteen samples originating from wheat, corn, barley and blends were studied. Lysine and methionine content of DDGS-s varied from 1.4 to 4.0 and 1.3 to 2.0 g/16 g N, respectively. The milk protein score (MPS) of DDGS-s was low and ranged from 0.36 to 0.51, and lysine and isoleucine were estimated to be the most limiting AAs in DDGS-s and DDGS-r. DDGS-r contained slightly more essential AAs (EAAs) than did the DDGS-s. Rumen degradation after 16 h varied from 44% to 94% for CP, from 39% to 90% for lysine and from 35% to 92% for methionine. Linear regressions showed that the ruminal degradation of individual AAs can be predicted from CP degradation. The PPS of DDGS-s was higher than that of DDGS-r and it varied from 70% to 89% and from 47% to 81%, respectively. There was no significant correlation between the PPS of DDGS-s and PPS of DDGS-r (R 2=0.31). The estimated intestinally absorbable dietary protein (IADP) averaged 21%. Moderate correlation was found between the crude fibre (CF) content and PPS of DDGS-r (R 2=0.43). This study suggests an overestimation of the contribution of UDP of DDGS to digestible protein supply in the duodenum in some currently used protein evaluation systems. More research is required and recommended to assess the intestinal digestibility of AAs from DDGS.