Effect of lactose standardization of milk using low-concentration factor ultrafiltration: Effect of reducing the lactose-to-casein ratio on the properties of milled-curd Cheddar cheese

The pH of cheese is determined by the amount of lactose fermented and the buffering capacity of the cheese. The buffering capacity of cheese is largely determined by the protein contents of milk and cheese and the amount of insoluble calcium phosphate in the curd, which is related to the rate of acidification. The objective of this study was to standardize both the lactose and casein contents of milk to better control final pH and prevent the development of excessive acidity in Cheddar cheese. This approach involved the use of low-concentration factor ultrafiltration of milk to increase the casein content (∼5%), followed by the addition of water, ultrafiltration permeate, or both to the retentate to adjust the lactose content. We evaluated milks with 4 different lactose-to-casein ratios (L:CN): 1.8 (control milk), 1.4, 1.1, and 0.9. All cheesemilks had similar total casein (2.3%) and fat (3.4%) contents. These milks were used to make milled-curd Cheddar cheese, and we evaluated cheese composition, texture, functionality, and sensory properties over 9 mo of ripening. Cheeses made from milks with varying levels of L:CN had similar moisture, protein, fat, and salt contents, due to slight modifications during manufacture (i.e., cutting the gel at a smaller size than control) as well as control of acid development at critical steps (i.e., cutting the gel, whey drainage, salting). As expected, decreasing the L:CN led to cheeses with lower lactic acid, residual lactose, and insoluble Ca contents, as well as a substantial pH increase during cheese ripening in cheeses. The L:CN ratio had no significant effect on the levels of primary and secondary proteolysis. Texture profile analysis showed no significant differences in hardness values during ripening. Maximum loss tangent, an index of cheese meltability, was lower until 45 d for the L:CN 1.4 and 0.9 treatments, but after 45 d, all reduced L:CN cheeses had higher maximum loss tangent values than the control cheese (L:CN 1.8). Sensory analyses showed that cheeses made from milks with reduced L:CN contents had lower acidity, sourness, sulfury notes, and chewdown cohesiveness. Standardization of milk to a specific L:CN ratio, while maintaining a constant casein level in the milk, would allow Cheddar cheese manufacturers to have tighter control of pH and acidity.

Effect of Pseudomonas fluorescens proteases on the quality of Cheddar cheese

The objective of this study was to investigate the effect of adding different levels of a thermoresistant protease produced by a Pseudomonas fluorescens strain to milk on the manufacture and quality of Cheddar cheese. Fresh raw milk was collected, standardized, and pasteurized at 72°C for 15 s, and the enzyme was added to give a protease activity of 0.15 or 0.60 U/L (treatments P1 and P4, respectively), while one sample had no enzyme added (control). Milk was stored at 4°C for 48 h and Cheddar cheese was manufactured after 0 and 48 h of storage. Results indicated that the protease was active in milk during 48 h of storage; however, its effect on milk composition was minimal. The protein that was preferentially hydrolyzed by the protease over storage was β-casein, followed by κ-casein. The mean cheese yield and recovery of fat and protein obtained for all cheeses were not affected by protease activity. The protease showed low activity during cheese manufacture, possibly because of unfavorable conditions, including low pH. One of the factors that might have influenced protease activity was the pH of the curd (approximately 6.55 after acidification and 5.35 at milling), which was lower than that at which the enzyme would have optimum activity (pH 7 to 9). Consequently, the composition, pH, patterns of proteolysis, and hardness of all cheeses produced were similar and in accordance with values expected for that type of cheese, independently of the protease activity level. However, slight increases in proteolysis were observed in P4 cheeses and produced using milk stored for 48 h. Both the P1 and P4 cheeses had higher concentrations of free amino acids (FAA) compared with the control, whereas urea-PAGE electrophoretograms indicated a greater breakdown of caseins in the P4 cheese samples, which may be related to possible increases in numbers of proteolytic bacteria in milk during storage. Therefore, the thermoresistant psychrotrophic bacterial protease(s) tested in this study may affect the manufacture or quality of Cheddar cheese during ripening to a relatively limited extent. However, controlling initial levels of proteolytic bacteria in raw milk remains essential, because proteolysis affects the development of flavor and texture in cheese.

Influence of buttermilk powder or buttermilk addition on phospholipid content, chemical and bio-chemical composition and bacterial viability in Cheddar style-cheese

The effect of buttermilk powder addition post-curd formation or buttermilk addition to cheese milk on total and individual phospholipid content, chemical composition, enzyme activity, microbial populations and microstructure within Cheddar-style cheese was investigated. Buttermilk or buttermilk powder addition resulted in significant increases in total phospholipid content and their distribution throughout the cheese matrix. Addition of 10% buttermilk powder resulted in higher phospholipid content, moisture, pH and salt in moisture levels, and lower fat, fat in dry matter, L. helveticus and non-starter bacteria levels in cheeses. Buttermilk powder inclusion resulted in lower pH4.6/Soluble Nitrogen (SN) levels and significantly lower free amino acid levels in 10% buttermilk powder cheeses. Buttermilk addition provided a more porous cheese microstructure with greater fat globule coalescence and increased free fat pools, while also increasing moisture and decreasing protein, fat and pH levels. Addition of buttermilk in liquid or powdered form offers potential for new cheeses with associated health benefits.