Comparative study of interfacial properties and thermal behaviour of milk fat globules and membrane prepared from ultrasonicated bovine milk

Milk fat globules or milk fat globule membranes (MFGs/MFGM) have been added to the infant formula to fortify the phospholipids and narrow the nutritional gap from breast milk. The main aim of this study was to profile the interfacial and thermal properties of MFGs/MFGM prepared from ultrasonicated bovine milk. Bovine milk was sonicated at ultrasonic intensities of 20 kHz and 40 kHz independently or synchronously with the duration time of 0 min (control), 5 min, 10 min, and 15 min (work/rest cycles = 5 s: 3 s). Ultrasonic treatments at 20 kHz/ 5 min and 20 + 40 kHz/ 5 min improved the volume density (%) of smaller particles (1-10 µm) while significantly decreasing the surface hydrophobicity (H0) (p < 0.05). 40 kHz/5 min samples showed significantly higher ζ- potential than the other samples (p < 0.05), which might be because more negative charges were detected. In comparison with control samples, ultrasonic treatments decreased the interfacial tension (π) between the air and MFGs/MFGM liquid phase. 20 kHz ultra-sonicated treatments decreased the diffusion rate (k diff) of MFGs/MFGM interfacial compositions significantly as the duration prolonged from 5 min to 15 min (p < 0.05) but did not affect the adsorption or penetration rate (k a) (p > 0.05). X-ray diffraction (XRD) results showed that α-crystal peaks only existed in control and ultrasonicated 5 min samples but disappeared in all 15 min samples. According to the different scanning calorimetry (DSC), one or two new exothermic events (in the range of 17.29 - 18.81 ℃ and 22.14 - 25.21 ℃) appeared after ultrasonic treatments, which, however, were not found in control samples. Ultrasonic treatments resulted in the low-melting fractions (LMF) (TM1) peaks undetectable in MFGs/MFGM samples in which only peaks of medium-melting fractions (MMF) (TM2) and high-melting fractions (HMF) (TM3) were detected. Compared with the control, both enthalpies of crystallisation (ΔHC) and melting (ΔHM) decreased in ultrasonicated samples. In conclusion, ultrasonic treatment affects the interfacial and thermal properties of MFGs/MFGM.

Microbacterium represents an emerging microorganism of concern in microfiltered extended shelf-life milk products

Growing interest in the manufacture of extended shelf-life (ESL) milk, which is typically achieved by a high-temperature treatment called ultra-pasteurization (UP), is driven by distribution challenges, efforts to reduce food waste, and more. Even though high-temperature, short-time (HTST) pasteurized milk has a substantially shorter shelf life than UP milk, HTST milk is preferred in the United States because consumers tend to perceive UP milk as less desirable due to the "cooked" flavor associated with high-temperature processing. While ESL beyond 21 d may be possible for HTST, the survival and outgrowth of psychrotolerant aerobic spore-forming bacteria can still be a limitation to extending shelf life of HTST milk. Microfiltration (MF) is effective for reducing vegetative microorganisms and spores in raw milk, but it is unclear what the effects of membrane pore size, storage temperature, and milk type (i.e., skim vs. whole) are on the microbial shelf life of milk processed by both MF and HTST pasteurization. To investigate these factors, raw skim milk was MF using different pore sizes (0.8 or 1.2 μm), and then MF skim milk and standardized whole milk (MF skim with heat-treated [85°C for 20 s] cream) were HTST pasteurized at 75°C for 20 s. Subsequently, milk was stored at 3°C, 6.5°C, or 10°C and total bacteria counts were measured for up to 63 d. An ANOVA indicated that mean bacterial concentrations between storage temperatures were significantly different from each other, with mean maximum observed concentrations of 3.67, 5.33, and 8.08 log10 cfu/mL for storage temperatures 3°C, 6.5°C, and 10°C, respectively. Additionally, a smaller difference in mean maximum bacterial concentrations throughout shelf life was identified between pore sizes (<1 log cfu/mL), but no significant difference was attributed to milk type. An unexpected outcome of this study was the identification of Microbacterium as a major contributor to the bacterial population in MF ESL milk. Microbacterium is a psychrotolerant, thermoduric gram-positive, non-spore-forming rod with a small cell size (∼0.9 μm length and ∼0.3 μm width), which our data suggest was able to permeate the membranes used in this study, survive HTST pasteurization, and then grow at refrigeration temperatures. While spores continue to be a key concern for the manufacture of MF, ESL milk, our study demonstrates the importance of other psychrotolerant, thermoduric bacteria such as Microbacterium to these products.

Lipidomic and Proteomic Profiling of the Milk Fat Globule Membrane from Different Industrial By-Products of the Butter and Butter Oil Manufacturing Process

Recent studies have demonstrated the positive effects of regular intake of milk fat globule membranes (MFGMs) on neural and cognitive development, as well as immune and gastrointestinal health in infants and elders. Dairy products and by-products generated from the butter and butter oil manufacturing process are valuable sources of MFGM. Thus, in view of the growing need to reduce by-products and waste, it is crucial to foster research aimed at the valorization of dairy by-products rich in MFGM. For this purpose, all the by-products coming from butter and butter oil production (from raw milk to the related by-products) were used to study the MFGM isolated fractions, followed by their characterization through a combined lipidomic and proteomic approach. The patterns of polar lipids and proteins indicated that buttermilk (BM), butterserum (BS), and their mix (BM-BS blend) are the most suitable by-products to be employed as starting material for the isolation and purification of MFGMs, thus obtaining MFGM-enriched ingredients for the manufacture of products with high biological activity.

Changes in Milk Fat Globules and Membrane Proteins Prepared from pH-Adjusted Bovine Raw Milk

Milk fat globules (MFGs) have tri-layer biological membrane structures, and their compositions are gaining more interest for their physiological benefits. In this study, the changes in MFGs and milk fat globule membrane (MFGM) proteins after cream separation from different pH bovine raw milk were investigated. Raw milk samples were adjusted to pH 5.30 and 6.30 using citric acid at 25 °C. The effect of pH and centrifugation on the structure of MFGs was evaluated by means of particle size, zeta potential and confocal laser scanning microscopy (CLSM). Sodium dodecyl sulfate-polyacrylamide gel electrophoresis (SDS-PAGE) was used to analyze the proteins in the obtained fractions. It was found that both pH and centrifugation could affect the particle size of all samples. As the volume distribution (Dv; Dv (10), Dv(50)and Dv (90)) decreased, the corresponding specific surface area (SSA) increased, and span and uniformity values showed the same trend. The decrease in the zeta potential of MFG correlated with the Dv(50), which was further confirmed by CLSM observation. More butyrophilin (BTN) and periodic acid Schiff 6/7 (PAS 6/7) were lost in cream samples at pH 5.30. The findings could provide valuable knowledge for the application of MFGs ingredient in the food industry since their structures and compositions could affect their potential functional and physiological properties.

Variation in milk fat globule size and composition: A source of bioactives for human health

Milk fat globules (MFGs) are secreted from the mammalian gland and are composed of a triacylglycerol core surrounded by a triple membrane structure, the milk fat globule membrane (MFGM). The MFGM contains complex lipids and proteins reported to have nutritional, immunological, neurological and digestive functions. Human and ruminant milk are shown to share a similar MFG structure but with different size, profile and abundance of protein and polar lipids. This review summarizes the reported data on human, bovine, caprine and ovine MFG composition and concentration of bioactive components in different MFG-size fractions. A comprehensive understanding of compositional variations between milk from different species and MFG size fractions may help promote various milk sources as targeted supplements to improve human development and health. MFG size and MFGM composition are species-specific and affected by lactation, diet and breed (or maternal origin). Purification and enrichment methods for some bioactive proteins and lipids present in the MFGM have yet to be established or are not scaled sufficiently to be used to supplement human diets. To overcome this problem, MFG size selection through fractionation or herd selection may provide a convenient way to pre-enrich the MFG fraction with specific protein and lipid components to fulfill human dietary and health requirements.

Evaluation of Fetal Intestinal Cell Growth and Antimicrobial Biofunctionalities of Donor Human Milk After Preparative Processes

BACKGROUND

Donor human milk is considered the next best nutrition following mother's own milk to prevent neonatal infection and necrotizing enterocolitis in preterm infants who are admitted at neonatal intensive care unit. However, donor milk biofunctionalities after preparative processes have rarely been documented.

OBJECTIVE

To evaluate biofunctionalities preserved in donor milk after preparative processes by cell-based assays.

MATERIALS AND METHODS

Ten pools of donor milk were produced from 40 independent specimens. After preparative processes, including bacterial elimination methods (holder pasteurization and cold-sterilization microfiltration) and storage conditions (-20°C freezing storage and lyophilization) with varied duration of storage (0, 3, and 6, months), donor milk biofunctionalities were examined by fetal intestinal cell growth and antimicrobial assays.

RESULTS

At baseline, raw donor milk exhibited 193.1% ± 12.3% of fetal intestinal cell growth and 42.4% ± 11.8% of antimicrobial activities against Escherichia coli. After bacteria eliminating processes, growth promoting activity was better preserved in pasteurized donor milk than microfiltrated donor milk (169.5% ± 14.3% versus 146.0% ± 11.8%, respectively; p < 0.005), whereas antimicrobial activity showed no difference between groups (38.3% ± 14.1% versus 53.7% ± 17.3%, respectively; p = 0.499). The pasteurized donor milk was further examined for the effects of storage conditions at 3 and 6 months. Freezing storage, but not lyophilization, could preserve higher growth-promoting activity during 6 months of storage (163.0% ± 9.4% versus 72.8% ± 6.2%, respectively; p < 0.005). Nonetheless, antimicrobial activity was lost at 6 months, regardless of the storage methods.

CONCLUSIONS

This study revealed that fetal intestinal cell growth and antimicrobial assays could be applied to measure donor milk biofunctionalities and support the utilization of donor milk within 3 months after preparative processes.

Milk fat globules and associated membranes: Colloidal properties and processing effects

The composition and physical-chemical properties of the milk fat globule membrane (MFGM) is a subject that has gained increased interest in the field of food colloids, mainly because the nutritional and technological value of the MFGM. In fact, related changes in integrity and structure during milk processing pose a huge challenge as far as efforts directed to isolate the components of the fat globule membrane. MFGM characteristics and potential utilization are subjects of dissension. Thus, the effects of processing and the colloidal interactions that exist with other milk constituents need to be better understood in order to exploit milk fat and MFGM, their functionality as colloids as well as those of their components. These are the main subjects of this review, which also reports on the results of recent inquiries into MFGM structure and colloidal behavior.