Effect of Milk Type Subjected to Different Heat Treatments on Cryo-Survivability and In Vivo Fertility of Buffalo (Bubalus bubalis) Spermatozoa in a Milk-Based Extender

Oxidative stress is a major contributory factor to cellular damage during semen cryopreservation and results in a decreased fertilizing capacity of cryopreserved bull sperm. The inclusion of exogenous antioxidants sometimes exerts deleterious effects on sperm quality. Thus, enhancing the endogenous production of antioxidants is a requirement. This study aimed to investigate the effect of milk type heated at different temperatures on the antioxidant potential of extenders, and the subsequent post-thaw quality parameters and in vivo fertility of buffalo bull semen. Cow (C) and buffalo whole milk (B) were used separately for semen extender preparation, heated at five different temperatures (T₁ = 90°C, T₂ = 100°C, T₃ = 110°C, T₄ = 120°C, T₅ = 130°C) for 10 minutes. Reactive sulfhydryl groups were measured in each subgroup by Ellman's reagents as CT₁ = 143.2 μM, CT₂ = 147.4 μM, CT₃ = 151.5 μM, CT₄ = 157.2 μM, CT₅ = 161.8 μM, BT₁ = 168.3 μM, BT₂ = 172.5 μM, BT₃ = 176.7 μM, BT₄ = 196.3 μM, and BT₅ = 205.7 μM. All semen samples were cryopreserved in milk-based extenders by using standard procedures. Post-thaw quality parameters including total and progressive motility, mitochondrial membrane potential, plasma membrane integrity, and acrosome integrity were found to be higher (p < 0.05) in the group (BT₃) containing buffalo milk heated at 110°C, whereas in the same group, lipid peroxidation was found to be lower (p < 0.05) as compared with other treatment groups and control group. In vivo fertility of cryopreserved buffalo sperm was compared among BT₃, CT₁ (conventionally used milk extender), and a Tris egg yolk extender group. The fertility rates [47% (54/114), 30% (33/108), and 36% (37/103)] were higher (p < 0.05) in BT₃ as compared with other groups. This study suggests that buffalo milk heated at 110°C has high antioxidant potential and improves post-thaw quality and in vivo fertility of cryopreserved buffalo bull semen.

Influence of Processing Temperature on Membrane Performance and Characteristics of Process Streams Generated during Ultrafiltration of Skim Milk

The effects of processing temperature on filtration performance and characteristics of retentates and permeates produced during ultrafiltration (UF) of skim milk at 5, 20, and 50 °C were investigated. The results indicate that despite higher flux at 50 °C, UF under these conditions resulted in greater fouling and rapid flux decline in comparison with 5 and 20 °C. The average casein micelle diameter was higher in retentate produced at 5 and 20 °C. The retentate analysed at 5 °C displayed higher viscosity and shear thinning behaviour as compared to retentate analysed at 20 and 50 °C. Greater permeation of calcium and phosphorus was observed at 5 and 20 °C in comparison with 50 °C, which was attributed to the inverse relationship between temperature and solubility of colloidal calcium phosphate. Permeation of α-lactalbumin was observed at all processing temperatures, with permeation of β-lactoglobulin also evident during UF at 50 °C. All UF retentates were shown to have plasmin activity, while lower activity was measured in retentate produced at 5 °C. The findings revealed that UF processing temperature influences the physicochemical, rheological, and biochemical properties of, and thereby govern the resulting quality and functionality of, retentate- and permeate-based dairy ingredients.

Changes in concentration of aflatoxin M1 during manufacture and storage of skim milk powder

In this study, skim milk powder was produced from cow's milk contaminated artificially with aflatoxin M1 (AFM1) at two different levels, 1.5 and 3.5 microg/liter (ppb), and the effects of process stages on the AFM1 contents were investigated. Pasteurization, concentration, and spray drying caused losses of about 16, 40, and 68%, respectively, in AFM1 content of the milk contaminated with 1.5 microg/liter AFM1, and losses of 12, 35, and 59%, respectively, in the milk contaminated with 3.5 microg/liter AFM1. These losses were found to be statisticially significant at the level of P < 0.01. After 3- and 6-month storage periods, AFM1 content of the skim milk powder produced from milk with 1.5 microg/liter AFM1 decreased by 2 and 5%, respectively, whereas these rates were 2 and 4%, respectively, for the skim milk powders made from milk with 3.5 microg/liter AFM1 (after adjustment for sample weight). Changes in AFM1 content of milk powder samples were found statistically insignificant (P > 0.05 and P > 0.01) for 3- and 6-month storage periods.