Financial Analysis of the Use of Two Horizontal Drain Water Heat Recovery Units

Horizontal Shower Heat Exchanger as an Effective Domestic Hot Water Heating Alternative

Wastewater has significant potential as a source of clean energy. This energy can be used both within external sewer networks and on the scale of individual residential buildings, and the use of shower heat exchangers appears to be the most reasonable solution. However, in the case of Poland, the problem is still the unwillingness of society to use this type of solution, caused mainly by the lack of space for the installation of vertical drain water heat recovery (DWHR) units and the low efficiency of horizontal units. In response to this issue, the efficiency of a new compact shower heat exchanger designed to be mounted below the shower tray, as well as its linear counterpart, was investigated under various operating conditions. In addition, the financial efficiency of using the compact DWHR unit with average water consumption for showering was evaluated. For this purpose, discount methods were used to estimate the financial efficiency of investments. The study showed that the compact shower heat exchanger has higher efficiency than its linear counterpart. Depending on the temperature of cold water and the flow rate of both media through the heat exchanger, it achieves efficiencies ranging from 22.43% to 31.82%, while the efficiency of the linear DWHR unit did not exceed 23.03% in the study. The financial analysis showed that its use is particularly beneficial when the building uses an electric hot water heater. The investment’s sensitivity to changes in the independent variables is small in this case, even with low water consumption per shower. The only exceptions are investment outlays. Therefore, the compact DWHR unit is a clean energy device, which in many cases is financially viable.

Introducing a Calculator for the Environmental and Financial Potential of Drain Water Heat Recovery in Commercial Kitchens

Food service providers like restaurants, cafes, or canteens are of economic importance worldwide, but also contribute to environmental impacts through water and energy consumption. Drain water heat recovery from commercial kitchens, using a heat exchanger, has shown large potential to decarbonise hot water use across food services, but is rarely deployed. This work translates previous findings on the technical feasibility and heat recovery potential for commercial kitchens into a publicly available calculator. It facilitates decision-making towards recovery and reuse of the freely available heat in kitchen drains by estimating both financial costs and payback time, as well as environmental burdens associated with the installation and environmental savings from avoided energy consumption. Environmental burdens and savings include, but are not limited to, carbon emissions. Further, the tool highlights key aspects of the technical implementation to understand installation requirements. The tool is freely available and could contribute to the uptake of heat recovery in the food service sector, ideally in conjunction with policy support through financial incentives or subsidies.

Assessment of the Feasibility of Implementing Shower Heat Exchangers in Residential Buildings Based on Users’ Energy Saving Preferences

In Poland, domestic hot water is heated mainly using fossil fuel energy sources. Such an approach results in the depletion of natural resources, pollution of the atmosphere and, consequently, irreversible changes to the climate. In response to this problem, this research identified the factors that most determine energy savings for heating water in residential buildings, as well as those that affect the choice of an alternative energy source. Additionally, the possibility of implementing shower heat exchangers in existing and newly built residential buildings was assessed, as well as society’s willingness to use such devices. The research was carried out on a sample of 462 inhabitants of the Podkarpackie Voivodeship (Poland). A questionnaire survey was used as a tool. The conducted research has shown that the perspective of environmental protection is not a sufficient motivator to save energy for heating domestic hot water. It is necessary to implement appropriate programs aimed at informing the public about the possibilities offered by the use of alternative energy sources and co-financing the purchase of appropriate devices. In the case of drain water heat recovery systems, a significant problem is also the need to develop new, highly effective designs of shower heat exchangers which can be installed under the floor linear shower drain or on the horizontal shower waste pipe.

Heat Recovery from Wastewater—A Review of Available Resource

The EU Directive 2018/2001 recognized wastewater as a renewable heat source. Wastewater from domestic, industrial and commercial developments maintains considerable amounts of thermal energy after discharging into the sewer system. It is possible to recover this heat by using technologies like heat exchangers and heat pumps; and to reuse it to satisfy heating demands. This paper presents a review of the literature on wastewater heat recovery (WWHR) and its potential at different scales within the sewer system, including the component level, building level, sewer pipe network level, and wastewater treatment plant (WWTP) level. A systematic review is provided of the benefits and challenges of WWHR across each of these levels taking into consideration technical, economic and environmental aspects. This study analyzes important attributes of WWHR such as temperature and flow dynamics of the sewer system, impacts of WWHR on the environment, and legal regulations involved. Existing gaps in the WWHR field are also identified. It is concluded that WWHR has a significant potential to supply clean energy at a scale ranging from buildings to large communities and districts. Further attention to WWHR is needed from the research community, policymakers and other stakeholders to realize the full potential of this valuable renewable heat source.

Environmental and energy saving potential from greywater in hotels

Reducing energy consumption, increasing energy efficiency technologies and solutions, decreasing emissions are very effective tools towards EU environmental policy. The constant demand for domestic hot water (DHW) throughout the year creates great benefits for drain water heat recovery (DWHR) systems in hotels, which is the most promising and significant feature of energy saving potential for the hotel sector in Poland. This paper determines the feasibility of heat recovery in a typical hotel in Poland. The energy analysis was carried out for the installed DWHR system (from washbasins and showers) at the hotel building. To evaluate the energy saving potentiality, daily, monthly and yearly calculation results were performed for an exemplary hotel in Poland. Two types of heat exchangers were adopted for further calculations: vertical (System 1) and horizontal (System 2), this intention aimed to find the most efficient type and relevant solution of energy saving and reduction of CO2 emissions in the analysed hotel. The analysis and calculations were repeated to enhance the saving potentiality of the proposed DWHR systems for various parameters like constant and variable temperature of supply cold water, daily hot water consumption profiles, the efficiency of heat recovery, reduction of annual carbon dioxide emission (CDE), facility standard of operating procedure, the impact of hotel size, etc. The obtained results of the conducted calculations ensure a significant potential of energy savings by implementing the proposed DWHR systems in analysed hotel, which allow to save energy demand and to reduce CO2 emission by 27.3% and improve the efficiency of the DHW preparation system.

Adaptation of HVAC Systems to Reduce the Spread of COVID-19 in Buildings

In 2020, all the world has been confronted with COVID-19. Bringing people together in buildings is proving to be a risk factor that we have to deal with. Although the greatest attention is paid to the SARS-CoV-2 virus, there are a number of other pathogens (viruses, bacteria, fungi, etc.) that can be transmitted through the air. These pathogens are sensitive to UV-C radiation. UV-C fluorescent lamps have been developed with technical parameters that are adapted to HVAC operating conditions. By using germicidal sources to disinfect the transported air, more than 90% of the SARS-CoV-2 virus, more than 97% of Influenza A virus, and 100% of Legionella pneumophila can be inactivated. The use of UV-C emitters for air disinfection allows the use of circulation and recuperation. Total balance of energy and CO2 emissions by variants and energies used, including humidification were performed for Slovak conditions. The operation of germicidal sources during the heating period in selected cities in our example would represent only 0.45% of the difference in heat demand and 0.42% of the difference in energy demand between operation according to recommendations and operation with germicidal sources. It is therefore an effective means of ensuring health safety and energy efficiency for the future.