Evaluation of Microaeration and Sound to Increase Biogas Production from Poultry Litter

Microbiome Diversity of Anaerobic Digesters Is Enhanced by Microaeration and Low Frequency Sound

Biogas is produced by a consortium of bacteria and archaea. We studied how the microbiome of poultry litter digestate was affected by time and treatments that enhanced biogas production. The microbiome was analyzed at six, 23, and 42 weeks of incubation. Starting at week seven, the digesters underwent four treatments: control, microaeration with 6 mL air L-1 digestate per day, treatment with a 1000 Hz sine wave, or treatment with the sound wave and microaeration. Both microaeration and sound enhanced biogas production relative to the control, while their combination was not as effective as microaeration alone. At week six, over 80% of the microbiome of the four digesters was composed of the three phyla Actinobacteria, Proteobacteria, and Firmicutes, with less than 10% Euryarchaeota and Bacteroidetes. At week 23, the digester microbiomes were more diverse with the phyla Spirochaetes, Synergistetes, and Verrucomicrobia increasing in proportion and the abundance of Actinobacteria decreasing. At week 42, Firmicutes, Bacteroidetes, Euryarchaeota, and Actinobacteria were the most dominant phyla, comprising 27.8%, 21.4%, 17.6%, and 12.3% of the microbiome. Other than the relative proportions of Firmicutes being increased and proportions of Bacteroidetes being decreased by the treatments, no systematic shifts in the microbiomes were observed due to treatment. Rather, microbial diversity was enhanced relative to the control. Given that both air and sound treatment increased biogas production, it is likely that they improved poultry litter breakdown to promote microbial growth.

Lagoon, Anaerobic Digestion, and Composting of Animal Manure Treatments Impact on Tetracycline Resistance Genes

Increased demand for animal protein is met by increased food animal production resulting in large quantities of manure. Animal producers, therefore, need sustainable agricultural practices to protect environmental health. Large quantities of antimicrobials are used in commercial food animal production. Consequently, antimicrobial-resistant bacteria and the resistance genes emerge and are excreted through feces. Manure management is essential for the safe disposal of animal waste. Lagoons, with or without covers, and anaerobic digesters, with the primary purpose of methane production, and composting, with the primary purpose of producing organic fertilizer, are widely used methods of manure treatment. We reviewed manure management practices and their impact on tetracycline resistance genes. Lagoons are maintained at ambient temperatures; especially uncovered lagoons are the least effective in removing tetracycline resistance genes. However, some modifications can improve the performance of lagoons: sequential use of uncovered lagoons and the use of covered lagoons resulted in a one-log reduction, while post-treatments such as biofiltration following covered lagoon treatment resulted in 3.4 log reduction. Mesophilic digestion of animal manure did not have any significant effect; only a 0.7 log reduction in tet(A) was observed in one study. While thermophilic anaerobic digesters are effective, if properly operated, they are expensive for animal producers. Aerobic thermophilic composting is a promising technology if optimized with its economic benefits. Composting of raw animal manure can result in up to a 2.5 log reduction, and postdigestion composting can reduce tetracycline resistance gene concentration by >80%. In general, manure management was not designed to mitigate antimicrobial resistance; future research is needed to optimize the economic benefits of biogas or organic fertilizer on the one hand and for the mitigation of foodborne pathogens and antimicrobial resistance on the other.

Pilot-scale microaerobic hydrolysis-acidification and anoxic-oxic processes for the treatment of petrochemical wastewater

Microaerobic hydrolysis and acidification (MHA), as a promising pre-treatment method of industrial wastewater, is drawing increasing attention to enhance the hydrolysis-acidification rate and inhibit the production of toxic gas H₂S. In the present work, a pilot-scale MHA reactor coupled with anoxic-oxic (A/O) processes for treating the petrochemical wastewater was established and the mechanism and application of the MHA reaction were explored. The results showed that the ratio of VFA/COD was increased by 43-90% and low effluent S^2- concentration (less than 0.2 mg/L) was obtained after MHA treatment with 5.5-13.8 L air m^-3 h^-1 supply. The MHA sludge exhibited a good settleability, a higher protease activity and plentiful community diversity. In addition to the dominant anaerobic bacteria responsible for hydrolysis and acidification such as Clostridiales uncultured, Anaerovorax, Anaerolineaceae uncultured and Fastidiosipila, the sulfate reducing bacteria involving Desulfobacter, Desulfomicrobium and Desulfobulbus, the sulphur oxidizing bacteria involving Thiobacillus, Arcobacter and Limnobacter, the nitrifies such as Nitrosomonadaceae uncultured and Nitrospira, and denitrifies Thauera were also identified. MHA pre-treatment guaranteed the efficacy and stability of the following A/O treatment. The removal efficiency of COD and ammonium of the MHA-A/O system remained at around 78.3% and 80.8%, respectively, although the organic load fluctuated greatly in the influent.

High-Solid Anaerobic Digestion: Reviewing Strategies for Increasing Reactor Performance

High-solid and solid-state anaerobic digestion are technologies capable of achieving high reactor productivity. The high organic load admissible for this type of configuration makes these technologies an ideal ally in the conversion of waste into bioenergy. However, there are still several factors associated with these technologies that result in low performance. The economic model based on a linear approach is unsustainable, and changes leading to the development of a low-carbon model with a high degree of circularity are necessary. Digestion technology may represent a key driver leading these changes but it is undeniable that the profitability of these plants needs to be increased. In the present review, the digestion process under high-solid-content configurations is analyzed and the different strategies for increasing reactor productivity that have been studied in recent years are described. Percolating reactor configurations and the use of low-cost adsorbents, nanoparticles and micro-aeration seem the most suitable approaches to increase volumetric production and reduce initial capital investment costs.