Changes in the Physicochemical Properties of Chia (Salvia hispanica L.) Seeds during Solid-State and Submerged Fermentation and Their Influence on Wheat Bread Quality and Sensory Profile

Effects of Ugali Maize Flour Fortification with Chia Seeds (Salvia hispanica L.) on Its Physico-Chemical Properties and Consumer Acceptability

The study investigated the effect of incorporating whole chia seeds (WCS) and defatted chia seed flour (DCF) into whole maize meal for ugali preparation. Both were incorporated at substitution levels of 3%, 6%, and 9% separately, and the resulting treatments subjected to laboratory analysis. In addition, ugali samples were prepared from all the resulting flour formulations and subjected to consumer acceptability assessment. Incorporation of both DCF and WCS resulted in increased water absorption capacity (ranging from 0.78 to 0.98 g/mL), swelling index (ranging from 0.15 to 3.25 mL/g), and swelling capacity (ranging from 2.46 to 5.74 g/g). WCS decreased the bulk density and oil absorption capacity. DCF, however, resulted in an increase in bulk density and oil absorption capacity. Both DCF and WCS lowered the lightness (L*) of the products. Proximate composition ranged from 4.78 to 7.46% for crude fat, 7.22% to 9.16% for crude protein, and 1.74 to 4.27% for crude fiber. The obtained results show the potential of chia seeds as a good fortificant of maize flour since it resulted in nutritionally superior products (crude ash, crude protein, crude fat, and energy value) when compared to control. The freshly prepared ugali samples were generally acceptable to the panelists up to 9% WCS and 6% DCF substitution levels.

Psyllium husk gel used as an alternative and more sustainable scalding technology for wheat bread quality improvement and acrylamide reduction

This study aimed at evaluating the influence of different amounts (5, 10, 15, 20, and 25%) of psyllium husk gel (PHG) on wheat bread (WB) characteristics - chiefly, overall acceptability (OA), porosity, specific volume (v), mass loss after baking (ML), shape retention coefficient, crust and crumb color coordinates, bread crumb hardness during storage, saccharides content, and acrylamide (AA) concentration. PHG was prepared by mixing 100 g of psyllium husk powder with 800 mL of warm water. It was established that the amount of psyllium husk gel is a significant factor in dough redness (a*) (p < 0.001). A moderate positive correlation (r) was found between acrylamide content in wheat bread and maltose concentration in dough (r = 0.567). The psyllium husk gel increased the overall acceptability and specific volume of wheat bread. Wheat bread porosity showed a moderate positive correlation with mass loss after baking (r = 0.567) and a strong positive correlation with texture hardness (r = 0.664). Lower acrylamide content was obtained in wheat bread prepared with 5, 10, 15, 20, and 25% of psyllium husk gel (1.53, 2.34, 3.80, 2.69, and 3.62 times lower than the control wheat bread, respectively). Acrylamide content showed a strong positive correlation with the porosity of wheat bread (r = 0.672), with crust brightness (L*), and yellowness/blueness (b*) coordinates, as well as with crumb brightness, redness, and yellowness coordinates. Overall, psyllium husk gel hydrocolloids reduced acrylamide formation in wheat bread and can be recommended for the quality improvement of wheat bread.

Effect of Growth Stages and Lactic Acid Fermentation on Anti-Nutrients and Nutritional Attributes of Spinach (Spinacia oleracea)

Spinach (Spinacia oleracea) is a winter-season green, leafy vegetable grown all over the world, belonging to the family Amaranthus, sub-family Chenopodiaceae. Spinach is a low-caloric food and an enormous source of micronutrients, e.g., calcium, folates, zinc, retinol, iron, ascorbic acid and magnesium. Contrarily, it also contains a variety of anti-nutritional factors, e.g., alkaloids, phytates, saponins, oxalates, tannins and many other natural toxicants which may hinder nutrient-absorption. This study was aimed at investigating the effect of fermentation on improving the nutrient-delivering potential of spinach and mitigating its burden of antinutrients and toxicants at three growth stages: the 1st growth stage as baby leaves, the 2nd growth stage at the coarse stage, and the 3rd growth stage at maturation. The results revealed the significant (p < 0.05) effect of fermentation on increasing the protein and fiber content of spinach powder from 2.53 to 3.53% and 19.33 to 22.03%, respectively, and on reducing total carbohydrate content from 52.92 to 40.52%; the effect was consistent in all three growth stages. A significant decline in alkaloids (6.45 to 2.20 mg/100 g), oxalates (0.07 mg/100 g to 0.02 mg/100 g), phytates (1.97 to 0.43 mg/100 g) and glucosinolates (201 to 10.50 µmol/g) was observed as a result of fermentation using Lactiplantibacillus plantarum. Fermentation had no impact on total phenolic content and the antioxidant potential of spinach, as evaluated using 2,2-diphenyl-1-picrylhydrazyl (DPPH) and ferric-reducing antioxidant power (FRAP) assays. This study proposes fermentation as a safer bioprocess for improving the nutrient-delivering potential of spinach, and suggests processed powders made from spinach as a cost-effective complement to existing plant proteins.

On the Molecular Selection of Exopolysaccharide-Producing Lactic Acid Bacteria from Indigenous Fermented Plant-Based Foods and Further Fine Chemical Characterization

Exopolysaccharides (EPSs) produced by lactic acid bacteria present a particular interest for the food industry since they can be incorporated in foods via in situ production by selected starter cultures or applied as natural additives to improve the quality of various food products. In the present study, 43 strains were isolated from different plant-based fermented foods and identified by molecular methods. The species found were distinctively specific according to the food source. Only six Lactiplantibacillus plantarum strains, all isolated from sauerkraut, showed the ability to produce exopolysaccharide (EPS). The utilization of glucose, fructose and sucrose was explored with regard to EPS and biomass accumulation by the tested strains. Sucrose was clearly the best carbon source for EPS production by most of the strains, yielding up to 211.53 mg/L by strain Lactiplantibacillus plantarum ZE2, while biomass accumulation reached the highest levels in the glucose-based culture medium. Most strains produced similar levels of EPS with glucose and fructose, while fructose was utilized more poorly for biomass production, yielding about 50% of biomass compared to glucose for most strains. Composition analysis of the EPSs produced by strain Lactiplantibacillus plantarum ZE2 from glucose (EPS-1) and fructose (EPS-2) revealed that glucose (80-83 mol%) and protein (41% w/w) predominated in both analyzed EPSs. However, the yield of EPS-1 was twice higher than that of EPS-2, and differences in the levels of all detected sugars were found, which shows that even for the same strain, EPS yield and composition vary depending on the carbon source. These results may be the basis for the development of tailored EPS-producing starter cultures for food fermentations, as well as technologies for the production of EPS for various applications.