Physiological Effects of 2-Bromoethanesulfonate on Hydrogenotrophic Pure and Mixed Cultures

Experimental simulation of H2 coinjection via a high-pressure reactor with natural gas in a low-salinity deep aquifer used for current underground gas storage

If dihydrogen (H2) becomes a major part of the energy mix, massive storage in underground gas storage (UGS), such as in deep aquifers, will be needed. The development of H2 requires a growing share of H2 in natural gas (and its current infrastructure), which is expected to reach approximately 2% in Europe. The impact of H2 in aquifers is uncertain, mainly because its behavior is site dependent. The main concern is the consequences of its consumption by autochthonous microorganisms, which, in addition to energy loss, could lead to reservoir souring and alter the petrological properties of the aquifer. In this work, the coinjection of 2% H2 in a natural gas blend in a low-salinity deep aquifer was simulated in a three-phase (aquifer rock, formation water, and natural gas/H2 mix) high-pressure reactor for 3 months with autochthonous microorganisms using a protocol described in a previous study. This protocol was improved by the addition of protocol coupling experimental measures and modeling to calculate the pH and redox potential of the reactor. Modeling was performed to better analyze the experimental data. As in previous experiments, sulfate reduction was the first reaction to occur, and sulfate was quickly consumed. Then, formate production, acetogenesis, and methanogenesis occurred. Overall, H2 consumption was mainly caused by methanogenesis. Contrary to previous experiments simulating H2 injection in aquifers of higher salinity using the same protocol, microbial H2 consumption remained limited, probably because of nutrient depletion. Although calcite dissolution and iron sulfide mineral precipitation likely occurred, no notable evolution of the rock phase was observed after the experiment. Overall, our results suggested that H2 can be stable in this aquifer after an initial loss. More generally, aquifers with low salinity and especially low electron acceptor availability should be favored for H2 costorage with natural gas.

Two-stage conversion of syngas and pyrolysis aqueous condensate into L-malate

Hybrid thermochemical-biological processes have the potential to enhance the carbon and energy recovery from organic waste. This work aimed to assess the carbon and energy recovery potential of multifunctional processes to simultaneously sequestrate syngas and detoxify pyrolysis aqueous condensate (PAC) for short-chain carboxylates production. To evaluate relevant process parameters for mixed culture co-fermentation of syngas and PAC, two identical reactors were run under mesophilic (37 °C) and thermophilic (55 °C) conditions at increasing PAC loading rates. Both the mesophilic and the thermophilic process recovered at least 50% of the energy in syngas and PAC into short-chain carboxylates. During the mesophilic syngas and PAC co-fermentation, methanogenesis was completely inhibited while acetate, ethanol and butyrate were the primary metabolites. Over 90% of the amplicon sequencing variants based on 16S rRNA were assigned to Clostridium sensu stricto 12. During the thermophilic process, on the other hand, Symbiobacteriales, Syntrophaceticus, Thermoanaerobacterium, Methanothermobacter and Methanosarcina likely played crucial roles in aromatics degradation and methanogenesis, respectively, while Moorella thermoacetica and Methanothermobacter marburgensis were the predominant carboxydotrophs in the thermophilic process. High biomass concentrations were necessary to maintain stable process operations at high PAC loads. In a second-stage reactor, Aspergillus oryzae converted acetate, propionate and butyrate from the first stage into L-malate, confirming the successful detoxification of PAC below inhibitory levels. The highest L-malate yield was 0.26 ± 2.2 molL-malate/molcarboxylates recorded for effluent from the mesophilic process at a PAC load of 4% v/v. The results highlight the potential of multifunctional reactors where anaerobic mixed cultures perform simultaneously diverse process roles, such as carbon fixation, wastewater detoxification and carboxylates intermediate production. The recovered energy in the form of intermediate carboxylates allows for their use as substrates in subsequent fermentative stages.

Influence of oxygen partial pressure on homoacetogenesis and promotion of acetic acid accumulation through low pH regulation under microaerobic conditions

Homoacetogenesis is an important pathway for bio-utilization of CO2; however, oxygen is a key environmental influencing factor. This study explored the impact of different initial oxygen partial pressures (OPPs) on homoacetogenesis, while implementing low pH regulation enhanced acetic acid (HAc) accumulation under microaerobic conditions. Results indicated that cumulative HAc production increased by 18.2% in 5% OPP group, whereas decreases of 31.3% and 56.0% were observed in 10% and 20% OPP groups, respectively, compared to the control group. However, hydrogenotrophic methanogens adapted to microaerobic environment and competed with homoacetogens for CO2, thus limiting homoacetogenesis. Controlling influent pH 5.0 per cycle increased cumulative HAc production by 18.3% and 18.2% in 5% and 10% OPP groups, respectively, compared with the control group. Consequently, regulating low pH effectively inhibited methanogenic activity under microaerobic conditions, thus increasing HAc production. This study was expected to expand the practical application of homoacetogenesis in bio-utilization of CO2.

Unraveling prevalence of homoacetogenesis and methanogenesis pathways due to inhibitors addition

Three inhibitors targeting different microorganisms, both from Archaea and Bacteria domains, were evaluated for their effect on CO₂ biomethanation: sodium ionophore III (ETH2120), carbon monoxide (CO), and sodium 2-bromoethanesulfonate (BES). This study examines how these compounds affect the anaerobic digestion microbiome in a biogas upgrading process. While archaea were observed in all experiments, methane was produced only when adding ETH2120 or CO, not when adding BES, suggesting archaea were in an inactivated state. Methane was produced mainly via methylotrophic methanogenesis from methylamines. Acetate was produced at all conditions, but a slight reduction on acetate production (along with an enhancement on CH₄ production) was observed when applying 20 kPa of CO. Effects on CO₂ biomethanation were difficult to observe since the inoculum used was from a real biogas upgrading reactor, being this a complex environmental sample. Nevertheless, it must be mentioned that all compounds had effects on the microbial community composition.

Microbial Recycling of Bioplastics via Mixed-Culture Fermentation of Hydrolyzed Polyhydroxyalkanoates into Carboxylates

Polyhydroxyalkanoates (PHA) polymers are emerging within biobased biodegradable plastic products. To build a circular economy, effective recycling routes should be established for these and other end-of-life bioplastics. This study presents the first steps of a potential PHA recycling route by fermenting hydrolyzed PHA-based bioplastics (Tianan ENMATTM Y1000P; PHBV (poly(3-hydroxybutyrate-co-3-hydroxyvalerate)) into carboxylates acetate and butyrate. First, three different hydrolysis pretreatment methods under acid, base, and neutral pH conditions were tested. The highest 10% (from 158.8 g COD/L to 16.3 g COD/L) of hydrolysate yield was obtained with the alkaline pretreatment. After filtration to remove the remaining solid materials, 4 g COD/L of the hydrolyzed PHA was used as the substrate with the addition of microbial nutrients for mixed culture fermentation. Due to microbial conversion, 1.71 g/L acetate and 1.20 g/L butyrate were produced. An apparent complete bioconversion from intermediates such as 3-hydroxybutyrate (3-HB) and/or crotonate into carboxylates was found. The overall yields of the combined processes were calculated as 0.07 g acetate/g PHA and 0.049 g butyrate/g PHA. These produced carboxylates can theoretically be used to reproduce PHA or serve many other applications as part of the so-called carboxylate platform.

Impacts of 2-bromoethanesulfonic sodium on methanogenesis: Methanogen metabolism and community structure

Production of medium-chain carboxylic acids (MCCAs) by chain elongation (CE) presents a competitive alternative to conventional products of methane in anaerobic digestion treating organic waste streams, considering energy recovery, economic, and environmental profits. However, the system stability and performance largely rely on the selective suppression of methanogens while stimulation of CE bacteria. Commercial inhibitors such as 2-bromoethanesulfonic sodium (BES) was shown to be effective, but controversial conclusions exist on its inhibition characteristics and the inhibition mechanism remains unclear. Therefore, this study systematically investigated the responses of methanogenesis in granular sludge to various BES levels, focusing on methane production, methanogenic pathway, dynamic populations, electron transport and energy metabolism. Results showed that compared with the control, 3.0 g/L BES was sufficient to induce a 72.9% reduced level on accumulative methane production by the end of 4 cycles (28 days), which was likely to be attributed to the significantly suppressed metabolic pathways and intracellular regulations. Specifically, BES suppressed the electron transport via unproper electron carriers and reduced electron amount as indicated by the decreased level of enzymes and genes involved such as coenzyme F₄₂₀, CO dehydrogenase and NADH:ubiquinone reductase (H⁺-translocating). Moreover, BES regulated the intracellular energy metabolism, leading to the impeded ATP synthesis but enhanced ATP consumption as evidenced by the variations on the activity or abundance of acetate kinase, A1Ao-ATP synthase, nitrogenase and ATP citrate synthase. Additionally, BES enriched hydrogenotrophic methanogenesis over acetoclastic one as supported by variations on the archaeal community structures and regulations of differentially expressed genes involved. Moreover, BES also reduced the contents of both protein and carbohydrate in extracellular polymeric substances (EPS). This study is expected to enhance understanding of BES contribution to methanogenesis inhibition but MCCAs production in CE bioreactors.

Syngas biomethanation: Current state and future perspectives

In regions highly dependent on fossil fuels imports, biomethane represents a promising biofuel for the transition to a bio-based circular economy. While biomethane is typically produced via anaerobic digestion and upgrading, biomethanation of the synthesis gas (syngas) derived from the gasification of recalcitrant solid waste has emerged as a promising alternative. This work presents a comprehensive and in-depth analysis of the state-of-the-art and most recent advances in the field, compiling the potential of this technology along with the bottlenecks requiring further research. The key design and operational parameters governing syngas production and biomethanation (e.g. organic feedstock, gasifier design, microbiology, bioreactor configuration, etc.) are critically analysed.