Surface Functionalization of Polyester Textiles for Antibacterial and Antioxidant Properties

Enhancing the Production of Eco-Friendly Silk Fabrics through the Application of Nonthermal Plasma Wettability Techniques

The combination of the effects of nonthermal plasma using atmospheric pressure of plasma jet and the photocatalytic effects of titanium dioxide nanoparticles was used to study the plasma flow modes, electrical characteristics, nonthermal characteristics, antimicrobial measurements, and surface modifications. Using different wettabilities of argon discharges in a laminar flow: (i) wet I, wettability with 2.4 slm argon mixture with oxygen ratio O2, equivalent to 15 mslm (Ar/O2), and (ii) wet II, wettability (Ar/O2) mixture combined with titanium dioxide, to accelerate the inactivation process on the nonwoven fabric surface. For wet 0, wet I, and wet II discharges, the average rate of heat transfer to the nonwoven silk fabric increased significantly. Specifically, it goes from 104.6 to 118.6 and then to 241.7 mW, respectively. The kinetic deactivation rate of Escherichia coli increases starting at 0.20, then going up to 0.32, and finally reaching 0.57 min-1. The increased wettability of the TiO2 photocatalyst results in an enhanced bactericidal rate, which is caused by both the heat impact from the nonthermal jet and potentially photocatalytic disinfection, leading to the generation of active species. The mechanical parameters owing to different wettabilities and plasma interactions with the fabric membrane were tested for the treated samples, such as stiffness, ultimate yield strength, tensile strength, strain, hardening, elongation, resilience, and toughness.

Investigation of plasma parameters, distributions, and optical emission for the anti-microbial performance of non-woven fabric under direct current glow discharge

The distribution of electron temperature Te and density Ne for direct current glow plasma discharge was investigated, using a single Langmuir probe, inserted inside the plasma cell. The radial temperature distribution has the same values, except with a small increment variation at the cathode edge, and an axial decrement for the temperature Te distribution profiles from the cathode fall region, passing the abnormal glow region, up to the faraway axial region. The radial distribution of the electron density Ne has its highest value at the cathode, with very intense plasma at the cathode fall region, and more Ne decrement in the abnormal glow region, passing the abnormal glow region up to the faraway axial region. In the axial Ne distribution, an increase in Ne from the cathode fall region reaches maximum values in the abnormal glow region and decreases in the faraway axial region. The optimal plasma surface treatment of non-woven silk fabric (n-WSF) can be achieved by utilizing a high plasma density and low energy of electrons to inactivate viable cells attached to (n-WSF) at very short application times, leading to complete inactivation, where the bacterial inactivation rate increases in the abnormal glow region. Based on analyses of the experimental data of initial and final densities of viable cells using survival curves in the abnormal glow discharge region, a dramatic inhibitory effect of plasma discharge on the residual survival microbe ratio was observed.