A New Adjustment Strategy to Relieve Inhibition during Anaerobic Codigestion of Food Waste and Cow Manure

A comprehensive review on food waste anaerobic co-digestion: Research progress and tendencies

Food waste (FW) anaerobic digestion systems are prone to imbalance during long-term operation, and the imbalance mechanism is complex. Anaerobic co-digestion (AcoD) of FW and other substrates can overcome the performance limitations of single digestion, allowing for the mutual use of multiple wastes and resource recovery. Research on the AcoD of FW has been widely conducted and successfully applied to a practical engineering scale. Therefore, this review describes the research progress of AcoD of FW with other substrates. By analyzing the problems and challenges faced by AcoD of FW, the synergistic effects and influencing factors of different biomass wastes are discussed, and improvement strategies to improve the performance of AcoD of FW are summarized from different reaction stages of anaerobic digestion. By combing the research progress of AcoD of FW, it provides a reference for the optimization and improvement of the performance of the co-digestion system.

Evaluation of methane generation rate and energy recovery potential of municipal solid waste using anaerobic digestion and landfilling: A case study of Dhanbad, India

In this study, two most common biological waste to energy conversion techniques have been analysed and compared on the basis of methane generation and energy recovery potential. The biogas generation potential has been estimated using anaerobic co-digestion experiment. The main substrate used for this study was food waste, while cow dung and anaerobic digester sludge were used as co-digestion substrates. Food waste was used because of its maximum composition (36% of total wastes) in the study area (Dhanbad city, India) with high biogas generation potential. Cow dung acted as a natural buffer, while anaerobic digester sludge was a source of active inoculum. Based on the maximum biogas yield of 402 mL g^-1 VS and annual food waste generation rate in the study area, the energy recovery potential using anaerobic digestion was estimated to be 6.59 × 10⁶ kWh year^-1. Presently, the wastes in the mixed form are being dumped on a large abandoned land with an approximate area of 93 ha in the outskirts of Dhanbad city in an uncontrolled manner. The annual landfill gas generation from the existing landfill has been estimated using Landfill Gas Emissions Model (LandGEM) based on the waste characteristics, anticipated landfill life and other region-specific parameters of the present study area. The maximum electrical energy recovery potential of 44.62 × 10⁵ kWh from landfill gas has been estimated for the year 2041. Although, the results are based on the waste generation and characteristics of Dhanbad city, the comparison methodology can be applied to other cities.

Solid state anaerobic digestion of food waste and sewage sludge: Impact of mixing ratios and temperature on microbial diversity, reactor stability and methane yield

Food waste (FW) and sewage sludge (SS) were anaerobically co digested under solid state conditions (Total solids >15%) and observed that mixing ratio of 3:1 and 2:1 is optimum for mesophilic and thermophilic conditions respectively. The VS reduction and methane yield at optimized ratio was 76% and 0.35 L CH₄/(g VS reduced) respectively at mesophilic temperature whereas it was 88% and 0.42 L CH₄/(g VS reduced) at thermophilic temperature. The metagenomic analysis for these cases were done and high throughput DNA sequencing revealed that diversified bacterial groups that participate in the different metabolisms (hydrolysis, acidogenesis and acetogenesis) were mainly dominated by the phylum Firmicutes and Bacteriodetes. Genus Methanothrix is found to be dominant which is capable of generating methane by any methanogenic pathway among all the archaeal communities in the reactors followed by Methanolinea and Methanoculleus. However, it was understood through metagenomic studies that acetotrophic pathway is observed to be the major metabolic pathway in the reactors.

Simultaneous synergistic effects of graphite addition and co-digestion of food waste and cow manure: Biogas production and microbial community

The effects of graphite on the anaerobic digestion of food waste (FW), cow manure (CM) and its mixture (FW/CM) via batch experiments under mesophilic conditions have been investigated in this study. Maximum biogas production with graphite addition for FW + 1 g/L, CM + 1.5 g/L and FW/CM + 0.75 g/L are 1128.46, 829.6 and 1471.1 mL/gVS respectively. Additionally, this study investigates the link between microbial community structure and biogas production when graphite addition of anaerobic digester was conducted. Based on 16S rRNA gene amplicon sequencing results, Aminiphilus (13-14%), Actinobaculum (13-15%) and Clostridium (12-18%) were the predominant bacterial genera in graphite-added FW, CM and FW/CM reactors, respectively. Comparatively higher biogas production of FW/CM synergistically affected by abundances of Clostridium as well as co-digestion in this anaerobic digestion setup. Methanosaeta was the most abundant methanogen in the graphite added digesters; however, the relative abundance of these genera was different.