Gossypol Exhibited Higher Detrimental Effect on Ruminal Fermentation Characteristics of Low-Forage in Comparison with High-Forage Mixed Feeds

Effects of 3-nitrooxypropanol (3-NOP, Bovaer®10) and whole cottonseed on milk production and enteric methane emissions from dairy cows under Swiss management conditions

The objective of this study was to determine the potential effect and interaction of 3- nitrooxypropanol (3-NOP; Bovaer®) and whole cottonseed (WCS) on lactational performance, and enteric methane (CH4) emission of dairy cows. A total of 16 multiparous cows, including 8 Holstein Friesian (HF) and 8 Brown Swiss (BS) [224 ± 36 d in milk, 26 ± 3.7 kg milk yield], were used in a split-plot design, where the main plot was the breed of cows. Within each subplot, cows were randomly assigned to a treatment sequence in a replicated 4 × 4 Latin Square design with 2 × 2 factorial arrangements of treatments with 4, 24-d periods. The experimental treatments were: 1) Control (basal TMR), 2) 3-NOP (60 mg/kg TMR DM), 3) WCS (5% TMR DM), and 4) 3-NOP + WCS. The treatment diets were balanced for ether extract, crude protein, and NDF contents (4%, 16%, and 43% of TMR DM, respectively). The basal diets were fed twice daily at 0800 and 1800 h. Dry matter intake (DMI) and milk yield were measured daily, and enteric gas emissions were measured (using the GreenFeed system) during the last 3 d of each 24-d experimental period when animals were housed in tie stalls. There was no difference in DMI on treatment level, whereas the WCS treatment increased ECM yield and milk fat yield. There was no interaction of 3-NOP and WCS for any of the enteric gas emission parameters, but 3-NOP decreased CH4 production (g/d), CH4 yield (g/kg DMI), and CH4 intensity (g/kg ECM) by 13, 14 and 13%, respectively. Further, an unexpected interaction of breed by 3-NOP was observed for different enteric CH4 emission metrics: HF cows had a greater CH4 mitigation effect compared with BS cows for CH4 production (g/d; 18 vs. 8%), CH4 intensity (g/kg MY; 19% vs. 3%) and CH4 intensity (g/kg ECM; 19 vs. 4%). Hydrogen production was increased by 2.85 folds in HF and 1.53 folds in BS cows receiving 3-NOP. Further, there was a 3-NOP ' Time interaction for both breeds. In BS cows, 3-NOP tended to reduce CH4 production by 18% at around 4 h after morning feeding but no effect was observed at other time points. In HF cows, the greatest mitigation effect of 3-NOP (29.6%) was observed immediately after morning feeding and it persisted at around 23% to 26% for 10 h until the second feed provision, and 3 h thereafter, in the evening. In conclusion, supplementing 3-NOP at 60 mg/kg DM to a high fiber diet resulted in 18 to 19% reduction in enteric CH4 emission in Swiss Holstein Friesian cows. The lower response to 3-NOP by BS cows was unexpected and has not been observed in other studies. These results should be interpreted with caution due to low number of cows per breed. Lastly, supplementing WCS at 5% of DM improved ECM and milk fat yield but did not enhance CH4 inhibition effect of 3-NOP of dairy cows.

The rumen-derived Lact. mucosae LLK-XR1 exhibited greater free gossypol degradation capacity during solid-state fermentation of cottonseed meal and probiotic potential

BACKGROUND

This study aimed to isolate the rumen-derived bacteria with the ability to degrade free gossypol (FG), and to evaluate the probiotic potential in vitro for ensuring safe utilization.

METHODS

The strains were anaerobically isolated from fresh rumen fluid of sheep with long-term fed cottonseed meal (CSM) with the screening agar medium containing gossypol as the sole carbon source. Afterwards, the isolated strain incubated with CSM was subjected to the determination of the FG degradation and in vitro evaluation of probiotic characteristics.

RESULTS

The target strain labeled Lact. mucosae LLK-XR1 [Accession number: OQ652016.1] was obtained, and its growth on MRS Liquid medium exhibited degradation efficiency of FG up to 69.5% which was significantly greater than its growth on Man-Rogosa-Sharpe medium with glucose free for 24 h (p < 0.01). Meanwhile, LLK-XR1 showed 40.652% degradation rate of FG for unautoclaved, non-pulverized, and no additional nutrients supplementation CSM. Furthermore, LLK-XR1 presented good survivability at pH 3.0 (above 88.6%), and 0.3% bile (78.5%). LLK-XR1 showed sensitivity to broad-spectrum antibiotics except Sulfamethoxazole, Ciprofloxacin and Gentamycin and significantly inhibited E. coli CICC 10,899, Staph. aureus CICC 21,600, and Salmonella. Typhimurium CICC 21,483. LLK-XR1 demonstrated good cell surface hydrophobicity and auto-aggregation ability.

CONCLUSIONS

Taken together, this study for the first time noted that rumen-originated Lact. mucosae LLK-XR1 with probiotic properties exhibited substantial FG degradation capacity when it was applied to the solid-state fermentation of CSM.

Biodegradation of Gossypol by Aspergillus terreus-YJ01

Gossypol, generally found in the roots, stems, leaves, and, especially, the seeds of cotton plants, is highly toxic to animals and humans, which inhibits the use of cotton stalks as a feed resource. Here, a promising fungal strain for biodegrading gossypol was successfully isolated from the soil of cotton stalk piles in Xinjiang Province, China, and identified as Aspergillus terreus-YJ01 with the analysis of ITS. Initial gossypol of 250 mg·L-1 could be removed by 97% within 96 h by YJ01, and initial gossypol of 150 mg·L-1 could also be catalyzed by 98% or 99% within 36 h by the intracellular or extracellular crude enzymes of YJ01. Sucrose and sodium nitrate were found to be the optimal carbon and nitrogen sources for the growth of YJ01, and the optimal initial pH and inoculum size for the growth of YJ01 were 6.0 and 1%, respectively. To further elucidate the mechanisms underlying gossypol biodegradation by YJ01, the draft genome of YJ01 was sequenced using Illumina HiSeq, which is 31,566,870 bp in length with a GC content of 52.27% and a total of 9737 genes. Eight genes and enzymes were predicted to be involved in gossypol biodegradation. Among them, phosphoglycerate kinase, citrate synthase, and other enzymes are related to the energy supply process. With sufficient energy, β-1, 4-endo-xylanase may achieve the purpose of biodegrading gossypol. The findings of this study provide valuable insights into both the basic research and the application of A. terreus-YJ01 in the biodegradation of gossypol in cotton stalks.

Anaerobic solid-state fermentation with Bacillus subtilis for digesting free gossypol and improving nutritional quality in cottonseed meal

Microbial fermentation is an effective method to degrade free-gossypol, which is a toxic substance restricting the utilization of cottonseed meal in animal husbandry. However, there are few researches on the nutritional effect and the change of bacterial community on cottonseed meal fermented with anaerobic solid-state fermentation. This study evaluated the effects of fermentation with Bacillus sp. on gossypol degradation and nutritional quality improvement in cottonseed meal (CM), as well as the changes of bacterial community structure during fermentation. The strains with high activity for digesting free gossypol were screened from high protease-producing strains preserved in the laboratory. Then the strains which had both the gossypol degradation activity and protease producing activity were selected to degrade macromolecular protein and free gossypol in CM. The unsterilized SSF medium was inoculated with 109 CFU/kg Bacillus culture and fermented at room temperature for 14 days. Each group had three parallels. And the effects of anaerobic solid-state fermentation on unsterilized CM was evaluated. Results showed that for the seven strains with high activity for digesting free gossypol and producing protease that were screened, free gossypol content in fermented cottonseed meal (FCM) decreased and acid-soluble protein (ASP) contents increased. Among them, strain M-15 had the best fermentation effect, with the free gossypol degradation rate of 93.46% and acid soluble protein content of 13.26%. M-15 was identified as Bacillus subtilis. During fermentation with M-15, the bacterial diversity in CM was reduced, but not significant and the community structure was simpler significantly. The strain M-15 selected in this experiment reduced the free gossypol content and improved the nutritional quality of CM through anaerobic solid-state fermentation, which can be used for industrial large-scale production.

Cysteamine Supplementation In Vitro Remarkably Promoted Rumen Fermentation Efficiency towards Propionate Production via Prevotella Enrichment and Enhancing Antioxidant Capacity

Cysteamine (CS) is a vital antioxidant product and nutritional regulator that improves the productive performance of animals. A 2 × 4 factorial in vitro experiment was performed to determine the effect of the CS supplementation levels of 0, 20, 40, and 60 mg/g, based on substrate weight, on the ruminal fermentation, antioxidant capacity, and microorganisms of a high-forage substrate (HF, forage:corn meal = 7:3) in the Statistical Analysis System Institute. After 48 h of incubation, the in vitro dry matter disappearance and gas production in the LF group were higher when compared with a low-forage substrate (LF, forge hay:corn meal = 3:7), which was analyzed via the use of the MIXED procedure of the HF group, and these increased linearly with the increasing CS supplementation (p < 0.01). With regard to rumen fermentation, the pH and acetate were lower in the LF group compared to the HF group (p < 0.01). However, the ammonia N, microbial crude protein, total volatile fatty acids (VFA), and propionate in the LF group were greater than those in the HF group (p < 0.05). With the CS supplementation increasing, the pH, ammonia N, acetate, and A:P decreased linearly, while the microbial crude protein, total VFA, and propionate increased linearly (p < 0.01). Greater antioxidant capacity was observed in the LF group, and the increasing CS supplementation linearly increased the superoxide dismutase, catalase, glutathione peroxidase, total antioxidant capacity, glutathione, and glutathione reductase, while it decreased the malondialdehyde (p < 0.05). No difference occurred in the ruminal bacteria alpha diversity with the increasing CS supplementation, but it was higher in the LF group than in the HF group (p < 0.01). Based on the rumen bacterial community, a higher proportion of Bacteroidota, instead of Firmicutes, was in the LF group than in the HF group. Furthermore, increasing the CS supplementation linearly increased the relative abundance of Prevotella, norank_f_F082, and Prevotellaceae_UCG-001 under the two substrates (p < 0.05). Prevotella, norank_f_F082, and Prevotellaceae_UCG-001 were positively correlated with gas production, rumen fermentation, and antioxidant capacity in a Spearman correlation analysis (r > 0.31, p < 0.05). Overall, a CS supplementation of not less than 20 mg/g based on substrate weight enhanced the rumen fermentation and rumen antioxidant capacity of the fermentation system, and it guided the rumen fermentation towards glucogenic propionate by enriching the Prevotella in Bacteroidetes.

Rumen Fermentation and Microbiome Responses to Enzymatic Hydrolysate of Cottonseed Protein Supplementation in Continuous In Vitro Culture

This study aimed to evaluate the effect of enzymatic hydrolysate of cottonseed protein (ECP) on the kinetic of gas production, rumen fermentation characteristics, and microbial diversity in continuous in vitro culture with a single factorial design of supplementation with various concentrations of ECP or yeast culture. Treatments were control (without supplementation, CON), supplementation with 10 g/kg Diamond-V XP yeast culture of substrate (XP), and supplementation with 6, 12 and 18 g/kg ECP of substrate (ECP1, ECP2, ECP3), each incubated with 30 mL of buffered incubation fluids and 200 mg of fermentation substrate in graduated glass syringes fitted with plungers for 48 h. Compared with the CON treatment, supplementation of XP yeast culture increased the cumulative gas production at 12 and 24 h, the concentration of ammonia nitrogen (NH3-N) concentration at 24 and 36 h, the concentration of microbial protein (MCP) concentration at 24 and 48 h, the molar butyrate proportion at 12, 24, and 48 h, the molar valerate proportion at 48 h, and the ratio of non-glucogenic to glucogenic acids (p < 0.05). Compared with the CON treatment, the concentration of MCP and the molar propionate proportion at 12 h were higher in the ECP1 treatment (p < 0.05); the cumulative gas production at 2, 4, and 12 h, the concentration of NH3-N at 36 h and the molar valerate proportion at 48 h were higher in the ECP2 treatment (p < 0.05); the cumulative gas production at 2, 12, and 48 h, the concentration of NH3-N at 12 and 36 h, the concentration of MCP at 12, 36, and 48 h, the molar butyrate proportion at 12 and 48 h, and the molar valerate proportion at 48 h were higher in the ECP3 treatment (p < 0.05). Compared with the CON treatment, supplementation with XP yeast culture significantly altered the relative abundance of the phyla Firmicutes, Kiritimatiellaeota, and Proteobacteria, while supplementation with ECP had minimal effect on bacterial diversity. The prediction of bacterial functions showed that the main gene functions of rumen bacteria are associated with carbohydrate metabolism, amino acid metabolism, and membrane transport. The findings of this study suggest that ECP can be used as a superior feed ingredient for ruminants, the suitable level of ECP was 18 g/kg in vitro experiment.

High-Gossypol Whole Cottonseed Exhibited Mediocre Rumen Degradability and Less Microbial Fermentation Efficiency than Cottonseed Hull and Cottonseed Meal with an In Vitro Gas Production Technique

To explore whether or not the gossypol varied in cottonseed by-products affect rumen degradability and fermentation efficiency, an in vitro cumulative gas production experiment was applied with mixed rumen microorganism to compare rumen fermentation characteristics of whole cottonseed (WCS, n = 3 samples), cottonseed meal (CSM, n = 3 samples), and cottonseed hull (CSH, n = 2 samples). The five-replicate fermentation per sample per incubation time continuously lasted for 0.5, 1.5, 3, 6, 12, 24, 36, and 48 h with an automated gas production recording system. Regardless of distinct nutrient differences, the free gossypol level in these cottonseed by-products ranked: WCS > CSH > CSM. After 48 h of incubation, the in vitro dry matter degradability and ammonia N concentration ranked as: CSM > WCS > CSH. The cumulative gas production and total volatile fatty acid (VFA) levels in the culture fluids ranked: CSM > CSH > WCS, in which the average production rate ranked: CSM > WCS > CSH. Regarding the molar VFA pattern, WCS in comparison with CSH and CSM presented the lowest production of non-glucogenic acids (e.g., acetate) and exhibited the highest fermentation efficiency of energy from carbohydrates to VFAs. There was a significant negative correlation between the gossypol content and cumulative gas and total VFA production, suggesting that the greater gossypol in cottonseed by-products, the more detrimental effect occurred for rumen fermentation. In a brief, WCS exhibited mediocre rumen degradability and less microbial fermentation efficiency than CSH and CSM, depending on their gossypol levels.

Isolation and Identification of a Rumen Lactobacillus Bacteria and Its Degradation Potential of Gossypol in Cottonseed Meal during Solid-State Fermentation

Cottonseed meal (CSM) is an important protein feed source for dairy cows. Its inclusion in ruminant diets is limited due to the presence of the highly toxic gossypol though rumen microorganisms are believed to be capable of gossypol degrading and transforming. The objective of the present study was to isolate the gossypol-degrading bacteria from the rumen contents and to assess its potential for gossypol degradation in vitro. A strain named Lactobacillus agilis WWK129 was anaerobically isolated from dairy cows after mixed rumen microorganisms were grown on a substrate with gossypol as the sole carbon source. Furthermore, the strain was applied at 5% inoculum concentration in vitro to continuously ferment CSM at 39 °C for five days, and it presented gossypol degradability as high as 83%. Meanwhile, the CSM contents of crude protein, essential amino acids increased significantly along with the increase of lactic acid yield (p < 0.01). Compared with the original CSM, the fermented CSM contents of neutral detergent fiber and acid detergent fiber was remarkably decreased after the anaerobic fermentation (p < 0.01). In brief, the Lactobacillus strain isolated from the rumen is not only of great importance for gossypol biodegradation of CSM, but it could also be used to further explore the role of rumen microorganisms in gossypol degradation by the ruminants.

In situ rumen degradation characteristics and bacterial colonization of whole cottonseed, cottonseed hull and cottonseed meal with different gossypol content

Regarding whole cottonseed (WCS), cottonseed meal (CSM), and cottonseed hull (CSH), in situ rumen incubation was applied to determine their nutrient and gossypol degradation characteristics and bacterial colonization profile in lactating Holstein cows. Nylon bags containing the cotton by-products were incubated for 0, 6, 12, 24, 36, 48 and 72 h in the rumen, respectively. The relationship between nutrient degradability and free gossypol (FG) content were examined, and the differences in the composition and inferred gene function of the colonized microbiota were studied. As a result, CSM presented highest effective degradability of dry matter, neutral detergent fibre and acid detergent fibre, but the highest effective degradability of crude protein was found in WCS. Free gossypol disappearance rate increased significantly in the first 6 h, and it reached approximately 94% at 72 h of incubation among all samples. The level of FG did not affect nutrient degradability of cotton by-products. Significant differences were noted in attached bacterial community structure among cotton by-products after 24 h rumen incubation. Among the most abundant taxa at genus level, a greater abundance of Cercis gigantea and Succiniclasticum was observed in WCS samples, whereas the CSH and CSM samples contained a greater proportion of Prevotella 1 and Rikenellaceae RC9 gut group. The redundancy analysis revealed that the level of neutral detergent fibre, ether extract, and FG in cotton by-products were significantly positive related with the composition of the attached bacteria. Collectively, our results revealed the dynamics of degradation characteristics, and the difference in the composition of bacterial colonization. These findings are of importance for the targeted improvement of cotton by-products nutrient use efficiency in ruminants and further understanding of the gossypol degradation mechanism in the rumen.